2005 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 441 owner complaints filed for this model year. This is the 12th highest complaint count among 19 Focus model years with reports.
Of the 2005 reports, 43 involved a crash and 9 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: electrical system
113 reports, newest first. Show all
Electrical system, Sep 1, 2007
2005 FOCUS WITH APPOX. 18000 MILES, I AM UNABLE TO START MY CAR. IGNITION SWITCH WILL NOT TURN TO CRANK POSITION NOR WILL IT TURN ON ACCESSORIES. *JB
Electrical system, Aug 21, 2007
DRIVING THE CAR (FORD FOCUS 2005 - 52000 MILES) IN RESIDENTIAL NEIGHBORHOOD. STOPPED THE CAR TO GET OUT, KEY WOULD NOT RELEASE FROM THE IGNITION. UNABLE TO LEAVE THE CAR UNTIL WE GOT BACK INTO SECURE PARKING GARAGE AT HOME. KEY HAS BEEN LEFT IN THE IGNITION & IS VULNERABLE TO THEFT. I AM CURRENTLY IN THE PROCESS OF FINDING A WAY TO GET IT REPAIRED. INITIALLY TOLD BY FORD DEALER THAT IGNITION NEEDS TO BE REPLACED, APPROX $400. *TR
Electrical system, Nov 28, 2006
KEY WILL NOT COME OUT OF THE IGNITION - WE HAVE NO MONEY TO REPLACE ANYTHING. *JB
Electrical system, Air bags, Sep 25, 2006
2005 FORD FOCUS AIRBAG SYSTEM INOPERATIVE AT AROUND 23,000 MILES AND 1.5 YEARS OF SERVICE. DEALERSHIP ADVISED WIRING HARNESS SEVERED BY RODENT. NOT COVERED BY FORD WARRANTY REMAINS UNCORRECTED. *NM
Electrical system, Aug 30, 2006
2005 FORD FOCUS. THE KEY IS STUCK IN THE IGNITION. IT WILL NOT COME OUT. I HAVE BEEN TOLD I WILL HAVE TO REPLACE THE IGNITION. SINGLE MOM HERE DON'T HAVE THE MONEY. *JB
Service brakes, Hydraulic, Electrical system, Aug 16, 2006
WHILE DRIVING IN THE EARLY MORNING OR EVENNGS I NOTICE THAT THE ABS LIGHT AND BATTERY LIGHT GLOW ON. THEY COME ON AND GO OFF. LAST EVENING THE CAR WAS SITTING IN MY DRIVEWAY WITH THE DOORS LOCKED AND WINDOWS UP. THE DOME LIGHT CAME ON AND WENT OFF SEVERAL TIMES. I LOOKED INTO THE CAR AND FOUND THAT THE OIL LIGHT AND THE DOOR AJAR LIGHT WERE ON WHEN THE DOME LIGHT WAS OFF. ALSO, WHEN THE DOOR AJAR AND OIL LIGHT ARE ON, THE WIRELESS REMOTES DO NOT WORK. I HAVE TAKEN THE VEHICLE IN FOR THE ABS AND BATTERY LIGHT 2 TIMES WITH NO RESOLVE. I TOOK THE VEHICLE IN FOR SERVICE TODAY WITH VIDEO OF THE DOME LIGHT, OIL LIGHT, AND THE DOOR AJAR LIGHT. *NM
Electrical system, Nov 22, 2005
DT: THE CONTACT STATED A LIGHT ON THE DASHBOARD ILLUMINATED, THE OWNER'S MANUAL STATED IT WAS A BATTERY NOT CHARGING PROPERLY LIGHT. LATER IN THE DAY, THE DASHBOARD LIGHTS FAILED, AND THE VEHICLE LOST ALL ELECTRICAL POWER. THE ENGINE CONTINUED TO RUN FOR APPROXIMATELY ONE MINUTE. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THEY FOUND IT WAS A PROBLEM WITH THE ALTERNATOR, AND THE ALTERNATOR IS BEING REPLACED. *AK
Electrical system, Oct 10, 2005, fire
THURSDAY MORNING, (10/6/05) I WAS DRIVING NORTHBOUND ON THE DAN RYAN I94. I WAS IN THE LEFT HAND LANE IN RUSH HOUR TRAFFIC. I NOTICED WHITE SMOKE COMING FROM THE FRONT OF MY HOOD. I THOUGHT I MUST BE OVERHEATING, THOUGH THAT SEEMED WEIRD SINCE IT WAS FAIRLY COOL OUTSIDE AND NOTHING ON MY DASH SHOWED DISTRESS. I PULLED QUICKLY TO THE LEFT SHOULDER, TURNED OFF THE CAR AND DECIDED TO CALL ROAD SIDE ASSISTANCE. WHILE ON HOLD A STRANGE SMELL STARTED TO FILL THE CAR AND I NOTICED MORE SMOKE AND THE SMOKE WAS GETTING DARKER. I GRABBED MY BAG, AND GOT OUT OF THE CAR. WITHIN A MINUTE, THERE WERE SMALL FLAMES COMING FROM THE FRONT OF THE CAR. I BEGAN TO WALK QUICKLY AWAY FROM THE CAR ALONG THE SHOULDER. ALL THIS TO SAY THAT THE CAR IS TOTALED, THE FIRE DEPARTMENT MADE IT BEFORE IT EXPLODED....BUT IT IS DESTROYED. *NM
