2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints
1,790 reports, newest first.
Latches/locks/linkages, Jul 22, 2011
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE LATCH ON THE REAR DRIVER AND PASSENGER SIDE DOORS WOULD NOT CLOSE PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V030000(LATCHES/LOCKS/LINKAGES: DOORS:LATCH). THE FAILURE RECURRED SEVEN YEARS LATER. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THEY PREVIOUSLY REPAIRED THE VEHICLE UNDER THE RECALL AND WOULD NOT PROVIDE ANY FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS UNKNOWN.
Fuel system, Gasoline, Jul 21, 2011
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT NOTICED THAT WHILE ATTEMPTING TO MAKE A RIGHT TURN, WITH A QUARTER TANK OF GAS OR LOWER, THE VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. THE DEALER WAS NOTIFIED WHO INFORMED THE CONTACT THAT THEY WERE AWARE OF THE FAILURE AND THAT THE MANUFACTURER HAD ISSUED A SILENT RECALL FOR THE FUEL DELIVERY MODULE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE VEHICLE NEEDED AN ENTIRE FUEL PUMP ASSEMBLY. THE MANUFACTURER WAS AWARE OF THE FAILURE; HOWEVER, DID NOT REPAIR THE VEHICLE UNDER CAMPAIGN ID NUMBER: 03V482000 ( FUEL SYSTEM, GASOLINE). NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 115,101.
Exterior lighting, Equipment, Jul 19, 2011
2001 FORD FOCUS SE 4 DOOR SEDAN. 67,140 MILES. TURN SIGNAL WILL NOT TURN OFF AUTOMATICALLY ONCE TURN IS COMPLETED EITHER TURNING LEFT OR RIGHT. HAVE TO NOW TURN OFF THE SIGNAL MANUALLY. HAPPENED ON MY WAY HOME FROM WORK ON 7-19-2011. NOTHING YET HAS BEEN DONE TO CORRECT THE FAILURE OTHER THAN AN INTERNET SEARCH TO DETERMINE WHAT MIGHT BE WRONG. *KB
Vehicle speed control, Jun 22, 2011
TL* THE CONTACT OWN A 2001 FORD FOCUS. WHEN THE CONTACT APPLIED THE BRAKES AND STOPPED THE VEHICLE IT ACCELERATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE THROTTLE POSITIONING SENSOR REPLACED. A YEAR AFTER THE VEHICLE WAS REPAIRED, THE VEHICLE CONTINUED TO ACCELERATE. THE TRANSMISSION AND THE THROTTLE POSITIONING SENSOR WERE ALSO REPLACED; YET, THE VEHICLE CONTINUED TO ACCELERATE WHENEVER THE BRAKES WERE APPLIED. THE CONTACT STATED THE THROTTLE POSITIONING SENSOR WAS DEFECTIVE AND CAUSED THE VEHICLE TO ACCELERATE. THE CONTACT WAS CONCERNED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 153,000. THE CONSUMER ALSO STATED THE VEHICLE WENT INTO NEUTRAL WHILE DRIVING. THE MECHANIC STATED IT WAS DUE TO A FAULTY TPS SENSOR. THE CONSUMER STATED THE SUDDEN ACCELERATION WOULD CEASE FOR ABUT SIX MONTHS AND THEN RETURN. THE TPS SENSOR WAS REPLACED THREE TIMES. UPDATED 07/29/11
Equipment, Jun 14, 2011
THE A/C EVAPORATOR CORE LEAKING REFRIGERANT INTO VENTS OF CAR. FUMES MAKING DRIVER AND PASSENGERS NAUSEOUS AS WELL AS A/C FAILURE. *TR
Fuel system, Gasoline, Jun 3, 2011
TL* THE CONTACT OWNS A 2001 FORD FOCUS SE. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR WHEN THE FUEL TANK WAS ONE HALF FULL OR MORE. IN ADDITION, THE VEHICLE WOULD LUNGE FORWARD ABNORMALLY AND WOULD OFTEN HESITATE. THE VEHICLE WAS NOT INSPECTED BY THE DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE HAD NO RECALLS ASSOCIATED WITH IT. THE FAILURE MILEAGE WAS APPROXIMATELY 26,000.
