2005 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 441 owner complaints filed for this model year. This is the 12th highest complaint count among 19 Focus model years with reports.
Of the 2005 reports, 43 involved a crash and 9 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: electrical system
113 reports, newest first. Show all
Electrical system, Latches/locks/linkages, May 18, 2014
THE BACK DOOR DRIVERS SIDE WILL NOT LOCK. THE DRIVERS DOOR WILL NOT OPEN FROM THE OUTSIDE. I REPLACED THE DOOR HANDLE BUT IT WILL STILL NOT WORK. IT DOES NOT SEEM TO BE TOUCHING OPENING MECHANISM. *JS
Electrical system, Exterior lighting, Service brakes, May 16, 2014
THIS IS THE THIRD TIME I HAD TO PLACE FRONT LEFT AND RIGHT HEAD LAMPS AND HIGH BEAMS . I BROUGHT THIS CAR OFF OF ENTERPRIZE DEALER IN NEVADA. OVER THE YEARS I BEGAN HAVEN LOTS OF PROBLEMS WITH THIS CAR. SO MUCH NEEDED TO BE DONE ON THIS CAR AND I SPENT LOTS OF MONEY TOO. NOT KNOWING UNTIL NOW THIS CAR HAS SOME RECALL ISSUES. PASSENGER REAR DOOR REPLACE AND BROKEN AGAIN. THE REAR BRAKE ARE RUSTED AND NEEDS TO BE REPLACE,DRUMS PADS EXT.. NOISE IN THE STEERING WHEEL WHEN I TURN THE CAR. *TR
Electrical system, Exterior lighting, Dec 22, 2013, fire
REFERRING TO CASE # [XXX]. UPON FURTHER INSPECTION IT WAS DETERMINED THAT THE ROOT CAUSE OF THE SHORT WAS IN FACT THE SMALL BUNDLE OF WIRES GOING INTO THE LIFTGATE. REPAIRS HAVE BEEN MADE TO ALL AFFECTED WIRES. INCLUDING INSTALLATION OF A BRAND NEW HEADLIGHT SWITCH FORD CERTIFIED. COST OF REPAIRS 2347 DOLLARS AND 97 CENTS.UPON READING OTHER COMPLAINTS ON THIS WEBSITE I'VE SEEN AT LEAST 40 OTHER CASES CAUSED BY THE SAME BUNDLE OF WIRES. THIS IS VERY DANGEROUS AND AS YOU CAN SEE COULD POTENTIALLY CAUSE A VEHICLE TO BURST INTO FLAMES WHILE DRIVING. SOMETHING'S GOTTA BE DONE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Dec 21, 2013, fire
DRIVING ON ROUTE 209 APPROXIMATELY 40 MILES AN HOUR. I NOTICED WHITE SMOKE COMING THROUGH THE DASH. IMMEDIATELY PULLED THE CAR OVER, PUT THE CAR IN PARK, REMOVED THE KEY, AND GOT OUT OF THE CAR. WITH NO KEY IN THE IGNITION THE STARTER BEGAN TURNING OVER. I DIDN'T HAVE ANY TOOLS TO UNHOOK THE BATTERY. THE STARTER TURNED OVER FOR ABOUT A MINUTE, THEN THE WINDSHIELD WIPERS, HEADLIGHTS, AND HORN ALL BEGAN ACTIVATING. I IMMEDIATELY CALLED MY MECHANIC FOR EMERGENCY ROADSIDE ASSISTANCE. AFTER ABOUT 4 MINUTES OF THE WIPERS HEAD LIGHTS AND HORN ALL ACTIVATING WITH NO KEY IN THE IGNITION, SOMEONE STOPPED AND HAD SOME TOOLS UNHOOK THE BATTERY.MECHANIC SHOWED UP ABOUT FIVE MINUTES LATER, HAD THE CAR TOWED TO HIS SHOP, AND BEGAN SEARCHING FOR THE PROBLEM. AFTER REMOVING THE DASH PANELS HE SAYS THAT THE HEADLIGHT SWITCH COST A SHORTWHICH MELTED ALL THE WIRES TOGETHERUNDER THE DASH AND GOING BACK TO THE TAIL LIGHTS.HE SAYS IT IS DUE TO THE SMALL WIRES THAT FORD USES AND THEY'RE HARNESSES AND THE WAY THEY TWIST THEM TOGETHER SO THEY WILL FIT INTO THE SMALL PLASTIC TUBE UNDER THE DASH. I HAVEN'T BEEN ABLE TO FIND A RECALL TO ATTACH THIS PROBLEM TOO. HOWEVER I REALLY THINK FORD SHOULD BE RESPONSIBLE FOR THESE DAMAGES. I'M CONSIDERING THIS CAR A TOTAL LOSS. *TR
