2015 Jeep Wrangler
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 472 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Wrangler model years with reports.
Of the 2015 reports, 15 involved a crash and 27 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Seat belts, front, anchorageSep 26, 2019
Chrysler (FCA US LLC) is recalling certain 2011-2018 Jeep Wrangler right hand drive vehicles. The driver's seat belt buckle mounting strap may fracture and separate from the seat frame.
A separated or severed seat belt buckle strap will result in an inoperable seat belt, increasing the risk of injury in the event of a crash.
FCA US will notify owners, and dealers will replace the driver's seat belt buckle, free of charge. Interim notices informing owners of the safety risk were mailed November 19, 2019. Owners will received a second letter and the recall began March 26, 2020. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is VA6.
Campaign 19V680000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedJan 15, 2019
Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 4, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V01.
Campaign 19V018000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleMay 11, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2016 Right Hand Drive Jeep Wrangler vehicles manufactured February 16, 2010, to May 2, 2016. The clockspring assembly may become contaminated with dust and cause the air bag circuit to fail.
Failure of the air bag circuit may prevent the driver's frontal air bag from deploying in the event of a crash, increasing the risk of injury.
Chrysler will notify owners, and dealers will replace the clockspring, wheel back cover, and column shroud, free of charge. The recall began on August 11, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S40.
Campaign 16V288000 on NHTSA.gov
Representative owner complaints: engine
132 reports, newest first. Show all
Engine, Sep 6, 2022
I have had the oil filter housing crack two times costing over 1 grand each time to have replaced by a shop. The lifters and rockers have gone out on each side of engine now with not even 91k miles on vehicle. Drivers side had 62,000 miles and then the passenger side had 91,000 miles on it. Maintenance has been done on time and not over due.
Engine, Aug 25, 2022
Oil filter housing leaking oil,build up of oil sludge on top of intake manifold,if build up persists it may cause vehicle to catch fire
Engine, Jul 5, 2022
Check engine light came on. Took jeep to dealership - indicated that the left side cylinder head needed replaced, not placing would cause extensive damage. The vehicle had 65779 miles on it and is in excellent condition, there was no reason for the engine to have such significant problems based on usage. Learned this is a faulty issue and that Jeep is aware of it, although no additional warranty or recall was provided. I was paid over $3,392 to get the issue diagnosed and repaired.
Engine, Jul 2, 2022
No crash or injuries. My Jeep only has 45,000 original miles and it is leaking oil from the oil cooler. I researched and this seems to be a very common issue with the 2015 3.6 L Jeep Wrangler. It cost over $1,500 to repair. As the other gentleman stated in his complaint, I feel this is a major issue that needs to be addressed by Jeep. See the other post below for further detail: I OWN TWO JEEP WRANGLERS, A 2013 AND A 2015. I HAD THE 2015 REPAIRED AT A COST OF OVER $1,000.00. NOW MY 2013 HAS DEVELOPED THE SAME PROBLEM; TO WIT, THE OIL COOLER/ OIL FILTER HOUSING CRACKS ON CHRYSLER 3.6 ENGINES AND THE OIL IS SPREAD ONTO THE EXHAUST PIPE WHICH HAS THE POTENTIAL OF CAUSING A FIRE. IF THIS IS NOT DISCOVERED, THE OIL WILL SPREAD TO THE REAR TIRES WHICH WILL CAUSE A TRACTION OR BRAKING HAZARD. CHRYSLER HAS NOT MODIFIED THE HOUSING AND WHEN YOU REPLACE , IT IS REPLACED WITH THE SAME PART THAT WILL FAIL IN THE FUTURE. CHRYSLER HAS TO KNOW THAT THIS PROBLEM EXISTS BY THE # OF UNITS THAT THEY HAVE SOLD, NOT TO MENTION THE THOUSANDS OF UNITS THAT ARE SOLD ON EBAY AND AUTOMOTIVE PARTS STORES. THERE SHOULD BE A RECALL ON THIS SITUATION BEFORE PEOPLE ARE INJURED OR KILLED.