Air bags, Jun 3, 2011, crash
IN JULY OF 2010 I WAS DRIVING MY 2001 FORD FOCUS IN STOP AND GO TRAFFIC. THE LADY INFRONT OF ME STOPPED, I HAD TURNED FOR A SECOND, WHEN I TURNED BACK I SAW THE AIRBAGS BLOW IN MY FACE. I WAS TRAVELING A MAXIMUM OF 10MPH THERE WAS NO DAMAGE TO THE OTHER VEHICLE OR MINE (FROM THE ACCIDENT). THE DRIVER AIRBAG BURNED MY ARM, THE PASSENGER SHATTERED THE WINDSHIELD, GUN POWDER COVERED THE ROOF LINING. THE PARTS MANAGER AT THE LOCAL DEALERSHIP SAID THAT THE AIRBAGS WHERE RATED 25-30MPH. I CONTACTED FORD IN AUGUST OF 2010, IN JANUARY OF 2011 THEY FINALLY REPLIED BY SAYING THAT "ALL EQUIPMENT FUNCTIONED PROPERLY." *TR
Air bags, May 12, 2011
I WAS DRIVING MY 2001 FORD FOCUS AND FOR NO REASON THE PASSENGER SEAT SIDE AIR BAG WENT OFF. THE LOUD NOISE SCARED ME AND I ALMOST WRECK THE VEHICLE. MY EARS ARE STILL RINGING FROM THE LOUD BLAST FROM THE AIR BAG WENT OFF. I CHECKED AND FOUND THERE ARE SOME PENDING LAW SUITES FOR THIS SAME OCCURRENCE IN OTHER 2001 FORD FOCUS. I FEEL THE FORD MOTOR CO. NEEDS TO LOOK INTO THIS PROBLEM BEFORE SOMEONE GET SERIOUSLY HURT OR KILLED. *TR
Electrical system, May 10, 2011
THERE WERE NO WARNING SIGNS. ON MAY 09, 2011, THE KEY BECAME STUCK IN THE IGNITION AND WOULD NOT COME OUT. DID SOME RESEARCH ONLINE TO FIND OUT THIS IS A COMMON PROBLEM WITH NO RECALL. *TR
Visibility, May 3, 2011
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE LAMINATION ON ALL FOUR GLASS WINDOWS EXHIBITED SIGNIFICANT SEPARATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY INFORMED THE CONTACT THAT EACH WINDOW WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000.
Steering, Electrical system, Apr 12, 2011
THE EVENTS LEADING UP WERE INTERMITTENTLY SPACED THIS HAS BEEN HAPPENING SINCE I PURCHASED THE VEHICLE FROM A PRIVATE OWNER IN 2004. WHEN I WOULD PUT THE KEY IN THE IGNITION THE WHEEL WOULD NOT TURN AND FEEL LOCKED I WOULD SIT FOR 10-20 MINUTES AND WORK ON IT BY PUSHING THE KEY IN HARD AND TURNING THE WHEEL AS HARD IT WOULD COME LOOSE AND THE IGNITION WOULD TURN. THIS IMPACTED MY LIFE AS A NUISANCE. RECENTLY IN DEC OF 2010 THE OCCURRENCES BECAME MORE FREQUENT TWO TO FOUR TIMES A WEEK CONSTANTLY BEING STRANDED UNTIL I COULD GET THE IGNITION AND WHEEL TO TURN. HAPPENING FREQUENTLY WHILE AT THE STORE, WORK OR SOMEWHERE AWAY FROM HOME AND AGAIN CAUSING A GREAT NUISANCE AND FRUSTRATION AS IT HAS MADE ME LATE FOR WORK SEVERAL TIMES, ALLOWED ME TO BE VULNERABLE IN SITUATIONS THAT COULD HAVE BEEN AVOIDED WITH PROPER RECALL. THEN AROUND DEC 20TH 2010 THE IGNITION STOPPED WORKING. I WAS AT WORK LEAVING FOR THE DAY AND I SAT THERE FOR OVER AN HOUR, NOT KNOWING ANY OF THIS WAS A NORMAL RECURRENCE