2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints
1,790 reports, newest first.
Visibility, Dec 28, 2007
I AM HAVING THE EXACT PROBLEM DESCRIBED IN EA0515. THE DEALERSHIP HAS SAID IT HAS SEEN THE PROBLEM BEFORE. MY LEAK HAS RUINED THE GEM MODULE ACCORDING TO THE DEALERSHIP. THE TOTAL DAMAGE $980.00. MY INSURANCE COMPANY HAS THE BELIEF THIS IS A MANUFACTURES DEFECT AND IS NOT RESPONSIBLE EITHER. *TR
Electrical system, Dec 24, 2007
ABOUT 4 MONTHS AGO I WENT TO PUT KEY IN IGNITION AND I STRUGGLED FOR AN HOUR OR MORE TO GET IT TO TURN. VERY FRUSTRATED AT THAT POINT THAT I FINALLY HAVE RESIDED TO KEEPING THE KEY IN THE IGNITION, WHICH IS NOT A GOOD IDEA,BUT AFRAID OF BEING STRANDED SOMEWHERE. *TR
Electrical system, Dec 14, 2007
RECENTLY THE IGNITION LOCK ON MY FORD FOCUS JAMS UP. I PLACE THE KEY IN THE LOCK, WHICH IS A BIT STICKY, AND THEN THE KEY WILL NOT TURN. AFTER 15-30 MINUTES OF TRYING TO TURN IT, IT WILL START, OTHER TIMES NO. WE ARE STILL RESEARCHING ON THE WEB HOW TO REPLACE THIS PART. *TR
Engine and engine cooling, Dec 10, 2007
UPPER INTAKE GASKET MANIFOLD. *TR
Electrical system, Dec 10, 2007
2001 FORD FOCUS ZTS - IGNITION WOULDN'T START DURING SUMMER MONTHS (NOT PREDICTABLE); HAVE BEEN STRANDED ON SIDE OF ROAD A FEW TIMES UNTIL ENGINE COOLED DOWN (30 MINUTES TO 1 HOUR) BEFORE WOULD START AGAIN. LAST WEEK, WHEN KEY INSERTED INTO CAR, STEERING WHEEL WOULD BE LOCKED UP AND KEY WOULDN'T TURN. FINALLY FAILED ON ME TWO DAYS AGO; LUCKILY I WAS AT HOME AND NOT ON THE HIGHWAY WITH MY 2-YEAR-OLD IN ZERO-DEGREE WEATHER! DEALER SAID IT WAS FAULTY SOLENOID SWITCH IN STARTER. HAVE READ THIS IS VERY COMMON PROBLEM THAT REPEATS ITSELF! I HOPE TO NOT HAVE TO GO THROUGH THIS AGAIN. *TR
Fuel system, Other, Dec 6, 2007
AFTER CAR HAS WARMED UP FOR 30 MINUTES APPROX. IT RESTARTS AFTER TURNING ENGINE OFF BUT WILL NOT IDLE ON IT'S OWN. THE DRIVER MUST KEEP THERE FOOT ON THE GAS PEDAL AT ALL TIMES, EXCEPT WHEN CAR IS MOVING AND ENGINE IS ENGAGED. THE CAR HAS A STANDARD TRANSMISSION. THIS DOESN'T HAPPEN EVERYTIME. BUT AFTER CAR HAS WARMED UP AND HAS HAD THE ENGINE TURNED OFF 2 OR 3 TIMES THIS ACCORES. IF THE ENGINE IS ALLOWED TO COOL DOWN FOR 15 MIN. TO 45 MIN. THE CAR WILL IDLE AGAIN. THE TIME IS DEPENDENT ON THE OUTSIDE TEMPERATURE. *TR
Electrical system, Dec 6, 2007
AS THE OWNER OF A FORD FOCUS 2001 - I ATTEMPTED TO START MY CAR AND WAS UNABLE TO TURN THE KEY IN THE IGNITION. I WAS STRANDED IN A PARKING LOT - HAD TO BE TOWED. THE PROBLEM IS CHRONIC IN FORD FOCUS - YET FORD IS NOT RECALLING OR ATTEMPTING TO ASSIST CUSTOMERS IN ANY WAY TO REMEDY THE FLAW. *TR
Electrical system, Nov 30, 2007
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AFTER ADDING FUEL. THE VEHICLE WAS TOWED TO THE DEALER. THE FAILURE OCCURRED ON DECEMBER 15, 2003 AND RECURRED APPROXIMATELY THREE WEEKS AGO. THE IGNITION LOCK ASSEMBLY SWITCH WAS REPLACED. THE COST TO REPAIR THE VEHICLE WAS $433 AT THE OWNER'S EXPENSE; HOWEVER, THE FIRST REPAIR WAS COVERED BY THE WARRANTY. THE IGNITION SWITCH SHOULD NOT FAIL AFTER THREE YEARS. THE FORD MANUFACTURER STATED THAT THEY WERE UNABLE TO ASSIST BECAUSE THE WARRANTY EXPIRED. THE FAILURE MILEAGE WAS 52,474 AND CURRENT MILEAGE WAS 52,732.
