2002 Jeep Wrangler
Problems, recalls and owner-reported issues
Structure is the leading concern among 108 owner complaints filed for this model year. This is the 23rd highest complaint count among 26 Wrangler model years with reports.
Of the 2002 reports, 15 involved a crash and 5 involved a fire. 17 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Service brakes, hydraulicMar 13, 2006
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
Campaign 06E022000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 1, 2006
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.
Campaign 06E011000 on NHTSA.gov
EquipmentJun 7, 2004
BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.
SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.
BESTOP WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BESTOP CUSTOMER SERVICE DEPARTMENT AT (800) 845-3567.
Campaign 04E041000 on NHTSA.gov
Fuel system, gasoline, fuel injection system, injectorsApr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
THIS COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V104000 on NHTSA.gov
Electrical system, ignition, switchMar 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES, WATER AND IMPURITIES CAN ENTER INTO THE IGNITION SWITCH, CAUSING A SHORT CIRCUIT.
THIS COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL REPLACE THE IGNITION SWITCH WITH A REDESIGNED SWITCH. OWNER NOTIFICATION BEGAN APRIL 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V075000 on NHTSA.gov
Representative owner complaints: power train
14 reports, newest first. Show all
Suspension, Power train, Dec 24, 2019
FRAME RUSTING OUT
Power train, Structure, Jun 12, 2014
THE 2002 JEEP WRANGLER HAS APPROX. 85000 MILES ON IT. NEVER USED OFF ROAD - JUST TO AND FROM WORK. BROUGHT VEHICLE IN FOR WORK ON CLUTCH AND REPAIR SHOP STATES THAT THE VEHICLE FRAME IS ROTTED THROUGH AND NEED TO BE REPLACED BEFORE TRANSMISSION IS ABLE TO BE REMOVED. FRONT FENDERS HAVE RUSTED THROUGH IN SAME SPOT ON EACH SIDE. *TR
Power train, Dec 17, 2013
GOING DOWN THE FREEWAY ABOUT 60MPH AROUND 5:30PM. FEEL SOME HUMMING FROM THE VEHICLE FOLLOW BY A LOUD HIGH PITCH. THEN HEARD A LOUD BAND AND PARTS STARTED TO FALL ON THE FREEWAY. THE CAR WAS STILL MOVING WITHOUT POWER AND LIGHT. I WAS ON THE THIRD LANE OF A FIVE LANE FREEWAY. CARS BEHIND ME SLOW DOWN AND ALLOW ME TO PULL TO THE SIDE. I WAS STOP BETWEEN AN ENTRANCE AND THE FREEWAY. AFTER EXAM THE CAR WITH THE SHOP. THE TRANSFER CASE WAS BROKEN INTO PIECES. CALLED JEEP AND WAS TOLD TO TOLL THE CAR TO A DEALER. AFTER DEALER CONFIRMED THE TRANSFER CASE WAS BROKEN INTO PIECES WITH NO CLUE. JEEP REFUSED TO PAY BECAUSE WARRANTY WAS DUE ON 2004 EVEN KNOWING THE VEHICLE HAS ONLY 6500 MILES ON IT. THIS JEEP WAS PARKED IN THE GARAGE MOST OF THE PAST YEARS. AND EVERY TIME WHEN I CAME BACK FROM OVERSEA. OIL AND FILTER CHANGE WERE SERVICE ON THE CAR. I DON'T BELIEVE A 6500MILES TRANSFER CASE WILL JUST BLOW UP. *TR
Steering, Power train, Nov 6, 2013
TL* THE CONTACT OWNS A 2002 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN NUMBER: 13V234000 (POWER TRAIN , STEERING). THE DEALER WAS CONTACTED AND STATED THE PART WAS NOT AVAILABLE; THEREFORE, THE VEHICLE WAS NOT REPAIRED. THERE ARE NO FAILURES AT THIS TIME. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 13,000.
