2020 Jeep Wrangler
Problems, recalls and owner-reported issues
Steering is the leading concern among 610 owner complaints filed for this model year. This is the 12th highest complaint count among 26 Wrangler model years with reports.
Of the 2020 reports, 16 involved a crash and 12 involved a fire. 7 people were injured.
What owners report most often
Recalls and investigations
Electrical system, propulsion system, traction batteryPark outsideOct 30, 2025
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
A vehicle fire can increase the risk of injury.
Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.
Campaign 25V741000 on NHTSA.gov
Back over prevention, sensing system, cameraSep 12, 2024
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Campaign 24V676000 on NHTSA.gov
Electrical system, instrument cluster/panelSep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."
An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.
Campaign 24V652000 on NHTSA.gov
Structure, frame and membersMar 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler vehicles. A stud on the frame assembly may puncture the fuel tank in a crash, which can result in a fuel leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Dealers will inspect and, if necessary, remove the frame stud and apply paint, free of charge. Owner notification letters were mailed April 6, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 28A.
Campaign 23V191000 on NHTSA.gov
Power train, clutch assemblyFeb 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.
Campaign 23V116000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpOct 13, 2022
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.
An engine stall can increase the risk of a crash.
Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.
Campaign 22V767000 on NHTSA.gov
Back over prevention, display functionAug 25, 2022
Chrysler (FCA US, LLC) is recalling certain 2020-2021 Jeep Wrangler, RAM 1500 and 2021 Jeep Gladiator vehicles. A radio software error may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Dealers will update the radio software, free of charge. Owner notification letters were mailed October 6, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA, LLC's number for this recall is Z86.
Campaign 22V638000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsAug 26, 2021
Chrysler (FCA US, LLC) is recalling certain 2020 Jeep Wrangler vehicles equipped with the 2.0 Liter engine. A cracked fuel supply line connector may leak fuel into the engine compartment.
A fuel leak in the presence of an ignition source increases the risk of fire.
Dealers will inspect and replace the fuel supply line as needed, free of charge. Owner notification letters were mailed on September 10, 2021. Owners may contact FCA US LLC customer service at 1-800-853-140. FCA US LLC's number for this recall is Y10.
Campaign 21V665000 on NHTSA.gov
Power train, clutch assemblyJan 28, 2021
Chrysler (FCA US, LLC) is recalling certain 2018-2021 Jeep Wrangler and 2020-2021 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
FCA US LLC will notify owners, and dealers will add software to reduce engine torque capability when clutch assembly temperatures rise to a level that may damage the inner pressure plate, free of charge." FCA has ordered a stop sale for the affected vehicles as of February 25, 2021. Owner notification letters were mailed on March 4, 2021.
Campaign 21V028000 on NHTSA.gov
Back over prevention, sensing system, cameraSep 10, 2020
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
The lingering rearview image can distract the driver, increasing the risk of a crash.
Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.
Campaign 20V191000 on NHTSA.gov
Power train, clutch assemblyMar 3, 2020
Chrysler (FCA US LLC) is recalling certain 2018-2020 Jeep Wrangler and 2020 Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
The overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Chrysler will notify owners, and dealers will reroute a wire harness and inspect the clutch system, and replace components as needed. The recall began April 30, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W12.
Campaign 20V124000 on NHTSA.gov
Suspension, front, control arm, lower armJan 24, 2020
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Wrangler vehicles. The left side lower control arm bracket and weld may not be correctly positioned.
The improper weld may allow the lower control arm to separate from the axle which can increase the risk of a crash.
Chrysler will notify owners, and dealers will inspect the front axles, replacing them as necessary, free of charge. The recall began February 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W01.
