2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints: hydraulic
175 reports, newest first. Show all
Service brakes, Hydraulic, Engine and engine cooling, Tires, Equipment, Jan 15, 2004
MY SECURITY SYSTEM BASICALLY WENT NUTTY...IT EVEN SOUNDED FUNNY WHEN THE HORN SOUNDED, THE CRUISE WOULD ALSO STICK OR NOT WORK AT ALL WHEN IT SHOULD HAVE BEEN TURNED ON. I HAVE HAD THE HEGO SENSOR OR THE FRONT OXYGEN SENSOR REPLACED 3 TIMES, ONE AT MY OWN COST...I HAD A HUGE BULGE POP OUT ON MY TIRE EARLY ON, FIRESTONE REPLACED IT AT NO COST...THE BRAKES HAVE INTERMITTANTLY SQUEALED SINCE THE VEHICLE HAD FEW MILES ON IT, WHEN I TOOK IT IN TO GET IT FIXED, IT BASICALLY FELT LIKE THEY HAD LOOSENED THEM BECAUSE YOU HAD TO PRESS ON THE PEDAL HARDER TO STOP, SOON AFTER THEY STARTED SQUEALING AGAIN, ALL FORD WILL TELL ME IS THAT I NEED NEW BRAKE PADS AT MY COST BECAUSE IT IS ROAD HAZARD...SHOULD A CAR WITH 40,000 MILES NEED BRAKE PADS? I THINK NOT. THE LAST COMPLAINT THAT I HAVE IS THAT THE CAR WILL STALL WITH NO APPARENT REASON WHY...NO MATTER WHAT THE SPEED IS OR IF I HAVE JUST STARTED IT OR HAVE DRIVEN IT ALL DAY IT DOES NOT MATTER, I WILL JUST BE STUCK UNTIL IT DECIDES TO START AGAIN.
Service brakes, Hydraulic, Other or unspecified, Jan 15, 2004
MY WARRANTY WAS 36,000 WHICH IS UP. FIXING THE BRAKES WAS NO PROBLEM BUT I DONT FEEL MY WHEEL BEARINGS NEED REPLACED THIS QUICKLY WITHOUT HAVING SOME KIND IF DEFAULT IN THEM FROM THE START. MY CAR IS MAKING THIS LOUD, ROARING SOUND, WHICH IS DRIVING ME CRAZY. I'M WRITING TO SEE IF THERE'S ANYTHING THE HEADQUARTERS OF FORD CAN DO. THERE ARE RECALLS ON 2001 FORD FOCUSES BUT JUST SO HAPPEN NOT ON MY CAR AND WHY IS THAT WHEN IM HAVING COMPLICATIONS WITH IT. IT SOUNDS LIKE A TRACTOR AND IVE ONLY HAD THE CAR FOR 16 MONTHS. I WAS A STUDENT IN DALLAS AND THAT WAS THE ONLY TRAVELING I DID. I'M NOT HARD ON VEHICLES AT ALL. THE WHEEL BEARING ARE GONE BAD ON MY CAR AND I HOPE THERE'S SOMETHING SOMEONE CAN DO. ITS THE FRONT ONES. BY THE WAY IT DOESN'T SEEM AS IF MY TRANSMISSION IS CHANGING THE CORRECT # OF GEARS.
