2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints
3,738 reports, newest first.
Suspension, Sep 6, 2005
THE RIGHT FRONT WHEEL BEARING GAVE OUT. THIS IS A KNOWN PROBLEM AND ONE OF THE TOP 3 PROBLEMS THAT PEOPLE HAVE BEEN ASKING FOR A RECALL ON THIS VEHICLE ALONG WITH THE IGNITION LOCK BREAKING. THE REAR WHEEL BEARING WAS RECALLED, BUT FORD WON'T RECALL THE FRONT. I HAVE NEVER HAD, NOR EVER KNOWN ANYONE WHO EVER HAD A WHEEL BEARING GIVE OUT ON A CAR, AND CERTAINLY NOT ONE ONLY 5 YEARS OLD. *NM
Electrical system, Sep 6, 2005
FORD REFUSES TO ISSUE A RECALL OR REPLACE THE IGNITION LOCK ASSEMBLY WHICH IS FAULTY. *NM
Suspension, Sep 6, 2005
DT: THE FRONT RIGHT PASSENGER SIDE COIL SPRINGS BROKE. WHEN THIS OCCURRED IT STOPPED THE CAR AND PUNCTURED THE RIGHT FRONT TIRE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE REPAIR BILL COST $1000. THE TIE ROD END WAS DAMAGED ALONG WITH THE STRUTS, UPPER BEARING PLATES, FRONT STABILIZER RINGS, TIRE, A NEW RIGHT SIDE AXLE, AND CONTROL ARM. THEY WERE REPLACED. THE MECHANIC SAID THERE WAS A CRACK IN THE FRONT COIL SPRINGS THAT CAUSED THE AFOREMENTIONED FAILURES. IN 11/04 THERE WAS A RECALL ON THE FRONT COIL SPRINGS AND THE CONSUMER WAS NOTIFIED BY RECALL LETTER. RECALL REPAIRS HAD ALREADY BEEN DONE IN APRIL WHEN THE INCIDENT OCCURRED. CONSUMER TOOK REPAIR BILL AND RECALL LETTER TO DEALER, AND THEY SUBMITTED IT TO FORD. HOWEVER, FORD SENT BACK A CHECK FOR $480 BUT NOT THE $1000 THE CONSUMER SPENT. THEY ONLY PAID FOR THE COILS AND SOME OTHER WORK, BUT CLAIMED THAT SOME OF THE OTHER REPAIRS WERE UNNECESSARY. THE CONSUMER WANTED TO FILE A COMPLAINT ATTEMPTING TO FORCE FORD TO PAY FOR ALL REPAIRS THAT WERE DONE. *AK *JB
Electrical system, Sep 6, 2005
DT: CALLER HAD IGNITION SWITCH REPLACED ABOUT A YEAR AGO AND WAS NOW HAVING THE SAME PROBLEM AGAIN. IT WAS HARD TO TURN THE KEY, AND CURRENTLY IT WONT TURN AT ALL. DEALER SAID THERE WAS NOTHING THEY COULD DO. MANUFACTURER HAS NOT BEEN CONTACTED YET.*AK *NM
Fuel system, Gasoline, Sep 3, 2005
FAILING FUEL PUMP FOR THE SECOND TIME IN TRAFFIC ONLY ONE YEAR AND FOUR MONTHS AFTER ORIGINAL REPLACEMENT. *JB
Wheels, Sep 2, 2005
MY DRIVER'S SIDE REAR WHEEL BROKE AND NEARLY CAME COMPLETELY OFF WHILE I WAS DRIVING IN THE CAR WITH MY CHILDREN. THE CAR IS PARKED IN MY GARAGE BECAUSE I REFUSE TO SPEND ANYMORE MONEY TRYING TO GET IT FIXED.
Electrical system, Sep 2, 2005
KEY STUCK IN THE IGNITION AND WOULD NOT TURN. I HAD A FLAT TIRE ON THE HIGHWAY AND I TURNED OFF THE CAR TO CHANGE THE TIRE. WHEN RETURNING TO THE CAR TO START THE CAR THE KEY WOULD NOT TURN. I HAD TO PAY FOR A TOW TRUCK AND A FORD DEALER BILL OF OVER $250 TO REPLACE THE ENTIRE IGNITION.
