2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints: gasoline
277 reports, newest first. Show all
Fuel system, Gasoline, Oct 11, 2004
HISTORY OF FUEL SYSTEM PROBLEM: 11/25/03: ENGINE HESITATION, LOSS OF POWER, ENGINE STALL (PD REPAIR COST- DIAGNOSTIC TEST; NO PROBLEMS FOUND). 2/04: RECEIVED RECALL LETTER FROM FORD REGARDING FUEL PUMP IN MY VEHICLE. 3/8/04: RECALL WORK PERFORMED(REPLACED FUEL DELIVERY MODULE - N/C). 3/9/04: SAME PROBLEM RE-OCCURRED(REPLACE DPFE SENSOR AND CLEAR DTCS - N/C). 6/04: SAME PROBLEM RE-OCCURRED (DIFF. DEALER - REPLACED FUEL FILTER- PD REPAIR COST). 8/5/04: SAME PROBLEM RE-OCCURRED (BROKE DOWN IN OHIO - REPLACED VACUUM HOSE - PD REPAIR COST). VEHICLE HAS STALLED AT LEAST 20 TIMES WHILE OPERATING. 2 CLOSE-CALLS: 8/5/04 IN OHIO- STALLED IN BUSY INTERSECTION WHILE TURNING. 9/04: ALMOST HIT CHILD ON BIKE IN NEIGHBORHOOD DUE TO VEHICLE STALL AND LOSS OF ASSISTED STEERING. *NM
Fuel system, Gasoline, Vehicle speed control, Sep 2, 2004
CONSUMER NOTICED FUEL RAIL SYSTEM WAS LEAKING GASOLINE, RESULTING IN STALLING. INDEPENDENT SHOP CLEANED THE FUEL INJECTION AN THROTTLE CABLE. DEALER WAS NOTIFIED. *AK
Fuel system, Gasoline, Aug 24, 2004
1. WITHOUT CRASH OR OTHER DAMAGE, FUEL BEGAN TO LEAK OUT OF THE TOP OF THE GAS TANK AND DOWN THE TANK ONTO THE UNDERCARRIAGE. OCCURS ONLY WHEN IGNITION IS ON AND VEHICLE IS DRIVEN. 2. FAILURE APPEARS TO BE A SEAL ON SIPHON/FUEL LINE GOING INTO TOP OF TANK. CONSEQUENCES ARE POTENTIAL SERIOUS FIRE/EXPLOSION HAZARD, UNPREDICTABLE LOSS OF POWER WHEN DRIVING. AWAITING SERVICE ON THE VEHICLE.*AK
Fuel system, Gasoline, Jul 30, 2004
POSSIBLE DEFECT WITH CLIP/CLAMP ON FUEL PUMP.*MR ON JAN 20, 2004 THE FUEL PUMP WAS REPLACED PER RECALL, THE MILEAGE AT THE TIME WAS 18446. ON JUNE 7, 2004 THE CLAMP OR HOSE FROM THE FUEL PUMP DETACHED WHICH RESULTED IN THE VEHICLE NOT STARTING. THE CONSUMER ALSO SAW A SIZEABLE AMOUNT OF FUEL UNDER THE VEHICLE AFTER SHE ATTEMPTED TO START THE VEHICLE, MILEAGE AT THAT TIME WAS 20640. THE VEHICLE WAS TAKEN TO THE DEALER WHO EXPLAINED THAT THE CLAMP MUST HAVE BECAME LOOSE AFTER THE VEHICLE HIT A POTHOLE. *NM
Fuel system, Gasoline, Jul 14, 2004
THE CONSEQUENCES DESCRIBED IN THE STALLING RECALL 03V482000 OCCURRED ON NUMEROUS OCCASIONS, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AL
Fuel system, Gasoline, Jul 12, 2004
ON 2 OCCASIONS MY CAR HAS FAILED TO START AND CUT OFF. LEADING UP TO THIS THE CAR WAS WORKING FINE AND JUST ALL OF A SUDDEN JUST STOPPED. THE 1ST TIME IT STARTED WITH THE HESITATION AND STUTTERING OF THE ENGINE. WHERE THERE WAS A RECALL ON THE GAS LINE WHICH THE DEALER FIXED. THE 2ND TIME IT JUST KEEP CUTTING OFF EVERYTIME I PUT THE CAR IN DRIVE. I TOOK IT TO THE FORD AND THEY SAID THEY COULD FIND NOTHING WRONG WITH THE CAR BUT I HAVE A FEELING IT IS GOING TO DO IT AGAIN AND I WILL BE STRANDED BY THE ROAD AGAIN. EVERYTIME IT HAPPENS FORD CAN'T FIND ANYTHING WRONG OR AREN'T LOOKING WELL ENOUGH. *LA
Fuel system, Gasoline, Jul 7, 2004