Engine, Jun 7, 2022
There’s a ticking sound coming from my engine and it’s misfiring in cylinder 5 and the check engine light is on. My concern is it’s the rocker arm
Engine, Jun 6, 2022
Our temperature gauge says it’s overheating but it’s not overheating. We’ve had the radiator replaced twice. We’ve had it at three different places to take a look at it, we had the dealership look at it and says they can’t find anything. But it keeps losing coolant. This has been going on for the last 6 to 9 months can’t drive the car more than a few miles.
Engine, Mar 9, 2022
I OWN TWO JEEP WRANGLERS, A 2013 AND A 2015. I HAD THE 2015 REPAIRED AT A COST OF OVER $1,000.00. NOW MY 2013 HAS DEVELOPED THE SAME PROBLEM; TO WIT, THE OIL COOLER/ OIL FILTER HOUSING CRACKS ON CHRYSLER 3.6 ENGINES AND THE OIL IS SPREAD ONTO THE EXHAUST PIPE WHICH HAS THE POTENTIAL OF CAUSING A FIRE. IF THIS IS NOT DISCOVERED, THE OIL WILL SPREAD TO THE REAR TIRES WHICH WILL CAUSE A TRACTION OR BRAKING HAZARD. CHRYSLER HAS NOT MODIFIED THE HOUSING AND WHEN YOU REPLACE , IT IS REPLACED WITH THE SAME PART THAT WILL FAIL IN THE FUTURE. CHRYSLER HAS TO KNOW THAT THIS PROBLEM EXISTS BY THE # OF UNITS THAT THEY HAVE SOLD, NOT TO MENTION THE THOUSANDS OF UNITS THAT ARE SOLD ON EBAY AND AUTOMOTIVE PARTS STORES. THERE SHOULD BE A RECALL ON THIS SITUATION BEFORE PEOPLE ARE INJURED OR KILLED.
Electrical system, Other or unspecified, Engine, Feb 21, 2022
My vehicle has been suddenly shutting off while I am driving. There is no warning that anything is wrong with the vehicle. The first time it happened was October 2021. When it has these failures they happen multiple times. The next day the car operates normally. There are no consistencies when this happens - it has shut off when I am driving 20mph and 60mph. There are no error messages that come up on the vehicle. I took it to Chuck Patterson and they were unable to retrieve an error code and refused to diagnose intermittent issues. They did not find any visible issues with the vehicle. I have an open case with Stellantis but they have not done anything. This issue has happened when I am driving my 2 year old nephew and is life threatening. Stellantis has not sent out anyone to inspect my vehicle. I bought the vehicle brand new special order and it has 104,000. I have not had any issues until now.
Engine, Jan 22, 2022
I have owned my Jeep since 2015 and bought it brand new from the dealership. I have replaced the thermostat three times already. Yesterday, 1-21-22, I was driving home on the interstate. The thermostat stuck again, would not open, and caused it to start dumping coolant out of it while driving. That caused the belt to slip and causing me to almost get into an accident trying to pull over. This Jeep has had several issues with overheating in the almost seven years I’ve had it.
Engine, Dec 10, 2021
2015 Jeep Wrangler 66,000 mi on it rocker arms are rattling need to be replaced it's a problem at all 2015 what I understand
Engine, Oct 21, 2021
I have 2015 Jeep Wrangler Unlimited Rubicon 1000,15 miles on and it has the ticking noise. I took it to my independent mechanic shop. The independent mechanic diagnosed the issue and said that the tick is coming from the passenger side of the Engine .I chatted with FCA to see if they can provide any assistance on this issue they denied even if the vehicle its out of warranty therefore is has to be cover out of my pocket cost.
Engine, Oct 18, 2021
My 2015 Jeep Wrangler with 80,200 developed the well know Pentastar Tick. The Jeep would misfire at idle when slowing to a stop light. The check engine light came on and the code was a P0304. I'm the original owner and took it to the dealer I purchased it from. They diagnosed the issue and called me stating that he Jeep needs new rockers and a cam shaft on the drivers side engine bank. FCA has known about this issue since 2012. I called FCA to see if they would provide any assistance to repair the Jeep. FCA refused to acknowledge that this issue exists and refuses any assistance for owners even slightly out of warranty even though it is a manufacturing defect.
