2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints: fuel system
297 reports, newest first. Show all
Fuel system, Gasoline, Apr 5, 2007
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THIS VEHICLE IS PERFORMED SIMILAR TO THE INFORMATION FOUND IN NHTSA RECALLM CAMPAIGN # 03V482000. THE FORD MANUFACTURER STATED THAT THIS VEHICLE WAS EXCLUDED FROM THE RECALL. THE CURRENT AND FAILURE MILEAGE WERE 61,000.*AK
Fuel system, Gasoline, Feb 16, 2007
DRIVING ON HIGHWAY, 45 MPH...5:30 AM MST...NO INDICATION OF ANY PROBLEM. VEHICLE DRIVING SMOOTHLY, NO SPUTTERS AND NO INDICATOR LIGHTS. DROVE MY SON TO HIS WORKPLACE APPROXIMATELY 20 MILES AND ON THE WAY HOME, VEHICLE SIMPLY STALLED, JERKED AND AS I STEPPED ON THE GAS....NOTHING. CARS SWERVED AROUND ME AS I STRUGGLED TO PULL OFF TO THE RIGHT. I WAS NEARLY HIT BY THREE DIFFERENT VEHICLES. IT WAS VERY DARK AND I WAS ALONE IN THE CAR. I MANAGED TO WALK TO A GAS STATION/STORE AND CALLED MY DAUGHTER. HER HUSBAND HELPED ME TOW THE VEHICLE TO KEARNS AUTO CENTER NEAR WHERE THE CAR HAD STALLED. THE FUEL PUMP HAD TO BE REPLACED. MANAGER ADVISED THAT THE FUEL PUMP SHIELD WAS A 2002 ADDITION, EVEN THOUGH VEHICLE WAS SOLD AND MANUALS DISTRIBUTED WAS FOR A 2001 FORD FOCUS. THE SHIELD HAD ALLOWED GAS TO LEAK UNTIL IT TOTALLY DESTROYED THE FUEL PUMP ITSELF. THERE WAS NO DISCLOSURE, VEHICLE WAS BOUGHT BRAND NEW WITH 8 MILES SHOWING. MANUAL AND CARE SCHEDULE WAS FOR THAT OF A 2001. VEHICLE MILEAGE AT THE TIME OF INCIDENT WAS 47,312 MILES...FORD CUSTOMER SERVICE, AND TWO DEALERS IN THE SALT LAKE CITY AREA WERE NOTIFIED OF THE SITUATION, NONE HAVE RESPONDED. *NM
Fuel system, Gasoline, Dec 21, 2006
CONTINUALLY STALLING OF THE ENGINE VEHICLE WHILE DRIVING, HARD TO START AS IT WILL STALL DURING STARTUP. IT BEGAN JUST STALLING FOR A SECOND ABOUT ONCE A WEEK AT THE MOST. NOW WHEN I DRIVE IT, IT DOES IT ABOUT EVERY 10 SECONDS. IT HAS LEAD TO MY CAR FAILING TO SPEED UP, THE ENGINE KICKING AND STALLING WHILE DRIVING AND THE CAR ALTOGETHER FAILING TO DRIVE WHILE ON A BUSY HIGHWAY. IT IS NOW NEARLY UNDRIVABLE. THE CAR WILL BE LOOKED AT IN THE FOLLOWING WEEK BUT FORD SAYS THAT WHILE THEY HAVE RECALL FOR THE PROBLEM ON THE SAME YEAR AND MODEL OF VEHICLE, IT DOES NOT INCLUDE MY VEHICLE BECAUSE OF THE MANUFACTURED DATE. *JB
Fuel system, Gasoline, Nov 10, 2006
AS IN NHTSA CAMPAIGN ID # 03V482000, MY 2001 FORD FOCUS STALLS WHEN THE FUEL TANK IS LESS THAN 1/3 FULL, THE VEHICLE IS ACCELERATING, AND TURNING TO THE RIGHT. FORD WILL NOT FIX THE PROBLEM BECAUSE THEY CLAIM TO HAVE REACHED A SOLUTION ON VEHICLES ASSEMBLED AFTER JUNE 13, 2001. MY VEHICLE WAS ASSEMBLED JUNE 19, 2001. SINCE IT EXHIBITS THE SAME SYMPTOMS, THEY HAD NOT CORRECTED THE PROBLEM BY JUNE 13, 2001. ACCORDING TO NHTSA DOCUMENTS FORD DIDN'T START INSTALLING REDESIGNED FUEL PUMPS UNTIL SOMETIME IN 2004. NHTSA SHOULD REQUIRE FORD TO EXTEND THE PROGRAM TO ALL FOCUS VEHICLES THAT USED THE POORLY DESIGNED FUEL PUMP AND DISPLAY FAILURE SYMPTOMS. *NM
