2004 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 387 owner complaints filed for this model year. This is the 14th highest complaint count among 19 Focus model years with reports.
Of the 2004 reports, 34 involved a crash and 13 involved a fire. 34 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints
387 reports, newest first.
Electrical system, Aug 29, 2016
THE CAR HAS HAD 5-6 REPAIRS OVER THE LAST 6 YEARS. 3 BATTERIES AND 2 ALTERNATORS. THE CAR DIES OUT WHILE DRIVING AND WONT RESTART WITHOUT A JUMPSTART, IS DEAD RANDOMLY OR ONLY CLICKS.JUST SPENT ANOTHER $200 ON AN ALTERNATOR WHEN THE KEY WONT TURN AND THE REAL PROBLEM OVER ALL THESE YEARS HAS COME TO LIGHT. VERY DANGEROUS SITUATION WITH THE CAR JUST DIEING WHEREVER AND WHENEVER.
Engine, Aug 24, 2016
WE HAD PURCHASE A 2004 FORD FOCUS AND WE HAVE HAD IT FOR 2 YEARS NOW. FOR THE LAST 4 MONTHS I HAVE NOTICE THAT THE CAR OVERHEATS WELL THE NEEDLE WILL SHOOT UP TO THE HOT AND YOU CAN HEAR THE FAN/ENGINE WHATEVER OTHER COMPONENTS RUNNING LOUD AS IF ITS REVVING THE ENGINE. I HAVE BEEN SCARED A FEW TIMES BECAUSE IT WOULD ALSO STALL LIKE ITS ABOUT TO GO OFF AND A COUPLE TIME IT HAS WHILE AT A STOP LIGHT. WONDERING IS THIS A COMMON PROBLEM FOR THIS VEHICLE? THE OVERHEATING HAPPENS VERY OFTEN IT HAPPEN DURING A SHORT DRIVE OR LONG DRIVE LIKE 12 TO 16 MILES. IT ALSO SEEMS TO DO IT A LOT WHEN I'M AT HEAVY TRAFFIC AND WHEN YOU SIT THERE FOR 3 LIGHTS TURNS BECAUSE OF THE AMOUNT OF CARS I NOTICE IT OVERHEATS THEN. ALSO, ALWAYS OVERHEATS WHEN I GO TO COSTCO TO BUY GAS. DUE TO THE LONG WAIT FOR MY TURN TO PUMP GAS IT OVERHEATS THEN. IT DOESN'T SEEM TO MATTER OF THE WEATHER BECAUSE IT HAS BEEN COOL IN THE MORNINGS AND IT HAS DONE THAT AND ALSO DONE SO DURING HIGH NOON. HAVE ALSO EXPERIENCE IT DURING NIGHT TIME. IS THERE A RECALL FOR THIS ON THIS TYPE OF VEHICLE? WE BOUGHT THIS FROM A PRIVATE PARTY SO WOULD LIKE TO KNOW HOW WE CAN MAKE SURE IF THERE IS A RECALL WE WOULD BE CONTACTED. RECENTLY I CAN START THE CAR UP GO ONE BLOCK FROM MY DRIVEWAY AND THE CAR WILL OVERHEAT. VERY CONCERN ABOUT THE SAFETY ISSUE ON THIS.
Latches/locks/linkages, Aug 2, 2016
TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE TRUNK PANEL DID NOT LATCH INTERMITTENTLY AND THE TRUNK PANEL WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT IT TOOK NUMEROUS ATTEMPTS FOR THE TRUNK PANEL TO LATCH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LATCHES WERE DEFECTIVE. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE CONTACT ATTEMPTED TO REPAIR THE VEHICLE NEARLY THREE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 101,000.
Power train, Jul 12, 2016
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Other or unspecified, Jun 13, 2016
WHILE LEAVING WORK, I ATTEMPTED TO START MY VEHICLE, HOWEVER, WHEN I PUT THE KEY INTO THE IGNITION, THE KEY WOULD NOT TURN. THE STEERING WHEEL WAS LOCKED UP, AND I COULD NOT GET THE VEHICLE TO START. I LOOKED ONLINE AND APPARENTLY THIS IS A COMMON ISSUE. I AM A POLICE OFFICER IN MY UNIFORM AND IT IS VERY UNNERVING TO BE STRANDED LIKE THAT.
Electrical system, Apr 8, 2016
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE PARKED, THE VEHICLE WAS NOT ABLE TO START. THE FAILURE OCCURRED CONSTANTLY. THE CONTACT HAD TO JUMPSTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 142,000.
Visibility/wiper, Mar 31, 2016
DRIVER WINDOW SHATTERED WITH PIECES OF GLASS FALLING ON SPOUSE. CAR WAS NOT MOVING. WINDOW WAS GOING UP. HAD INDEPENDENT SHOP REPLACE WINDOW, SWITCH, REGULATOR. COST $490.
Electrical system, Electronic stability control (ESC), Visibility/wiper, Feb 4, 2016
MY CAR WAS TURNED OFF AND MY DASH LIGHTS WOULD FLICKER AND BEEP, MY RADIO GOES ON AND OFF BY IT SELF, THE REAR WIPER AND THIRD BRAKE LIGHT DO NOT WORK, AND NOW EVERYTHING DOES NOT WORK.
