2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
248 reports, newest first. Show all
Engine and engine cooling, Jun 12, 2008
ENGINE FAILED AT 109,000. IT THREW A ROD AND DESTROYED THE ENGINE WITH NO WARNING. *TR
Engine and engine cooling, May 26, 2008
THE VALVE COVER GASKET LEAKS PREMATURELY, WHICH CAUSES OIL TO DRIP ONTO THE EXHAUST MANIFOLD. THE BURNING OIL CREATES FUMES. THE POORLY DESIGNED SEALS AROUND INTAKE AIR BOX ALLOW FUMES FROM THE ENGINE COMPARTMENT TO ENTER THE PASSENGER COMPARTMENT. THESE TWO DESIGN FAILURES COMBINE WITH EACH OTHER TO EXPOSE PASSENGERS TO BURNING OIL FUMES. NOW, I HAVE TO REPLACE THE VALVE COVER GASKET TO AVOID EXPOSING MYSELF TO BURNING OIL FUMES. *TR
Engine and engine cooling, May 14, 2008
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE ATTEMPTING TO ACCELERATE AT ANY SPEED, THE VEHICLE HESITATES FOR SEVERAL SECONDS BEFORE EVENTUALLY ACCELERATING. THE FAILURE OCCURS EVERYTIME THE VEHICLE IS DRIVEN. THE VEHICLE HAS NOT BEEN IN ANY CRASHES DUE TO THE FAILURE AND HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 107,000 AND FAILURE MILEAGE WAS 100,000
Engine and engine cooling, May 7, 2008
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STARTED THE IGNITION AND THE VEHICLE MADE A STRANGE NOISE. THE ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE COULD NOT BE DRIVEN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC. THE CURRENT AND FAILURE MILEAGES WERE 125,000.
Engine and engine cooling, Apr 29, 2008
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD BEGIN TO STALL AND THEN SHUT OFF. THE VEHICLE WOULD ALSO STALL AND THEN REGAIN POWER. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS 86,000.
Engine and engine cooling, Fuel system, Other, Electrical system, Mar 28, 2008
I BOUGHT THIS CAR IN JUL07. IN DEC07 STARTED HAVING PROBLEMS WITH CAR SURGING/JOLTING WHILE DRIVING ON HIGHWAY (55-65 MPH) THEN CAR WOULD JUST STALL, COMPLETELY DIE. ENGINE LIGHT WOULD COME ON, NO POWER STEERING NO LIGHTS. I WOULD MANAGE TO GET IT OVER TO THE SIDE OF THE ROAD NARROWLY AVOIDING ACCIDENT AND CAR WOULD NOT START. AFTER SAT FOR ABOUT 10 MINS IT WOULD START. IT WOULD DRIVE OK FOR ABOUT 10-20 MILES AND THEN SURGE AND DIE. IT HAPPENS PERIODICALLY AND IN BETWEEN THE CAR MAY DRIVE FINE FOR WEEKS. SERVICE CENTER CAN'T FIND ANYTHING WRONG WITH IT. IT JUST HAPPENED AGAIN 3-18-08 WHILE I WAS DRIVING ON INTERSTATE AT 65MPH, JOLTED TWICE AND COMPLETELY DIED. I WAS NEARLY KILLED AS A SEMI WAS BEHIND ME AND ANOTHER BESIDE ME. I HAD TO FIGHT THE CAR TO GET IT OFF THE SIDE OF THE ROAD AND NARROWLY MISSED THE SEMI RUNNING UP OVER THE TOP OF ME. AFTER SITTING FOR 10 MIN IT STARTED AGAIN BUT WOULD NOT REACH FULL POWER. I COULD ONLY GET IT UP TO ABOUT 50 MPH, THEN STARTED JOLTING AND DIED AGAIN AFTER ABOUT 6 MILES THIS CONTINUED FOR 30 MILES. ENGINE LIGHT WAS ON. I HAD THAT READ BY ADV AUTO LATER AND IT WAS TWO CODES ONE FOR MASS AIRFLOW SENSOR. IT HAS BEEN IN SERVICE