Electrical system, Exterior lighting, Dec 10, 2013
THE LEFT REAR TURN SIGNAL STOPPED WORKING- THE BLOWN BULB INDICATION WAS NOTICED BY THE FAST FLASH SIGNAL ON THE DASHBOARD INDICATOR. WHEN GOING TO REPLACE THE BULB IT WAS FOUND THAT THE UPPER SOCKET FOR THE TURN SIGNAL SOCKET IS MELTED TO THE LENS COVER. THE LENS COVER SOCKET MOUNTING HOLE WAS DISTORTED BY HEAT. ONCE THE SOCKET WAS REMOVED THE BULB WAS FOUND NOT TO BE BLOWN. THE SOCKET HOUSING SHOWS INTERNAL SIGNS OF HEAT DAMAGE -COLOR CHANGE. THE BULB WAS IN POSITION IN THE SOCKET AND THE BULB BASE SHOWED NO SIGN OF MELTING AT THE BULB CONTACT POINTS. IT APPEARS THE HEAT WAS GENERATED IN THE SOCKET CONNECTION TO THE BULB BASE. THERE ARE MULTIPLE COMPLAINT OF A SIMILAR FINDING ON MULTIPLE YEARS OF THE FORD FOCUS THAT WERE EASILY FOUND WITH A INTERNET SEARCH- FORD FOCUS MELTED SOCKET. PURCHASING REPLACEMENT SOCKET FROM DEALER AS THIS IS A MAJOR PERSONAL SAFETY ISSUE. *TR
Electrical system, Vehicle speed control, Service brakes, Oct 8, 2013
SINCE WE RECEIVED THE CAR, WE HAVE NOTICED INCONSISTENT ACCELERATION AND DECELERATION - BOTH IN TOWN AND ON THE HIGHWAY. THIS PARTICULAR INCIDENT WAS A SIMPLE SLOWING DOWN FOR A STOP LIGHT. I PRESSED ON THE BRAKE GENTLY TO START COMING TO A FULL STOP BEHIND A FEW CARS. AS MY CAR TRIED TO SLOW DOWN, I NOTICED IT WAS FIGHTING TO SLOW DOWN. I PRESSED ON THE BREAK HARDER, BUT IT WASN'T GOING TO BE ENOUGH TO STOP WITHOUT HITTING THE CAR IN FRONT OF ME. I TAPPED THE ACCELERATOR, THEN BACK ON THE BREAK, NO CHANGE. NOT KNOWING WHAT ELSE TO DO, I PUT THE CAR INTO NEUTRAL. THE ENGINE DID NOT STOP REVVING UP SO I TURNED THE CAR OFF. AFTER WAITING A MINUTE, I TURNED THE CAR BACK ON AND OPERATED FINE FOR THE REMAINDER OF THE DAY. *TR
Electrical system, Jun 10, 2013
TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE WIRING HARNESS FAILED ON THE REAR HATCH OF THE VEHICLE. THE BRAKE LIGHTS STOPPED WORKING AND IT CAUSED THE GEAR SHIFT TO BECOME STUCK. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE DESIGN OF THE WIRING HARNESS WAS TOO SHORT AND WHEN IT WAS STRETCHED THE WIRES CAUSED THE FAILURE TO OCCUR. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 110,000. *TR
Electrical system, May 29, 2013
TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH WITH THE HEADLIGHTS IN OPERATION, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS BECAME EXTREMELY DIM. THE ENGINE WAS TURNED OFF AND THE VEHICLE FAILED TO RESTART. A CERTIFIED MECHANIC INSPECTED THE VEHICLE AND REPLACED THE ALTERNATOR. THE FAILURE WAS CONTRIBUTED TO A FAULTY LIFTGATE WIRING HARNESS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 176,000. UPDATED 08/15/13*LJ