Electrical system, Engine, Aug 4, 2021
The contact owns a 2015 Jeep Wrangler. The contact stated that while driving approximately 60 mph, the vehicle started to hesitate. The contact pulled over to the far right of the roadway. The contact then turned off the vehicle and while attempting to restart the vehicle, the vehicle failed to start-up. The contact had the vehicle towed to a certified mechanic who diagnosed that the starter had failed and needed to be replaced. The contact stated that while attempting to run the starter, the vehicle made a clunking sound and it was confirmed that the engine also failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 13V234000 (Steering, Power Train) as a possible solution to the failure however, the VIN nor the model year was included. The manufacturer was made aware of the failure and confirmed that the model year was not included. The contact was referred to the NHTSA for assistance. The approximate failure mileage was 140,823.
Engine, Jul 13, 2021
Check engine light on, OBD codes P0016, P0390, P0394. Replaced camshaft and crankshaft sensors and problem still persists; limp mode up hills, and oil loss. Per MULTIPLE Jeep Wrangler forums, this is a very wide-spread Jeep phenomenon. Dealers do not know how to fix this. Jeep needs to own up to this defect.
Engine, Jun 21, 2021
I have a 2015 Jeep Wrangler with the Fiat Chrysler's 3.6 liter V- 6 Pentastar engine. The Jeep has only 44,465 miles on it and now has apparent design and manufacturing defects on the engine's left side , its the Pentastar Tick. The Tick Tick Tick is very loud and the engine will shudder, its only a matter of time before the engine shuts off on the highway when I am driving causing an accident. My dealer Hollywood Chrysler Jeep estimated repairs - need left side cams and full set of rockers - oil filter housing is leaking replace - replace abs sensor - coolant flush - carbon fuel cleaning -fluids service total $6,000.07 invoice # 584685. It looks like the cylinder head, gasket, cams, lifters and rockers need to be replaced. Chrysler needs to disclose these defects. Yes my jeep is available for inspection.
Engine, May 4, 2021
APOLOGIES IF THIS COMPLAINT IS A REPEAT, BUT I KEEP GETTING A SUBMISSION ERROR NOTICE WHENEVER I TRY TO SUBMIT THIS FORM. THE JEEP 4.0 LITER SIX CYLINDER ENGINE HAS A KNOWN DEFECT WITH RESPECT TO THE ROCKER ARM BEARINGS THAT CAUSES A LOUD TICKING NOISE IN THE ENGINE AND FAILURE OF THE EXHAUST AND INTAKE CAMSHAFTS. THIS HAPPENED TO OUR 2015 JEEP IN JANUARY 2020 WHEN IT HAD ONLY 31,000 MILES BUT WAS ONE MONTH OUT OF WARRANTY. CHRYSLER DID FIX IT AT THAT TIME AS A COURTESY SUBJECT TO A $100 FEE, AND A COPY OF THE INVOICE FOR THAT REPAIR IS PROVIDED. UNFORTUNATELY, A LITTLE OVER ONE YEAR LATER, AND WITH LESS THAN 10,000 MILES HAVING BEEN DRIVEN SINCE THE INITIAL REPAIR, THE SAME PROBLEM HAS REAPPEARED. THE DEALER IS NOW CLAIMING THE PROBLEM IS WITH THE REMAINING ROCKERS THAT WERE NOT REPLACED, AS IT IS CHRYSLER'S POLICY TO ONLY REPLACE THE ROCKER ARMS AND CAMSHAFTS THAT ARE DAMAGED AT THAT TIME. THE SERVICE MANAGER AT THE DEALER SAYS THAT THEY "SEE THIS ALL THE TIME" AND THAT THEY TRY TO GET ALL THE ROCKER ARMS REPLACED WHEN DOING ANY REPAIRS, BUT CHRYSLER DOES NOT ALLOW THEM TO DO SO. OF COURSE, CHRYSLER IS NOW REFUSING TO COVER THE REPAIRS, EVEN THOUGH THIS IS A KNOWN PROBLEM AND SHOULD HAVE BEEN FIXED THE FIRST TIME. THIS IS TOTALLY UNACCEPTABLE, AND CHRYSLER SHOULD BE FORCED TO DO A FULL RECALL OF ALL AFFECTED ENGINES AND PAY FOR ALL REQUIRED REPAIRS. THERE ARE THOUSANDS OF COMPLAINTS ABOUT THIS PROBLEM ONLINE, YET CHRYSLER STILL REFUSES TO CORRECT THIS PROBLEM.