WITH OTHER FORD FOCUS OWNERS. AFTER WORKING ON THIS MYSELF I HAD TO CONTACT MY SPOUSE TO COME AND TRY AND HE WAS UNSUCCESSFUL AS WELL. I HAVE KEPT UP THE MAINTENANCE ON MY FOCUS AND IT IS IN VERY GOOD CONDITION FOR THE YEAR. CURRENTLY IT HAS NOT BEEN FIXED ONLY TOWED TO MY HOME RESIDENCE. THE COST IS SO HIGH FOR THE IGNITION REPLACED I HAVE BEEN GIVEN ESTIMATES OF $500 PLUS EXTRA FOR TOWING. THIS COST COMES AFTER MONTHS PREVIOUS I HAD REPLACED THE RADIATOR TANK AT A $400 COST. THIS CAR SEEMS TO HAVE SOME OF THE HIGHEST AMOUNT OF RECALLS AND SERVICE BULLETINS AND I DO NOT UNDERSTAND HOW THE MAIN POWER TO THE CAR, THE IGNITION, IS NOT SEEN AS A HAZARD TO THE PUBLIC WHO PURCHASED THESE VEHICLES. *TR
Fuel system, Gasoline, Mar 28, 2011
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE WOULD SUDDENLY STALL INTERMITTENTLY WITHOUT WARNING. THE DEALER MADE THREE ATTEMPTS TO REPLACE THE FUEL PUMP HOWEVER, THE VEHICLE CONTINUED TO STALL WITHOUT WARNING. THE FAILURE BEGAN FIVE MONTHS AGO AND THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE. THE CURRENT MILEAGE WAS 65,622 AND THE FAILURE MILEAGE WAS 63,739. UPDATED 5/2/11 *CN UPDATED 05/16/11
Engine and engine cooling, Mar 14, 2011
AFTER PURCHASING CAR WITH 62K MILES ON IT, I DISCOVERED A COOLANT LEAK THE NEXT DAY. THIS LEAK HAS GOTTEN WORSE OVER THE LAST WEEK. A SEARCH OF DIFFERENT INTERNET SITES FOUND AT LEAST 15 REPORTS OF THE THERMOSTAT HOUSING COMING LOOSE/BREAKING LOOSE FROM ITS POSITION AGAINST THE ENGINE BLOCK. THIS IS WHERE THE LEAK IS COMING FROM ON MY CAR, AND THE DESCRIPTION IN AT LEAST ONE OTHER CASE APPEARS TO BE IDENTICAL TO MY OWN LEAK. THE DESCRIPTIONS FOUND ONLINE RANGE FROM NEARLY IMMEDIATELY AFTER PURCHASE TO APPROXIMATELY 1 YEAR AFTER PURCHASE. THIS LEAK IS SEVERE ENOUGH TO GENERATE A 2FT WIDE BY 4FT LONG PUDDLE OF COOLANT IN APPROXIMATELY 12HOURS. CONTINUOUS LEAK EVEN AFTER CAR HAS SAT FOR GREATER THAN 12 HOURS RULES OUT A FAILURE ONLY WHILE UNDER PRESSURE. *TR
Electrical system, Feb 14, 2011
THE IGNITION ON THIS CAR HAS BEEN REPLACED ALREADY BY THE FIRST OWNER. WELL, THE KEY CANNOT NOT BE REMOVED FROM THE IGNITION. NOW THE KEY HAS BROKEN OFF IN THE IGNITION. THE KEY STUB CAN BE REMOVED AND THE ENGINE WILL STILL RUN. THIS MORNING I MOVED THE 01 FOCUS AND I SHUT OFF THE CAR AND TOOK THE KEY OUT BUT THE SHIFTER WAS STILL IN DRIVE. I LOCKED THE DOOR, WALKED BEHIND THE CAR AND IT ROLLED BACKWARDS INTO ME. LUCKY MY NEIGHBOR WAS THERE TO HELP ME STOP THE CAR. THERE ARE MANY COMPLAINTS FROM OTHER FOCUS OWNERS REGARDING THE FAILURE OF THE IGNITION SWITCHES AND FORD WILL NOT RECALL THE CAR AND FIX THIS DANGEROUS PROBLEM. THANKS FOR ANY HELP IN THIS MATTER.
