2016 Grand Design Reflection
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 19 owner complaints filed for this model year. This is the 4th highest complaint count among 10 Reflection model years with reports.
Of the 2016 reports, 2 involved a fire.
What owners report most often
Recalls and investigations
Equipment, appliance, refrigeratorJan 28, 2022
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
An electrical arc increases the risk of a fire.
Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Campaign 22V038000 on NHTSA.gov
Electrical system, wiringJun 19, 2020
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2018 Reflection trailers. A wiring connector in the vehicle underbody may not be properly secured, allowing water intrusion into the wiring connector, possibly resulting in an electrical short circuit.
If water enters the wiring connector, it can cause a short circuit, increasing the risk of a fire.
Grand Design will notify owners, and dealers will inspect and secure the wiring connectors up to prevent water intrusion, free of charge. This recall began June 29, 2020. Owners may contact Grand Design's customer service at 1-574-825-9679. Grand Design's number for this recall is 910020.
Campaign 20V362000 on NHTSA.gov
Equipment, other, labelsOct 7, 2016
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2017 Reflection recreational trailers, model 357BHS and 367BHS, manufactured November 12, 2014, to September 22, 2016. The affected vehicles have an incorrect Gross Axle Weight Rating (GAWR) on the Federal Certification Label, stating a GAWR of 7,000 lbs when the actual GAWR is 6,400 lbs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
If the operator loads the vehicle to the GAWR on the label, it can cause a loss of vehicle control, increasing the risk of a crash.
Grand Design will notify owners, and dealers will install a corrected Federal Certification Label, free of charge. Owners will also have the option to replace the Certification Label themselves, free of charge. The recall began on October 28, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910007.
Campaign 16V717000 on NHTSA.gov
Equipment, recreational vehicle/trailer, lpg systems, lines and fittingsMay 25, 2016
Grand Design RV, LLC (Grand Design) is recalling certain model year 2016-2017 Imagine and Reflection recreational trailers manufactured January 15, 2016 to May 4, 2016. The MB Sturgis LP regulator on these vehicles may allow propane gas to leak into the regulator sight glass causing it to degrade and potentially crack.
If the indicator sight glass cracks, propane gas may leak out, increasing the risk of a fire.
Grand Design will notify owners, and dealers will replace the LP regulator kit, free of charge. The recall began on June 6, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910006.
Campaign 16V355000 on NHTSA.gov
Suspension, rear, axle, non-powered axle assemblyAug 14, 2015
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
Campaign 15V518000 on NHTSA.gov
Suspension, rear, axle, non-powered axle assemblyApr 10, 2015
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2016 Reflection 303RLS, 308BHTS and 313RLTS, model 2016 Solitude 375RE trailers manufactured March 12, 2015, to April 6, 2015. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
If the wheel studs break, the wheel could detach from the vehicle, increasing the risk of a crash.
Grand Design has notified owners, and dealers will replace any affected wheel hub, free of charge. The recall began on April 14, 2015. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910003.
Campaign 15V212000 on NHTSA.gov
Representative owner complaints: electrical system
2 reports, newest first. Show all
Electrical system, Nov 18, 2016, fire
MY RV IS ONLY 9 MONTHS OLD AND IT IS ON CITY POWER. LIGHTS WITH MOTION SENSING- THE LIGHT IN THE MOTION SENSING POSITION, STARTED TO SMOKE AND INDICATE FIRE WITHIN THE LIGHT ITSELF. MODEL #SD1510-PIR 12V DC, 4W SMD LED. ON GRAND DESIGNS WEB SITE IT INDICATES NOT TO USE THE LIGHT PICTURED AND TO USE A DIFFERENT PART NUMBER. THEY ARE NO LONGER WANTING TO INSTALL THE ORIGINAL PART FOR SOME REASON. THE POTENTIAL FOR FIRE AND A DEATH ARE HIGH IF WE DON'T REMEDY THIS ISSUE. I WAS FORTUNATE ENOUGH TO BE PRESENT WHEN IT FAILED. I STILL HAVE 4 MORE OF THE SAME LIGHTS IN MY RV.
Electrical system, May 19, 2016, fire
TL* THE CONTACT OWNED A 2016 GRAND DESIGN REFLECTION RV. THE VEHICLE CAUGHT FIRE WHILE PARKED. A FIRE REPORT WAS NOT FILED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE CONTACT WAS INFORMED BY THE FIRE MARSHALL THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAILURE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.