2004 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 387 owner complaints filed for this model year. This is the 14th highest complaint count among 19 Focus model years with reports.
Of the 2004 reports, 34 involved a crash and 13 involved a fire. 34 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints
387 reports, newest first.
Engine and engine cooling, May 19, 2004
2004 FORD FOCUS SVT *PURCHASED NEW ON APRIL 30; CAR IS LESS THAN 20 DAYS OLD *ENGINE EXHIBITS "SURGING" BETWEEN 2000-3500, ALL GEARS, ALL TEMPERATURES, LIGHT ACCELERATION *CONCERN THAT SURGING COULD THE CAR TO LUNGE FORWARD, CAUSING AN ACCIDENT OR FATALITY *CONTACTED FORD SVT TEAM (800-367-3788) AND WAS TOLD THEY ARE AWARE OF THE PROBLEM, BUT NOT CURRENTLY WORKING ON A FIX AS "NOT ENOUGH. *AK
Engine and engine cooling, Apr 30, 2004
WHILE DRIVING, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER MANAGED TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC PERFORMED A DIAGNOSTIC TEST ON VEHICLE AND FOUND THAT SPARK PLUGS AND THE HEAD OF THE ENGINE WERE WORN. MECHANIC REPLACED THE SPARK PLUGS AND THE HEAD ENGINE. *LA
Visibility, Apr 22, 2004
FORD SPORT KA HAS PRODUCED A COMMERCIAL SHOWING A CAT BEING DECAPITATED AS ITSHEAD IS LOOKING INTO THE VEHICLE VIA THE POWER SUN ROOF.*AK AS THE SUNROOF CLOSES THE CAT'S HEAD IS SEVERED. THIS COMMERCIAL WHILE MEANT TO BE HUMOROUS ONLY TO FORD CLEARLY DEMONSTRATES THE CLEAR DANGER OF SERIOUS INJURY AND DEATH TO PETS AND CHILDREN. I FORMALLY REQUEST THAT THIS COMMERCIAL BE SCENE AND REVIEWED AS A DEMONSTRATION BY FORD THAT IT'S SUNROOFS ON THIS VEHICLE AND POSSIBLY OTHER FORD VEHICLES IS INHERANTLY UNSAFE TO CHILDREN BUT NOT PROVIDING A RESISTANCE MECHANISM THAT WOULD RETRACT THE MOVING ROOF WHEN MET WITH RESISTANCE E.G. A CHILDS HEAD OR BODY PART.
Power train, Apr 12, 2004
VEHICLE WAS DRIVEN LESS THAN SEVENTY MILES AFTER BEING RELEASED FROM THE MANUFACTURER. WITHIN THAT TIME, UPON MERGING ONTO THE HIGHWAY, TRANSMISSION FAILED. TRANSMISSION STARTED SLIPPING WITH ENGINE REVVING TO 3000 RPMS, AND VEHICLE SLOWLY ACCELERATED ONTO THE HIGHWAY. WITHIN A FEW SECONDS THE TRANSMISSION ENGAGED,BUT ONLY IN THE FIRST GEAR. THIS ENTIRE INCIDENT OCCURRED AFTER THE MANUFACTURER HAD HELD THE VEHICLE BECAUSE OF A QUALITY CONTROL ISSUE. THE DEALERSHIP WANTED TO REPLACE THE ENTIRE TRANSMISSION.*AK
Electrical system, Apr 8, 2004
IGNITION CYLINDER / LOCK SEIZED AND PREVENTED VEHICLE FROM STARTING.*AK
Engine and engine cooling, Mar 29, 2004
WHILE DRIVING 35 MPH VEHICLE STALLED. *AK
Suspension, Mar 24, 2004
WHILE DRIVING 25 MPH, A LOUD POPPING NOISE WAS HEARD COMING FROM THE REAR. THE DRIVER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. PLEASE FILL ION ADDITIONAL INFORMATION. *JB
Suspension, Mar 17, 2004
WHILE DRIVING 55 MPH A LOUD BANGING NOISE WAS HEARD COMING FROM THE REAR WHEEL. DRIVER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC INFORMED CONSUMER THIS VEHICLE WAS NOT COVERED UNDER A RECALL. *AK
Wheels, Mar 12, 2004
I WOULD LIKE TO HAVE SOMEONE INVESTIGATE THE MATERIAL USED IN THE REAL WHEEL COVERS OF THE 2004 FORD FOCUS ZTW WAGON. I BELIEVE THIS PRODUCT DOES NOT PROTECT THE VEHICLE FROM MOVING OBJECTS. *AK
Engine and engine cooling, Mar 5, 2004
WHILE DRIVING ENGINE LIGHT ILLUMINATED, THEN VEHICLE STALLED. *AK
Engine and engine cooling, Mar 2, 2004
WHILE DRIVING THE ENGINE LIGHT ILLUMINATED. THEN, VEHICLE STALLED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Electrical system, Feb 3, 2004
WHILE DRIVING VEHICLE STALLED. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DID NOT RESOLVE THE PROBLEM. *AK