Electrical system, Sep 2, 2005
DT: 2000 FORD FOCUS. THE IGNITION KEEPS LOCKING UP ON THE VEHICLE. THE VEHICLE WAS TAKEN IT TO THE DEALERSHIP. THEY STATED THEY FIXED IT, BUT IT CONTINUALLY HAPPENED. THIS HAPPENS BEFORE THE VEHICLE IS STARTED, THE LAST TIME IT WOULDN'T RELEASE THE KEY. THE DEALERSHIP STATES THEY ARE REPLACING THE SWITCH, WHEN THE VEHICLE WAS RETURNED THERE WAS METAL IN THE FLOOR. *JB
Engine and engine cooling, Electrical system, Aug 30, 2005
I HAVE A FORD FOCUS 2000, MY COMPLAINT IS I HAVE PUT NEW PARTS ON THIS CAR , A NEW ENGINE, FUEL PUMP, PARTS ON THE FRONT END AND A LOT MORE. PLUS MAKING A CAR PAYMENT. WHEN I TAKE IT TO THE FORD SHOP I DON'T LIKE THE WAY I AM TREADED. I STILL HAVE ALL MY RECEIPTS FOR MY CAR I FEEL FORD SHOULD CARE ABOUT THEIR CARS AND THE BUYERS. *NM
Power train, Aug 29, 2005
DT: THE CONTACT OWNS A 2000 FORD FOCUS WITH 22,000 MILES ON THE VEHICLE. THE CONTACT HAD TO REPLACE TWO AUTOMATIC TRANSMISSIONS. THE FIRST TRANSMISSION WAS REPLACED 9 MONTHS AGO WITH ABOUT 18,000 MILES. THE SECOND TRANSMISSION WAS REPLACED LAST WEEK. THE DEALERSHIP TOLD HER TO PAY $129.00 OR TRADE THE VEHICLE IN TO THE DEALERSHIP. SHE REFUSED TO PAY THE $129.00 AND SHE DID NOT WANT TO TRADE IN THE VEHICLE IN FOR ANOTHER FORD. SHE SENT AN E-MAIL TO FORD. AS OF RIGHT NOW THEY HAVE NOT GOTTEN HER E-MAIL. THE DEALERSHIP PROVIDED HER WITH A RENTAL CAR. HOWEVER ,THEY TOLD HER THAT IF SHE DID NOT COME AND PICKUP CAR SHE WILL HAVE TO START PAYING FOR THE RENTAL CAR. THE CONTACT TOOK VEHICLE TO DEALER ON AUGUST 22, 2005 ,AND THE DEALERSHIP PERFORMED RECALL REPAIRS THAT SHE WAS NEVER NOTIFIED ABOUT. THE DEALERSHIP TOLD HER THAT SHE KNEW HER CAR WAS A LEMON. HOWEVER, SHE BROUGHT HER CAR IN TOO LATE. *AK
Air bags, Aug 29, 2005, crash
I WAS IN THE PASSENGER SIDE OF MY CAR WHILE MY BOYFRIEND WAS DRIVING IT. WE WERE GOING NORTH ON A CITY ROAD IN MISSISSAUGA ONTARIO CANADA, WHEN MY BOYFRIEND ATTEMPTED TO CHANGE LANES. HE LOOKED OVER HIS SHOULDER TO SEE HIS BLIND SPOT, BUT HADN'T REALIZED THE TRAFFIC IN OUR CURRENT LANE HAD SLOWED TO A STOP. HE TURNED BACK AROUND AND REALIZED THE TRAFFIC HAD BEEN HALTED, SO HE HIT THE BRAKES TO SLOW THE CAR. WITH NOT ENOUGH ROOM, WE HIT THE CAR IN FRONT OF US AT 5 KILOMETERS PER HOUR. FROM SUCH A SMALL NUDGE, THE AIRBAGS DEPLOYED, SMASHING MY WINDSHIELD, AS WELL AS MY FACE! I ENDED UP WITH A SLIGHT CONCUSSION, TYPE 2 WHIPLASH, AND MINOR BURNS TO MY FACE AND ARM. I FOLLOWED UP WITH PHYSIOTHERAPY, BUT MY NECK PAIN WILL NEVER GO AWAY. WE HAD THE WINDSHIELD REPLACED AND THE AIRBAGS RESET. NO DAMAGE WAS DONE TO THE FRONT OF THE CAR, OR THE REAR OF THE CAR OF THE OTHER VEHICLE.*JB