Latches/locks/linkages, Nov 27, 2007
BROUGHT 2001 FORD FOCUS IN FOR RECALL ON REAR DOOR LATCH, CAMPAIGN ID: 05V030000. DEALER AT ENFEILD, CT FORD WOULD NOT HONOR RECALL FOR THE REAR LATCH DOOR WHICH HAD THE SAME FAILURE AND FAILED OPEN WHILE AT HIGHWAY SPEEDS. THEY CLAIMED THE RECALL ONLY COVERED THE REAR PASSENGER DOORS AND NOT THE REAR HATCH OF A WAGON. *TR
Fuel system, Gasoline, Nov 27, 2007
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE HESITATES, STALLS, AND HAS TO BE RESTARTED EACH TIME. THE VEHICLE WAS TAKEN TO FORD AT LEAST 12 TIMES; HOWEVER, THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE DISCOVERED THAT THE FUEL PUMP FAILED. HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS RETURNED TO THE DEALER AND THEY STATED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE CURRENT MILEAGE WAS 72,000 AND FAILURE MILEAGE WAS 42,000.
Service brakes, Hydraulic, Equipment, Nov 25, 2007
BRAKES HAVE BEEN FAILING FREQUENTLY. AFTER TAKING IT TO BE REPAIRED THE FIRST TIME IN JUNE, I ATTEMPTED TO MAKE A STOP AT A RED LIGHT AND THE CAR WAS NEARLY II THE INTERSECTION BEFORE THE BRAKES WORKED. THE PROBLEM IS REPEATED AND I FEEL AS THOUGH THE CAR IS UNSAFE TO DRIVE IF THE BRAKES CAN NOT BE REPAIRED PROPERLY BY EVEN THE DEALERSHIP. *TR
Engine and engine cooling, Nov 23, 2007
THERMOSTAT HOUSING IS LEAKING. FOUND INTERNAL SEAL WALL CRACKED/WASHED OUT ALLOWING LEAKAGE PAST SEAL RING. STEADY DRIP OF COOLANT FROM THERMOSTAT HOUSING EVEN AFTER REPLACING SEAL RING. FOUND MANY OTHER COMPLAINTS OF SAME PROBLEM IN DISCUSSION THREADS ON INTERNET. COOLANT PUDDLED UNDER CAR WHERE PETS CAN DRINK IT AND LOSS OF COOLANT CAUSING OVERHEATING. *TR
Engine and engine cooling, Nov 21, 2007
EMISSIONS LIGHT WENT ON AND OFF AND THE CAR SEEMED TO MISFIRE. DID NOT DRIVE SMOOTH. I WAS GLAD I WAS CLOSE TO HOME. I FELT THE CAR WOULD CONK OUT WHILE I WAS DRIVING. *TR
Visibility, Nov 20, 2007
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE REAR WINDOWS COLLAPSED IN THE VEHICLE. THE MECHANIC STATED THAT THE PLASTIC HOLDER FAILED AND CAUSED THE CABLES TO INTERTWINE, WHICH THEN CAUSED THE WINDOW MOTOR TO MALFUNCTION. THE PASSENGER SIDE REAR PASSENGER WINDOW WAS REPLACED AT THE COST OF $300. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO A FORD DEALER FOR A DIAGNOSTIC, BUT THEY COULD NOT GUARANTEE THAT THEY WOULD BE ABLE TO ASSIST. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 25,000 AND FAILURE MILEAGE WAS 23,000.
