2004 Hyundai Elantra
Problems, recalls and owner-reported issues
Air bags is the leading concern among 182 owner complaints filed for this model year. This is the 19th highest complaint count among 26 Elantra model years with reports.
Of the 2004 reports, 24 involved a crash and 2 involved a fire. 26 people were injured.
What owners report most often
Recalls and investigations
Air bagsOct 17, 2005
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
Campaign 05V479000 on NHTSA.gov
Air bagsSep 12, 2005
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V395000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 30, 2004
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. ON CERTAIN PASSENGER VEHICLES, A VAPOR TUBE HOSE CLAMP THAT IS LOCATED NEAR THE FUEL TANK MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE FUEL LEAKAGE.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP EARS AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V370000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 3, 2004
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND FACING TOWARD THE FUEL TANK.
IN THE EVENT OF A CRASH, DAMAGE TO THE VEHICLE COULD CAUSE THE MISPOSITIONED CLAMP TO PUNCTURE THE FUEL TANK CAUSING FUEL LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V208000 on NHTSA.gov
Air bagsAug 26, 2003
ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. HOWEVER, THE OCCUPANT CLASSIFICATION SENSOR MAY INCORRECTLY INTERPRET THAT A SEATED ADULT IS AN INFANT SEAT AND DEACTIVATE THE PASSENGER AIR BAG IF SOMEONE HEAVIER THAN 56.4 POUNDS WHO IS SEATED WITH ONE LEG RESTING ON THE OUTBOARD OR INBOARD EDGE OF THE SEAT; WITH LEGS SPREAD; OR POSITIONED OFF-CENTER TOWARD THE CENTER CONSOLE AND WITH HIS OR HER ARM LEANING ON THE CONSOLE.
IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
THE OCCUPANT CLASSIFICATION SENSOR WILL BE REPROGRAMMED.
Campaign 03V322000 on NHTSA.gov
Representative owner complaints
182 reports, newest first.
Air bags, Jun 16, 2006
I HAVE A 2004 HYUNDAI ELANTRA. IT HAD A RECALL ON THE AIRBAG SENSOR. I HAVE TAKEN IT BACK TWO TIMES TO BE FIXED. THIS WILL BE THE THIRD. IT COMES ON AND OFF REGARDLESS IF ANYONE IS IN THE SEAT OR NOT. EACH TIME I TAKE IT BACK THEY SAY IT IS FIXED. I AM AFRAID IF I AM IN A WRECK IT WILL NOT WORK IF SOMEONE IS SITTING THERE. *NM
Air bags, Jun 9, 2006
DT*: THE CONTACT STATED THE PASSENGER AIR BAG (OCS SYSTEM) IS SUPPOSE TO ACTIVATE WHEN AN ADULT IS SITTING IN THE SEAT AND NOT ACTIVATE WHEN A CHILD IS SITTING IN THE SEAT. THE OCS SYSTEM WILL NOT ACTIVATE FOR THE OWNER OF THE VEHICLE WHEN SITTING IN THE SEAT PROPERLY. THE DEALERSHIP DETERMINED THE DRIVER IS LESS THAN 120 POUNDS WHICH IS THE REASON THE OCS WILL NOT ACTIVATE. THE CONTACT CONTENDS THIS INFORMATION IS NOT LISTED IN THE HANDBOOK AND THE CONTACT WAS NOT INFORMED OF THIS WHEN THE VEHICLE WAS PURCHASED.
Service brakes, Hydraulic, May 30, 2006
DT*: THE CONTACT STATED WHILE TURNING LEFT AT LOW SPEEDS THERE WAS A GRINDING NOISE THAT CAME FROM THE REAR OF THE VEHICLE. THE DEALERSHIP WAS UNABLE TO DETERMINE WHY THE REAR BRAKES HAD FAILED. THE VEHICLE WAS TAKEN TO A LOCAL INDEPENDENT REPAIR SHOP. THE MECHANIC DETERMINED THE REAR BRAKE SENSORS WERE BENT AND BOTH REAR BRAKES WERE REPLACED AND THE ROTORS WERE TURNED. THE MANUFACTURER HAS BEEN ALERTED.