GARAGE SINCE THEN. THEY CAN'T FIND ANYTHING WRONG WITH IT. I DID NOTICE THAT THIS SEEMS TO ONLY BE HAPPENING WHEN IT RAINS. THEY SPRAYED WATER TODAY ON THE FRONT OF THE CAR WHILE IT WAS RUNNING AND IT DIED IN THEIR SHOP. THEY STILL HAVE NO IDEA WHAT IS WRONG WITH IT. IT ALSO HAS A LOUD VIBRATION/NOISE IN FRONT END. MOTOR MOUNTS HAVE BEEN CHANGED, NEW ALTERNATOR, NEW BATTERY, NEW BELT REPLACED DEC 27,07. THE VEHICLE DIED AGAIN FEB 5, 2008 6 TIMES. IT DIES AT ALL SPEEDS AND SOMETIMES STALLS AT STOP LIGHTS/SIGNS. I AM EXTREMELY FRUSTRATED WITH IT AND NEED A RELIABLE CAR TO GET TO WORK AND AM MAKING CAR PAYMENTS ON A CAR THAT HAS BEEN IN THE SHOP 36 DAYS IN THE LAST 90. ALSO VERY CONCERNED ABOUT CAUSING AN ACCIDENT OR KILLING MYSELF, MY KIDS OR SOMEONE ELSE. *TR
Suspension, Engine and engine cooling, Electrical system, Mar 24, 2008, fire
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING APPROXIMATELY 25 MPH AND APPROACHING A TRAFFIC LIGHT, THE BATTERY LIGHT ILLUMINATED. THE CONTACT NOTICED SMOKE COMING FROM THE HOOD AND THEN FLAMES APPEARED. SHE STOPPED AND EXITED THE VEHICLE WHEN IT BECAME COMPLETELY ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENTS ARRIVED AND A REPORT WAS FILED. THE VIN, ENGINE SIZE, AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 52,899. UPDATED 04/11/08 *BF THE DEALER STATED CONSUMER HAD VEHICLE IN A PINCH BOLT TORQUED AND A ZETEC ENGINE CABLE ROUTING. THE DEALER ALSO REPLACED BOTH FRONT COIL SPRINGS. UPDATED 04/11/08 *TR
Engine and engine cooling, Mar 4, 2008
MY DAUGHTER WAS DRIVING AROUND 30 TO 40 MPH AND WHEN SHE HIT OR TAP THE BRAKE THE CAR WOULD VIBRATE AND TRY TO CUT OFF. THE CAR DID CUT OFF AND WOULD NOT START . I TOWED THE CAR TO A SHOP AND FOUND THAT THE VALVE SEAT CAME LOOSE AND FELL ON THE PINIONS, THEREFORE, DESTROYING THE ENGINE. THE VALVE SEAT WAS TOTALLY GONE AND WENT THROUGH THE EXHAUST. FORD MECHANIC RECOMMENDED REPLACING WITH NEW MOTOR AND MANIFOLD PLENUM SINCE THEY WOULD NOT BE ABLE TO GET ALL THE METAL FROM THE VALVE SEAT OUT OF THE PLENUM. I COULD GET A USED MOTOR BUT FOUND OTHER ON THE INTERNET THAT HAD THE SAME PROBLEM, THEREFORE THE PROBLEM COULD HAPPEN AGAIN. *TR
Engine and engine cooling, Fuel system, Gasoline, Feb 8, 2008
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE ENGINE LIGHT WOULD ILLUMINATE AND THE VEHICLE WOULD STALL, STUTTER, SKIP, AND NOT RUN WHEN THE TANK REACHED A QUARTER TANK. INITIALLY, THE CONTACT WAS INFORMED THAT THE CYLINDER HEAD NEEDED TO BE REPLACED. THEN SHE WAS INFORMED THAT THE TIMING BELT, GEAR, PULLEY, AND TENSIONER NEEDED TO BE REPLACED. THE COMPONENTS WERE REPLACED. FINALLY, THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. FORD STATED THAT THE VEHICLE WAS MANUFACTURED TOO LATE TO BE INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE PURCHASE DATE AND SPEED WERE UNKNOWN. THE CURRENT MILEAGE WAS 88,000 AND FAILURE MILEAGE WAS 83,073. UPDATED 03-04-08 *BF\THE FUEL PUMP WAS REPLACED.