Engine and engine cooling, Power train, Jun 9, 2009
MARCH 2009: WHILE DRIVING AT 55MPH, HEAR A RATTLE NOISE, THEN THE SHIFT ON THE FLOOR SHAKES VIOLENTLY. PULL OVER, CANNOT FIND ANYTHING WRONG, TRAVEL HOME LESS THAN 50 MPH, FINE. FEW MORE TIMES, ON THE HIGHWAY, CAR DOES IT AGAIN. PUT IN FUEL INJECTOR CLEANER, CHANGE OIL, CLEAN ALL AROUND BATTERY. DOES NOT DO IT FOR A WEEK OR TWO THEN DOES IT AGAIN. TOLD TO REPLACE CAMSHAFT SENSOR & CRANKSHAFT SENSOR. DID AND RAN FINE NO ISSUES FOR TWO WEEKS. 4/13/09 AFTER SITTING AT A RED TRAFFIC LIGHT, PROCEEDED TO TURN RIGHT, ENGINE DIED. NO WARNING NO SOUND,NO DASH LIGHTS ON, WAITED A FEW MINUTES, STARTED UP & TRAVELED HOME. 4/15/09 AFTER SITTING AT A TRAFFIC LIGHT WHILE DRIVING FORWARD, CAR DIED, NO SOUND,CHUGGING, NO DASH LIGHTS WE WENT TO JEEP IN FORT MYERS FLORIDA. THEY SAID WE NEED TO CHANGE OUR OIL, ADD A FUEL ADDITIVE, INJECTOR CLEANER & CLEAN OUR BATTERY IN ADDITION TO REPLACE ONE OF THE SENSORS. ALL OF THIS WAS ALREADY DONE. IF THAT DOES NOT SOLVE THE ISSUE, THEN IT IS OUR IGNITION SWITCH. COST TO US FOR THIS DIAGNOSIS $110.19. 4/27/09 TOWED JEEP WITH RV TO MAINEWENT TO JEEP DEALER MACDONALD MOTORS BRIDGTON MAINE. 5/04/09 CAR DIED WHILE DRIVING TO THE APPOINTMENT, THIS TIME 45-50MPH. WANTED TO REPLACE CRANK SENSOR WITH A ?MOPAR? BRAND, EVEN THOUGH WE TOLD HIM IT WAS JUST DONE. ALSO WANTED TO COMPLETE COMBUSTION CHAMBER CLEANER FROM BULLETIN 09-003-03. DECLINED. COST $55.81 5/18/09 TOOK CAR INTO MACDONALDS MOTORS FOR BULLETIN 09-003-03 TO BE DONE & ASKED THEM TO CHECK GROUNDING MOUNTS. REC'D CALL THAT THEY PERFORMED FUEL SYSTEM CLEANING & NEED A NEW CRANK SENSOR. WE SPOKE TO THE MANAGER, BECAUSE THE WORK WE REQUESTED WAS NOT PERFORMED, AND OTHER ITEMS WERE. HE ASSURED US THE BULLETIN WOULD BE PERFORMED THE INSPECTION WAS PERFORMED, NO REPAIR WAS NEEDED AND THE GROUNDING MOUNTS WERE FINE AND THE COMPUTER NO LONGER TELLS THEM IT NEEDS A CRANK SENSOR. THIS VEHICLE HAS DIED THREE MORE TIMES SINCE THEIR REPAIRS. *TR
Power train, Nov 1, 2006
BAD THROW-OUT BEARING OR NOISY NV3550 5-SPD TRANSMISSION. *NM
Power train, Jan 10, 2006
2002 JEEP WRANGLER HAS TRANSMISSION PROBLEMS. *TS THE CONSUMER WAS TOLD TRANSMISSION FLUID WAS LEAKING ONTO THE EXHAUST PIPE. *JB
Power train, Apr 12, 2005