Power train, Electrical system, May 16, 2013
KEY STUCK IN IGNITION. THE COLUMN WAS NOT LOCKED. ON THE GEAR SHIFT THERE IS A PLASTIC SLEEVE. I PUT THE GEAR SHIFT IN PARK AND SLID MY HAND BELOW THE KNOB AND PULLED THE SLEEVE UP AND THE KEY COMES OUT. *TR
Electrical system, Latches/locks/linkages, Feb 20, 2013
THE REAR DRIVER SIDE DOOR LOCK WILL NOT LOCK. THE CHILD SAFETY LOCK DOESN'T EVEN MAKE IT WORK. ALL OTHER DOORS WORK WITH THE REMOTE ENTRY KEY FOB AND ALARM ACTIVATES BUT THE REAR PASSENGER DOOR REMAINS UNLOCKED. I CAN NOT EVEN LOCK IT MANUALLY. I FEAR MY GRANDCHILDREN WILL BE ABLE TO SIMPLY OPEN THE DOOR AND EXIT THE CAR AND AM VERY CONCERNED FOR THEIR SAFETY NOT TO MENTION THE POSSIBLITY OF SOMEONE ENTERING THE CAR TO DO HARM OR VANDELIZE THE VEHICLE. *TR
Steering, Suspension, Engine and engine cooling, Power train, Electrical system, Exterior lighting, Visibility, Latches/locks/linkages, Wheels, Seats, Dec 5, 2012
TL* THE CONTACT OWNS A 2005 FOR FOCUS ZXW STATION WAGON. THE CONTACT STATED THAT WHEN THE KEY WAS IN THE IGNITION AND THE SHIFT OVER RIDE BUTTON WAS DEPRESSED, THE KEY WOULD BECOME LOCKED IN THE IGNITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE CONTACT GLUED THE SHIFT OVER RIDE BUTTON IN PLACE AND CHANGED THE IGNITION, WHICH RESOLVED THE FAILURE. THE CONTACT ALSO STATED THE METAL FRAME OF THE DRIVER'S SEAT BECAME CRACKED. THE CONTACT HAD TO PROP THE SEAT UP SO THAT HE COULD DRIVE THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 205,000. UPDATED 02/20/13*LJ THE CONSUMER STATED THE TRANSMISSION WAS POORLY DESIGNED. UPDATED 02/21/13 THE CONSUMER STATED THE EXPERIENCED NUMEROUS PROBLEMS WITH THE TRANSMISSION, AFTER HAVING THE FLUID FLUSHED. THE CONSUMER STATED THE SIDE VIEW MIRRORS WERE RIGID AND WERE EASY TO BREAK, THE REAR SUSPENSION SPRINGS WERE NOT DESIGNED TO CARRY WEIGHT, WHICH CAUSED THE VEHICLE TO BOUNCE ON THE HIGHWAY AND SECONDARY ROAD BUMPS. THE HEAT SHIELDS ATTACHED TO THE EXHAUST SYSTEM WERE DESIGNED POORLY, TO THE POINT THEY WERE BENT AND CAUSED A RATTLE. THE STEEL RIMS, BENT EASILY, WHICH CREATED A VIBRATION AND BALANCE PROBLEM. THE HEADLIGHTS LENSES WERE DISCOLORED, THE VALVE COVER GASKET LEAKED OIL ONTO THE SPARK PLUGS, THE HOOD CABLES WERE DEFECTIVE. THE HOOD CABLE FROZE AND BROKE. UPDATED 07/25/13
Electrical system, Sep 30, 2012
PURCHASED THE CAR NEW, HAVE HAD TO HAVE ALTERNATOR AND BATTERY REPLACED 3 TIMES NOW. EVERY TIME IT GOES OUT WITHOUT WARNING AND IN MOST CASES ON THE HIGHWAY OR IN HEAVY CITY TRAFFIC. I ALMOST COULDN'T STOP NOR STEER THE CAR SAFELY AWAY FROM THE ROAD. EACH OCCURRENCE HAS COST ME 500.00 USD FROM TOWING, PARTS, AND LABOR. *TR