Engine and engine cooling, Jan 2, 2008
I AM THE SECOND OWNER OF THIS VEHICLE THE DAY AFTER I PURCHASED THE 2001 FORD FOCUS THE ENGINE LIGHT CAME ON AND I HAD LOSS OF POWER. I TOOK IT BACK TO THE DEALERSHIP AND THEY REPLACED SOME PARTS AND ALSO HAD REPLACED A FEW RECALLED PARTS. THE ENGINE AT THAT TIME HAD 78,000 MILES ON IT. I HAVE OWNED THE CAR FOR A YEAR AND A HALF IT CURRENTLY HAS 128,000 MILES ON IT NOW AND HAD TO REPLACE SERVERAL PARTS WHICH ARE OXYGEN SENSORS CATALYC CONVERTER, STRUTS, SHOCKS AND IDLE PULLEY. I GET MY OIL CHANGES AND TUNE UPS ON A REGULAR BASIS. ONE MORNING WENT TO START MY CAR TO GO TO WORK AND IT WOULD NOT START. IT WAS ACTING AS IF IT HAD RUN OUT OF GAS BUT I HAD OVER A HALF OF TANK OF GAS IN IT. AFTER TRYING TO START IT IT FINALLY STARTED AND WAS MAKING A HORRIBLE RATTLING NOISE IN THE ENGINE. IT RAN FOR ABOUT 15 SECONDS THEN DIED. I LEFT IT ALONE THEN CALLED A TOW TRUCK TO TAKE IT TO AN AUTOREPAIR SHOP AND HAD A DIAGNOSTIC TEST DONE ON IT. I WAS TOLD THAT A BEARING HAD BROKE OFF AND HIT MY THIRD CYLINDER AND SMASHED MY SPARK PLUG. IT ALSO HIT THE PISTON AND THE PISTON WAS CRACKED. THERE WERE NO WARNING SIGNS AND I WOULD NOT HAVE HAD A CLUE THAT THERE WAS ANYTHING WRONG WITH MY CAR. THE AUTO REPAIR PLACE SAID THE I WAS LUCKY THAT IT HAPPENED AT HOME AND NOT WHILE I WAS DRIVING BECAUSE IT COULD HAVE BEEN VERY DANGEROUS. I AM NOW HAVING TO GET A REMANUFACTURED ENGINE COSTING ME $3,300. WHICH I HAVE TO HAVE FINANCED. IS THERE ANY THING THAT I CAN DO?*CN
Engine and engine cooling, Dec 10, 2007
UPPER INTAKE GASKET MANIFOLD. *TR
Engine and engine cooling, Nov 23, 2007
THERMOSTAT HOUSING IS LEAKING. FOUND INTERNAL SEAL WALL CRACKED/WASHED OUT ALLOWING LEAKAGE PAST SEAL RING. STEADY DRIP OF COOLANT FROM THERMOSTAT HOUSING EVEN AFTER REPLACING SEAL RING. FOUND MANY OTHER COMPLAINTS OF SAME PROBLEM IN DISCUSSION THREADS ON INTERNET. COOLANT PUDDLED UNDER CAR WHERE PETS CAN DRINK IT AND LOSS OF COOLANT CAUSING OVERHEATING. *TR
Engine and engine cooling, Nov 21, 2007
EMISSIONS LIGHT WENT ON AND OFF AND THE CAR SEEMED TO MISFIRE. DID NOT DRIVE SMOOTH. I WAS GLAD I WAS CLOSE TO HOME. I FELT THE CAR WOULD CONK OUT WHILE I WAS DRIVING. *TR
Engine and engine cooling, Oct 20, 2007
2001 FORD FOCUS. ORIGINAL OWNER. MAINTAINED. SPARK PLUG BLEW OUT OF CYLINDER. DEALER SUGGESTED MOST EXPENSIVE FIX - NEW CYLINDER HEAD AND SPARK PLUGS. NOT COVERED BY WARRANTY. WILL INSTEAD JUST GET SPARK PLUGS RETHREADED AND TRADE IN CAR ASAP BEFORE ANY OTHER MAJOR ISSUES. CAR LOST POWER. WAS AT A STOP LIGHT AND THEN MADE A RIGHT TURN. LOST POWER AND LOUD EXPLOSIVE NOISES RESULTED ON FREEWAY ACCESS ROAD. POLICE HAD TO COME OUT UNTIL TOW. DANGEROUS SITUATION. *TR
Engine and engine cooling, Sep 5, 2007
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 5 MPH, THE CONTACT HEARD A POPPING NOISE COMING FROM UNDER THE HOOD. SHE THEN NOTICED STEAM RISING FROM THE ENGINE AND THE VEHICLE SHUT OFF. APPROXIMATELY 5 MINUTES LATER, SHE WAS ABLE TO RESTART THE VEHICLE. THE DEALER STATED THAT THE EGR VALVE CAUSED THE FAILURE AND THEY REPLACED THE VALVE AND THE HOSE ASSEMBLY. THE CONTACT STATED THAT THE VEHICLE DROVE ROUGHLY AFTER THE EGR REPLACEMENT. SHE RETURNED TO THE DEALER AND THEY STATED THAT THE ENGINE CAUSED THE FAILURE. AS OF SEPTEMBER 5, 2007, THE DEALER HAD NOT REPLACED THE ENGINE. THE FAILURE AND CURRENT MILEAGES WERE 141,000.