Latches/locks/linkages, Nov 15, 2007
PASSENGER AND DRIVERSIDE DOORS ON THE 2001 FORD FOCUS ZX3 HAVE QUIT OPENING FROM THE OUTSIDE OF THE VEHICLE. DOORS HAVE LOST THE ABILITY TO BE OPENED AND I WAS INFORMED BY THE DEALERSHIP THAT THE LOCKING MECHANISMS WE "FROZEN". TO THIS DATE I HAVE NOT BEEN ABLE TO GET THE DOORS FIXED MUST LEAVE WINDOW DOWN TO REACH TO THE INSIDE TO OPEN THE DOORS IN THAT FASHION. *TR
Electrical system, Nov 15, 2007
VEHICLE IGNITION LOCK FROZE WITHOUT ANY PREVIOUS INDICATION OF MALFUNCTION. IGNITION KEY WAS UNABLE TO OPERATE LOCK. DRIVER WAS LEFT STRANDED AND LOCK SMITH HAD TO BE CALLED TO DRILL OUT THE IGNITION AS A TEMPORARY FIX AND THE IGNITION LOCK CYLINDER REPLACED AS A PERMANENT REPAIR. VEHICLE MAKE: FORD VEHICLE MODEL: FOCUS SE YEAR: 2001 *TR
Air bags, Nov 12, 2007
DEFECT REPORTED BY A PROFESSIONAL TOW COMPANY, THE INDIVIDUAL A CERTIFIED ASE AUTOMOTIVE TECHNICIAN.(VERIFIABLE) SEAT-SIDE AIRBAG DEPLOYMENT WHILE CRANKING VEHICLE. . FIRST OCCURRENCE: CRANKING VEHICLE ON ROADSIDE. DRIVER'S SEAT-SIDE AIRBAG DEPLOYS. SECOND OCCURRENCE: FOLLOWING DAY, CRANKING VEHICLE WITH PASSENGER SEATED IN FRONT. PASSENGER SEAT-SIDE AIRBAG DEPLOYS WHILE CRANKING MOTOR.NO COLLISION OR IMPACT INVOLVED NO INJURIES WORTHY OF DOCUMENTING. AIRBAG FAULTS ARE NON-DISPUTABLE UNACCEPTABLE. ANY UNWARRANTED AIRBAG DEPLOYMENT CAN COST LIVES, AND WARRANTS A FULL INVESTIGATION TOWARDS A RECALL FOR INSPECTION, AND/OR REPLACEMENT OF THE FAULT DESIGNED AIRBAG SYSTEM. *TR
Electrical system, Nov 12, 2007
I BOUGHT MY 2001 FORD FOCUS IN APRIL 2007 FROM A USED CAR DEALERSHIP. ONE DAY A COUPLE OF MONTHS AGO I WENT INTO A STORE AND WHEN I CAME OUT MY KEY WOULD NOT GO INTO THE IGNITION AND THE STEERING WHEEL WAS LOCKED. FORTUNATELY I GRABBED A PASSERBY TO HELP ME AND HE WAS ABLE TO GET THE KEY INTO THE IGNITION AND I WAS ABLE TO DRIVE THE CAR. THEN A FEW DAYS AGO I GOT HOME FROM WORK ONE NIGHT, PARKED MY CAR, AND WENT INSIDE. NEXT MORNING WHEN I TRIED TO LEAVE FOR WORK THE KEY WOULD NOT GO INTO THE IGNITION AND THE WHEEL WAS LOCKED AGAIN. AFTER AN HOUR OF TRYING TO GET THE KEY IN, I HAD TO CALL A MECHANIC TO TOW THE CAR TO THE SHOP AND GET IT REPAIRED. IT COST ME $400. *TR
Electrical system, Nov 10, 2007
