2023 GMC Sierra 1500
Problems, recalls and owner-reported issues
Engine is the leading concern among 482 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Sierra 1500 model years with reports.
Of the 2023 reports, 5 involved a crash and 2 involved a fire. 2 people were injured.
What owners report most often
Recalls and investigations
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Service brakes, hydraulic, brake fluid low warning, lampSep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Campaign 24V674000 on NHTSA.gov
Exterior lighting, lighting control module, softwareDec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Campaign 22V903000 on NHTSA.gov
Representative owner complaints
482 reports, newest first.
Structure, Aug 17, 2026
The upper grill chrome trim blew off at highway speed. The plastic brackets holding it in place sheared off. This was a known defect resulting in 70,000 recalled trucks for the prior year model (2022), but for some reason isn't covered for 2023. Same exact issue
Fuel/propulsion system, Aug 14, 2026
The fuel pump control module went bad and the vehicle shut off while driving. The vehicle is only 3 years old. Everyone I know with a GM truck or SUV has had the same issue and the dealer service writer even told me they get at least 6 vehicles with the same issue per week. There is already a recall for GM SUV's for 2021-22 model years but not for anything else even though many other vehicles have the same issue. They replaced the module under warranty but it is all but guaranteed to just keep happening.
Structure, Aug 13, 2026
Whilst driving down the highway at 65 mph the plastic front grill deflector broke off and slammed into my windshield and the vehicle behind me. Luckily the vehicle behind me sustained no damage other than how frightened she and her children were. This is a known issue and was subject to a recall for the 2022 GMC Sierra Denali's. Nothing has changed between the 2 models as far as I can tell and it's the exact same grill deflector. When I informed the dealership of this they told me it would be a $950 repair out of pocket. First of all, it is unacceptable for a $75,000 vehicle to have a plastic component that can just break off and become an immediate and unavoidable hazard on the highways. The recall MUST be extended to these vehicles. I have reached out to GM and they confirmed it would be an out of pocket expense, but I am escalating the situation. Thank you!
Service brakes, Hydraulic, Aug 12, 2026
The contact owns a 2023 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the brakes failed to respond as needed. The vehicle was towed to the dealer to be diagnosed. The vehicle was diagnosed with an inoperable battery, which caused the brake module to fail, preventing the brakes from operating as intended. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 29,000.
Other or unspecified, Aug 11, 2026
The OnStar module in the truck is broke it affects all communications. The truck has including things like let me know what the speed limit is. It happened after they did a software update, which seems a little fishy because there was nothing wrong with it before I understand. Some people were having problems with this module, causing their batteries to die, but now I’m the one having issues and they won’t seem to fix it unless I pay them $900.
Power train, Aug 10, 2026
My truck threw the code p0747 for fail valve body. When I do my research its a common problem. GM is stating my truck isnt covered.
Structure, Aug 10, 2026
I started to notice detached broken plastic pieces behind the upper grill housing. I notified the dealer, and in the meantime of trying to figure out what to do, the upper grill housing came detached when I was driving down the highway and flew up and back onto the highway. Sounds similar to safety recall N242490120, which was for 2022 model year trucks. Not sure why this stopped at 2022, but it happed on my 2023.
Steering, Electrical system, Service brakes, Aug 9, 2026
My 2023 GNC Sierra 1500 has experienced a recurring electrical and safety-related malfunction on multiple occasions while driving. The dashboard and warning lights intermittently flash on, and off and numerous warning messages appear simultaneously. During previous occurrences, warnings included power steering service, safety restraint system, check engine and transmission related messages, including a message instructing me to pull over and shut the vehicle off. During one occurrence, the electric power steering assist stopped working while I was driving. The vehicle was taken to an authorized GMC dealership multiple times while under the factory warranty. The dealer replaced the Brake System Control Module and performed vehicle-wide software/programming updates. When the problem continued, the dealer contacted GM Technical Assistance. The Dealer subsequently diagnosed an intermittent open circuit involving the electric power steering rack-and-pinion/steering gear assembly and replaced the complete steering gear assembly. Despite these repairs, the malfunction has occurred again, during another occurrence while driving on the freeway, the dashboard flashed on and off and multiple warning lights and messages repeatedly appeared, similar to the condition that occurred before the steering gear was replaced. The vehicle currently has approximately 55,000 miles. The condition remains intermittent despite multiple repair attempts. I am concerned that this recuring electrical or vehicle communication failure could again cause loss of power steering assistance or affect other safety-related vehicle systems while driving.