Service brakes, Air, Engine and engine cooling, Fuel system, Gasoline, Fuel system, Other, Tires, Equipment, Aug 22, 2007
BOUGHT NEW IN '01 FORD FOCUS. NOTICED RIGHT OFF BRAKES WOULD MAKE A GRINDING NOISE AND SQUEAK. TIRES WERE WORN REAL BAD ON INSIDE ON ONE FRONT SIZE SINCE WE BOUGHT IT. REPEATED ALIGNMENTS WITH NO IMPROVEMENT. STILL EXPERIENCE THIS PROBLEM. STARTED EXPERIENCING PROBLEMS WITH IT MISSING DURING ACCELERATION. CHECK ENGINE LIGHT CAME ON IN FEBRUARY 2005 AND TOOK IT TO THE DEALERSHIP. THEY REPLACED SENSORS THAT HAD RECALL,WAS RECALL CODE P0401. ENGINE LIGHT STAYED ON. THEY SAID THAT WE WERE USING GAS THAT WAS DIRTY AND WAITING TOO LATE TO PUT GAS INTO THE CAR AND THAT WAS WHY IT WAS STALLING. WE PAID $272.98 FOR THEM TO REPLACE THIS WHOLE SECTION THAT HAD TO DO WITH THE FUEL BEING FILTERED. CAR LOSES POWER AND STUTTERS GOING AROUND CURVES WITH EVEN OVER A HALF A TANK OF GAS. STALLING TO THE POINT WE MUST PULL OVER INTO THE EMERGENCY LANE AFRAID OF ACCIDENT! I OWN CAR I BOUGHT BRAND NEW AND IT JERKS AND SPUTTERS LIKE SOME PIECE OF CRAP FROM JD BYRIDER! EVERYTIME WE START THE CAR YOU SMELL OIL BURNING FOR15 MINUTES AFTERWARDS. HAD IT CHECKED NO LEAKS OR ANYTHING COULD BE FOUND. APRIL OF 2005 NOTICED WHEN THE CAR IDLED AT A TRAFFIC LIGHT THE THERMOSTAT WOULD SHOW SHOOT UP SHOWING IT WAS RUNNING HOT! TOOK IT IN TO THE DEALERSHIP AND THEY FOUND ANTI-FREEZE LEAKING. WAS TOLD THE THERMOSTAT HOUSING AND THERMOSTAT HAD TO BE REPLACED. RETESTED IT AND WAS TOLD PROBLEM SOLVED. OUR BILL WAS $375.00. THIS WAS FIRST BRAND NEW CAR AND WAS TAKEN WELL CARE OF, IT ONLY HAS AROUND 78,000 MILES ON THE ODOMETER. I WAS TOLD THERE WAS A SILENT RECALL ON THESE FOR THE ENGINE PROBLEMS AND THEY WERE BEING FIXED FOR NO COST TO THE OWNER. WE WERE NOT NOTIFIED OF A RECALL AND PAID FOR ALL OF THIS OUT OF POCKET .CAR IS PAID OFF NOW AND CANNOT ENJOY HAVING A PAID OFF CAR WITH LOW MILEAGE BECAUSE WE ARE SCARED TO DRIVE IT AND BOUGHT A NEW CAR THAT WAS SAFE TO DRIVE AROUND WITH OUR KIDS! TIME GOES ON AND IT IS GETTING WORSE. SOMETIMES NOT WANTING TO START AT ALL! ENGINE STILL STALLS DESPITE ALL THESE REPAIRS. *TR
Engine and engine cooling, Aug 1, 2007
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 25 MPH, THE VEHICLE BEGAN TO MAKE A LOUD RATTLING NOISE. THERE WERE NO WARNING INDICATORS OR PRIOR FAILURES. THE CONTACT DROVE APPROXIMATELY 1/2 MILE TO HER RESIDENCE. THE MECHANIC STATED THAT THE BOTTOM PISTON FAILED IN THE ENGINE. THE CURRENT AND FAILURE MILEAGES WERE 93,000.