Electrical system, Feb 6, 2011
INTERIOR DASHBOARD LIGHTS WENT OUT, ALSO NOTICED EXTRIOR REAR LIGHTS WENT OUT. REPLACED FUSES, BLEW NEW FUSES IMMEDIATELY SO SOME SORT OF SHORT IN THE ELECTRICS. WIRING ON HATCH LID APPEARS TO BE FRAYED. WE HAVE FOUND A RECALL FOR THIS FOR THE 2000 VERSION OF THIS CAR BUT NOT THE 2001.
Structure, Feb 2, 2011
HI, I RECENTLY WENT TO A FORD DEALERSHIP TO GET AN OIL CHANGE ON MY 2001 FORD FOCUS, SO WHEN THEY LIFTED MY CAR UP TO CHANGE THE OIL THEY NOTICED SOMETHING THAT WAS A MAJOR PROBLEM, MY FRONT SUBFRAME HAD ABOUT A HALF A FOOT DIAMETER HOLE IN IT BECAUSE IT HAD COMPLETELY RUSTED OUT, IT WAS ALL CORRODED AND THEY SAID THAT IF I HAD HIT A POT HOLE IN THE ROAD THAT IT COULD HAVE BROKEN IN HALF AND THE FRONT END WOULD FALL STRAIGHT TO THE GROUND BECAUSE THE FRONT SUBFRAME HOLDS UP THE WHOLE FRONT OF THE CAR. I THINK THIS SHOULD BE A RECALL BECAUSE THIS IS A MAJOR SAFETY RISK TO ALL DRIVERS OF SOME FORD FOCUS BECAUSE THEY MAY NOT KNOW ABOUT THIS, BECAUSE I WOULD HAVE NEVER KNOWN ABOUT THIS UNLESS THEY HAD TOLD ME AT THE DEALERSHIP. I CAN SEND SOME PICTURES OF THE SUBFRAME IF YOU LIKE. I JUST WANT TO MAKE SURE NO ONE GETS SERIOUSLY INJURED BECAUSE OF THIS FRONT SUBFRAME RUSTING AWAY, I WAS TOLD BY FORD THAT THE FRONT SUBFRAME SHOULD LAST THE LIFE OF THE CAR, BUT APPARENTLY THAT WASN'T THE CASE FOR MINE. I AM GETTING IT REPAIRED AS SOON AS POSSIBLE BECAUSE OF THE SAFETY RISK IT CAN CAUSE. THANK YOU FOR YOUR TIME READING THIS. *TR
Visibility, Structure, Latches/locks/linkages, Jan 30, 2011
DRIVING DOWN THE HIGHWAY OUR CHILDREN ROLLED DOWN THE BACK POWER WINDOWS AND THEY WOULD NOT GO BACK UP - SWERVED INTO OTHER LANE TRYING TO CONTAIN THE SITUATION BECAUSE OF THE NOISE FROM THE TRAFFIC HAS TO EXIT THE HIGHWAY IMMEDIATELY TO NOTE THAT THE WINDOWS WOULD NO LONGER GO UP - HAD TO MANUALLY PUSH THEM UP TO KEEP THEM UP - ALTHOUGH WHILE DRIVING THEY WILL GO BACK DOWN - WHICH CAUSE A JUMP IN REFLEXES. TO TEMPORARILY FIX THE PROBLEM WE HAVE APPLIED DUCT TAPE. ALSO WHEN IT RAINS THERE IS NOW WATER ACCUMULATING ON THE PASSENGER FLOOR BOARD AND SPREADS TO THE BACK SEAT FLOOR BOARD - HAS DOOR SEALS CHECKED AND WILL REPLACE ALTHOUGH THIS IS A REAL HEALTH CONCERN BECAUSE OF RUST AND MOLD. *TR