Fuel system, Gasoline, Sep 8, 2006
DT*: THE CONTACT STATED WHEN THE VEHICLE WAS STARTED, THE ENGINE STALLED COMPLETELY. THE VEHICLE WAS RESTARTED, AND STALLED A SECOND TIME. THE VEHICLE WAS SHIFTED INTO PARK, AND WOULD NOT START BACK UP FOR 3 DAYS. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE IT WAS DETERMINED THAT THE FUEL PUMP HAD FAILED. THERE WAS A NHTSA RECALL# 03V482000 WHICH PERTAINED TO THE GASOLINE FUEL SYSTEM. THE FUEL DELIVERY MODULE HAD PREVIOUSLY BEEN REPLACED 3 TIMES WITH NO SUCCESS. THE MANUFACTURER WAS ALSO NOTIFIED, WHO INFORMED THE CONTACT THAT THERE WAS NOTHING THAT COULD BE DONE.
Fuel system, Gasoline, Sep 5, 2006
DT*: THE CONTACT STATED THE VEHICLE'S FUEL PUMP HAD FAILED 4 TIMES, WHICH CAUSED A LOSS OF POWER FOLLOWED BY STALLING. THE CONTACT MENTIONED RECALL NUMBER 03V482000 (FORD RECALL 03N01), FOR THE FUEL FILTER, BUT DID NOT CONTACT THE MANUFACTURER TO SEE IF THE VIN WAS INCLUDED.
Fuel system, Gasoline, Aug 31, 2006
I HAVE A 2001 FORD FOCUS -- CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES LEADED TO STALLING AND OTHER RELATED SYMPTOMS. THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING. STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL. *NM
Fuel system, Gasoline, Aug 4, 2006
WE OWN A 2001 FORD FOCUS. FOR SEVERAL YEARS WE HAVE BEEN CHASING A FUEL SYSTEM OR ELECTRONIC SYSTEM BUG IN-WHICH THIS CAR FOR SOME REASON STALLS. OUR FORD DEALER HAS BEEN CHECKING THE SPARK, FUEL INJECTOR AND OTHER SYSTEMS LOOKING FOR THE STALLING ISSUE. IT SEEMS LIKE IT WOULD STALL ONLY WHEN YOU TEEN DRIVERS WERE BEHIND THE WHEEL, ONLY HAPPENS IN THE SUMMER AND ALWAYS ON CROWDED HIGHWAYS IN RUSH HOUR TRAFFIC. TUESDAY WE GOGGLED FORD FOCUS FUEL PUMP AND FOUND THAT FORD WON A LAWSUIT NOT TO RECALL 2000-2002 FOCUS FOR STALLING ISSUES RELATED TO THE FUEL SYSTEM. WE ARE SHOCKED THAT FORD WOULD PUT THAT MANY DRIVERS AT RISK. THE FOCUS BEING A CHEAP SMALL CAR IS DRIVEN BY MOSTLY YOUNG INEXPERIENCED DRIVERS. MY KIDS HAVE HAD THIS CAR STALL SEVERAL TIMES ON THE BUSY INTERSTATE AROUND MILWAUKEE AND GREEN BAY. OUR LOCAL DEALER REPLACED THE BAD PARTS N/C BUT THE POINT IS THAT LIVES WERE PUT AT RISK. IF A FOCUS IS RUN OVER BY A SEMI BECAUSE OF STALLING OUT IN TRAFFIC, WHO WOULD KNOW THE REAL ISSUE OR BE ABLE TO RECREATE THE CIRCUMSTANCES THAT LEAD TO THE ACCIDENT. THE LITTLE CAR AND DRIVER WOULD BE CRUSHED. *JB
Fuel system, Gasoline, Jul 18, 2006
VEHICLE STARTS SURGING AND LOSING POWER 2 DAYS LATER, VEHICLE STALLS IN LEFT TURN LANE AND CONTINUES AT EVERY STOP(I HAVE TO DOUBLE PEDDLE TO KEEP VEHICLE RUNNING). FOUND RECALL ON NHTSA WEBSITE TAKE VEHICLE TO DEALERSHIP HOWEVER, I AM TOLD THAT MY VEHICLE DOESN'T FALL UNDER NHTSA: 03V482000. I AM FILING THIS COMPLAINT TO HAVE THE PLANT MY VEHICLE WAS BUILT IN TO BE RE-EVALUATED I AM HAVING THE SAME EXACT PROBLEM THAT THE RECALL DESCRIBES. *NM