STARTED CAR AND DROVE 1/4 MILE, SMELLED GAS, CONTINUED FOR ANOTHER 1/4 MILE AND NOTED GAS SMELL STRONGER. PULLED OVER AND NOTED WET TRAIL BEHIND VEHICLE AND GASOLINE POURING OUT UNDERNEATH VEHICLE. IN LESS THAN 5 MINUTES, HALF A TANK OF GAS (ALMOST 10 GALLONS) WAS DISCHARGED FROM THE VEHICLE. GAS LEAKED ONLY WHEN IGNITION WAS ON. HAD VEHICLE TOWED TO DEALERSHIP. TOW TRUCK DRIVER COMMENTED THIS HAPPENS ALL THE TIME WITH THESE VEHICLES AND THAT IT WAS A SEAL ON TOP OF THE FUEL TANK THAT FAILED. DEALER COMMENTED MUCH THE SAME. HAD FUEL PUMP REPLACED BY DEALER AFTER PREMATURE FAILURE 8 MONTHS EARLIER.*AK
Fuel system, Gasoline, Jun 28, 2004
RECALL 03V482000 CONCERNING STALLING. VEHICLE EXPERIENCED A HESITATION/STALLING PROBLEM, AND LOSS OF POWER. DEALER WAS NOTIFIED, AND INFORMED THE CONSUMER THAT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
Fuel system, Gasoline, Jun 14, 2004
NO CRASHES OR INJURIES, HOWEVER THER COULD HAVE BEEN SINCE THE CAR STALLED SEVERAL TIMES WHILE MY WIFE WAS DRIVING IT. SOME MONTHS AGO THE "CHECK FUEL CAP" LIGHT APPEARED. THIS HAD NEVER BEEN A PROBLEM, AS I ALWAYS TURN THE CAP SEVERAL TIMES AFTER FUELING. I HAD A LOCAL AUTO PARTS STORE RESET THE LIGHT. THIS HAPPENED AGAIN SO I SWITCHED GAS CAPS WITH THE OTHER 2001 FOCUS I OWN. THE LIGHT CAME ON AGAIN, FOLLOWED BY A "CHECK ENGINE" LIGHT. WHEN I HAD THE AUTO PARST STORE CHECK IT BEFORE RESETTING THE LIGHTS THEIR READOUT STATED "LARGE VACUUM LEAK". SINCE THE CAR RAN OK AND THERE WAS NO NOTICEABLE DROP IN FUEL ECONOMY, I FELT THERE WAS NO PROBLEM, UNTIL MY WIFE DROVE IT AND CAME BACK VERY UPSET THAT IT HAD STALLED SEVERAL TIMES AND SHE HAD TO USE THE GAS AS WELL AS THE BRAKE TO GET HOME. UPON TAKING IT TO THE DEALERSHIP, I WAS ADVISED THAT THERE WAS A LEAK IN THE FUEL FILLER NECK AND THAT THE PART AS WELL AS THE $30 FUEL CAP NEEDED REPLACED AT A COST OF OVER $350. I EXPLAINED THE FILLER CAP SWITCH (THE OTHER FOCUS HAS NOT HAD THE PROBLEM SINCE IT WAS BUILT IN MICHIGAN AND NOT MEXICE) AND THEY ONLY REPLACED THE FUEL FILLER NECK TO THE TUNE OF $324.65 WHILE THIS VEHICLE HAS 60,000 MILES ON IT I DO NOT FEEL THAT THIS WAS A COST THAT I SHOULD HAVE ABSORBED. *AK
Fuel system, Gasoline, May 26, 2004
WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF A BUSY INTERSECTION. THE DEALER STATED THE FUEL PUMP MALFUNCTIONED AND WAS NOT SENDING FUEL TO THE ENGINE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
Fuel system, Gasoline, May 4, 2004
MY CAR STALLED AFTER COMING AROUND A SHARP RIGHT HAND TURN. I RESTARTED THE ENGINE AND CARRIED ON A FEW MORE YARDS WHEN THE ENGINE STALLED AGAIN. I TRIED TO START THE CAR SEVERAL MORE TIMES BECAUSE I WAS STUCK AT THE ENTRANCE TO THE FREEWAY ON-RAMP IN VERY BUSY TRAFFIC. I COULD NOT GET THE CAR STARTED AND HAD TO GET IT TOWED AWAY. THE MECHANIC AT THE REPAIR OUTFIT REPLACED THE FUEL FILTER AND SAID THAT THE OLD ONE WAS CLOGGED UP WITH DIRT. THIS HAS NEVER HAPPENED TO ME BEFORE. I DID SOME RESEARCH ON THE INTERNET AND FOUND THAT I AM NOT THE ONLY FOCUS OWNER WITH THIS PROBLEM. I THINK THIS RELATES TO RECALL #03V482000. *AK