Air bags, Mar 2, 2006
DT*: THE CONTACT STATED THE PASSENGER SIDE AIR BAG SENSORS WERE REPROGRAMMED ON TWO OCCASIONS. THE SENSORS ARE STILL NOT WORKING PROPERLY. IF A SMALL STATURE PERSON IS SITTING IN THE FRONT PASSENGER SEAT, THE INDICATOR LIGHT ILLUMINATES, INDICATING THE AIR BAG IS TURNED OFF. THERE IS A RECALL # 03V322000, CONCERNING THE AIR BAGS, HOWEVER THE RECALL DID NOT CORRECT THE PROBLEM. THE VEHICLE IS HAVING THE SAME PROBLEMS AGAIN. THE DEALER WAS NOTIFIED AND REPROGRAMMED THE OSC ELECTRICAL CONTROL UNIT. THE DEALER STATED THE PERSON SITTING IN THE FRONT PASSENGER SEAT MUST SIT IN A CERTAIN MANOR FOR THE SENSOR TO BE ACTIVATED.
Air bags, Feb 22, 2006
2004 ELANTRA PASSENGER SIDE AIR BAG REMAINED ON. *TS THE CONSUMER WAS NOT SATISFIED WITH THE RECALL WORK THAT WAS PERFORMED ON THE VEHICLE REGARDING THE AIRBAG. THE CONSUMER STATED WHEN THE PASSENGER SEAT WAS OCCUPIED THE PASSENGER AIR BAG OFF LIGHT STAYED ILLUMINATED. *JB
Tires, Feb 21, 2006
BUBBLE IN SIDEWALL OF TIRE ABOUT ONE MONTH AFTER BUYING IT NEW. *JB
Air bags, Feb 15, 2006, crash
WAS INVOLVED IN A HEAD ON COLLISION AT 30 MPH. THE AIRBAGS NEVER DEPLOYED. IS THERE A SPEED AT WHICH THE AIRBAGS ARE SUPPOSED TO DEPLOY?*JB
Power train, Electrical system, Jan 31, 2006
ON 3/4/2005, WHILE DRIVING ON AN INTERSTATE HIGHWAY, THE CAR STALLED AND WOULDN'T IMMEDIATELY START. IT DID START LATER. I WAS TOWED TO A DEALER, WHICH REPLACED THE CRANKSHAFT POSITION SENSOR. ON 4/21/2005, I GOT TO MY PARKED CAR TO FIND THAT IT WOULDN'T START FOR 10-15 MINUTES. THE SYMPTOMS WERE VERY SIMILAR TO THE MARCH 4 INCIDENT, WITHOUT THE STALLING OUT ON THE HIGHWAY TO PREFACE IT. THE FOLLOWING DAY, I TOOK THE CAR TO A DIFFERENT DEALER, WHERE THEY TESTED THE CAR BUT MADE NO REPAIRS. I WROTE HYUNDAI. A REGIONAL REPRESENTATIVE CONTACTED ME AND ASKED THAT HYUNDAI HAVE AN ATTEMPT TO FULLY INVESTIGATE. I HAD AN APPOINTMENT AT THE DEALER I PURCHASED THE CAR FROM, AND THE REGIONAL REPRESENTATIVE CONTACTED THEM TO COORDINATE EXAMINATION OF THE CAR. THE DEALER HAD ONE OF THEIR TOP ELECTRICAL SYSTEMS PEOPLE EXAMINE THE CAR IN CONSULTATION WITH THE REGIONAL OFFICE ON 5/7/2005. THEY COULD FIND NO PROBLEMS. ON 1/3/2006, THE