Suspension, Aug 26, 2005
AT APPROXIMATELY 70,000 MILES, I NOTICED A CLUNKING NOISE WHILE TURNING. AFTER INVESTIGATING THE PROBLEM, MY HUSBAND NOTICED THAT THE DRIVER SIDE FRONT SPRING COIL WAS BROKEN. IF I WOULD HAVE CONTINUED TO DRIVE I'M SURE IT WOULD HAVE PUNCTURED THE TIRE. WE TOOK IT AND HAD THE SPRING COILS IN THE FRONT BOTH REPLACED. *JB
Electrical system, Aug 26, 2005, fire
BATTERY CABLE WAS LOCATED IN A WAY THAT CAUSED ABRASION AGAINST BATTERY CASE. WEAR BY THIS ABRASION CAUSED FAILURE OF THE INSULATION AND A SHORT CIRCUIT. THIS RESULTED IN TOTAL ENGINE AND ELECTRICAL FAILURE AND STARTED A SMALL, BRIEF ELECTRICAL FIRE OF THE CABLE INSULATION AND BATTERY CASE. THE INCIDENT OCCURRED ON A FREEWAY, AND PUT THE OCCUPANT IN SIGNIFICANT DANGER. VEHICLE WAS TOWED TO GARAGE. BATTERY AND BATTERY CABLE HARNESS ASSEMBLY WAS REPLACED. STATUS OF ALTERNATOR NOT YET AVAILABLE.*JB
Power train, Aug 24, 2005
2000 FORD FOCUS TRANSMISSION DEVELOPED PROBLEMS.*MR THE CONSUMER STATED THE VEHICLE WAS STUCK IN SECOND GEAR. THE VEHICLE BROKE DOWN 5 TIMES DUE TO TRANSMISSION PROBLEMS. *JB
Suspension, Aug 24, 2005
DT: 2000 FORD FOCUS. THE CONSUMER COMPLAINED ABOUT THE REAR TIRES WEARING OUT ON FEBRUARY 12, 2003. BOUGHT TWO NEW TIRES FOR THE REAR. THE NEXT DAY I HAD A FOUR WHEEL TIRE ALIGNMENT. MARCH 31, 2003 TWO MORE NEW TIRES BLEW OUT, AND ON SEPTEMBER 23, 2003 WAS HAVING PROBLEM WITH ALIGNMENT, TWO TIRES WERE REPLACED. THE TIRE COMPANY SAID REAR END WAS OUT ALIGNMENT AND THEN WENT TO THE DEALERSHIP AND HAD A FOUR WHEEL ALIGNMENT AGAIN. IN NOVEMBER OR DECEMBER 2003 A NEW SET OF FOUR NEW TIRES WERE BOUGHT. THEN, IN JUNE 2004 TWO NEW TIRES WERE BOUGHT. THE CONSUMER WENT TO A NEW TIRE COMPANY AND IT TOOK THEM FOUR TIMES OF DRIVING CONSUMER'S CAR TO GET IT ALIGNED. WAS LOOKING ON THE INTERNET ABOUT RECALLS AND I FOUND INFORMATION ON SILENT VEHICLE RECALL. CALLED THE MANUFACTURER ABOUT THIS SILENT RECALL, THEY SAID THEY COULD NOT ASSIST CONSUMER ON THIS SILENT RECALL. THEN ,CALLED FORD WORLD HEADQUARTERS, THEY WERE STILL NOT TELLING ANYTHING ON THIS SILENT RECALL. CONSUME R FOUND TSB 03135 ON A CANADIAN WEBSITE BUT COULD NOT PULL UP ANY INFORMATION. *AK