Steering, Service brakes, Hydraulic, Fuel system, Gasoline, Other or unspecified, Jan 15, 2004
IN NOVEMBER OF 2002, I NOTICED A SQUEAL UNDER THE HOOD OF MY 2001 FOCUS. THE FIRST TIME I TOOK IT IN, THEY CLAIMED THEY HEARD NO SOUND. I THEN TOLD THE MECHANIC YOU MUST ACTUALLY STEP OUT OF THE CAR TO HEAR THE NOISE.; HE DID HEAR THE NOISE AND FORD HAD TO REPLACE THE BELT TENSIONER AND SERPENTINE BELT. I BEGAN NOTICING THAT MY WINDSHIELD WIPERS WOULD FUNCTION AT WILL. THE LEFT HEADLAMP AND TURN SIGNAL WAS ALSO MALFUNCTIONING. I COULD NOT GET THE WIPERS TO TURN OFF AT TIMES. I WOULD TURN THE HEADLIGHTS OFF AND BACK ON AGAIN, AND THE WIPERS WOULD TURN OFF. THIS WOULD ALSO WORK AT TIMES WHEN THE WIPERS WOULD NOT TURN ON, BUT NOT ALWAYS. I NEVER NOTICED AN ABSOLUTE CONSISTENCY AS TO WHAT WOULD GET THE WIPERS TO FUNCTION PROPERLY. THEY ALSO WOULD NOT FUNCTION AT THE CORRECT SPEED. THEY WOULD GO FAST WHEN I WANTED THEM TO GO SLOW AND VICE-VERSA. I HAD TAKEN THE CAR IN TWICE TO HAVE THIS PROBLEM FIXED. THEY REPLACED THE MULTI FUNCTION SWITCH BOTH TIMES. A WEEK FOLLOWING THE SECOND VISIT, I NOTICED THEY WOULD NOT WORK AGAIN. I SCHEDULED AN APPOINTMENT FOR THE THIRD TIME. IN BETWEEN THE TIME I SCHEDULED THE APPOINTMENT AND THE ACTUAL DAY OF THE APPOINTMENT, I NOTICED THE GAS LIGHT HAD COME ON WHEN I STILL HAD ABOUT 36 MILES WORTH OF GAS LEFT IN MY CAR. I NOTICED THE LIGHT WAS ON FOR A BIT AND THEN IT WENT OFF. SO, I TOLD THEM ABOUT THAT PROBLEM AS WELL WHEN I TOOK THE CAR IN. THEY REPLACED THE FUEL PUMP AND SENDING UNIT ASSEMBLY. ALSO THEY REPLACED WHATEVER WIRES WERE CAUSING THE MULTI FUNCTION SWITCH TO GO OUT AGAIN AND AGAIN. I LEFT THE DEALERSHIP AND MADE A STOP AT A CONVENIENCE STORE. WHEN I TRIED TO START MY CAR, IT WOULD NOT START. NOT A SOUND OR ANYTHING. THE CAR WAS TOTALLY DEAD. I CALLED FORD TO HAVE THEM TOW THE CAR. THIS TIME, THEY CLAIMED THEY NEEDED TO REPLACE THE CLUTCH SAFETY START SWITCH, WHICH THEY DID. MY BREAKS ALSO SQUEAK CONSTANTLY. THEY ADJUSTED THE BREAKS AND CLEAN THEM UP. THEY CLAIM THE SQUEAKING BREAKS ARE NORMAL. DO NOT BUY A FORD.
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Wheels, Equipment, Jan 15, 2004
I HAVE HAD NUMEROUS PROBLEMS WITH MY FOCUS. ABOUT 3MO AFTER I BOUGHT IT, THE TRANSMISSION BEGAN TO FEEL LIKE IT WAS SLIPPING, AND MAKING A NOISE. I TOOK IT TO THE PURCHASING DEALERSHIP, AND A MECHANIC TOLD ME IT WAS THE TORQUE CONVERTER. THEY DIDN'T HAVE A LOANER CAR FOR ME, SO I MADE AN AN APPOINTMENT FOR THE FOLLOWING WEEK. THE NEXT DAY ON MY WAY HOME FROM WORK, THE CAR SHUT DOWN. I CALLED A TOW TRUCK, THEY TOOK IT TO THE CLOSEST DEALERSHIP. WHEN I CALLED THE DEALERSHIP THE NEXT DAY, THEY SAID THE FUEL PUMP WENT OUT. THEY TOLD ME THAT THE STUTTER I WAS FEELING IN MY CAR WAS PROBABLY THAT. A FEW DAYS LATER, THE