Fuel system, Gasoline, Jul 1, 2006
VEHICLE STALLS UNDERWAY DUE TO CLOGGED FUEL FILTER. I HAVE REPLACED THE FUEL FILTER THREE TIME IN THE LAST 10,000 MILES. APPEARS TO BE CLOGGED WITH BLACK MATERIAL. BELIEVE THIS COULD BE RELATED TO EA02022. THIS LAST TIME MY 17 YR OLD WAS THE DRIVER. *NM
Fuel system, Gasoline, May 15, 2006
I HAVE A 2001 FORD FOCUS ZX3. MY WIFE AND I WERE ON A CROSS-COUNTRY MOVE FROM MICHIGAN TO ARIZONA. WE WERE IN NEW MEXICO (IN THE MIDDLE OF THE DESERT) WHEN THE VEHICLE BEGAN TO JERK/PULSE AT 70 MPH, AND THEN THE VEHICLE PROCEEDED TO STALL. ALL VITAL SYSTEMS WERE FINE. OIL WAS OKAY. WE HAD A LITTLE MORE THAN HALF A TANK OF GAS. THE ENGINE WAS NOT OVERHEATING. WE PROCEEDED TO DRIVE AT 35 MPH TO THE CLOSEST FORD DEALERSHIP WHICH WAS JACK KEY, IN DEEMING, NEW MEXICO. THEY DID A DIAGNOSTIC, AND CAME TO THE CONCLUSION THAT IT WAS THE FUEL PUMP AND FILTER. THEY WERE ABLE TO REPAIR THE VEHICLE, BUT WE HAD TO STAY IN TOWN OVERNIGHT. AFTER THE INCIDENT, I THOUGHT THAT IT WAS A LITTLE BIT BAZAAR THAT A CAR LESS THAN TEN YEARS OF AGE WOULD LOOSE IT'S FUEL PUMP AND IT HAD JUST OVER 78,000 MILES ON THE CAR. I BEGAN TO DO SOME OF MY OWN RESEARCH AND FOUND THAT MY VEHICLE WAS MANUFACTURED IN AUGUST OF 2001. IN JUNE OF 2001, THEY STARTED TO CHANGE THE FUEL PUMPS. SO ANY CAR MADE BEFORE JUNE WAS RECALLED, BUT HOWEVER, MINE WAS NOT SINCE THE CAR CAME OFF THE LINE IN AUGUST. SO, NICELY ENOUGH, I'M LEFT WITH A HEFTY BILL...AND IF IT WAS MADE ONLY 2 MONTHS EARLIER, FORD WOULD HAVE REPLACED THE PART FOR FREE. MAYBE FORD DIDN'T WEED OUT ALL OF THEIR ISSUES WITH THE 2001 FUEL PUMP?? *JB
Fuel system, Gasoline, Apr 13, 2006
2001 FOCUS FUEL PUMP FAILED. *TS THE FUEL PUMP FAILED WHILE THE VEHICLE WAS BEING DRIVEN AND HAD TO BE TOWED TO THE DEALER. THE SERVICE DEPT MANAGER SHARED A RECALL WITH THE CONSUMER WHICH WAS GIVEN TO THEM JAN 2004 REGARDING A RECALL OF THE FUEL PUMP. THE CONSUMER NEVER RECEIVED THAT RECALL NOTICE. THE DEALER REPLACED THE FUEL PUMP FREE OF CHARGE. THE CONSUMER REQUESTED REIMBURSEMENT. *NM
Fuel system, Gasoline, Mar 31, 2006
DT*: THE CONTACT STATED WHILE DRIVING 65MPH UPHILL, THE VEHICLE HESITATED AND OPERATED AT A REDUCED SPEED. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. THE DEALERSHIP DETERMINED THE FUEL DELIVERY MODULE WAS BLOCKING THE FLOW OF FUEL TO THE ENGINE. THERE IS A NHTSA RECALL, # 03V482000, REGARDING THE FUEL SYSTEM. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
Engine and engine cooling, Fuel system, Gasoline, Mar 14, 2006
DT*: THE CONTACT STATED WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE VEHICLE STALLS. AFTER ONE HOUR THE VEHICLE RESTARTS. THE DEALER REPLACED THE FUEL PUMP, FUEL FILTER, CAM, OXYGEN SENSOR, FUEL SENSOR, FUEL LINE, COIL TECH, AND VACUUM HOSE; HOWEVER THIS DID NOT REMEDY THE PROBLEM.