Structure, Aug 9, 2026
While driving southbound on Interstate 95 in Florida, the front upper grille molding/deflector completely detached from my 2023 GMC Sierra 1500 SLE at highway speed and separated from the vehicle, creating a potential road hazard for other motorists. Prior to the complete separation, I noticed that the upper grille molding was becoming loose and lifting away from the vehicle. I stopped and photographed the component and its attachment areas. The photographs show failed/broken attachment points while the molding was still partially attached to the truck. Later, while driving on I-95, the remaining attachments failed and the entire molding separated from the vehicle. The part could not safely be recovered from the interstate. The vehicle recently underwent dealer service involving the active grille shutter/damper area near this component. I cannot determine whether that service contributed to the failure, so I am reporting it as part of the vehicle's recent service history rather than asserting it as the cause. I subsequently became aware that NHTSA Recall 25V-060 / GM Recall N242490120 addresses separation of a front upper grille deflector on certain GMC Sierra 1500 vehicles due to fractured attachment points. My vehicle is a 2023 model and does not presently appear to be included in that recall. Because my vehicle experienced a similar failure mode resulting in the exterior component completely separating at highway speed, I am submitting this complaint so NHTSA can determine whether this condition may extend beyond the vehicles currently covered by the recall. Photographs documenting the component and failed attachment areas before its complete separation are available.
Structure, Aug 9, 2026
Vehicle: 2023 GMC Sierra 1500 SLE VIN: [XXX] While driving southbound on [XXX] near exit [XXX], the front upper grille molding/deflector completely detached from my 2023 GMC Sierra 1500 SLE at highway speed and separated from the vehicle, creating a potential road hazard for other motorists. Prior to the complete separation, I noticed that the upper grille molding was becoming loose and lifting away from the vehicle. I stopped and photographed the component and its attachment areas. The photographs show failed/broken attachment points while the molding was still partially attached to the truck. Later, while driving on [XXX] to work, the remaining attachments failed and the entire molding separated from the vehicle. The part could not safely be recovered from the interstate. The vehicle recently underwent dealer service involving the active grille shutter/damper area near this component. I cannot determine whether that service contributed to the failure, so I am reporting it as part of the vehicle's recent service history rather than asserting it as the cause. I subsequently became aware that NHTSA Recall 25V-060 / GM Recall N242490120 addresses separation of a front upper grille deflector on certain GMC Sierra 1500 vehicles due to fractured attachment points. My vehicle is a 2023 model and does not presently appear to be included in that recall. Because my vehicle experienced a similar failure mode resulting in the exterior component completely separating at highway speed, I am submitting this complaint so NHTSA can determine whether this condition may extend beyond the vehicles currently covered by the recall. Photographs documenting the component and failed attachment areas before its complete separation are available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Structure, Aug 8, 2026
While driving my 2023 GMC Sierra on the highway at highway speeds, a piece of the front grille suddenly detached and flew off the vehicle. There was no prior accident, impact, or external damage to the grille; the part failed and unclipped on its own due to defective manufacturing or weak retaining clips. This creates a severe safety hazard as the flying debris could have struck the windshield of the vehicles traveling behind me, potentially causing a major accident. I am aware that the 2022 GMC Sierra has an active recall (N242490120) for this exact same issue, yet GM is refusing to cover this 2023 model under warranty or recall despite presenting identical component failure.