Power train, Electrical system, Seat belts, Structure, Aug 27, 2005
I PURCHASED A BRAND NEW 2005 FORD FOCUS ZX4 IN DECEMBER OF 2005. UPON DELIVERY I NOTICED MY CAR HAD A HARD TIME STARTING AND THE WHOLE ENGINE WOULD SHAKE AND KNOCK. AFTER A MONTH I TOOK IT INTO THE DEALER AND THEY SAID THEY COULDN'T FIND A PROBLEM. THE CONDITION CONTINUED AND I TOOK IT IN AGAIN AND THEY COULDN'T FIND A PROBLEM BUT ASKED TO KEEP IT FOR AN OVERNIGHT START. I BROUGHT IT IN A FEW DAYS LATER SO THEY COULD KEEP IT OVER NIGHT AND THEY FOUND A BULLETIN BY FORD SAYING THEY KNOW THERE IS A HARD START PROBLEM BUT THEY DON'T KNOW HOW TO FIX IT. I THEN HAD TO HAVE THE DRIVER'S SEAT BELT REPLACED BECAUSE IT WOULDN'T UNLATCH OCCASIONALLY. I THEN HAD TO HAVE THE PASSENGER SIDE DOOR CASING REPLACED BECAUSE IT WAS DISCOLORED. THEN ABOUT A MONTH AND A HALF AGO I WAS DRIVING DOWN THE HIGHWAY AT 62 MILES AN HOUR AND MY CLUTCH WENT OUT AND MY CAR DIED IN THE MIDDLE OF THE HIGHWAY. I WAS ALMOST HIT BY ANOTHER CAR AND HAD TO WEIGHT IN 90 DEGREE WEATHER FOR 2 HOURS FOR A TOW TRUCK TO COME. MY CAR WAS TOWED TO FORD AND THEY SAID MY FLY WHEEL HAD CRUMBLED AND MY CLUTCH WAS BAD. IT TOOK THEM 9 DAYS TO REPLACE MY CLUTCH. A DAY LATER MY CAR WOULD NOT DOWNSHIFT WITHOUT GRINDING AND I HAD TO TAKE IT BACK TO THE DEALER. THEY SAID THAT THIS TIME THEY HAD TO REPLACE MY TRANSMISSION BECAUSE IT WAS RUINED AS WELL. TO THIS DAY MY CAR IS STILL IN THE SHOP AND HAS BEEN THERE FOR 32 DAYS JUST FOR THE REPLACEMENT OF THE TRANSMISSION. MY CAR IS ONLY 8 MONTHS OLD AND HAS BEEN IN THE SHOP FOR REPAIR OR DIAGNOSIS FOR A TOTAL OF 45 DAYS SO FAR. NEITHER WENDLE MOTORS OR FORD WILL REPLACE THE CAR SO I AM PERUSING A LEMON LAW CASE. *JB
Electrical system, Aug 17, 2005, fire
DT: THE CIGARETTE LIGHTER POPPED OUT AND LANDED ON PAPERS AND VEHICLE CAUGHT ON FIRE. IT BURNED THE PASSENGERS IN THE MIDDLE BETWEEN THE TO SEATS. HAVE NOT CONTACTED THE DEALER. THIS HAPPENED MONDAY AUGUST 15, 2005. THE CONSUSMER SUSTAINED BURNS ON RIGHT HAND.*AK
Steering, Suspension, Fuel system, Other, Electrical system, Mar 24, 2005
CAR BOUGHT SEPT 2004. CAR REGULARLY DOESN'T START, AND IF IT DOES ALWAYS RUNS AT OVER 3500 RPM FOR UP TO 5 MINUTES WITH NO ACCELERATOR PRESSURE. ALARM GOES OFF WHEN DRIVING, FOR NO REASON. CAR SWERVES AND VIBRATES ON ROAD IN DRY AND WET CONDITIONS (SEEMS LIKE STEERING AND / OR SUSPENSION BROKEN / DEFECTIVE). BRAKES ALSO CREAK. ALL PROBLEMS FROM CAR PURCHASE TO NOW, MARCH 2005. TAKEN TO 2 DEALERSHIPS ON 4 SEPARATE OCCASIONS, WHO COULD NOT "REPLICATE THE CONCERN". REPORTED TO FORD MOTOR COMPANY IN JANUARY WHO INFORMAED ME THAT THE ORIGINAL DEALER SERVICE MANAGER WOULD CONTACT ME. SO FAR, 7 WEEKS ON, AND NO CONTACT. POSSIBLE LEMON LAW CASE.
Electrical system, Equipment, Feb 14, 2005
IGNITION PROBLEMS, CD PLAYER MALFUCTION, WAS REPAIRED BUT FAILED AGAIN 3 TIMES TO START AND TOWED 3 TIMES TO THE DEALER. *AK
Engine and engine cooling, Electrical system, Feb 1, 2005
I PURCHASED MY VEHICLE IN EARLY NOVEMBER 2004. AS THE WEATHER BEGAN GETTING COLDER AND DAMPER, MY VEHICLE WOULD NOT START PROPERLY. THE ENGINE WOULD STUMBLE AND CRANK, BUT WOULD NOT TURN OVER. I WOULD HAVE TO TRY 3-4 TIMES BEFORE THE CAR WOULD ACTUALLY START. I TOOK THE VEHICLE IN FOR SERVICE IN DECEMBER 2004 AND TSB 04-23-4 WAS PERFORMED. THE VEHICLE CORRECTLY STARTED FOR A WHILE AFTER THAT, BUT IS HAVING THE SAME PROBLEM AGAIN NOW.