Campaign 20V042000 on NHTSA.gov
Representative owner complaints: engine
59 reports, newest first. Show all
Engine, Fuel/propulsion system, Sep 12, 2026
My Jeep Wrangler currently has a very strong fuel smell, and when the AC is on the smell is very strong inside the cabin. My kids and I became Ill and had headaches. It's been parked for two weeks. Pending an inspection by an independent mechanic. We came across an article stating that a lot of 2020 Jeep Wranglers with 2.0L motors were recalled because of the same issue but my Jeep was not recalled and I'm having the same issue. Is there anything you can do to help me?
Engine, Aug 22, 2026
The 2.0L Turbo engine suffers from premature failures. Jeep issued a TSB over leaking around the water pump, but did not notify owners. My engine overheated due to low coolant (there's no low coolant warning), and the temperature gauge proves to be unreliable. My engine suffered a head gasket failure due to overheating, while within the factory warranty period, and Jeep would not honor their warranty. My Jeep only has 33,700 miles on it, and the failure initially happened in 2024. I spent over a year going back and forth with Jeep, and in the end, they simply stopped responding. BTW, tried to upload 2 small .JPG files, but repeatedly said "upload failed".
Engine, Fuel/propulsion system, Aug 22, 2026
Absolutely terrible gasoline vapor filling the inside cabin of the vehicle causing burning eyes, nausea and feeing ill. Checked for fuel, leak, leakage recall, while there was one it wasn’t including our VIN, however, after inspection and repair, it is the exact same damage as what was indicated in the recall. Looking for a full refund for repair and compensation for danger, discomfort, safety and inconvenience of vehicle not being included in the original recall. I am appalled and insulted that JEEP dealerships aren’t more more proactive in having to appeal these dangerous situations.
Engine and engine cooling, Aug 17, 2026
The contact owns a 2020 Jeep Wrangler. While the contact’s daughter was driving at an undisclosed speed, the engine temperature gauge became extremely elevated. The vehicle was towed to an independent mechanic, where it was discovered that the coolant reservoir was empty and no leak was found. The coolant reservoir was refilled, and the vehicle operated normally. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 64,000.
Power train, Electrical system, Engine, Aug 11, 2026
While driving on the highway, the check engine light illuminated. Approximately 5 to 10 minutes later, the battery warning light came on. Upon exiting the highway and coming to a stop at an intersection, the automatic engine Start/Stop system engaged and shut down the engine. When attempting to safely proceed, the vehicle suffered a complete electrical failure due to the 48V mild-hybrid eTorque system failing to restart the engine. The vehicle refused to crank, would not shift, and became entirely disabled and stranded in the middle of a live intersection, creating an extreme safety and collision hazard. The vehicle was towed to an authorized dealership, where technicians officially confirmed the failure. The dealer diagnosed the root cause as an internal electrical failure of the Motor Generator Unit (MGU / Belt-Driven Hybrid Starter Generator Assembly), which completely disabled the vehicle's charging and hybrid restart capabilities. The failed component is available for inspection.
Steering, Electrical system, Engine, Jul 9, 2026
On July 1,2026 , My 2020 Jeep wrangler jl sport died in the middle of traffic causing a safety issue. I was not able to start my jeep and move out of traffic. I was able to disable the transmission and roll out of the road. But it was very dangerous while cars were passing me and coming towards me. Also before I was able to disable to roll my steering column was locked. The cause of this safety issue is the set up of the batteries. A jeep has 2 batteries a main and underneath an auxillary battery. Without any kind of warning your battery can die caused by the drain of the auxillary battery on the main battery causing the main battery to just stop working without notice. This is the 2nd time this happened.I had to call a tow truck both times. 1st time 4/14/24, then on 07/02/2026 I had it towed to the same dealership as the time before. This is an on going issue with jeeps that have the 2 batteries. Not only is it unsafe but a costly issue.
Engine and engine cooling, Jun 30, 2026, fire
The contact owned a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the engine temperature gauge was increasing. The engine overheating warning light illuminated, the vehicle was turned off, and the contact exited the vehicle to open the hood and immediately closed it when the fire was discovered. The contact stated that there were flames coming from the back of the engine, and the front of the vehicle became engulfed in flames. The engine, seat cover, and front windshield were damaged, and the hood was melted. There was no injury sustained. The fire was extinguished by the Fire Department. The contact stated that the police were on the scene, but a Police report was not filed. The insurance company deemed the vehicle a total loss. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 96,000.