SAME PROBLEM. TOOK IT BACK TO THE SELLING DEALERSHIP, AND THE SHOP SUPERVISOR WENT OUT WITH ME. HE SAID I WAS DRIVING THE CAR OUT OF CONTEXT. WHAT HE MEANT BY THAT, HE WOULDN'T ELABORATE, BUT SAID THERE IS NOTHING WRONG WITH MY CAR. I HAVE BEEN DRIVING IT SINCE, AND THE COMPUTER WILL FADE IN AND OUT, BUT I WON'T LOSE ENGINE POWER. MY CAR HAS TO HAVE NEW BRAKE PADS EVERY COUPLE OF MONTHS, NEW TIRES, AND OTHER MAINTENANCE THINGS. AT LESS THAN 40000 MILES, IT NEEDED NEW SPARK PLUGS, AND WIRES, WHICH I HAPPILY BOUGHT. THE DEALERSHIP WANTED $300, BECAUSE THE PLUGS WERE IN THE BACK OF THE MOTOR. I WENT TO MY CAR, POPPED THE HOOD, FOUR SPARK PLUGS LINED THE TOP OF THE HEAD COVER. THERE WAS NO FURTHER EXPLANATION OF THE ATTEMPTED OVER CHARGE. MY CAR HAS SEVERAL OTHER PROBLEMS. THE POSITIVE CABLE ON THE BATTERY, HAS MELTED BACK, THERE IS A LOUD ROAR IN THE CAB OF THE CAR, AND THREE OF THE FOUR LUG NUTS ON THE RIGHT REAR TIRE HAS SNAPPED OFF. THE EXPLANATION FOR THE LUG NUTS, WAS THAT THE TIRE WAS LOOSE, NOT FASTENED PROPERLY. BUT THIS PROBLEM OCCURRED 3-4 MO AFTER I BOUGHT IT. THE TIRES HAD NOT BEEN TAKEN OFF. I AM TO THE POINT WHERE I HATE FORD FOR SELLING ME THIS CAR. I WILL EVER BUY FORD AGAIN, BUT I LOVE THE CONCEPT OF THE CAR
Steering, Suspension, Service brakes, Hydraulic, Tires, Wheels, Jan 15, 2004, crash
I HAVE HAD SEVERAL REPAIRS FOR THIS CAR. IN REGARDS TO STEERING, WHEEL, TIRE AS WELL THE SUSPENSION. AS THE CAR WAS UNDER 18000 MILE I HAD SO MUCH PROBLEM WITH MENTIONED ABOVE PROBLEMS. I COULD NOT CONTROL MY CAR WHEN IT RAINED OR WHEN EVER THE ROAD WAS NOT IN PERFECT SHAPE.
Steering, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Visibility, Structure, Tires, Wheels, Equipment, Other or unspecified, Jan 15, 2004
THERE IS JUST TO MUCH PAPERWORK TO COPY OUT, BUT WOULD LIKE TO MAIL COPIES. I AM GOING TO PICK UP CAR THIS AFTERNOON JUST HAD SECOND FUEL PUMP FITTED AND NEW GAS TANK. TO DATE NO RECALL INFO RECEIVED BY POST. HOWEVER I HAVE BEEN DRENCHED WITH GAS ON MORE THAN ONE OCCASSION WHILE FILLING CAR. I HAVE NEARLY BEEN KILLED WHEN CAR CUT OUT AT 55MPH ON HIGHWAY NARROWLY MISSED BY TWO OTHER MOTORISTS. VEHICLE HAS 38,000 MILES & HAS HAD THE FOLLOWING REPAIRS. 1/COUNTLESS ENGINE SENSORS 2/FOUR NEW TYRES 3/NEW FRONT BRAKE PADS 4/NEW FRONT BRAKE ROTAS 5/NEW FRONT WHEEL BEARINGS 6/TWO FUEL PUMPS 7/ONE FUEL TANK 8/WAITING FOR THIRD SET OF A FRAME PLASTIC COVERS 9/THREE STEREO PLAYERS 10/TRACKLINK RESET THREE TIMES 11/STILL HAVE REALY NOISY BRAKES 12/ENGINE SOUNDS LIKE 10 YEAR OLD CAR 13/REAR PASSENGER WINDOW WORKS WHEN FEELS LIKE IT 14/RIGHT HAND DOOR SPEAKER SOUNDS AS IF BROKEN 15/NEW TIRES FITTED SHOWING SIGNS OF ODD WEAR 16/TAIL GATE LEAKES WATER 17/ THOUGHT LINCOLN/MERCURY DEALER MIGHT GIVE BETTER RESULTS NO JUST LONGER WAIT.