Engine, Mar 24, 2021
NOTICED SIGNIFICANT KNOCKING NOISE COMING FROM ENGINE THAT CONTINUED TO GET LOUDER. TOOK TO DEALER FOR A NICE 2 THOUSAND DOLLAR FIX. DEALER REPLACED RIGHT SIDE LIFTERS, ROCKER ARMS, AND BOTH CAM SHAFTS. THIS SOUNDS WAY TOO MUCH LIKE THE 2011-2013 ISSUE THAT JEEP "FIXED" AND WAS UNDER WARRANTY FOR THOSE IT SOUNDS LIKE. VERY COINCIDENTAL AND I AM NOT THE ONLY ONE WITH THESE ISSUES BASED ON JEEP FORUMS
Engine, Mar 19, 2021
CEL ON SCAN FOR CODE PO302 CYLINDER 2MISFIRE. R&R SPARK PLUGS, IGNITION COIL, AIR FILTER, UPPER INTAKE GASKET & CLEAN THROTTLE BODY. PERFORM UPPER INDUCTION CLEANING. FOUND MISFIRE TO RETURN ONLY ON IDLE ON CYLINDER 2. PERFORM COMPRESSION TEST. COMPRESSION SPEC OK. REPLACED PLUGS AND COIL AGAIN. THERE IS A SLIGHT TICK FROM CYLINDER 2 VALVE TRAIN AREA. RECOMMEND GOING TO DEALER. DEALER: ENGINE DOES HAVE A SLIGHT TICK. PERFORMED A COMPRESSION TEST AND LEAK DIWN TEST. FOUND LIW COMPRESSION AND AN 80% LEAK ON THE EXHAUST SIDE OF CYLINDER 2. REMOVED THE CYLINDER HEAD AND FOUND THE EXHAUST VALVES BURNT AND EXCESSIVE PLAY IN THE VALVE GUIDES. REPLACED THE LEFT CYLINDER HEAD, ROCKER ARMS AND LIFTERS. CLEARED CODES AND ROAD TESTED VEHICLE. MISFIRE NO LONGER PRESENT. THIS IS ON A 2015 WRANGLER SAHARA UNLIMITED WITH ONLY 51,892 MILES.
Engine, Mar 19, 2021
STARTED OUT WITH OIL IN THE AIR FILTER, HAD THE PVC VALVE AND CAM SHAFT REPLACED. STILL GOT OIL SO AN OIL CATCH CAN WAS INSTALLED, THEN CHECK ENGINE LIGHT CAME ON (AIR FLOW FILTER). THIS WAS CAUSING MY ENGINE TO NOT BE ABLE TO ACCELERATE BEYOND 70 MPH. THEY CHANGED THE SENSOR, BUT AGAIN, WAS UNABLE TO GO OVER 70, AND ON AN INCLINE WOULD DROP DOWN TO 60 AND COULD GO NO FASTER (NO ENGINE LIGHT THIS TIME). NEXT DAY GOT IT UP TO 78, ENGINE LIGHT CAME ON, AND AGAIN COULD NOT ACCELERATE BEYOND 75.
Engine, Mar 17, 2021, fire
TL* THE CONTACT OWNS A 2015 JEEP WRANGLE. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THERE WAS A ODOR OF BURNING OIL PRESENT AND SMOKE WAS SEEN COMING FROM UNDER THE HOOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE PLASTIC OIL COOLER HAD CRACKED CAUSING OIL TO LEAK. THE LOCAL DEALER JACKY JONES DODGE LOCATED AT 2840 US-129, CLEVELAND, GA 30528 WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE OIL COOLER PART NEEDED TO REPAIR THE FAILURE WAS ON BACK ORDER. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 44,000.