Electrical system, Latches/locks/linkages, Sep 26, 2012
THE REAR PASSENGER DOOR WILL NOT LOCK OR UNLOCK WITH THE KEYLESS ENTRY NOR THE BUTTONS IN THE CAR. TURNING ON OR OFF THE CHILD LOCK FEATURE DOES NOT AFFECT IT. I CAN MANUALLY 'FORCE IT' EITHER WAY - BARELY - FOR NOW. THIS HAPPENED ONCE BEFORE SEVERAL YEARS AGO - WHERE IT WAS STUCK COMPLETELY UNLOCKED, AND YOU COULDN'T MANUALLY FORCE IT. IT WAS LIKE THAT FOR SEVERAL MONTHS AND THEN MYSTERIOUSLY FIXED ITSELF. I HAVE LOOKED UP THIS PARTICULAR PROBLEM ONLINE AND HAVE FOUND THAT THIS MAKE & MODEL APPEARS TO HAVE MANY CARS WITH THIS ISSUE YET FORD HAS NOT DONE A RECALL ON IT. THIS IS A SAFETY ISSUE. TWO SCENARIOS ARE POSSIBLE HERE THAT ALARM ME: EITHER EMERGENCY PERSONNEL CAN NOT OPEN THE DOOR BECAUSE IT'S STUCK IN THE LOCKED POSITION AND CANNOT BE MOVED OR THE DOOR REMAINS UNLOCKED AND UNWANTED PERSONS GET IN OR THINGS IN THE CAR GET STOLEN BECAUSE THE LOCK IS STUCK UNLOCKED. COMMON SENSE WOULD SEEM TO ARGUE THAT THIS DESERVES TO BE FIXED AT NO COST TO THE CONSUMER, GIVEN THE SAFETY ISSUES WITH THIS DEFECT. *TR
Electrical system, Air bags, Seats, Jun 22, 2012
ON 2/26/2011 AT APPROXIMATLY 1900 HRS. I WAS AT NELLIS AIR FORCE BASE IN LAS VEGAS NEVADA I HAD TO PULL OVER IN A SAFE AREA TO LOOK FOR MY ID AS I GOT OUT OF THE CAR WITH THE CAR IN PARK AND EMERGENCY BRAKE ON I PROCEEDED TO LIFT THE HANDLE IN FRONT OF THE SEAT THAT ALLOWES IT TO BE MOVED FORWARD SO I CAN LOOK UNDER THE SEAT FOR MY ID,I COULDN'T SEE IT SO I PROCEEDED TO DO THE SAME WITH THE PASSANGER SEAT AND IT WASEN'T THERE SO AGAIN I WAS ON THE DRIVERS SIDE AND AGAIN PULLING UP THE HANDLE AND MY RIGHT SIDE OF MY FACE AND EAR WAS WITHIN AN INCH OF THE SIDE AIR BAG WHEN IT EXPLODEDAND NOCKED ME UP AGAINST THE DRIVERS DOOR FRAME AND THE AIRBAG POWDER WAS ALL OVER ME AND FOR 30 SECONDS I COULDN'T SEE OR HEAR. MY FACE WAS ON FIRE WITH ACID BURNS ALL OVER MY FACE AND MY RIGHT EAR. I WAS SEEN AT THE ER AND WAS TREATED WHICH INCLUDED A CAT SCAN OF MY HEAR TO SEE IF THERE WAS ANY INTERNAL TRAMA AND THAT WAS NEGATIVE HOWEVER I HAD DEVELOPED TMJ BECAUSE OF THE IMPACT TO MY JAW AND MIGRAIN HEADACHES WHICH HAVE NOT SUBSIDED TO THIS DAY. ALL REPORTS AND PICTURES ID TAKEN WERE SENT THROUGH E-MAIL TO FORD CLAIMS DEPT. I WAS SENT THE PAPER WORK TO FILL OUT AND SEND IT BACK TO THEM,IN MARCH 2011 I HAVE TO GOT TO A DEALER TO HAVE THE CHIP RED AND IT COST TO HAVE THAT DONE WAS $103.48. IT STATES THAT THE DTC B1231 RESTRAINT SYSTEM WAS SUFFICIENT IMPACT TO WARRENT A DEPLOYMENT YET INDICATES THAT NO COLLISION OCCURED. SO THEN NOW THE MODUAL NEEDS TO BE TAKEN OUT BY THE DEALER WHICH I WENT TO FORD AND THEY REFUSED TO HELP, SO THAT EVENING WENT TO ANOTHER FORD AND THEY HELPED IT TOOK THEM JANUARY 2012 TO COORDINATE WITH FORD TO TAKE OUT THE MODGUAL, I JUST FOUND OUT A WEEK AGO JUNE 14TH. THAT BOSH IS JUST NOW TAKING A LOOK AT THAT PRODUCT THAT WAS SENT TO THEM IN JANUARY 2012.16 MONTHS LATER NOTHING ELSE HAS BEEN DONE AND I DON'T KNOW WHAT ELSE I CAN DO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