Engine and engine cooling, Aug 1, 2007
WHILE DRIVING ON AN INTERSTATE HIGHWAY THE CAR BEGAN TO SURGE AND LOOSE POWER. EVENTUALLY THE CAR STALLED COMPLETELY. THIS HAPPENED WHILE TRAVELING IN NORMAL CONDITIONS AT ~65MPH. THE DATE GIVEN IS THE MOST RECENT OCCURRENCE. THIS SAME SITUATION OCCURRED ONCE BEFORE ~1 YEAR AGO UNDER THE EXACT SAME CONDITIONS. ENGINE SURGE HAS BEEN A PERSISTENT PROBLEM WITH THE VEHICLE SINCE IT WAS NEW (~6 YEARS). *TR
Engine and engine cooling, Jul 19, 2007
PUDDLE OF COOLANT ON DAILY BASIS. SLOW BUT CONTINUOUS LEAK. HAD TO HAVE THERMOSTAT HOUSING REPLACED. PART MADE OF PLASTIC RATHER THAN METAL. *JB
Engine and engine cooling, May 14, 2007
I OWN A FORD FOCUS 2001,ZX3 FOR 59,000. THE CHECK ENGINE LIGHT CAME ON 6 TIMES NOW! 2 FOR A DPFE SENSOR OUT, 2 FOR EGR PRESSER VALVE. ALSO STARTED TO STALL,BUCK AND SURGE AT 35,000 MILES, AND FOUND OUT THE FDM HAD TO BE REPLACED. THAT LASTED FOR A SHORT TIME WHICH THE SYMPTOMS CAME BACK, AND THE FDM WAS REPLACED AGAIN. I HAVE HAD TO DEAL WITH INCONVENIENCE AND THE LAST REPAIR WHICH WAS DPFE SENSOR WHICH FORD PICKED UP 50% OF COST BUT THIS CAR IS A LEMON! I ALSO HAD TO REPLACE THE IGNITION SWITCH WHEN THE KEY WOULD NO LONGER GO IN.NOW THE CHECK ENGINE LIGHT IS ON YET AGAIN AND I HAVE TO GO BACK TO BOB BAKER FORD. *AK
Engine and engine cooling, Fuel system, Gasoline, Electrical system, Apr 10, 2007
TL* - THE CONTACT OWNS A 2001 FORD FOCUS WITH A CURRENT AND FAILURE MILEAGE OF 140,000. THE CONTACT STATED THAT SHE WAS DRIVING 55 MPH ON A HOT DAY AND THE VEHICLE WOULD SPUTTER AND LOSE ACCELERATION , THEN LOST POWER. THE CONTACT STATED THAT THE ENGINE WOULD STALL, BUT THE CAR WOULD STILL BE DRIVING UNTIL THE CONTACT APPLIED THE BRAKES. THE CONTACT HAD THE MECHANIC CHANGED THE SPARK PLUGS, WIRES, AND FUEL FILTER, BUT THE PROBLEM PERSISTED. THE CONTACT CALLED THE MANUFACTURER, AND THEY TOLD HIM TO TAKE IT TO THE FORD DEALER TO GET IT DIAGNOSED. THE MECHANIC STATED THAT IT WAS A FAILURE IN THE FUEL DISTRIBUTION SYSTEM, BUT THE PARTS WERE ON NATIONWIDE BACK ORDER. *AK
Engine and engine cooling, Visibility, Feb 21, 2007