Electrical system, Jan 27, 2011
I HAVE HAD MY FOCUS NOW FOR ONLY ABOUT 3 YEARS, & HAVE HAD MORE PROBLEMS THAN I HAVE HAD WITH ANY OTHER VEHICLE I HAVE EVER OWNED BEFORE, COMBINED. FORD FOCUSES FROM THE YEARS 2000-2003 HAVE AN APPARENT IGNITION PROBLEM, AND I AM ONE OF THE UNFORTUNATE OWNERS TO BE LEFT STRANDED BY THIS ISSUE. I AM COMPLETELY ASTONISHED THAT PRACTICALLY EVERY SINGLE FOCUS OWNER HAS HAD THIS PROBLEM & YET THE IGNITION HAS NOT BEEN RECALLED! I HAVE HAD 2 OTHER RECALLS ON MY VEHICLE, BOTH VERY STUPID TRIVIAL ITEMS WHICH HAS NEVER AFFECTED ME IN THE SLIGHTEST. I AM VERY CLOSE TO JUST SCRAPPING THIS VEHICLE, & I AM POSITIVE I WILL NEVER BE PURCHASING ANOTHER FORD EVER AGAIN. IT DISGUSTS ME THAT SOMETHING THAT SEEMS LIKE IT WAS MADE TO BREAK... SOMETHING THAT LEFT ME STRANDED & WITHOUT A CAR FOR OVER 2 WEEKS NOW... IS ALSO SOMETHING THAT EVERY OTHER FOCUS OWNER HAS HAD TO REPLACE OUT OF THEIR OWN POCKET. HOW HAS THIS ISSUE NOT BEEN RESOLVED BY FORD YET?!?!? *TR
Fuel system, Gasoline, Jan 25, 2011
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING 5 MPH AND APPLYING THE BRAKES FOR A TRAFFIC STOP WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL ATTEMPTS. THE FAILURE WOULD OCCUR INTERMITTENTLY AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND POSSIBLE REPAIRS. THE DEALER ADVISED THE CONTACT THAT THERE WAS A LEAK IN THE PCV HOSE. THE VEHICLE WAS REPAIRED YET THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE DEALER ADVISED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 03V482000 (FUEL SYSTEM, GASOLINE) THAT COULD POTENTIALLY BE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 56,000 AND THE CURRENT MILEAGE WAS 56,500.
Fuel system, Gasoline, Jan 24, 2011
TL*THE CONTACT OWNS A 2001 FORD FOCUS ZX3 (NA). THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE FUEL SYSTEM STALLED AND HE WAS UNABLE TO MOVE THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE FUEL WAS NOT BEING PUMPED TO THE ENGINE WHICH CAUSED THE FAILURE; THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE AND ADVISED HIM THAT HIS VIN WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.