PROBLEMS WITH GEARS ON 2002 JEEP WRANGLER.***NO ANSWER REQUIRED***. *MR WHILE DRIVING ON A BEACH WITH THE GEAR IN 4 WHEEL DRIVE HIGH THE VEHICLE SUDDNELY CAME OUT OF GEAR AND THE CONSUMER COULD NOT GET IT BACK INTO GEAR. THE JEEP HAD TO BE TOWED OUT OF THE SAND. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER ASSURED THE CONSUMER THAT THE REPAIRS WOULD BE COVERED UNDER THE 3 YEAR-36000 MILE WARRANTY. AFTER THE VEHICLE WAS INSPECTED THE DEALER REFUSED TO REPAIR THE VEHICLE UNDER WARRANTY BECAUSE THEY FELT THE VEHICLE HAD BEEN ABUSED. THE CONSUMER CONTACTED THE MANUFACTURER SEVERAL TIMES BUT THEY REFUSED TO PROVIDE ANY ASSISTANCE. *NM
Power train, Feb 22, 2004
AT 65 MPH ON I-95 IN MARYLAND, THE CLUTCH AND BEARINGS BURNED OUT. ALL POWER TO POWER BRAKES AND STEERING WERE LOST IMMEDIATELY MAKING AN EMERGENCY STOP AND STEERING WAS VERY DIFFICULT. RECENT DEALER MAINTENANCE FAILED TO DETECT ANY EXCESS IVE WEAR OR POTENTIAL FOR FAILURE. *JB
Power train, Visibility, Seats, Dec 2, 2003
WHEN DRIVING ON ICE OR SNOW THE 4-WHEEL DRIVE KICKS OUT, CAUSING VEHICLE TO JERK AND POTENTIALLY SLID. NO IMPACT HAD BEEN REPORTED. *AK THE VEHICLE WAS IN MOTION WHEN IT FELT AS IF THE TRANSMISSION DROPPED OUT. THE VEHICLE HAD TO BE STOPPED TO GET BACK INTO 4WD. THE LEVER WAS HELD TIGHTLY AND POPPED OUT AGAIN. THE VEHICLE WAS DRIVEN IN 2WD FOR SEVERAL MILES THEN WAS ABLE TO BE PLACED BACK INTO 4WD AND STAYED. ALSO, THE UPHOLSTERY HAD STARTED TO TEAR ON THE DRIVER'S SEAT AND THE GASKETS ON BOTH MIRRORS DETERIORATED. *SCC *JB
Power train, Aug 27, 2003
THE AUTOMATIC TRANSMISSION HAS VERY HARSH ENGAGEMENT AND PRODUCES A LOUD CLICKING NOISE. OVER THE PAST SEVERAL WEEKS I HAVE HAD MY 2002 JEEP WRANGLER IN THE SERVICE DEPARTMENT AND THE REPAIRS HAVE NOT BEEN PERFORMED SATISFACTORILY. I AM TOLD CHRYSLER WILL NOT AUTHORIZE THE REPAIRS OR THE REPLACEMENT OF THE DEFECTIVE PARTS. THE VEHICLE IS STILL UNDER FULL FACTORY WARRANTY, THE TRANSMISSION SHOULD BE REPLACED IF IT CAN NOT BE REPAIRED.*AK
Power train, Apr 1, 2003
IN 4-LOW TRYING TO GET OUT OF SNOW IN A 2002 JEEP WRANGLER, THE AXLE BROKE FOR NO APPARENT REASON. THIS IS NOT BEING COVERED BY WARRANTY SINCE I WAS TOLD IT HAPPENED WHEN SPINNING TIRES HIT PAVEMENT, ALTHOUGH I NEVER DID GET TO PAVEMENT. *JB
Power train, Feb 18, 2003
IN MANUAL TRANSMISSION THE FIFTH GEAR "DOG LEG" STICKS WHEN SHIFTING FROM FIFTH TO FOUTH AND BACK TO FIFTH AND DOES NOT ALLOW FIFTH GEAR TO BE CHOSEN UNTIL YOU PLACE THE GEARSHIFT IN THE NEUTRAL POSITION AND THEN SHIFT INTO FIFTH
Power train, Sep 12, 2002
THE 5 SPEED TRANSMISSION MAKES A RATTLING SOUND WHEN IDLING IN NEUTRAL. NLM