Suspension, Service brakes, Hydraulic, Wheels, Other or unspecified, Jan 15, 2004, crash
MY DAUGHTER SLAMMED ON THE BRAKES AT 40MPH AND THE VEHICLE STEERING WHEEL JERKED TO THE RIGHT AND SHE FELT A DROP IN THE LEFT FRONT SIDE OF THE CAR, THE CAR STARTED SLIDING AND HIT A CURB. WHEN THE CAR CAME TO A STOP THE FRONT LEFT WHEEL WAS BROKE OFF. A TOW TRUCK TOOK IT TO THE FORD DEALERSHIP. THEY SAID IT NEEDED A CONTROL ARM; HUB ASSEMBLY; TIE ROD END; TIRE & WHEEL; AXLE; BRAKE LINE; BRAKE PADS & ROTOR; TRANS PAN AND INNER TIE ROD. THEY CONCLUDED IT WAS IN AN ACCIDENT AND IT WAS HER FAULT AND THE COST WOULD BE $2,387.77 JUST FOR THE MECHANICAL ONLY. SHE PURCHASED THE CAR SEPTEMBER OF 2002, PUTTING OVER $8,000.00 DOWN ON THE DAY OF PURCHASE WITH A REMAINING BALANCE OF $6,000.00. AT THE TIME OF THE ACCIDENT SHE HAD NO INSURANCE. I BELEIVE THERE WAS A PROBLEM WITH CAR TO CAUSE IT TO GO OUT OF CONTROL, AND FEEL FORD NEEDS TO ADDRESS IT.
Service brakes, Hydraulic, Engine and engine cooling, Power train, Tires, Jan 15, 2004
THE REASON SOME OF THESE ARE NOT DATED IS BECAUSE THE PROBLEMS KEEP ON PERSISTING THEY SAY THEY CAN NOT FIND OUT WHAT THE PROBLEM IS. MY CAR DIES ON ME AND THE CAN NOT FIND THE CAUSE. IT MAKES A WINDING SOUND WHEN I TAKE OFF AND STILL THEY CAN NOT FIND THE CAUSE. MY GEARS ALWAYS WIND AND AS SOON AS I GET IT OUT OF THE SHOP ABOUT ONE TO TWO WEEKS LATER IT IS DOING IT AGAIN, WHEN I AM DRIVING IT JERKS LIKE IT WANTS TO DIE OR GO OUT OF GEAR(KEEP IN MIND I HAVE HAD THESE PROBLEMS A COUPLE OF MONTHS AFTER I BOUGHT IT). I HAVE HAD TO REPLACE THE TIRES TWO TIMES I AM ON MY THIRD SET OF TIRES AND THEY ARE MESSED UP NOW. I AM NOT A BAD DRIVER I KNOW IT IS NOT ME I HAVE A CHILD THAT IS CONSTANTLY WITH ME I DO NOT DRIVE CRAZY TO MAKE ALL OF THESE PROBLEMS HAPPEN. I HAVE HAD THE BRAKE REPLACED ONCE ALREADY AND NOW THEY ARE SQEEKING AGAIN. MY CAR CIGARETTE LIGHTER KEEPS ON BURNING OUT. I JUST GET SO FRUSTRATED THAT I AM SPENDING ALL OF THIS MONEY FOR THEM TO WORK ON MY CAR WITH THE WARRANTY AND THEN TELL ME THEY DON'T KNOW WHAT THE PROBLEM IS AND NOW THE WARRANTY IS OUT I HAVE TO PAY FOR THIS PEICE OF JUNK. I HAVE HAD 2 OTHER CARS AND THEY NEVER GAVE ME ANY PROBLEMS AND KNOW I AM STUCK UNHAPPY EVERYDAY WITH THIS CAR I CAN NOT STAND TO DRIVE, I FEEL UNSAFE IN IT EVERYDAY.