Fuel system, Gasoline, Mar 3, 2006
2001 FOCUS FAULTY FDM WAS REPLACED. THIS CAUSED VEHICLE TO HESITATE, SURGE, STUTTER, AND LOSE POWER DURING ACCELERATION. *TS ***NAR*** THE CONSUMER DISCOVERED A RECALL HAD BEEN ISSUED, BUT WAS TOLD HIS VEHICLE WAS NOT INCLUDED. THE CONSUMER LATER DISCOVERED HIS VEHICLE WAS MANUFACTURED AT THE EXACT PLANT THAT WAS INCLUDED IN THE RECALL. *JB
Fuel system, Gasoline, Feb 28, 2006
TOOK VEHICLE IN FOR REPLACEMENT OF FUEL PUMP THAT WAS ON RECALL PROGRAM NUMBER 03N01 DUE TO HAVING THE VEHICLE STALL ON ME TWICE IN A SINGLE DAY. DEALERSHIP DID REPLACE FUEL PUMP BUT STATED THE STALLING PROBLEM WAS DUE TO THE PVC VALVE WAS COLLAPSE AND SHUTTING OFF THE AIR SUPPLY TO THE ENGINE. THAT HAD TO BE REPLACE AT MY EXPENSE AT A COST OF OVER $200. *NM
Fuel system, Gasoline, Jan 20, 2006
DT*: THE CONTACT STATED THE VEHICLE SHUTS OFF WHILE DRIVING. THERE ARE NO WARNING LIGHTS AND THIS OCCURS AT VARIOUS SPEEDS. AN INDEPENDENT REPAIR SHOP DETERMINED THE FUEL PUMP NEEDS TO BE REPLACED. THE CONTACT RECEIVED A RECALL LETTER, #03V482000, FOR THE FILTER IN THE FUEL DELIVERY MODULE. THE RECALL WORK HAS NOT BEEN PERFORMED, BECAUSE THE DEALERSHIP INSPECTED THE VEHICLE AND DETERMINED THIS VEHICLE IS NOT HAVING THE PROBLEM ASSOCIATED WITH THE RECALL. *NM
Fuel system, Gasoline, Dec 30, 2005
I OWN A 2001 FORD FOCUS THAT I PURCHASED IN NOV. OF 2001. I HAVE HAD INTERMITTENT STALLING PROBLEMS WITH THIS CAR STARTING ABOUT 2 YRS AGO. I HAVE REPLACED FUEL FILTER, SPARK PLUGS ETC ASSUMING THESE WERE THE CAUSES OF THE PROBLEM. ABOUT 2 WEEKS AGO, I WAS DRIVING ON I-90 IN NEW YORK STATE WHEN THE CAR SUDDENLY STALLED WHILE DRIVING AT ABOUT 65 MPH. I WAS FORCED TO PULL OFF THE ROAD FROM THE PASSING LANE WITH A TRACTOR TRAILER BEHIND ME. FORTUNATELY, THAT DRIVER WAS ABLE TO AVOID ME. I WAS ABLE TO LIMP OFF THE ROAD AT AN EXIT ABOUT 1/4 MILE DOWN THE ROAD. I FILLED THE CAR WITH GAS AND THE SYMPTOMS WENT AWAY. THE CAR WAS BELOW 1/4 TANK OF GAS AT THE TIME. I HAVE HAD ONE MORE EPISODE OF THIS PROBLEM A FEW MONTHS AGO ON ANOTHER TRIP (ALSO BELOW 1/4 TANK OF GAS). I FILLED THE CAR WITH GAS AND CHANGED THE SPARK PLUGS AT THAT TIME. HOWEVER, THAT SITUATION DID NOT INVOLVE A NEAR MISS OF AN ACCIDENT. IN MY RESEARCH OF THE PROBLEM, I DISCOVERED THIS IS A COMMON PROBLEM WITH FORD FOCUS VEHICLES. MY CAR WAS MADE IN THE "INTERIM PERIOD" MENTIONED ON THE NHTSA WEBSITE. I CONTACTED FORD'S CUSTOMER SERVICE LINE, BUT WAS TOLD MY VEHICLE WAS NOT INVOLVED IN THE SERVICE BULLETIN ALTHOUGH MY SYMPTOMS SEEM TO BE IDENTICAL. I TYPICALLY KEEP MY TANK FILLED EXCEPT ON LONGER TRIPS WHICH PROBABLY HID THE SYMPTOMS UP TO THIS TIME. AT THIS POINT, IT APPEARS THAT THE FUEL PUMP WILL NEED TO BE REPLACED. *JB