Air bags, Jan 2, 2011, crash
I OWN A 2001 FORD FOCUS. I WAS IN STOP AND GO TRAFFIC ON A ROAD NEAR MY HOUSE WHEN I ACCIDENTALLY BUMPED THE PERSON IN FRONT OF ME. BOTH MY PASSENGER AND MY DRIVER'S SIDE AIRBAGS DEPLOYED, SMASHING MY WINDSHIELD! THE OFFICER THAT REPORTED TO THE SCENE SAID THAT THERE WAS NO WAY I WAS GOING FAST ENOUGH FOR THEM TO DEPLOY BECAUSE I HAD BEEN SITTING IN THE TRAFFIC FOR A WHILE AND WE WERE MERELY ROLLING. THERE WAS NO DAMAGE TO THE FRONT OF MY CAR OR TO THE BACK OF THE OTHER PERSON'S CAR SO I FEEL THAT THE AIRBAGS PROBABLY SHOULD NOT HAVE GONE OFF. IS IT POSSIBLE THAT THIS IS A DEFECT?? *TR
Electrical system, Equipment, Dec 31, 2010
THE IGNITION WILL NOT TURN WITHOUT LARGE AMOUNTS OF SPRAY LUBRICANT AND PUMMELING THE KEY WHILE IN THE IGNITION TO CAUSE THE TUMBLERS IN THE CYLINDER TO FALL INTO PLACE. THIS IS A MAJOR SAFETY ISSUE, BECAUSE IT HAPPENS WITHOUT WARNING, AND RIGHT NOW, DURING THESE EPIC BLIZZARDS WE ARE EXPERIENCING, IT HAS CAUSED ME TO BE IN DANGER. THIS PROBLEM IS COMMON AMONG OWNERS OF THIS VEHICLE. MANY PEOPLE HAVE DEVELOPED WAYS TO TEMPORARILY FIX IT SINCE THEY DON'T HAVE MONEY AVAILABLE FIX THIS UNEXPECTED SAFETY ISSUE, WHICH IS NOT PART OF PREVENTATIVE MAINTENANCE OF AN AUTOMOBILE.... WHILE OTHERS HAVE OPTED TO JUST GET THE CAR TOWED TO A DEALERSHIP, WHICH REPLACES THE IGNITION ASSEMBLY WITH THE SAME FAULTY PARTS, AND THEN CHARGES UP TO $500. THIS IGNITION NEEDS TO BE RECALLED BY FORD, AND IT NEEDS TO BE REPLACED FREE OF CHARGE WITH A RELIABLE IGNITION ASSEMBLY. THIS MORNING, AFTER HAVING TO FIND OTHER TRANSPORTATION TO WORK FOR TWO DAYS, I FINALLY DEDICATED THREE HOURS TO GETTING THE IGNITION TO TURN. I HAD TO LEAVE THE KEY IN THE IGNITION, BECAUSE I CANNOT AFFORD TO LOSE MY JOB BY BEING ABSENT OR TARDY. I AM IN AN INITIAL PROBATIONARY PERIOD AT MY JOB, AND I THINK IT GOES WITHOUT SAYING THAT IF I HAD ENOUGH MONEY TO FIX FORD'S MISTAKES, I WOULD PROBABLY JUST GO AND BUY A DIFFERENT CAR ALTOGETHER. *TR
Suspension, Dec 30, 2010
2001 FORD FOCUS SE, VIN [XXX], 62000 MI. - BOTH FRONT COIL SPRINGS ARE BROKEN, MANY PEOPLE HAVE HAD THE SAME PROBLEM AND FORD ONLY ISSUED EXTENDED WARRANTY NUMBER 03M02 FOR 1999/2003 MODEL YEARS. I HAVE HAD THE CAR FOR ALMOST 2 YEARS AND NEVER RECEIVED ANY INFO FROM FORD ABOUT THE PROBLEM. SPRING BREAKS AND RUBS AGAINST TIRE AND CAUSES BLOW OUT. FAULTY SPRINGS. FORD ADMITS DEFECT BUT SAID I WAS PAST WARRANTY DATE AS OF 09/26/2010 THEY WOULD NO LONGER COVER THE PROBLEM - DISGRACEFUL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Equipment, Dec 29, 2010