Service brakes, Hydraulic, Engine and engine cooling, Air bags, Tires, Wheels, Jan 15, 2004, crash
THE TIRE AND THE BRAKES WENT OUT AND THE CAR STATED SLIDING. AFTER THE CRASH THERE WERE BOLTS THAT WERE FOUND ON THE GRASS WHERE THE CRASH HAPPENED
Service brakes, Hydraulic, Nov 29, 2003
I HAVE HAD MY CERTIFIED PREOWNED FORD FOCUS ZX3 FOR 10 MONTHS NOW. I HAVE RUN IT UNDER NORMAL DRIVING CONDITIONS. I STARTED HAVING A A NOISE COMING FROM THE ENGINE COMPARTMENT AND NOTICED A SLIGHT VIBRATION ON THE STEERING WHEEL. I CONTINUED TO DRIVE IT FOR A WEEK, THINKING THAT IT MAY BE A HARD SPOT IN THE BRAK PAD. I TOOK IT TO A DEALERSHIP A WEEK LATER TO HAVE THEM INSPECT IT, WHILE IT WAS STILL UNDER NEW CAR WARRANTY, AND THEY STATED THAT I NEEDED NEW PADS AND ROTORS, SERVICE CHARGE :$10. I CHECKED THEM MYSELF AND NOTICED THAT THE PADS WERE STILL AT 50%. I REPLACED THE PADS AND ROTORS. THE NOISE IS STILL PERSISTENT, BUT THE NOISE, ACCORDING TO FORD IS NORMAL. I WISH THERE WOULD BE AN INVESTIGATION BROUGHT FORWARD AND A RECALL FOR ALL FORD FOCUS TRIM LEVELS TO SERVICE BRAKE ISSUES, SUCH AS PREMATURE WEAR (STATES ON ORDFOCUSBRAKEPROBLEMS.COM).*AK
Service brakes, Hydraulic, Nov 3, 2003, crash
DUE TO A BRAKE BOOSTER DEFECT CONSUMER WAS NOT ABLE TO STOP THE VEHICLE UNTIL IT HIT ANOTHER VEHICLE. THE POLICE DID ARRIVE AND A POLICE REPORT WAS ISSUED. THERE WERE NO INJURIES. *AK
Service brakes, Hydraulic, Oct 29, 2003
2001 FORD FOCUS SERIOUS BRAKE PROBLEMS. I BOUGHT A NEW 2001 FORD FOCUS SE IN MAY 2001. ABOUT 6 MONTHS AFTER PURCHASE I NOTICED A GRINDING NOISE. FORD REPLACED "CRACKED BRAKE SHOES" ON THE CAR AND SAID IT WAS COVERED UNDER WARRANTY. ITS NOW OCTOBER 2003, MY AIR CONDITIONING SUDDENLY STOPPED WORKING. ALSO MY CAR WAS AGAIN MAKING LITTLE SQUEAKING NOISES WHEN BRAKING. SO, I TOOK IT TO A LOCAL FORD DEALER WHO TOLD ME THAT AT 22,000 MILES MY CAR BRAKES WERE TOTALLY SHOT, THAT IT WAS COMPLETELY UNSAFE TO DRIVE, I NEEDED ALL NEW BRAKES AND ROTORS IMMEDIATELY, AND THAT I SHOULD NOT DRIVE ANYWHERE. THERE ARE SEVERAL WEBSITES ALL WITH HUNDREDS OF OTHER FORD FOCUS OWNERS HAVING THE SAME PROBLEMS. SOME BRAKES ARE TOTALLY FAILING ON CARS! WWW.FORDFOCUSBRAKEPROBLEMS.COM FOR ONE WITH LINKS TO SEVERAL OTHERS. THIS NEEDS TO BE INVESTIGATED FAST! THANKS IN ADVANCE FOR YOUR TIME!*AK
Suspension, Service brakes, Hydraulic, Oct 22, 2003
WHILE DRIVING A GRINDING NOISE WAS HEARD WHEN DEPRESSING THE BRAKE PEDAL. DEALER REPLACED FRONT BRAKES AND ROTORS. THE PROBLEM OCCURRED AGAIN ,AND THE DEALER DETERMINED THAT VEHICLE NEEDED NEW FRONT WHEEL BEARINGS. *AK
Service brakes, Hydraulic, Oct 21, 2003