Fuel system, Gasoline, Exterior lighting, Dec 14, 2005
DT: CONTACT COMPLAINED ABOUT A FUEL INJECTION SYSTEM PROBLEM. WHEN THE CAR CAME TO A FULL STOP THE ENGINE TURNED OFF. AN INDEPENDENT MECHANIC ADVISED THE CONTACT TO TAKE THE CAR TO THE DEALER, WHICH SHE HAS NOT DONE. ADDITIONALLY, THE TURNING LIGHTS WERE NOT RETURNING TO THE ORIGINAL POSITION WHEN USED. SHE PURCHASED THE CAR FROM A FAMILY MEMBER. THEREFORE, SHE DID NOT KNOW THE DEALER'S NAME.*AK
Fuel system, Gasoline, Oct 20, 2005
THERE IS A RECALL PROGRAM ON THE 2001 FORD FOCUS THAT I OWN WHICH I WAS NOTIFIED OF IN WRITING BY LETTER. (03N01) THE LETTER STATES THAT THE FUEL PUMP IS FAULTY AND NEEDS TO BE REPLACED IF THE CAR IS EXHIBITING STALLING, SPUTTERING, CUTTING OFF, ETC. MY CAR DID ALL OF THOSE THINGS. THE LETTER ALSO STATES THAT THE REPAIR SHOULD TAKE 1/2 DAY. WHEN I TOOK THE CAR TO BE REPAIRED THE DEALERSHIP DID NOT ACKNOWLEDGE THAT THERE IS A PROBLEM AND REPAIRED SOMETHING TOTALLY DIFFERENT AT MY EXPENSE DESPITE THE FACT THAT I HAVE A LETTER. THE REPAIR THEY DID ALSO TOOK 4 DAYS. I WAS OUT OF POCKET FOR THE REPAIR. THE CAR IS NOW STALLING AND CUTTING OFF CONSTANTLY PUTTING MY FAMILY AND MYSELF IN A GREAT DEAL OF DANGER. I CALLED THE NUMBER ON THE LETTER I RECEIVED ABOUT THE RECALL. THE REPRESENTATIVE NAMED MOHAMMED WAS OF NO ASSISTANCE TELLING ME THAT I NEEDED TO HAVE THE PROBLEM DIAGNOSED AT THE DEALERSHIP. I EXPLAINED TO HIM THAT I DID ALREADY TAKE THE CAR AND HAVE IT DIAGNOSED WITH THE SYMPTOMS DESCRIBED ON THE LETTER PAID FOR THE REPAIR THAT WAS DONE THOUGH THE DEALERSHIP REFUSED TO REPLACE THE FUEL PUMP. I AM AFRAID THAT IF THE CAR IS NOT REPAIRED SOON, AT FORD'S EXPENSE THERE IS THE POSSIBILITY OF DANGER TO MY FAMILY OR MYSELF. LYNDON, MOHAMMED'S SUPERVISOR ALSO SPOKE WITH ME AND REPEATED THE SAME THINGS I TOLD HIM OVER AND OVER OFFERING NO ASSISTANCE. *NM
Fuel system, Gasoline, Oct 17, 2005
DT: THE CONTACT OWNS A 2001 FORD FOCUS. THERE IS NHTSA RECALL 03V482000 REGARDING THE FUEL SYSTEM FOR THIS YEAR, MAKE, AND MODEL VEHICLE, BUT THIS VEHICLE IS NOT INCLUDED IN THE RECALL. . HE EXPERIENCED LOSS OF POWER WHILE DRIVING. THE VEHICLE STALLED FOUR TIMES. THERE WAS HESITATION AND A VIBRATION WITH BEFORE IT LOST POWER. THE VEHICLE STALLED APPROXIMATELY 50 TIMES BEFORE THE CONTACT COULD ACTUALLY DRIVE THE VEHICLE AFTER IT WAS