Air bags, Feb 1, 2016
TAKATA AIR BAG RECALL: I LOOKED UP MY VIN NUMBER ON THE GOVT. WEBSITE MANY MONTHS AGO, AND FOUND THIS CAR HAS POTENTIALLY FAULTY TAKATA AIR BAGS. I HAVE NOT BEEN ABLE TO MOVE REPLACEMENT FORWARD ON SEVERAL OCCASIONS, SINCE FORD HAS YET TO ISSUE A RECALL ON THIS MODEL. THE DEALER SAYS THEY NEED A RECALL NOTICE FROM FORD USA AND WHEN I CALL FORD USA THEY DO NOT KNOW HOW TO MOVE FORWARD ON A RECALL FOR THIS AIRBAG. THE DEALER ALSO SAID I COULD NOT BE GUARANTEED A SAFE AIR BAG IF THEY JUST REPLACED THE ONE I HAVE, SINCE THE REPLACEMENT MIGHT ALSO BE FAULTY, UNLESS IT WAS A SPECIAL REDESIGNED ONE AS ISSUED IN A RECALL SETTING. I CALLED DTVSH ON THE RECOMMENDATION OF FORD USA AND THEY RECOMMENDED I FILE A COMPLAINT WITH THE FTC. THE FTC CONTACT GAVE ME A CASE NUMBER: 69255063. I FEEL VERY UNCOMFORTABLE DRIVING AROUND IN A CAR WITH A POTENTIAL BOMB IN THE STEERING WHEEL, OR LOANING IT TO FAMILY MEMBERS. THE DEALER EVEN SAID I COULD JUST QUIT USING MY CAR FOR THE YEARS IT MIGHT TAKE TO WAIT FOR THE RECALL (!!!) I THINK THEY SHOULD GIVE ME A LOANER IF THEY THINK ITS THAT SERIOUS, YET THEY DO NOT HAVE THE POWER TO MOVE FORWARD ON STARTING A RECALL. THEY HAVE THREE MODELS OF CARS FROM THE YEAR MINE WAS BUILT THAT ARE UNDER RECALL. PLEASE INITIATE A RECALL ON THE FORD FOCUS WAGON TO ENSURE IT IS REASONABLY SAFE TO DRIVE. THE TYPES OF ACCIDENTS THAT ARE KILLING PEOPLE FROM THE EXPLODING, SHRAPNEL FILLED AIR BAGS ARE LOW IMPACT AND OTHERWISE WOULD NOT BE FATAL. I DON'T WANT ME OR SOMEONE IN MY FAMILY DYING BECAUSE FORD IS NOT IN RECALL TO FIX THIS PROBLEM. THANK YOU. *TR
Steering, Jun 11, 2015
I PARKED THE CAR OVER NIGHT. IN THE MORNING ON MY WAY TO A MEDICAL APPOINTMENT I INSERTED THE KEY IN THE IGNITION AND THE STEERING WAS LOCKED UP. THE KEY GOES INSIDE THE IGNITION BUT IT WOULD NOT TURN. I ONLY IMAGINE THE SAME SITUATION WHILE I AM DRIVING THE VEHICLE. THE STEERING WHEEL WOULD NOT MOVE, CAN IT HAPPEN? HAS IT HAPPEN? LET YOU BE THE JUDGE.
Electrical system, May 29, 2015
CAR WAS INOPERABLE DUE TO KEY NOT WORKING IN THE IGNITION AND EMERGENCY REPAIR SERVICE IN PARKING LOT HAD TO BE DONE. READ MORE: HTTP://WWW.JUSTANSWER.COM/NEW-QUESTION/OPTIONAL-INFORMATION.ASPX?TQID=423907452&PT=630&CATID=56411&R=AUTOBEEF&RPT=220#IXZZ3BAC4IRXZ
Other or unspecified, May 29, 2015
MY WIFE HAS BEEN DRIVING THE FOCUS STATION WAGON SINCE 2004. ALL OF A SUDDEN, THE 'CLICKER' DID NOT ALLOW US TO CLOSE THE DRIVER'S SIDE REAR PASSENGER DOOR LOCK; WE FOUND THIS OUT WHEN THE CLICKER DID NOT SOUND THE 'BEEP' WE ARE USED TO. WE TRIED TO MANUALLY LOCK THE DOOR, BUT THAT WAS ALSO INEFFECTIVE. THE ONLY SOLUTION WAS A REPAIR BY OUR LOCAL SERVICE STATION FOR APPROXIMATELY $500.00. THERE WERE TWO SEPARATE ISSUES. THE PRIMARY ISSUE, OF COURSE, WAS THE SAFETY OF THE REAR SEAT PASSENGER. THE SECOND ISSUE WAS THE ONGOING PROBLEM OF ENTRY TO THE AUTO WHEN UNATTENDED.
Engine, Mar 31, 2015
TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE AIR FILTER NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 220,000.