AT ANY SPEED WHEN BRAKES ARE DEPRESSED A GRINDING NOISE IS HEARD. OWNER HAS CONTACTED THE DEALER, CAUSE OF FAILURE UNDETERMINED AT THIS TIME.*AK
Service brakes, Hydraulic, Oct 21, 2003
ON 11-12-2001 I PURCHASED A NEW FORD FOCUS AT A FORD DEALERSHIP. ON 5-13-03, THE FRONT WHEELS BEGAN TO MAKE A LOUD GRINDING NOISE AND THE BRAKES FAILED TO OPERATE NORMALLY. THE CAR HAD ONLY 18411 MILES ON IT AND WHEN TAKEN TO THE DEALERSHIP WHERE IT WAS PURCHASED, THEY SAID THE BRAKE PADS AND ROTORS WERE SHOT AND NEEDED TO BE REPLACED. I COMPLAINED THAT NO VEHICLE BRAKE SYSTEMS SHOULD FAIL THAT EARLY AT THAT LOW MILEAGE BUT THE DEALERSHIP WOULD NOT ASSIST ME IN ANY WAY, INSTEAD CHARGING ME $469.57. THE VEHICLE WAS NOT MISUSED AND WAS DRIVEN UNDER NORMAL CONDITIONS BY MATURE DRIVERS. THIS YEAR/MODEL FORD FOCUS WAS MANUFACTURED POORLY AND I HAVE READ OF NUMEROUS OTHER COMPLAINTS ABOUT THIS VEHICLE. THERE WAS A PROBLEM WHEN FORD BUILT THE CAR AND THEY SHOULD BE HELD RESPONSIBLE FOR CORRECTING THE PROBLEM. *LA
Service brakes, Hydraulic, Oct 8, 2003
BRAKE ROTORS NEEDED TO BE TURNED AT 18000 MILES AND FAILED AT 23,300 MILES. AT 23,300 MILES THE ROTORS WERE BELOW THE MINIMUM THICKNESS REQUIREMENT. THE BRAKE PADS, HOWEVER, SHOWED ONLY MINIMAL WEAR. THE DEALER REFUSED TO AWARD WARRANTY TO THE BRAKE COMPONENTS. *LA
Service brakes, Hydraulic, Tires, Oct 3, 2003
THE VEHICLES BRAKES SQUEAKED FREQUENTLY. THE DEALER STATED THAT THE FRONT PADS NEEDED TO BE REPLACED AT 37000 MILES. THE CONSUMER STATED IT IS TO EARLY TO CHANGE PADS. BOTH TIRES ALSO NEED TO BE REPLACED. *NLM
Suspension, Service brakes, Hydraulic, Power train, Electrical system, Visibility, Seats, Sep 23, 2003
REAR WHEEL BEARINGS ARE WEARING OUT ON VEHICLE.*MR THE AUTOMATIC TRANSMISSION DOES NOT SHIFT PROPERLY, THE CONSUMER DISCOVERED THE WRONG TRANSMISSION FLUID WAS IN THE VEHICLE. THE FRONT WINDSHIELD CRACKED DUE TO EXCESSIVE HEAT. THE REAR SEAT LATCH, THE SEAT FABRIC AND THE KEY IGNITION FAILED.*TS THE WINDSHIELD WIPERS WORE OUT, WHICH WERE ONLY USED ABOUT SEVEN TIMES AND THE REAR BRAKES HAD TO BE REPLACED. *JB
Service brakes, Hydraulic, Sep 13, 2003
PREMATURE BRAKE PAD AND ROTOR REPLACEMENTS ON FRONT OF FORD FOCUS SEDAN. BRAKES REPLACED AT 21,000 MILES. I HAVE NEVER HAD TO REPLACE ROTORS ON ANY CAR THIS EARLY. FORD OWNERS OF FOCUS HAVE LISTED THIS PROBLEM HUNDREDS OF TIMES. YET I KNOW OF NO RECALL FOR THIS PROBLEM. SOME HAVE HAD IT IN LESS THAN 10,000 MILES. THIS REALLY NEEDS TO BE LOOKED INTO. *JB
Service brakes, Hydraulic, Sep 8, 2003
BRAKES WERE APPLIED AT 35 MPH, AND BRAKE PEDAL WENT TO THE FLOOR. CONSUMER WAS FORCED TO DOWN SHIFT TO FIRST GEAR TO AVOID AN ACCIDENT, AND COME TO A STOP. *AK
Service brakes, Hydraulic, Sep 3, 2003