CAR STALLED OUT ON AN INTERSTATE HIGHWAY AND WOULDN'T START IMMEDIATELY. A DEALER REPLACED THE CRANKSHAFT POSITION SENSOR. ON 1/13/2006, THE CAR STALLED OUT ON AN INTERSTATE HIGHWAY AND WOULDN'T START IMMEDIATELY. A DEALER EXAMINED IT AND CONSULTED WITH HYUNDAI TECH LINE BUT DID NOTHING. I SENT HYUNDAI ANOTHER LETTER. THEY ASKED TO BE ABLE TO SEND A REGIONAL TECHNICIAN TO LOOK AT IT. A DEALER REPLACED THE POWER CONTROL MODULE AND CHECKED CONNECTIONS PER DIRECTIONS OF THE REGIONAL TECHNICIAN. HYUNDAI DEEMED THE CAR OKAY BECAUSE THE TECHNICIAN WENT FOR A 15 MILE TEST DRIVE; THE CAR HAS HAD THREE POTENTIALLY FATAL INCIDENTS IN 22,491 MILES. A REPRESENTATIVE AT THE REGIONAL OFFICE SAID THE THEY REPLACED THE POWER CONTROL MODULE BASED ON INCIDENTS IN OTHER CARS, WHERE THE ERROR CODE FOR THE CRANKSHAFT POSITION SENSOR HAS COME UP. HE SAID THIS WAS A "PRECAUTIONARY MEASURE," THAT THE TECHNICIAN WASN'T ABLE TO VERIFY THE COMPONENT THAT FAILED, AND COULD NOT EXPLAIN WHY THE POWER CONTROL MODULE WASN'T SUGGESTED EARLIER. *JB
Air bags, Jan 17, 2006
2004 HYUNDAI ELANTRA PASSENGER AIR BAG OFF LIGHT REMAINS ON. *TS THE VEHICLE WAS TAKEN TOT HE DEALER REGARDING RECALL CAMPAIGN #073 CONCERNING THE OCCUPANT CLASSIFICATION SYSTEM OF THE RIGHT FRONT PASSENGER SEAT FOR AIR BAG DEPLOYMENT. THE PASSENGER AIR BAG OFF LIGHT REMAINED ON NO MATTER WHO SAT IN THE SEAT. THE TECHNICIAN TOLD THE CONSUMER THAT THE AIR BAG OFF LIGHT MAY BE ILLUMINATED BECAUSE THE PASSENGER MAY NOT BE SEAT SQUARELY IN THE SEAT WITH FEET ON THE FLOOR. *NM
Tires, Dec 10, 2005
I BOUGHT MY HYUNDAI ELENTRA 2004 BRAND NEW. WHEN I BOUGHT IT I TOOK IT BACK BECAUSE THE TIRES LEAKED AT THE VALVE STEMS. AND WHEN IT GETS HOT IT STARTS TO TICK. WHEN I TOOK IT BACK TO WHERE I BOUGHT IT THEY TREATED ME LIKE I WAS DUMB. I ENDED UP PAYING FOR THIS MYSELF. MY CAR HOWEVER STILL TICKS. *JB
Air bags, Dec 4, 2005
WITH A PASSENGER IN THE RIGHT FRONT SEAT THE AIR BAG LIGHT OFF IS DISPLAYED QUITE FREQUENTLY. *NM
Air bags, Nov 22, 2005
THE FRONT AIRBAG OFF LIGHT STAYS ON EVEN WHEN THE FRONT PASSENGER, USUALLY MY NIECE WHO WEIGHS 130 POUNDS, OCCUPIES THE SEAT. THERE WAS A RECALL ON THE AIRBAGS, BUT IT DID NOT SPECIFY THIS PROBLEM. SO MANY COMPLAINTS ABOUT THIS SENSOR SHOULD BE LOOKED IN TO. *JB