IGNITION SWITCH- MY KEY WON'T ENTER THE IGNITION. I HAVE READ HUNDREDS OF COMPLAINTS ONLINE ABOUT THIS DEFECTIVE PART. FORD NEEDS TO ISSUE A RECALL ON THIS FAULTY PART. *TR
Suspension, Nov 3, 2007
2001 FORD FOCUS ZX3 WITH <55,000 MILES HAS BEEN FOUND TO HAVE BOTH FROM SPRINGS BROKEN. AT THE TIME OF DISCOVERY NEITHER SPRING HAD WORKED LOSE FROM THE PERCH, HOWEVER WITH ADDITIONAL TIME THE SPRINGS WOULD BE ABLE TO MOVE AND POTENTIALLY PUNCTURE A TIRE. *TR
Electrical system, Oct 23, 2007
IGNITION SWITCH LOCKED UP BEYOND A MERE STEERING LOCKUP AND COULD NOT BE STARTED. I HAD TO PAY TO HAVE THE VEHICLE TOWED TO THE LOCAL FORD DEALERSHIP. VEHICLE HAS 84K MILES. I HOPE I WON'T BE PAYING FOR A REPAIR THAT IS LIKELY TO BREAK AGAIN SOON. *JB
Other or unspecified, Oct 23, 2007
I HAVE A 2001 FORD FOCUS. WATER STARTED LEAKING INTO THE FRONT PASSENGER FLOOR. I TOOK IT TO THE DEALERSHIP AND THEY COULD NOT FIND A PROBLEM. THE LEAKING CONTINUED. AFTER IT RAINED AGAIN, THE WATER LEAKED INTO THE FLOOR ALL OVER MY NEW VIDEO CAMERA. I TOOK IT TO THE DEALERSHIP WHERE I LIVE AND TOLD THEM WHAT HAD HAPPENED. THEY SAID THEY COULD NOT FIND A PROBLEM, YET THE CAR DID NOT LEAK AGAIN. RECENTLY MY HUSBAND WAS DOING MAINTENANCE ON THE CAR AND FOUND A "FOR SALE" SIGN SPRAY PAINTED BLACK LODGED OVER THE CABIN AIR FILTER. HE REMOVED THE SIGN AND NOW MY CAR IS POURING WATER AGAIN. AFTER DOING SOME RESEARCH, THIS IS A COMMON PROBLEM AMONG FORD VEHICLES, ESPECIALLY '00 TO '04 FORD FOCUSES. THERE NEEDS TO BE A RECALL. *JB
Equipment, Oct 22, 2007
A/C FAN SWITCH BURNED ALONG WITH THE CONNECTING WIRE BLOCK, PUTTING SMOKE INTO THE VEHICLE, IF THE VEHICLE HADN'T BEEN TURNED OFF AFTER SEEING SMOKE COULD HAVE RESULTED IN FIRE. *TR
Electrical system, Oct 22, 2007
WHENEVER IT RAINS MY 2001 FORD EXPEDITIONS ELECTRICAL GOES CRAZY, I GET A LEAK FROM WHEAT I AM GUESSING IS THE WINDSHIELD, AND THE FLOOR GETS WET, THEN MY AC RUNS WITHOUT THE KEYS IN THE IGNITION AND MY LIGHTS COME ON AND OFF, THE RADIO GOES ON AND OFF AND KEEPS DRAINING THE BATTERY, TOOK IT TO FORD, BUT ALL THEY SAY IS IT NEEDS A NEW GEM MODULE BUT NEVER SAYS ANYTHING ABOUT THE WINDSHIELD. THIS HAS BEEN AN ON GOING PROBLEM FOR ABOUT 6 MONTHS. *JB
Steering, Oct 21, 2007
KEY CAN NOT TURN IGNITION CYLINDER. THIS IS THE ISSUE EVERY TIME I TRY TO START THE CAR. *TR