TL* - THE CONTACT OWNS A 2001 FORD FOCUS ZX3. THE CONTACT PURCHASED THE VEHICLE ,AND TWO WEEKS LATER THE HEAT STOPPED WORKING. THE CONTACT STATED THAT SHE TOOK THE VEHICLE TO THE DEALER FOR REPAIRS, AND THEY DID AN INCOMPLETE REPAIR JOB. THE DEALER GOT THE HEAT TO WORK BUT IT ONLY WORKED WHEN THE CONTACT TURNED THE HEAT ON HIGH. THE CONTACT STATED THAT ON A REALLY BAD SNOW DAY SHE SMELLED RUBBER BURNING AND TURNED THE HEAT OFF AND OPENED THE WINDOW. SHE HAD TO SHUT THE WINDOW AND TURN THE HEAT BACK ON, AND WHEN SHE DID FUMES BEGAN TO GATHER IN THE VEHICLE, AND THE ENTIRE VEHICL WAS FILLED WITH SMOKE. THE CONTACT CONTINUED TO DRIVE HOME WHEN THE CAR SHUT DOWN ENTIRELY. FORD AND TOYOTA GAVE HER THE RUN AROUND CONCERNING REPLACING THE VEHICLE AND A TRADE IN. THE CONTACT WAS INSTRUCTED TO CONTINUE USING THE VEHICLE WHILE A TRADE IN WAS BEING NEGOTIATED. WHEN THE CONTACT WENT TO SIGN NEGOTIATION PAPERS SHE WAS DECLINED. *AK THE CONSUMER STATED AFTER PICKING UP THE VEHICLE, ALL THE LIGHTS ILLUMINATED, THE CONSUMER WAS TOLD IT WAS FIXED. THE SALESMAN TEST DROVE THE VEHICLE AND IT CUT OFF IN THE MIDDLE OF THE STEET. UPDATED 03/30/07. *JB
Engine and engine cooling, Feb 7, 2007
AT SEEMINGLY RANDOM TIME MY 2001 FORD FOCUS ZX3 STALLS. SO FAR THE STALL HAS ONLY HAPPENED WHEN AT A STOP, BUT SPUTTERING AND LOSS OF POWER RANDOMLY AT HIGHWAY SPEEDS HAS ME WORRIED ABOUT AN EMINENT STALL. I HAVE HAD THE FUEL FILTER CHANGED AS WELL AS THE EGR VALVE AND EGR PRESSURE FLOW SENSOR AND NOTHING HAS SOLVED THIS PROBLEM. *MN
Engine and engine cooling, Oct 17, 2006
CRACKED THERMOSTAT HOUSING. I RECENTLY NEEDED TO HAVE THE PLASTIC THERMOSTAT HOUSING REPLACED ON MY FOCUS, AS IT WAS CRACKED AND LEAKING. I HAVE BEEN RESEARCHING ON THE WEB AND FOUND NUMEROUS OTHER ENTRIES REGARDING THE PROBLEM. I HAVE NOT SEEN A RECALL OR ANY INFO REGARDING IF THERE IS A SYSTEMATIC FAILURE OF THE PART. I HAVE THE PART IF NEEDED FOR RESEARCH. *NM
Engine and engine cooling, Electrical system, Aug 29, 2006, fire
DT: THE CONTACT STATED WHILE DRIVING 35 - 40 MPH, THE CHECK ENGINE LIGHT AND BATTERY LIGHT ILLUMINATED. WHILE PULLING THE VEHICLE INTO A PARKING LOT ALL THE DASHBOARD LIGHTS DARKENED AND THE VEHICLE HESITATED AS IF IT WAS GOING TO STALL. IT WAS PARKED FOR ABOUT 3 MINUTES AND THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS OBSERVED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT A BARREN CAME OUT OF ONE OF THE PULLEYS HOWEVER THAT WOULD NOT CAUSE THE VEHICLE TO STALL. THE VEHICLE WAS LEFT AT THE SCENE OF THE INCIDENT. TWO DAYS LATER THE CONTACT RETURNED TO THE VEHICLE AND THE VEHICLE WAS BURNED. THE INSURANCE INVESTIGATOR OBSERVED A SECURITY VIDEO WHICH IDENTIFIED THE VEHICLE SMOKING AND A WINDOW HAD FALLEN.