Steering, Power train, Electrical system, Oct 21, 2005
HYUNDAI ELANTRA GLS 2004 (1) NO EVENTS LED UP TO FAILURES (2) BETWEEN 15000-20000 MILES IGNITION STOPPED WORKING - FIXED BY HYUNDAI AFTER WE SEVERELY NAGGED THEM FOR DAYS - CAR IS LESS THAN 18 MONTHS OLD HAS 32,000 MILES ON IT NOW CLUTCH DISK IS SUPPOSEDLY BURNED OUT- I HAVE NEVER HAD A CLUTCH BURN OUT ON ME OR ANYONE I KNOW MUCH LESS AT A MERE 32,000 MILES WANT TO CHARGE ME 300 TO SEE IF WARRANTY MIGHT COVER IT; HOWEVER IF IT DOESN'T THEY WILL CHARGE ME 800 OR SO TO FIX THIS PROBLEM CAR GRINDS WHEN TURNING- HYUNDAI WILL NOT CHECK IT OUT, SUPPOSEDLY WARRANTY ALSO DOES NOT COVER THIS. STEERING WHEEL IS COMPLETELY FALLING APART VANITY MIRROR COVER FELL OFF YES, ALL THIS HAPPENED WITHIN 3 MONTHS OF EACH OTHER. I AM NOW COMPLETELY AFRAID TO DRIVE MY CAR. THE GEARS DO NOT CATCH WELL AND ARE GETTING PROGRESSIVELY WORSE. THE REASON I BOUGHT THIS CAR WAS FOR ITS AMAZING WARRANTY. COME TO FIND OUT THE WARRANTY DOESN'T COVER ANYTHING AT ALL. HYUNDAI DID REPLACE MY VANITY MIRROR. NOW IF ONLY THE FREAKING CAR WORKED! I WILL NEVER BUY ANOTHER HYUNDAI. *NM
Electrical system, Oct 17, 2005
(1) CAN HAPPEN ANYTIME WITHOUT WARNING. MAY GO FOR WEEKS, DAYS, OR MINUTES BEFORE RECURRING. (2)ENGINE SHUTS OFF WHILE DRIVING. MUST SHIFT INTO NEUTRAL TO RESTART. NOT EASY TO DO WHEN DOING 65 MPH ON RT 30, TO SUDDENLY HAVE NO POWER OR POWER STEERING AND A SEMI IS ON YOUR TAIL. IT HAS HAPPENED AT LEAST 20 TIMES SINCE THE FIRST TIME IN WET, DRY, FAST SLOW, OR IDLE. (3) 1ST TIME WIGGLE WIRES. IT WOULD NOT HAPPEN IN THE SHOP. REPLACED FUSE BOX, WE REFUSE TO DRIVE THE CAR AGAIN DUE TO FEAR FOR OUR LIVES. SINCE THERE IS NO WARNING AND IT CAN BE WEEKS BETWEEN HAPPENINGS YOU CAN'T PREPARE FOR IT. *NM
Electrical system, Sep 28, 2005
DT: A WIRING BURNING SMELL WAS COMING FROM THE DASHBOARD. WHEN THIS HAPPENED EVERYTHING ELECTRICAL IN THE DASHBOARD TURNED OFF. THE DEALERSHIP WAS UNABLE TO FIND THE CAUSE OF THE PROBLEM. THE PROBLEM FIRST STARTED ON JUNE 20, 2005. THE PROBLEM USUALLY HAPPENED FOR A SHORT PERIOD OF TIME. LATELY, IT HAS BEEN HAPPENING MORE OFTEN. *AK