Engine, Jun 30, 2026
Failed emission test and the car is 6 years old. I have had this car in for the death wobble and told them the engine fan stays on. It has done this for years. Dealer kept stating it just had to cool off. The Jeep vehicles that have the deal wobble should be recalled very dangerous. I have videos I can submit.
Engine, Fuel/propulsion system, May 11, 2026
On April 13, 2026, at approximately 67,312 miles, my vehicle experienced a fuel system failure when the main fuel supply line leading to the high-pressure fuel pump cracked and began actively leaking raw gasoline onto the top of the transmission in the engine compartment. There were no prior dashboard warning lights or error messages; the only symptom leading up to the failure was a extremely strong odor of raw gasoline coming from the engine bay area. I believed this fuel leak created an immediate, severe risk of an engine compartment fire. I immediately brought the vehicle to an authorized factory dealership, where certified technicians acting on behalf of the manufacturer inspected the system, confirmed the active leak emitting raw fuel odors, and successfully removed and replaced the failed supply line to resolve the issue. If needed, the vehicle is available for inspection upon request. Furthermore, my vehicle is factory-equipped with the 2.0L Turbo engine, meaning this failure is identical to the documented fire hazard covered under FCA Safety Recall Y10 (NHTSA Campaign 21V-665). Even though my specific production sequence was not actively flagged under the manufacturer's recall lookup system, I believe the component failed in the exact same hazardous manner described in the official recall.
Engine, Mar 27, 2026
WHILE DRIVING ON HWY AT HIGH RATE OF SPEED WHILE IN MODERATE TO HEAVY TRAFFIC- THE ENGINE FAILED, LOCKED UP AND STALLED IN THE FAST LANE- THERMOSTAT OVERHEATED WITHOUT WARNING OR LIGHTS- ENGINE LOST COMPRESSION- SHOULD BE RECALL AS THIS IS PREVALENT IN THIS MODEL ENGINE- 2020 JEEP WRANGLER SAHARA UNLIMITED 4 CYL 2.0 TURBO
Engine, Jan 16, 2026
Premature failure of right bank of intake camshaft and rocker arms/tappet valves requiring a $2000 repair on a 2020 Jeep Wrangler JLU with 64,596 miles.
Engine, Dec 21, 2025
I started out with a slow coolant leak coming from the middle front of the Jeep, that I was not aware of, until it got worse. Now it’s a steady stream only when the engine is on.
Engine, Dec 2, 2025
3 different spot leaking coolant leading to loss of collant for engine and the engine did over heat
Engine, Nov 11, 2025
TSB 07–0 01–22REVB on August 2022 upgraded to ZD8 December 2022 official open recall on January 2023. Both bolts fell off the water inlet engine overheated without antifreeze or water steering locked and entire engine needs to be replaced. Jeep wrangler 2.0T VIN number was not on the recall list. Please explain why not and what we can do about getting this covered.
Engine, Aug 27, 2025, fire
The contact owned a 2020 Jeep Wrangler. The contact stated that while her husband was driving at approximately 65 MPH, she noticed a burning odor in the vehicle's cabin, and the sway bar warning light illuminated. The husband looked out of the driver's window and observed fire coming from under the vehicle. While attempting to steer to the side of the road, the front of the vehicle became engulfed in flames. The couple managed to exit the vehicle safely. The contact's husband tried to extinguish the fire, but it continued to engulf more. The fire department arrived and extinguished the blaze. A police report was filed, and the vehicle was towed to a lot. The manufacturer was notified of the incident. The failure occurred at 51,000 miles.