I AM THE ORIGINAL OWNER OF A 2001 FORD FOCUS PURCHASED IN MOORESVILLE NC THE VIN IS #[XXX]. THE FUEL PUMP HAD TO BE REPLACED. THE PUMP IS THE SAME ONE DESCRIBED IN THE FORD EXTENDED COVERAGE PROGRAM03N01 DATED 2003 AND SUPPLEMENTS 1 & 2 DATED JANUARY 2004. FORD SAID MY WAS NOT COVERED UNDER THE PROGRAM BECAUSE IT WAS BUILT IN AUG. 2001 AFTER JUNE 13, 2001 CUT OFF. THE CAR WAS BUILT IN THE WAYNE ASSEMBLY PLANT, THE LOCATION OF THE FUEL PUMPS THAT FAIL. AFTER MORE SEARCH ON THE INTERNET , MY HUSBAND FOUND A TECHNICAL SERVICE BULLETIN ARTICLE #04-5-6 DESCRIBING THE PROCEDURE FOR INSTALLING A NEW DESIGN FUEL DELIVERY MODULE IN THE 2001-2002 FORD FOCUS. UNDER THE ISSUE IT STATES: THERE IS A NEW DESIGN FUELED DELIVERY MODULE AVAILABLE FOR SERVICE ON 2000-2002 FOCUS BUILT BEFORE 12/31/2001 AT WAYNE ASSEMBLY PLANT AND BUILT BEFORE 2/13/2001 AT HERMOSILLO PLANT. THE FORD MOTOR COMPANY SAID THAT MY DOES NOT QUALIFY FOR THE EXTENDED COVERAGE PROGRAM AS IT WAS BUILT IN AUG. 2001. WE THINK THAT BECAUSE THE CAR THIS THE PUMP DESCRIBED IN THE BULLETIN, WAS BUILT AT THE WAYNE ASSEMBLY PLANT WITHIN 2 MOS. OF THE JUNE 13, 2001 THAT FORD COULD HAVE COVE THE REPAIR BUT THE COMPANY WILL NOT. THIS IS AN $800 REPAIR. THE STEERING COLUMN LOCKING KEY CYLINDER IS ALSO IN NEED OF REPLACEMENT AGAIN. I NEED TO TURN THE KEY MANUALLY BACK TO A NEUTRAL POSITION FOR THE ENGINE TO RUN AFTER STARTING THE CAR. THIS IS THE THIRD LOCKING CYLINDER THAT I HAVE HAD INSTALLED IN MY CAR. I THINK FOUR CYLINDER IS A LITTLE MUCH FOR A 9 YEAR OLD CAR! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Dec 29, 2010
2001 FORD FOCUS. CONSUMER STATES FAULTY FUEL PUMP *TGW THE CONSUMER STATED AS SHE WAS DRIVING, THE VEHICLE BEGAN TO LOOSE POWER. THE VEHICLE BEGAN SURGING TO THE POINT WHERE SHE HAD TO PRESS THE ACCELERATOR ALL THE WAY DOWN TO THE FLOORBOARD AND THE VEHICLE WAS STILL BARELY MAINTAINING POWER TO GET OUT OF THE WAY OF TRAFFIC. THE FUEL FILTER WAS REPLACED AND SHE WAS ABLE TO GET THE VEHICLE BACK ONTO THE HIGHWAY. AS SHE BEGAN TO DRIVE, THE VEHICLE BEGAN TO SURGE AGAIN AND FINALLY THE VEHICLE SHUT OFF. AFTER DOING SOME RESEARCH, THE CONSUMER DISCOVERED THE VEHICLE WAS BUILT USING A FAULTY FUEL PUMP WHICH WAS FOUND TO BE A SAFETY ISSUE. NHTSA REQUIRED FORD TO ISSUE A CSP 03N01 WHICH REPLACED THE FUEL DELIVERY MODULE. THE CONSUMER STATED HER VEHICLE SHOULD HAVE BEEN INCLUDED, BUT BECAUSE THE VEHICLE WAS BUILT TWO MONTHS AFTER THE END OF THE CSP PRODUCTION DATE RANGE FORD WOULD NOT REPLACE THE FUEL PUMP FREE OF CHARGE. *JB