Steering, Electrical system, May 20, 2012
WENT TO PICK MY SON UP FROM SCHOOL. COULD NOT GET KEY OUT OF IGNITION. TOOK TO A LOCAL MECHANIC AND CYLINDERS WERE REPLACED. THAT WAS IN MARCH. GOT HOME TODAY (MAY) AND THE SAME PROBLEM. LUCKILY HAVE A DRIVEWAY BUT I AM ANNOYED AND NERVOUS ABOUT KEEPING THIS CAR. FEARFUL THAT THE KEY MAY GET STUCK AT AN INOPPORTUNE TIME. *TR
Electrical system, Apr 12, 2012
I PURCHASED THIS VEHICLE NEW IN 2005. WITHIN THE FIRST YEAR AND A HALF I STARTED NOTICING THAT THE DASH LIGHTS WOULD ILLUMINATE WHEN THE VEHICLE WAS PARKED, NO KEYS IN THE IGNITION. THE ABS AND BATTERY LIGHT WOULD FLICKER ON AND OFF ACCOMPANIED BY A BUZZING SOUND. THE WIRELESS REMOTES STOPPED WORKING AS WELL. I BROUGHT THE VEHICLE TO FORD AS IT WAS STILL WITHIN THE THREE YEAR/36,000 MILE WARRANTY PERIOD. THEY SAID THAT THEY COULD NOT DUPLICATE THE PROBLEM. THEY RE-PROGRAMMED THE WIRELESS REMOTES. AFTER THIS THE PROBLEM CONTINUED WITH THE FLICKERING LIGHTS AND BUZZING SOUND AND ALSO THE WIRELESS REMOTES STOPPED WORKING. I RETURNED THE VEHICLE TO FORD AND THEY TOLD ME THAT THE DASH LIGHTS WERE MALFUNCTIONING AND THEY WOULD HAVE TO OPEN UP THE DASH, THEY QUOTED ME $700 JUST TO OPEN UP AND DIAGNOSE PLUS THE LABOR CHARGES FOR WHATEVER THE PROBLEM WAS. THIS WAS RIGHT AFTER THE THE YEAR/36,000 MILE WARRANTY PERIOD WAS OVER. I MENTIONED THAT I HAD BEEN TO THE DEALERSHIP FOR THE VERY SAME REASON WHEN THE VEHICLE WAS UNDER WARRANTY BUT THEY COULD NOT FIND THE PROBLEM. FORD SAID THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. FORD DID NOT FIX THIS ISSUE AND ALSO SAID THAT THE WIRELESS REMOTES COULD NOT BE REPROGRAMMED. IN THE YEARS SINCE THE INITIAL PROBLEM, I HAVE HAD TO PUT IN TWO NEW ALTERNATORS. THE DASH LIGHTS FLICKER ALMOST CONTINUOUSLY. THE DASH DISPLAY (SPEEDOMETER, ODOMETER, ETC.) HAS COMPLETELY CUT OUT WHILE DRIVING THE VEHICLE SEVERAL TIME. THE VEHICLE STILL OPERATES BUT LOSES POWER WHEN THE DASH CUTS OUT. WHEN THE DASH DISPLAY CUTS OUT YOU ARE DRIVING WITHOUT A GAS GAUGE, SPEEDOMETER, ETC. WHEN THE DASH LIGHTS COME BACK ON, THERE IS A "HICCUP" OR POWER SURGE ACCOMPANIED BY THE SAME BUZZING SOUND THAT OCCURS WHEN THE DASH LIGHTS ARE FLICKERING WHEN THE VEHICLE IS PARKED. *TR
Electrical system, Apr 2, 2012
TL* THE CONTACT OWNS A 2005 FORD FOCUS. WHILE ATTEMPTING TO LOCK THE VEHICLE, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE ELECTRONIC LOCKING MECHANISM FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE DOOR LOCK ACTUATOR AND LOCKING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 92,000.