PROBLEM WITH THE 2001 FORD FOCUS BRAKES!!! MANY COMPLAINTS. *AK
Service brakes, Hydraulic, Aug 20, 2003
FRONT WHEEL ROTORS HAD TO BE REPLACED AT 20,598 MILES. BRAKES WERE SQUEALING FROM THE TIME OF PURCHASE (NEW CAR), BUT WE WERE TOLD THAT THEY WOULD "LOOSEN UP" AND BE OKAY --- THEY NEVER DID STOP SQUEALING..WHEN WE INQUIRED ABOUT ANY RECALL, WE WERE TOLD THERE WERE NO RECALLS FROM THE FACTORY WHERE THE CAR WAS MANUFACTURED.*AK
Service brakes, Hydraulic, Aug 20, 2003
CAR IS A 2001 FOCUS WITH 21,000 MILES. UPON BRAKING, STEERING WHEEL SHUDDERS AND VIBRATES. WAS TOLD THAT CAR NEEDED NEW ROTORS AS THESE WERE WARPED. NO RESOLUTION THROUGH FORD MOTOR COMPANY. NO CAR SHOULD REQUIRE BRAKES AND ROTORS AFTER ONLY 21,000 MILES OF DRIVING. CAR ACTUALLY STARTED DOING THIS AT ABOUT 19,000 MILES AND HAS STAEDILY WORSENED. *AK
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Visibility, Structure, Vehicle speed control, Aug 13, 2003
2001 FORD FOCUS DISPLAYING PROBLEMS WITH TRANSMISSION DUE TO SEVERAL LEAKS, CRUISE CONTROL, AND TRUNK OF VEHICLE. *MR WATER LEAKED ONTO THE FLOORBOARD OF THE TRUNK WHICH WAS ONLY ADJUSTED(PROBLEM REPEATED), THE CRUISE CONTROL WORKED INTERMITTENTLY(NEW SWITCH WAS ORDERED, THE DRIVERS SIDE WINDOW SQUEAKED AND WAS FIXED, THE TRANSMISSION LEAKED AND WAS REPLACED BUT THE SERVICE DEALER WAS UNABLE TO DETERMINE THE CAUSE, WATER LEAKED IN THE FRONT PASSENGER SIDE (PROBLEM REPEATED) THEN THE R & L COWL GRID WAS REPLACED TO REMEDY THE PROBLEM BUT DIDN'T, COOLANT LEAKED FROM THE UPPER RADIATOR AND THE HOSE CLAMP WAS REPLACED, THE TRUNK DID NOT SHUT PROPERLY AND THE LATCH WAS REPLACED BUT DID NOT FIX THE PROBLEM, THE VEHICLE WAS TAKEN IN DUE TO THE PARTS BEING RECALLED, THE REAL WHEEL BEARINGS WERE REPLACED, THE SECOND RECALLED PART WAS THE PINCH BOLT TORQUE AND BATTERY CABLE ROUTING WHICH WAS REPLACED, AND THE MECHANICS FOUND THAT THE BRAKES HAD WORN OUT IN THE FRONT AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN IN FOR WARRANTY REPAIRS ON 10 SEPARATE OCCASIONS AND SIX ATTEMPT FOR THE LEAKS, THE PROBLEM IN THE FRONT OF THE VEHICLE PERSISTED. IN ADDITION, THE ENTIRE TRANSMISSION HAD TO BE REPLACED BECAUSE OF SEVERAL LEAKS, SEVERAL CIRCUIT AND SWITCHES HAVE BROKEN DOWN ON THE CRUISE CONTROL. THE CONSUMER WAS ALSO CONCERNED WITH THE GAS MILEAGE WHICH HAD CONSISTENTLY FALLEN AND DID NOT ACT AS THE PROMOTED DEALERS STICKER. THE CONSUMER REQUESTED A FULL REFUND FOR THE PURCHASE PRICE. *SCC *JB
Service brakes, Hydraulic, Aug 12, 2003
CONSUMER STATES THAT SINCE PURCHASING THE VEHICLE REAR BRAKE PADS WORE OUT AT 8000 MILES. FRONT ROTORS AND PADS HAVE BEEN REPLACED TWICE. ONCE AT 12000 MILES, AND 34000 MILES. NEEDS TO REPLACE THEM AGAIN.*AK