Engine, Fuel/propulsion system, Aug 7, 2026
- vehicle started misfiring, ECM, valve timing code, throttle system code, data system, gateway, module,. Vehicle is available and currently at the GMC dealership for continued diagnostic. -this happened on the freeway and out of nowhere the vehicle started shaking, rough, losing power and acceleration, I had to cut someone off on the freeway just to get over to the right shoulder and turned off the vehicle called a tow truck and haven’t been able to use the vehicle since. Vehicle is unable to be driven due to safety issues of increased acceleration and loss of power, intense shaking. -the vehicle is at the dealership now, prior there was a diagnostic performed by a different dealer, and it has been confirmed. -the vehicle is at the GMC dealership now. -ECM check engine light came on prior to the vehicle misfiring and other codes coming up.
Structure, Aug 5, 2026
My grill deflector suddenly flew off, hit my windshield a flew into a semi hauling oil field equipment. We both pulled over and found no significant damage to his truck. I have a two inch scratch on my windshield and possibly lite hood scratching. Dealership required me to pay $390.73 but said I would be reimbursed for my losses. It never happened. Now I’m fighting with GM to get some resolution. This could be deadly for a motorcycle rider for sure. Hundreds of people reporting same issue on 22 and 23 Sierras and AT4’s.
Electrical system, Aug 3, 2026
The contact owns a 2023 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the instrument panel shut off without warning. The vehicle was restarted, and the panel remained blank with white streaks across the screen. The vehicle was towed to a dealer, and the dealer associated the failure with the instrument cluster. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 34,500.
Structure, Other or unspecified, Jul 30, 2026
The grill deflector flew off while driving on the highway. I was driving roughly 55 mph. It is available now, but will be getting repaired in the near future. My concern is that it appears that this was an issue with the 2022 models and it’s still an issue on the 2023. The safety issue is if there was a vehicle or motorcycle behind me that it could have harmed whoever could have been driving behind me, caused and accident, or damaged their vehicle or mine in the process. The service advisor (J.R.) told me that “sometimes the wind gets underneath the bezel and makes it snap”. No it has not been inspected by any of this mentioned. No warning signs prior to the incident.
Structure, Jul 30, 2026
The front grille bezel mounting clips broke and it started to fly off while driving on the highway. Luckily, I was able to pull over before the last clip broke and took it off before it became a spear flying at the cars behind me. There is an active recall for this issue for the 2022 GMC Sierra 1500 models, but not 2023/2024 models (same body I believe).
Power train, Jul 25, 2026
While towing my trailer the vehicle intermittently slams gears and will hesitate the back tires momentarily to the point of screeching. This has led to close calls being nearly rear ended and having to pull over. This started out as a hard slam while trailering on the highway and has progressively gotten worse. Had into dealership twice to multiple times to try and figure out the issue but it’s not throwing any codes and they can’t get it to duplicate the issues. Nothing can be replaced due to no codes even though they think the valve body is going bad. Leaving the vehicle as a ticking time bomb for failure which could result potentially in a catastrophic incident. Only had the vehicle for one year now has 37k miles on it and have had the ecm, full wiring harness, and multiple sensors replaced already for a different problem early this year that had the truck in the shop for a month.
Engine, Jul 23, 2026
Complete engine failure while driving on a highway. While cruise was set, the truck emitted a sound and sensation like we had run over something on the highway. Within a few minutes the engine started ticking. The cruise was disengaged which thru the truck into neutral. No dashboard sensors were illuminated. We were able to get off the highway but the truck would not restart. Truck was towed to nearest dealer who has confirmed engine failure.
Power train, Jul 22, 2026
Engine light came on while driving and a message on dashboard said Service Transmission Now.Unable To Shift Soon. Took to dealer and they said it was the park position switch 1circuit high. Had to order part but not knowing how long to get it. Truck only has 12468 miles. Luckily I got it to the dealer ASAP. IF I were on the highway or a remote road, I feel that a serious accident would have happened. Having an electronic controlled console shifter not being able to get the truck to shift gears to slow down or stop is a real safety issue. Extended warranty does not cover anything like this. Please look into this. Thank you
Engine, Jul 22, 2026
Driving down the interstate at 70 miles per hour, started losing power, engine light came on. Engine started making a loud banging noise as I pulled onto an exit.