Engine, Mar 12, 2021
OIL FILTER/COOLER HOUSING DEVELOPED A LEAK. WAS TOLD BY MECHANIC THAT IT IS MOST LIKELY CRACKED. REPLACEMENT PART IS ON INDEFINITE BACK ORDER, AT LEAST 45 DAYS. LEAK IS BAD ENOUGH THAT I CAN NOT SAFELY DRIVE THE VEHICLE. IT HAS BEEN SITTING IN THE GARAGE FOR 4 WEEKS.
Engine, Feb 26, 2021
OIL COOLER LEAK. I LOST OVER 2 QUARTS OF OIL AFTER A SHORT DRIVE. THE SEALS WERE ALSO LEAKING INTO THE INJECTORS CAUSING MULTIPLE CYLINDER MISFIRE CODES AND CHECK ENGINE LIGHT WARNINGS. NO WARNINGS FROM THE OIL COOLER EXCEPT THE LARGE PUDDLE OF OIL UNDER THE WRANGLER AND OIL COATING THE ENTIRE BACK OF THE ENGINE AND SKID PLATE.
Power train, Engine, Feb 21, 2021
JEEP 2014 AND OLDER ARE ISSUED A PART CALLED THE OIL COOLER/FILTER HOUSING WHICH IS PRONE TO LEAKING OIL ON ALL CHRYSLER ENGINEERS USING THIS PART. THIS IS DEFECTIVE AND OR A DESIGN FLAW RESULTING IN REPLACEMENT AND COSTLY REPAIR AND IS A REOCCURRING FAILURE ON ALL CHRYSLERS USING THIS PART. THIS FAILED ON MY JEEP WRANGLER WITH 48K MILES. THE PART IS APPROXIMATELY $300 TO REPLACE AND OVER ALL REPAIR AT A NON DEALERSHIP IS UPWARDS OF $1000.00. THIS ISSUE NEEDS TO BE A RECALL!
Engine, Feb 20, 2021
OIL COOLER ASSEMBLY HAS STARTED LEAKING BADLY AFTER 60,000 MILES AND IS A FIRE HAZARD. THIS ASSEMBLY IS TOO FRAGILE AND REQUIRES TAKING OFF THE INTAKE MANIFOLD TO ACCESS AND REPLACE, SO IT SHOULD NOT BE A PLASTIC PART. IT CONTAINS THE OIL FILTER WHICH CAUSES IT TO HAVE TORQUE APPLIED EVERY OIL CHANGE AND CAUSES IT TO BREAK PREMATURELY. THIS IS VERY COMMON PROBLEM AND I WAS TOLD BY THE DEALER THAT THERE WERE 25,000 OF THESE ASSEMBLIES ON BACK ORDER NATIONWIDE AND HE COULD NOT TELL ME WHEN IT WOULD BE IN STOCK. MY JEEP IS NOW UNDRIVEABLE UNTIL THE BACKLOG IS WORKED THROUGH WHICH MAY TAKE MONTHS. IF THIS WAS A RARE PROBLEM I COULD GET THE PART AND HAVE IT REPAIRED. THIS PROBLEM HAS RENDERED MY VEHICLE UNUSABLE. THIS IS UNACCEPTABLE AND JEEP HAS KNOWN ABOUT THIS ISSUE FOR YEARS ON MULTIPLE YEAR MODELS. PLEASE INVESTIGATE. THERE IS NO REASON THIS COULDN'T HAVE BEEN PROPERLY ENGINEERED WITH A METAL PART.
Power train, Electrical system, Engine, Feb 11, 2021
I I WILL BE DRIVING AND THE CAR WILL GO OUT OF GEAR AND LOOSES POWER. I HAVE TO STOP , TURN IT OFF AND START AGAIN FOR IT TO WORK. THIS HAS HAPPENED 5 TIMES IN THE LAST YEAR.