PARKED. THIS USUALLY HAPPENED AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT. BUT IT DOES HAPPEN SOMETIMES AT RANDOM. NO WARNING LIGHTS ILLUMINATED, INDICATING THAT THERE IS A PROBLEM WITH THE VEHICLE. . THE SERVICE DEALER STATES THAT THERE IS NOTHING WRONG WITH THE VEHICLE AND CAN NOT OFFER ANY ASSISTANCE. THE MANUFACTURER SAID THAT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL BECAUSE IT HAD A DIFFERENT FUEL DELIVERY SYSTEM. THEY REFERRED HIM TO THE DEALERSHIP TO HAVE THE VEHICLE REPAIRED AT HIS OWN COST. *AK
Engine and engine cooling, Fuel system, Gasoline, Oct 14, 2005
EVENTS LEADING UP TO THE FAILURE: CHECK ENGINE LIGHT CAME ON HAS NEVER GONE OFF SINCE, HIGHLY INCREASED RUNNING NOISE, ENGINE HESITATION THAT AT HIGHWAY SPEED IT CAUSES THE WHOLE CAR TO JERK FAILURE: I TOOK THE CAR IN AND THEY TOLD ME I NEEDED A NEW HEAD THAT FORD HAD REDESIGNED A NEW ONE AND IT WOULD COST $1000. THE ONE I CURRENTLY HAVE DEPOSITS CARBON AND WILL KEEP DOING SO UNTIL IT EVENTUALLY GIVES OUT. THE THING THAT IRKS ME IS FORD OBVIOUSLY KNEW THERE WAS A DESIGN FLAW IF THEY DESIGNED A NEW ONE, THEREFORE I FEEL THEY SHOULD BE COVERING THIS. CORRECTIONS: NONE, CANNOT AFFORD. WILL HAVE TO DRIVE IT UNTIL THE CAR GIVES OUT.
Fuel system, Gasoline, Oct 12, 2005
WAS DRIVING VEHICLE HOME EARLY IN THE MORNING OF THE 12TH WHEN I HEARD A LOUD CLUNK, AND THEN THE SOUND OF SOMETHING DRAGGING UNDER MY CAR. I PULLED OVER TO SEE MY GAS TANK HAD FALLEN OUT AND WAS BEING DRAGGED UNDER THE CAR. ANOTHER CAR PULLED UP BEHIND ME BECAUSE HE HAD SEEN SPARKS COMING FROM THE MOUNTING BRACKET AS IT WAS BEING DRAGGED ALONG WITH THE TANK. A POLICEMAN ALSO PULLED UP BEHIND ME AND LOOKED AT THE CAR, THEN HELPED ME MOVE IT OUT OF THE STREET. LATER THAT MORNING MY FATHER TEMPORARILY WIRED THE GAS TANK TO THE FRAME SO WE COULD BRING THE CAR HOME. HE PUT IT UP ON RAMPS AND LOOKED UNDERNEATH TO SEE THAT THE BOLT WHICH HELD THE GAS TANK IN PLACE HAD STRIPPED COMPLETELY OUT. HE SPENT THE NEXT 3 HOURS REMOUNTING THE TANK. IT WAS A BLESSING THAT THE SPARKS FROM THE BROKEN FRAME DID NOT IGNITE THE GAS TANK. IF IT HAD, MY CAR COULD HAVE EITHER CAUGHT ON FIRE OR BLOWN UP AND I COULD HAVE BEEN SERIOUSLY INJURED OR KILLED. *NM
Suspension, Fuel system, Gasoline, Oct 11, 2005