Structure, Jul 15, 2026
The upper top grille mold detached from the vehicle while traveling at highway speed (about 65 mph). It hit the hood, which it scratched and flew off into the air, above the vehicle and in the way of oncoming traffic. Fortunately, no one was behind me so the part did not hit another vehicle. Vehicle had around 65k miles when this occured. I have contacted a local dealership who informed me that while many similar vehicles have a recall for this issue my VIN is not included in that recall.
Structure, Other or unspecified, Jul 13, 2026
The upper hood trim that sits above the grill, flew off on the interstate at approx 80 mph. Upon research this is a common problem for this make and model in years of 22-24. GM has a service bulletin for this issue as well as the NHTSA. For this particular failure. There was no warning and when I contacted GM they were unwilling to assist as "service bulletins" are not recalls and the vehicle is out of warranty. There was no warning, no indicator, it just blew off and I had no idea until I got home and the piece was missing. I was unable to locate the part on the interstate, however I was able to keep all of the pieces attached to the vehicle for evidence and support. I am beside myself anyone thought this was acceptable to sustain the force of air flow!
Engine and engine cooling, Jul 10, 2026
The contact owns a 2023 GMC Sierra 1500. The contact stated that while operating the vehicle, there was an engine knock at start-up, and the engine intermittently hesitated and skipped. The vehicle was taken to the local dealer, who performed a PICO test on the engine, and the engine passed. Later, while hauling a trailer, there was a rattling sound coming from the engine. The vehicle was taken back to the dealer, who diagnosed the vehicle and determined that the engine needed to be replaced. The engine, radiator, and oil cooler were replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 17,000.
Engine, Jul 9, 2026
Oct 2025 I took my truck into my local GMC dealer for 6.2 recall. I was told it passed the testing. 6/12/26 driving about 70mph on highway and lost all acceleration. Warning stating engine oil hot,/ pull over and idle engine. Already using 0w40 oil for approx 8momnths. Oil changed approx 3 wks before this incident. I was able to pull to the shoulder w/in 1/4 mile. While the truck was still moving about 3 mph it went into park and shut off. The vehicle would not turn back on. Oil level was full. For about $300 I was able to have the truck towed to a local dealer (about 2hrs from my home) and have my trailer towed off the highway. 6/15/26 I was notified by a local dealer that the engine was seized and that this was probably the recall issue. I contacted my local dealer who had my truck towed to their location. On 6/19/26 I was told by local dealer rep that they had ordered an engine for my truck and that I was third in line. On 6/26/26 I was informed by the dealer that he engine is on an indefinite backorder nationwide. On 6/30/26 I received a call from GM giving me a case number and getting contact info for my local dealer. I was advised that someone would contact me within 48 business hours. 7/3/26 I was contacted by my case advisor from GM. Still no idea when replacement engines might be available. I inquired about a buyback since I need a truck for work/personal life. I advised her that I had already cancelled one vacation (towing an RV...my loaner Buick Encore won't work) and would probably have to cancel another. I tried to explain that farming doesn't work well with the loaner either. I was told that another advisor would look into a buyback situation. On 7/8/26 I received a call from GM advising that my engine had shipped on 7/6/26 and to expect a call the following week with an update on completion.
Power train, Vehicle speed control, Engine, Jul 7, 2026
I was driving my family on the highway and my truck completely shut down. The screen flashed a warning and it slowly started decelerating. Thankfully I was able to make it to the shoulder of the road safely. Engine failure was a known safety issue with my model of truck, but I completed the L87 Engine Loss of Propulsion safety recall testing on 9/18/2025 and was assured my engine passed the testing and was not at risk for engine failure.