Suspension, Aug 24, 2005
SUPPLEMENTAL INFORMATION REFERENCE NHTSA ODI # 10134021 THE AFOREMENTIONED ODI # IS THE THIRD IN A LINE OF SITUATIONS WHERE, IN MY OPINION, METAL FATIGUE HAS CAUSED A DEFECT. EXCESSIVE REGRIND MATERIAL IS BEING UTILIZED IN THE MANUFACTURE OF PARTS, LEADING TO PREMATURE WEAR/FAILURE AKA PLANNED OBSOLESSENCE. THE RH AXLE SUPPORT BEARINGS WOULD POSSIBLY HAVE NEVER FAILED HAD GOOD WORKMANSHIP PRACTICES AND STANDARDS BEEN IN PLACE AND UTILIZED. BEING A "PROUD FORD OWNER" ONLY SINCE 1969 I HAVE NEVER EXPERIENCED SUCH A RAPID / RAMPID PARTS FAILURE RATE. AS A SHOW OF GOOD FAITH, I EXPECT NOTHING LESS THAN FORD MOTOR COMPANY TO ABSORB ANY AND ALL COST OF REPLACING THE REAR AXLE IN MY 2000 FORD FOCUS. YOUR ATTENTION TO THIS MATTER IS GREATLY APPRECIATED. RESPECTFULLY, PAUL A. STADDEN
Service brakes, Hydraulic, Electrical system, Aug 24, 2005
DT: CONTACT STATED IGNITION LOCKED AND WILL NOT TURN. THIS WAS THE SECOND TIME THIS HAPPENED. THE FIRST TIME IT HAPPENED IN 10-2000. VEHICLE WAS TOWED, AND A NEW IGNITION WAS PUT IN, AND HAD TO ORDER ANOTHER SET OF KEYS. CONTACT CONTINUED TO HAVE THE SAME TROUBLE WITH IT STARTING VEHICLE. IGNITION FAILED AGAIN. CONTACT DID NOT TALK TO A DEALER, BUT PLANED TO DO SO.. THE DEALER ,WHERE CONTACT BOUGHT THE VEHICLE HAD IT TOWED FOR HER IN 2000. SHE IS GOING TO HAVE TO HAVE IT TOWED. THERE WERE NO LIGHTS THAT CAME ON PRIOR TO THE IGNITION LOCKING. *AK A YEAR AFTER THE VEHICLE WAS PURCHASED THE BRAKES AND ROTORS HAD TO BE REPLACED. *NM
Electrical system, Aug 23, 2005
DT: THE IGNITION CYLINDER LOCKED AND WILL NOT LET YOU TURN THE KEY. CONTACTED A FORD DEALER, THEY SAID THEY HAVE SEEN THIS PROBLEM WIDELY, BUT THERE WAS NO RECALL. THIS HAPPENED ON AUGUST 20, 2005. HAD VEHICLE TOWED TO DEALER BECAUSE IT WOULD NOT START IT.*AK
Electrical system, Aug 23, 2005
CAR WAS STARTING & RUNNING FINE ... STOPPED BY MY MOTHER'S HOUSE; CAME OUT, PLACED KEY INTO IGNITION, KEY REFUSED TO TURN. TRIED ALL THE REGULAR TRICKS (TURNIGN THE WHEEL TO THE STOPS, PRESSING BRAKE, CLUTHC, ACCELERATOR, ETC. TO NO EFFECT) CALLED TOWING SERVICE - THEY COULD NOT MAKE THE KEY TURN EITHER AND COMMENTED THAT THIS WAS "COMMON" IN FORD FOCUS. TOWED VEHICLE TO BALISE FORD - AGREED IT'S A COMMON FAILURE BUT THYE HAVE A REDESIGNED PART FROM FORD - THAT IS NOT COVERED BY FORD'S EXTENDED WARRANTLY. OVER $300 TO REPLACE A PART EVERYEN ADMITS TO FAILING FREQUENTLY!