Power train, Electrical system, Mar 22, 2012
AFTER STARTING THE CAR WHEN IT HAS SET A FEW HOURS THE OVERDRIVE OFF LIGHT IS FLASHES YELLOW, ODOMETER JUST SHOWS DASHES, AND SPEEDOMETER DOSENT WORK. CAR STILL OPERATES BUT SHIFTS GEARS HARD, WHEN IT REACHES THE SPEED FOR DOOR TO LOCK EVERYTHING STARTS WORKING. I HAVE HAD MULTIPLE PROBLEMS WITH THE ENGINE MGMT FUSE, AND HAVE HAD 3 ALTENATORS CHANGED OUT IN THE LAST 2 YEARS. ALSO I HAD A PROBLEM WITH KEY NOT COMING OUT OF IGNITION AND FOUND OUT THAT A PEICE OF THE SHIFTER HAD BROKE OFF AND SLID DOWN AND KEPT IT FROM GOING ALL THE WAY INTO PARK, AFTER REMOVING PART I HAVE HAD NO PROBLEM WITH THE KEY. ALSO ENGINE LIGHT STAYS ON WAS TOLD BY AUTO ZONE IT WAS VACCUM SYSTEM TOOK IT TO FORD PLACE THEY SAID IT WAS MOTOR MOUNTS, THEY WERE REPLACED 20,000 MILES AGO AND IT STILL HASNT HELPED. *TR
Electrical system, Nov 8, 2011
TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE KEY BECAME LOCKED IN THE IGNITION AND WOULD NOT ALLOW HER TO START THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HER TO TAKE THE VEHICLE TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 80,000.
Electrical system, Aug 2, 2011
WAS DRIVING 45 ON A BUSY ROAD AND ALL THE LIGHTS ON DASHBOARD FLICKERED AND THE CAR WENT DEAD AND HAD TO DRIFT OFF ONTO A MEDIAN. HAD 2 PEOPLE LOOK AT THE CAR AND FOUND THAT THERE WAS THE 20 AMP FUSE OUT. WENT TO GET ANOTHER ONE WE MADE SURE ALL THE WIRES WERE ATTACHED AND NOTHING WAS LOOSE, WE TURNED THE STEERING WHEEL A BIT AND WITH THE NEW FUSE IN THE CAR STARTED, AS WE TURNED THE STEERING WHEEL THE CAR STALLED AGAIN. WENT BACK TO THE STORE BOUGHT 2 MORE FUSES AND GOT THE CAR STARTED DROVE 1 MILE AND IT STALLED AGAIN. TRIED THE 3RD FUSE AND NOTHING. HAD TO HAVE THE CAR TOWED TO LOCAL GARAGE 20 MILES AWAY FROM WHERE IT STALLED. THE GARAGE STATES THAT THE ISSUE IS IN THE DASHBOARD AND THEY HAVE TO TAKE IT TO FORD TO HAVE IT TESTED TO FIND THE ISSUE. COST WILL BE ANYWHERE BETWEEN $400 TO $1000 TO FIX DEPENDING ON WHAT THEY FIND WITH THE TEST. GOT THE CALL FROM THE GARAGE IT IS GOING TO BE FIXED FOR $500. MONEY WE DO NOT HAVE FOR BAD WIRING THAT IS NOT OUR FAULT! FORD NEEDS TO STEP UP AND TAKE RESPONSIBILITY BECAUSE THIS SEEMS TO BE AN ISSUE! *KB
Electrical system, Jul 29, 2011
TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED WHILE DRIVING 65 MPH ALL OF THE WARNING LIGHTS WOULD FLASH ON THE DASH BOARD AND THE VEHICLE STALLED, NEARLY CAUSING A CRASH. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND RESTARTED THE VEHICLE WITHIN FOUR MINUTES. AFTER RESTARTING THE VEHICLE, THE IDENTICAL FAILURE RECURRED. THE CONTACT DROVE THE VEHICLE TO A DEALER WHO PERFORMED A DIAGNOSTIC TEST WHICH DID NOT IDENTIFY OR DUPLICATE THE FAILURE. THE CONTACT STATED THE FAILURE OCCURRED FOUR TIMES PRIOR TO TAKING THE VEHICLE TO THE DEALER. THE CONTACT WAS CONCERNED SINCE THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 77,000.