Suspension, Tires, Sep 9, 2005
STRONG STEERING WHEEL VIBRATION ON 2004 HYUNDAI ELANTRA AT SPEEDS OVER 60 MPH. HAVE TAKEN CAR TO DEALER 5 TIMES, IN WHICH THEY HAVE ROTATED WHEELS, BALANCED TIRES, ROAD FORCE BALANCED TIRES, WITH NO IMPROVEMENT. NUMEROUS OTHER ELANTRAS FROM 2001-2005 SUFFER FROM THIS PROBLEM AS A SIMPLE GOOGLE SEARCH WILL YIELD MANY. HYUNDAI WILL NOT ACKNOWLEDGE PROBLEM EVEN THOUGH THERE IS A TSB FOR THIS ISSUE. WILL FILE FOR LEMON LAW IF NOT FIXED ON 6TH ATTEMPT. *NM
Air bags, Aug 30, 2005, crash
DT: CONSUMER'S VEHICLE WAS INVOLVED IN AL HEAD-ON COLLISION AT 35 MPH WHEN ANOTHER VEHICLE MADE AN ILLEGAL LEFT TURN. UPON IMPACT, NEITHER FRONT OR SIDE AIR BAGS DEPLOYED. CONSUMER'S VEHICLE WAS TOTALED. BOTH DRIVER AND PASSENGER SUSTAINED INJURIES. *AK *JB
Service brakes, Hydraulic, Aug 17, 2005
CAR HAS BEEN SERVICED THREE TIME FOR GRINDING IN THE REAR OF CAR WHEN BRAKES ARE APPLIED. I HAVE NEVER BEEN TOLD WHAT THE PROBLEM IS, JUST THAT THEY HAVE FIXED IT, BUT IT NEVER STAYS FIXED. FIRST TIME (10/06/04) THEY LUBED BACKING PLATES AND SANDED SHOES; SECOND TIME (04/20/05) THEY REPLACED REAR BRAKE SHOES AND DRUMS; THIRD TIME (08/15/05) THEY REPLACED BOTH REAR WHEEL CYCLINDERS. I AM TREATED VERY WELL BY THE SERVICE DEPARTMENT PERSONNEL, BUT, I HAVE A CAR THAT CONTINUES TO HAVE BRAKE PROBLEMS. THIS IS A BAD ACCIDENT WAITING TO HAPPEN!. *AK
Wheels, Aug 12, 2005
2004 HYUNDAI ELANTRA STUD FELL FROM THE BACK OF THE HUB ON THE VEHICLE AND THE BRAKE PADS WERE BROKEN AND LAYING IN THE DRUM.*MR
Air bags, Jul 17, 2005
BHUGHT CAR USED 6 WEEKS AGO. EVER SINCE WHILE MY WIFE {120LBS] OCCUP[IES RIGHT FRONT PASSENGER SEAT , THE AIR BAG DISABLED LIGHT STAYS ILLUNINATED. TO EXTINGUISE SHE HAS TO WIGGLE AROUND ON SEAT , SLIDE FORWARD AND SOMEITMES LIFT HER WEIGHT OFF OF THE SEAT AND DROP ON TO SEAT SEVERAL TIMES/ TOOK CAR BACK TO DEALER, CREST HYUNDAI ,AND THEY TESTED SEAT WEIGHT REQUIREMENTS WITH A PROPANE BOTTLE. THIS IS HARDLY THE CORRECT PROCEDURE. THEY SAID THERE WAS NO PROBLEM. PROBLEM PERSISTS EVERY TIME SHE OR ANY ONE LIGHT RIDES IN THAT SEAT. HAVE VIEWED THIS SITE AND FOUND NUMEROUS OTHER COMPLAINTS RELATING TO THIS PROBLEM.