Suspension, Structure, Mar 18, 2015
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING AT VARIOUS SPEEDS, A RATTLING TYPE NOISE WAS HEARD COMING FROM THE REAR WHEEL AREA. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE REAR PASSENGER SHOCK ABSORBER PUNCTURED THROUGH THE WHEEL WELL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE FAILURE WAS DUE TO RUSTING AND CORROSION OF THE WHEEL WELL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.
Vehicle speed control, Mar 16, 2015, crash
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING AT 27 MPH, THE ACCELERATOR PEDAL BECAME STUCK CAUSING THE CONTACT TO CRASH INTO THE ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED AND TOWED. THE DRIVER SUSTAINED NECK AND BACK INJURIES AND THE PASSENGER SUSTAINED A BRUISE KNEE, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Engine, Mar 11, 2015
TL*THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT NOTICED THAT THE FAILURE RECURRED INTERMITTENTLY WHENEVER A BUMP OR A POTHOLE WAS HIT ON THE ROAD. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. UPDATED. 06/09/15 *BF
Vehicle speed control, Feb 25, 2015, crash
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING APPROXIMATELY 15 MPH, AN UNINTENDED ACCELERATION OCCURRED AND THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT CRASHED THE VEHICLE INTO A SNOW EMBANKMENT. THERE WERE NO INJURIES OR DAMAGES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DRIVEN FROM THE SCENE. THE VEHICLE WAS NOT DIAGNOSED REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Seats, Jan 8, 2015
WHILE I AM DRIVING THE CAR AND IT IS MOVING, THE DRIVER SIDE SEAT IS SUDDENLY DISENGAGING, MOVING BACK AND SO LEAVING MY DRIVING POSITION COMPROMISED, AS MY FOOT MOVES AWAY FROM THE GAS PEDAL AND MY ARMS ARE SUDDENLY OUTSTRETCHED REACHING FOR THE DRIVERS WHEEL SO THAT THERE IS A SUDDEN LOST OF CONTROL OF THE CAR. THIS HAS HAPPENED NUMEROUS TIMES AT THIS POINT. *TR
Structure, Dec 15, 2014
TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, AN ABNORMAL NOISE EMITTED FROM THE FRONT DRIVER SIDE DOOR. THE FRONT DRIVER SIDE DOOR SWUNG OPEN INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 770,714.
Engine, Nov 17, 2014
THE CAR CUT OFF WHILE DRIVING. ON TWO SEPARATE OCCASIONS , OUNCE WHILE DOING 60MPH, THE OTHER TIME DOING 35MPH. *TR
Air bags, Nov 5, 2014, crash
HEAD ON COLLISON WITH ANOTHER CAR. CARS IN FRONT OF ME STOPPED SUDDENLY. I GOING DOWN ONE OF THE BUSIEST ROADS IN TOWN AND I COULDNT STOP IN TIME. FRONT OF MY CAR HAS SIGNIFICANT UNDRIVABLE DAMAGE. THE AIR BAG DID NOT DEPLOY. *TR
Electrical system, Sep 14, 2014
IGNITION LOCK STUCK. KEY WOULD NOT WORK. CAR HAD TO BE TOWED. IGNITION HAD TO BE REPLACED. COULD HAVE BEEN VERY DANGEROUS DEPENDING ON WHERE CAR WAS PARKED. *TR
Service brakes, Engine, Aug 11, 2014
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. IN ADDITION, WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT HEARD AN ABNORMAL NOISE. THE FAILURES OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
Steering, May 14, 2014
TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, AN ABNORMAL NOISE EMITTED FROM THE REAR OF THE VEHICLE AS IT ABNORMALLY BEGAN STEERING TO THE RIGHT. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING HOWEVER, THEY COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Fuel system, Gasoline, Apr 23, 2014
VERY DANGEROUS FAULT OR DEFECT FOUND ON MY CAR. A FUEL LINE THAT RUNS ALONG THE TOP OF THE ENGINE IS CONTACTING AN OPPOSING METAL BRACKET. THIS CHAFFING CONDITION HAS RESULTED IN DAMAGE TO THE FUEL LINE. THE FUEL LINE IS PROTECTED WITH PADDED SILVER TAPE; THE TAPE AND PADDING HAS BEEN ENTIRELY CUT BY THE BRACKET AND HAS CREATED A CUT MARK ON THE FUEL LINE. NO FUEL LEAKED BECAUSE OF THIS CONDITION. HAD THIS GONE WITHOUT DISCOVERY, THE FUEL LINE WOULD HAVE LIKELY BURST AND ALLOWED FUEL TO SPILL ON TOP OF THE ENGINE. THE METAL BRACKET CREATING THIS HAZARD IS A MOUNTING POINT FOR AN AIR BYPASS VALVE (3S41-9F491-AC). THIS VALVE AND MOUNTING BRACKET IS A COMPONENT UNIQUE TO THE PZEV VARIANT OF THE FORD FOCUS. PICTURES OF THIS DEFECT HAVE BEEN POSTED IN AN ONLINE PUBLIC FORUM LOCATED HERE-> HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=407090 THE TITLE OF THE FORUM THREAD IS "DANGER - FUEL LINE BEING CUT ON A 2004 PZEV". *TR