Electrical system, Jul 11, 2011
TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THE CHECK ENGINE LIGHT CONSTANTLY ILLUMINATED CAUSING MULTIPLE FAILURES WITH THE VEHICLE. THE FAILURE WAS WITHIN THE ELECTRICAL PART OF THE VEHICLE INCLUDING THE SOLENOID, TRANSMISSION, VALVE BODY AND THE SAFETY SWITCH. THE VEHICLE WAS TAKEN TO A DEALER WHO PERFORMED A DIAGNOSTIC TEST BUT DID NOT DIAGNOSE A DEFINITE SOLUTION FOR THE REPAIRS. THE MANUFACTURER WAS CONTACTED AND STATED THERE WERE NO RECALLS OR WARRANTIES ON THE VEHICLE AND OFFERED NO OTHER ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 40,000 AND THE FAILURE MILEAGE WAS 43,000.
Electrical system, May 29, 2011
AN ELECTRICAL SHORT IN THE REAR WIRING HARNESS IN THE LIFTGATE HAS CAUSED THE REAR DEFROST, THE REAR WIPER AND THE HIGH-MOUNT REAR BRAKE LIGHT TO ALL FAIL, CONCURRENTLY. THE DEALERSHIP HAS COMMENTED THAT THIS WAS A COMMON PROBLEM WITH ZX3 FORD FOCUS MODEL AND WAS AS RECALLED SERVICE ISSUE ON A PRIOR MODEL YEAR. IT WAS ALSO CAUTIONED BY THE TECH THAT FIRE COULD RESULT. *TR
Electrical system, Apr 18, 2011
TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT WAS UNABLE TO RELEASE THE KEY FROM THE IGNITION. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES AND THE VEHICLE WAS TAKEN TO THE DEALER IN 2005 BUT THE DEALER DID NOT REPLACE THE IGNITION SWITCH. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS SCHEDULED TO HAVE DIAGNOSTICS PERFORMED AT THE LOCAL DEALER. THE FAILURE MILEAGE WAS 1,500 AND THE CURRENT MILEAGE WAS 54,000.
Electrical system, Apr 15, 2011
2005 FORD FOCUS STATION WAGON REAR HATCH: THE WIRES THAT GO TO THE HATCH (NEAR THE TOP) ARE TOO SHORT AND SO WEAK THAT AFTER 26,000 MILES THE WIRES BROKE AND DUE TO THIS BREAK/SHORT THE CAR WOULD NOT GO OUT OF "PARK". THE BRAKE LIGHTS QUIT WORKING AND IT BLOWS ONE FUSE AFTER ANOTHER FUSE. DUE TO THE WIRES BEING SO SHORT IT IS IMPOSSIBLE TO REPAIR THE BREAKS. THIS APPEARS TO BE A VERY COMMON PROBLEM FROM WHAT I SEE ON THE INTERNET. FORD SHOULD BE LIABLE FOR THESE REPAIRS. *TR