Seat belts, Jul 8, 2005
DT: THE CONSUMER OWNS A 2004 HYUNDAI ELANTRA. THE CONSUMER HAS CALLED THE MANUFACTURER AND WAS TOLD THEY DO NOT MAKE SEAT BELT EXTENDERS. THE CONSUMER NEEDS ONE FOR THIS VEHICLE. THE SEAT BELT EXTENDERS ARE NOT MADE FOR HYUNDAI OR KIAS. *TT *SC *JB
Vehicle speed control, Jun 23, 2005
DT: 2004 HYUNDAI ELANTRA, VEHICLE ACCELERATED WITHOUT THE GAS PEDAL BEING TOUCHED, CONSUMER FIRST TRIED THE BRAKES WHICH DID NOT STOP THE VEHICLE FROM ACCELERATING. THE CONSUMER HAD TO RIDE THE BRAKES UNTIL SHE COULD GET THE VEHICLE OFF THE FREEWAY, SHE PUT THE VEHICLE IN A VARIETY OF POSITIONS, FOR EXAMPLE DRIVE, PARK, AND NEUTRAL THE ENGINE STILL RACED, CONSUMER EVEN TURNED VEHICLE OFF AND BACK ON AND THE VEHICLE WOULD NOT STOP RACING, CONSUMER APPLIED BOTH FEET TO THE BRAKE AND TURNED VEHICLE OFF TWO OR THREE TIMES BEFORE THE VEHICLE FINALLY STOPPED, THE VEHICLE HAD TO BE TOWED HOME, THE DEALER FIXED THE VEHICLE THE FIRST TIME, AND REPLACED THE THROTTLE SENSOR, THIS OCCURRED ON NOV. 18, 2004; THIS SAME PROBLEM OCCURRED AGAIN ON JUNE 2, 2005, THE DEALER STATES THAT BY REPLACING THE ENGINE CHECK MODULAR THAT IT SHOULD FIX THE PROBLEM, AND THE DEALER REPLACED THE ENGINE CHECK MODULAR, CONSUMER IS CONCERNED ABOUT THE SAFETY OF THE VEHICLE, THE VEHICLE SMELLED OF A BURNING SMELL AFTER THE SECOND TIME . *JB UPDATED 12/27/2005. *NM
Power train, Jun 22, 2005
VEHICLE WAS UNDRIVABLE WHEN CLUTCH WENT BAD WITHOUT ANY WARNING AT ABOUT 13,900 MILES. DEALER CHARGES $900 TO REPLACE CLUTCH DUE TO WARRANTY ONLY BEING 12 MONTHS 12,000 MILES. I WAS ABLE TO HAVE HYUNDAI COVER THE COST OF THE PARTS ($260) BUT I PAID 100% OF THE LABOR. IN 30+ YEARS DRIVING I NEVER HAD A CLUTCH GO BAD ON ME IN LESS THAN 100,000 MILES. AND THE ONLY TIME I HAD PRIOR CLUTCH PROBLEMS I WAS ABLE TO PUT THE CAR IN GEAR AND DRIVE IT. THIS TIME THE CLUTCH WAS SO BAD THAT IT WOULD NOT MOVE THE CAR UNLESS IT WAS GOING DOWNHILL - ATOTHER TIMES THE MOTOR JUST REVED AND THE TRANSMISSION JUST SLIPS.
Engine and engine cooling, Jun 17, 2005
DT: CAR HAS BEEN IN SHOP FOR VARIOUS RESAONS. AFTER GETTING OUT OF SHOP,THERE WAS AN ISSUE WITH STALLING. WHILE DRIVING IN STOP AND GO TRAFFFIC THE STALLING BEGAN. . TODAY HOWEVER WHEN GOING THROUGH INTERSECTION VEHICLE STALLED, STOPPED AND LOST POWER, AND WAS ALMOST STRUCK FROM BEHIND. THE CAR DEALER WAS NOTIFIED IMMEDIATELY AND WAS TOLD TO BRING CAR IN MONDAY BUT OWNER WAS PLANNING TO CALL MANUFACTURER TO MAKE ARRANGEMENTS THROUGH DEALER TO HAVE VEHICLE TOWED THERE BECAUSE CONSUMER FELT IT WAS NOT SAFE. NO REPAIRS HAVE BEEN MADE AS OF YET INVOILVING THE STALLING. *AK
Air bags, Seat belts, May 13, 2005, crash
2004 HYUNDAI ELANTRA SEAT BELTS BROKE. THE VEHICLE WAS HIT BY ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. *MR THE SEAT BELTS BROKE AND TORE OUT. ANOTHER VEHICLE HIT THE CONSUMER HEAD ON. THE DRIVERS SIDE PASSENGER FRONT BUMPER SENSOR WAS INOPERATIVE. *SC *JB