2001 FORD FOCUS PROBLEMS PROBLEM 1 - IN THE PAST, WHENEVER I WOULD TRANSITION BETWEEN FREEWAYS, MY CAR WOULD BEGIN TO STALL. I PUSH THE GAS PEDAL, AND NOTHING WOULD HAPPEN FOR AT LEAST 10 - 15 SECONDS. IT HAPPENED MOSTLY ON A CIRCULAR ON RAMP. AND I THINK THIS PROBLEM LEAD TO THE NEXT ISSUE. PROBLEM 2 - I HAD TO REPLACE THE FUEL PUMP (WHICH WAS EXPENSIVE). I THINK THIS ISSUE HAPPENED DUE TO THIS STATEMENT I READ "NHTSA INVESTIGATORS SAID THE ALLEGED ENGINE STALL PROBLEM MAY BE CAUSED BY DEBRIS ACCUMULATING IN THE GAS TANK, BLOCKING FUEL FROM BEING DELIVERED TO THE ENGINE." EVENTUALLY, THIS "DEBRIS" PROBLEM CAUSES STRAIN ON THE FUEL PUMP. AND NOW, MY CHECK ENGINE LIGHT CAME ON. I CHECKED THE ISSUE, AND THEY SAID IT'S A GAS VAPOR LEAK OR SOMETHING TO THAT AFFECT. THEY TOLD ME TO KEEP AN EYE OUT FOR A GAS LEAK. THAT ISSUE MAYBE FROM THE MECHANIC WHO FIXED IT, BUT IF FORD WOULD HAVE PUT A RECALL FOR THAT ISSUE, I WOULDN'T BE HAVING THIS PROBLEM. PROBLEM 3 - I TOOK MY FOCUS INTO FORD TO GET A "BUZZING" SOUND CHECKED OUT. THEY FIXED THE BEARING PROBLEM BECAUSE MY CAR WAS UNDER WARRANTY. NOW, 2 YEARS LATER, THE SOUND IS BACK. I READ A STATEMENT "...A REAR-WHEEL BEARING FAILURE THAT COULD LEAD TO A WHEEL FALLING OFF..." I AM AFRAID THAT THIS NOISE I HEAR TODAY IS DUE TO THAT SAME PROBLEM 2 YEARS AGO. I CALLED FORD AND THEY TOLD ME IT WAS GOING TO COST ME CLOSE TO $400 TO REPAIR IT. FIRST OF ALL, THAT'S A LOT OF MONEY TO ME. SECONDLY, I'M VERY AFRAID FOR THE SAFETY OF MY WIFE. I'M AFRAID SOMETHING MIGHT HAPPEN WHEN SHE DRIVES THE CAR. THIRD, I DON'T THINK IT'S FAIR FOR ME TO HAVE TO REPAIR SOMETHING THAT IS "FAULTY" DUE TO THE MANUFACTURER. *NM
Fuel system, Gasoline, Power train, Sep 27, 2005
WHEN ACCELERATING IN VARIOUS INCLINES OR DECLINE MY CAR CHOKES AND HESITATES AS IF IT HAS WATER IN THE GAS LINE OR THE FUEL FILTER IS CLOGGED. IT STARTS TO JERK AND SPUTTER AND REFUSES TO ACCELERATE IF I PUSH ON THE PEDAL INSTEAD IT CHOKES OUT. EITHER THE CAR DIES RIGHT THERE OR I MANAGE TO PULL IT OVER AND LET IT DIE ON ITS OWN AS SOON AS I COME TO A STOP. TROUBLE RESTARTING THE CAR AS IF TO MUCH AIR INTAKE TO CHOKE IT OUT. FINALLY IT STARTS AND IT RUNS AFTER BLOWING THE LINES BEFORE PUTTING IT INTO DRIVE IT'S GOOD FRO MAYBE ANOTHER 10 15 MILES AND THE AGAIN IT STARTS PUTTERING AND WANTED TO DIE NO CHOICE BUT TO LET IT DIE TO RESTART. CAR HAS BEEN IN THE SHOP NUMEROUS TIMES HAVE HAD A COLLAPSED FUEL LINE AND HAS BEEN REPLACE BUT STILL THE PROBLEM PERSISTS AGAIN WHEN IT'S IN THE SHOP IT DOES NOT HAPPEN AND YET THEY DO NOT DRIVE IT AT THE TIME ITS NORMALLY DRIVEN OR AT THE EXTREMES OF THE TRAFFIC WHILE IT HAPPENS SO AS TO SEE WHAT IT DOES. A BEST EXPLANATION YOU CAN FIND FROM A MECHANIC IS NO PROBLEM SEEABLE. AND YET THERE IS ONE FROM US THE PURCHASER. *JB