Engine and engine cooling, Aug 22, 2005
DT: CALLER SAID THAT THE VEHICLE STARTED MAKING A CLANKING NOISE. THE VEHICLE STALLED AND WOULD NOT START. VEHICLE WAS ON A ROAD THAT HAD NO EMERGENCY LANE TO PULL OVER. VEHICLE WAS TOWED TO CALLER'S HOUSE, AND WAS STILL LEAKING OIL. A MECHANIC SAID THE ENGINE BLEW OUT. MANUFACTURER SAID THERE WAS NO RECALLS, AND CALLER'S WARRANTY EXPIRED. DEALER SAID TO BRING TO BRING VEHICLE BUT SHE WOULD HAVE TO PAY FOR ANY REPAIRS HERSELF. CALLER HAD A TUNE UP 2 WEEKS AGO. *AK
Electrical system, Aug 18, 2005
MY 2000 FORD FOCUS ZX3 IGNITION SYSTEM WILL NOT TURN. I TRIED EVERYTHING TO GET IT FIXED. AAA SENT A LOCKSMITH OUT AND HER TOLD ME THAT THIS IS THE 10TH FORD FOCUS THIS WEEK WITH THE EXACT SAME PROBLEM. HE SAID HE HAS TO REPLACE THE ENTIRE IGNITION SYSTEM. HE SAID HE HAS DONE OVER 150 IN THE LAST YEAR. I SEARCHED ONLINE AN FOUND OVER 5000 PEOPLE WITH THE EXACT SAME PROBLEM. I CALLED FORD AND THEY ACTED AS IF THEY HAVE NEVER HEARD OF THIS PROBLEM BEFORE. THE FORD FOCUS IS NOTORIOUS FOR RECALLS BUT THIS PROBLEM IS NOT ON THE LIST. I BELIEVE THAT IT SHOULD BE ADDED. FORD FOCUS IGNITION SYSTEM SHE BE RECALLED. *NM
Electrical system, Aug 18, 2005
MY CAR WAS NOT SHOWING SIGNS OF ANY PROBLEMS BEFORE THE INCIDENT. MY 2000 FORD FOCUS ZX3 WAS PARKED IN A LOCAL RESTAURANT PARKING LOT FOR ABOUT 3 HOURS. WHEN I RETURNED TO MY CAR, THE KEY WOULD NOT GO INTO THE IGNITION. WE PLAYED WITH IT ENOUGH TO GET IT IN HALF WAY AND THEN THE WHOLE WAY, BUT THE KEY WILL NOT TURN. I CALLED FOR A RIDE AT 12:00AM BECAUSE A COP INFORMED ME IT WAS MOST LIKELY MY TUMBLER OR IGNITION SWITCH. MY CAR WAS TOWED THE NEXT MORNING FROM THE PARKING LOT. THIS WAS A DIFFICULT PROCESS CONSIDERING MY STEERING WHEEL WAS LOCKED UP AND THEY HAD TO "DRAG" MY CAR TO GET IT ON TO THE FLAT BED. MY IGNITION SWITCH IS CURRENTLY BEING WORKED ON, BUT WE ARE UNABLE TO FIND THE "KEY CODE" TO SET MY TUMBLER. *NM
Electrical system, Aug 18, 2005
IGNITION LOCK CYLINDER FAILURE. I COULD NOT GET THE KEY TO GO IN THE IGNITION. AFTER 1/2 HOUR OF PUSHING, PULLING, ROCKING, TILTING, IN OUT, BACK FORTH, I GOT THE KEY IN. UPON ADVICE OF MY MECHANIC AT WOODY SANDER FORD IN CINCINNATI, OH, I WAS TOLD TO LEAVE THE KEY IN THE IGNITION UNTIL I COULD DELIVER IT TO THEM FOR REPLACEMENT. THEY SAY THE PROBLEM IS VERY COMMON BUT FORD WON'T RECALL BECAUSE IT ISN'T A SAFETY ISSUE. MY WEB RESEARCH SUPPORTS THAT IT IS INDEED VERY COMMON AND FOR MANY PEOPLE A RECURRING PROBLEM. THE CAR IS 5 YEARS OLD WITH 54,627 MILES ON IT. THE REPAIR WAS JUST OVER $200.00. *JB
Engine and engine cooling, Aug 16, 2005
2000 FORD FOCUS DIED WHILE DRIVING AND THE ENGINE LIGHT ILLUMINATED ON THE DASH. *MR *SC CONSUMER WAS TOLD THAT POSSIBLY THE MOTOR NEEDED TO BE REPLACED. *TT
Electrical system, Aug 16, 2005
2000 FORD FOCUS DEVELOPED PROBLEMS WITH THE IGNITION.***NO ANSWER REQUIRED*** *MR THE IGNITION SWITCH HAD TO BE DRILLED OUT AND REPLACED. *SC