Service brakes, Hydraulic, Fuel system, Gasoline, Apr 20, 2004
WHILE DRIVING AT ANY SPEED, THE VEHICLE INTERMITTENTLY STALLED. THE DEALER INFORMED THE CONSUMER THAT THE FUEL PUMP MODULE WAS DEFECTIVE. ALSO THE BRAKE ROTORS PADS, AND CALIPERS NEEDED TO BE REPLACED. *AK THE ENGINE LIGHT HAD COME ON DUE TO THE FUEL PUMP BEING INOPERATIVE. FORD MADE THE REPAIRS BUT FAILED TO REPLACE THE O RINGS WHICH CAUSED THE PUMP TO FAIL AGAIN. FORD HAD FUEL PUMP RECALL #03NO1 BUT THE SAME EXACT PART WENT BAD. THE ROTORS WERE WARPED DUE TO THE CALIPERS SEEPING FLUID, BINDING THE PISTONS. *SC *JB
Fuel system, Gasoline, Apr 18, 2004
WHILE DRIVING MY 2001 FORD FOCUS OVER A 6 LANE SUSPENSION BRIDGE FROM PA TO NJ, MY CAR STARTED TO ACT AS IF IT WAS RUNNING OUT OF GAS. CAR SLOWED WITHOUT WARNING THEN DIED,THIS HAPPENED AS A 18 WHEEL TRUCK WAS BARING DOWN ON ME AT A HIGH RATE OF SPEED. SITTING AS A DEAD DUCK THE TRUCK BARELY MADE IT AROUND ME NEARLY CAUSING A MULTI CAR ACCIDENT. AFTER RESTARTING THE CAR (BARELY KEEPING IT RUNNING) I SLOWLY MADE IT TO THE TOP AS IT DIED AGAIN , I GLIDED DOWN THE BRIDGE IN NEUTRAL, I PULLED OVER AT THE END OF THE BRIDGE AND RESTARTED THE CAR AGAIN, THIS HAPPENED 3 TIMES ON THE HIGHWAY, EACH TIME HAVING TO PULL OVER AND RESTART THE CAR.. I HAVE HAD THIS PROBLEM ABOUT A YEAR AGO AND HAD TO FIGHT FORD TO REPLACE THE FUEL PUMP, WHICH SEEMED TO SOLVE THE PROBLEM UNTIL NOW.. THIS TIME I ALMOST GOT KILLED.. THERE IS NO WARNING WHEN THIS HAPPENS! PLEASE DO SOMETHING ABOUT THIS BEFORE SOMEONE DIES. *JB
Fuel system, Gasoline, Apr 8, 2004
NHTSA RECAL 03V482000 CONCERNING STALLING. RECALL REMEDY WAS PERFORMED ON FEBRUARY 17,2004. SINCE THEN, VEHICLE HAS STALLED FOUR TIMES. WHILE ACCELERATING VEHICLE HESITATED, AND THEN STALLED IN THE MIDDLE OF AN INTERSECTION. CONSUMER CONTACTED THE DEALER WHO CHARGED THE CONSUMER TO DO A DIAGNOSTIC TEST.*AK *MR
Fuel system, Gasoline, Apr 3, 2004
MY 2001 FORD FOCUS ZX3 HAS STALLED AROUND TURNS AND WHEN IT GETS BELOW 1/3 TANK CONSISTENTLY SINCE I GOT IT, AND IN MID MARCH IT COMPLETELY STALLED OUT AS I WAS DRIVING DOWN THE ROAD AND TOOK NEARLY 20 MINUTES TO RESTART. I JUST VISITED FORDS WEB SITE TO FIND OUT ANY RECALL INFORMATION AND IT CAME UP WITH NO RECALLS FOR THIS PROBLEM, OR ANY OTHER PROBLEM. *NM
Fuel system, Gasoline, Mar 23, 2004
VEHICLE HESITATED AND STALLED DUE TO A CONTAMINATED FUEL TANK. *PH THE CONSUMER HAS SINCE RECEIVED A RECALL NOTICE, AND AFTER READING THE NOTICE SHE REALIZED THE VEHICLE HAD THE SAME PROBLEMS. *JB
Fuel system, Gasoline, Mar 12, 2004
CONSUMER RECEIVED A RECALL ON HIS DAUGHTER'S VEHICLE FOR THE FUEL PUMP. CONSUMER TOOK THE VEHICLE TO THE DEALER, AND LEFT IT THERE FOR 2 DAYS. WHEN CONSUMER PICKED UP THE VEHICLE HE FOUND THAT DEALER DID NOT REPLACE THE PARTS THAT SHOULD HAVE BEEN REPLACED. ALSO, CONSUMER DID NOT THINK THAT MECHANIC ACTUALLY CHECKED THE VEHICLE AFTER DOING RECALL REPAIRS. HE STATED THAT THE RECALL CALLED FOR THE REPLACEMENT OF THE FUEL PUMP WITH FULLER. VEHICLE WAS STILL DOING THE SAME THING, HESITATING AND STALLING. *AK
Fuel system, Gasoline, Mar 11, 2004
CONSUMER RECEIVED NHTSA RECALL 03V482000 CONCERNING FUEL PUMP PROBLEM. VEHICLE WAS TAKEN TO THE DEALER, AND DEALER REPLACED FUEL PUMP, CHARGING $25.00 FOR PARTS AND $40.00 DO FOR LABOR. TOTAL CHARGE WAS $75.00. CONSUMER OBJECTED PAYING FOR LABOR BECAUSE THE RECALL LETTER INDICATED IT WAS FREE OF CHARGE. *AK *SC
Fuel system, Gasoline, Mar 9, 2004
CONSUMER RECEIVED A RECALL NOTICE BUT DUE TO THE VEHICLE HAVING A "BRANDED TITLE", THE CONSUMER HAD TO PAY $430.48 FOR THE FUEL PUMP REPLACEMENT. (NAR) *PH *CB
Fuel system, Gasoline, Mar 9, 2004
WHILE DRIVING AT ANY SPEED ENGINE WOULD EITHER SURGE OR STALL WITHOUT ANY WARNING. DEALERSHIP WAS CONTACTED, AND INFORMED THE CONSUMER THAT FUEL PUMP NEEDED REPLACEMENT. *AK
Fuel system, Gasoline, Mar 3, 2004
DEALERSHIP REFUSED TO PERFORM THE STALLING RECALL 03V482000 REPAIRS UNLESS THE CONSUMER PAID $165.00 FOR A DIAGNOSTIC. *AK THE VEHICLE WAS REPAIRED AT ANOTHER DEALERSHIP AT NO CHARGE. *JB
Fuel system, Gasoline, Mar 2, 2004
CONSUMER WAS COMPLAINING OF A PROBLEM WITH THE FUEL LINE. VEHICLE WAS TURNED OFF AND THERE WAS A STRONG SMELL OF FUEL. ALSO, THERE WAS FUEL UNDER THE FRONT OF THE VEHICLE. *AK
Fuel system, Gasoline, Feb 24, 2004
RECALL 03V482000 CONCERNING STALLING. WHILE DRIVING ON THE HIGHWAY VEHICLE STALLED. DRIVER PULLED THE VEHICLE TO THE SIDE OF THE ROAD WITHOUT INCIDENT. DEALER INDICATED TO THE CONSUMER NO PROBLEM COULD BE FOUND. THE CONSUMER SHOWED THE DEALER A LETTER FROM FORD ABOUT THE FUEL DELIVERY PUMP. THE DEALER TOLD THE CONSUMER THAT THE REPAIRS WOULD NOT BE DONE UNLESS IT HAPPENED AGAIN. NO REPAIRS WERE DONE TO THE VEHICLE. *AK ROPER FORD HONORED THE RECALL ON 1/29/04. *NM
Fuel system, Gasoline, Feb 23, 2004
CONSUMER EXPERIENCED SUDDEN LOST OF POWER AND SURGING AT DIFFERENT LEVELS OF SPEED. *PH THE CONSUMER RECEIVED A RECALL REGARDING THE FUEL PUMP, THE VEHICLE WAS INSPECTED AND IT WAS DISCOVERED THERE WAS A PROBLEM WITH THE PUMP. THE CONSUMER WAS INFORMED THE PART WAS NOT AVAILABLE AND HAD TO BE ORDERED. THE CONSUMER WAS TOLD THE PUMP AND FILTER WOULD BE REPLACED, HOWEVER THE FILTER WAS NOT INCLUDED IN THE RECALL AND WOULD COST $40.00. THE CONSUMER REQUESTED REIMBURSEMENT. *JB
Fuel system, Gasoline, Feb 23, 2004
THE CONSUMER RECEIVED NOTIFICATION ABOUT THE FUEL PUMP PROBLEM ON 2000 AND 2001 FORD FOCUS. FORD DEALERS AND SERVICE DIDN'T KNOW ABOUT THE PROBLEM. *LA THE CONSUMER DISCOVER THAT IF SHE REFILLED THE TANK BEFORE THE VEHICLE HA 250 MILES, THE PROBLEM WOULD NOT OCCUR. THE FIRST TIME THE PROBLEM OCCURRED THE VEHICLE SPUTTERED AND EVENTUALLY STALLED. IT FELT LIKE A FUEL PROBLEM PER CONSUMER, IN WHICH SHE PLACED "STP FUEL INJECTION" IN THE TANK AND FILLED IT WHICH STOPPED THE PROBLEM. RECAL#03V482000 *SC