Engine, Aug 16, 2025
The engine in my 2020 Jeep Wrangler Sahara suddenly failed and was diagnosed by the dealership as a complete internal failure involving the lifters and camshaft. The dealership explained that this type of failure can spread metal fragments throughout the oil system, requiring a full engine replacement. This creates a serious safety hazard, as the engine can shut down unexpectedly while driving, putting both the driver and others at risk. The issue has been confirmed by the dealership’s technician and shop foreman, and the vehicle has been at the dealer for over a month awaiting a replacement engine, which is currently on national backorder. There were no prior warning lights or error messages before the failure. The failure occurred without warning, and the vehicle is not drivable. This problem appears to be affecting multiple Jeep Wrangler owners and may represent a systemic defect that should that should be investigated!
Engine, Jul 21, 2025
Had to take my 2020 wrangler in to have accessory battery replaced as it had drained my newly purchased battery and my car wouldn’t start. Repair shop replaced both batteries and about a week later the check engine light came on for about 2 minutes then went off so I chalked it up to the battery replacement. It didn’t come back on again until about 3 weeks later when I started feeling a slip when going in to second gear. When I got home after having that issue I noticed a small collection of what looked to me like transmission fluid on my garage floor so I had the car towed to the repair shop again. They informed me that engine oil was mixing with coolant due to a bad oil cooler. Between that diagnosis and my car completely breaking down and cracking my engine block the car was driven a total of 14 miles at the most. There was never any other signs prior to me taking it to the shop that the oil cooler had gone bad and even when they replaced the batteries no codes came up for the bad oil cooler and nobody noticed anything while working in the area. . Since then I have learned that this has been an ongoing issue with the wrangler since at least 2012 models and there has been several class action suits that were settled out of court I’m assuming so they don’t have to spend the money recalling and repairing every affected vehicle and finding a fix for future models. Meanwhile I have only had my car for 2 years as of last week and now am being charged $15000 $8000 of which I have to pay up front to even find out how long the parts needed will be on back order. Could be a week could be a year. Not to mention that I have no car to drive and a car payment to make while I wait. This needs to be fixed as these cars are overheating out of nowhere and shutting down when it does. It’s a safety issue as well as a consumer issue.
Electrical system, Service brakes, Engine, May 22, 2025
My vehicle had a rough idling and then flashed an autostart symbol and stated on the dashboard that my autodash has been disabled. Later that day I drove my vehicle again, then the dashboard lit up like a christmas tree and every light was on and my car went limp. I pulled over on the side of the road and let my car stay off thinking it would help. Waited some time and tried to turn it on and it wouldnt turn back on until the 5th attempt. took my vehicle to jeep a few days later where they diagnosed it saying it needs a new ABS control module. However, the control module is on back order with no ETA in sight. There are multiple other people in my exact situation waiting 6+ months for their ABS control module. My car is undriveable as it has no traction control, will go limp, and no ABS system. I have been without my car for a month and they have not provided a loaner. To my research this has been an issue since september of 2023 and has yet to be a recall.
Electrical system, Service brakes, Engine, May 22, 2025, crash
The contact owned a 2020 Jeep Wrangler Rubicon. The contact stated that the battery and engine lights were illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The contact stated that while driving up a hill at 30 MPH, the vehicle became uncontrollable and went into oncoming traffic. The driver was depressing the brake pedal, but the vehicle failed to stop and crashed into a Toyota Tacoma and a Toyota Corolla. The contact sustained an injury to her knee, and medical attention was provided. The airbags deployed. There were no reported fires. A police report was filed. The vehicle was towed to a towing lot. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 80,000. The vehicle was deemed a total loss by the insurance company.
Engine, May 16, 2025
The cams are bad. I am now waiting almost 2 months for repairs. I keep calling and am being told that this is a common problem and they have 15 other Jeeps with the same issue and can't get the parts. This is my third time having my Jeep at the dealership for the same problem.
Traction control system, Engine, Apr 25, 2025
The contact owns a 2020 Jeep Wrangler. The contact stated while driving 35 MPH and decelerating while approaching a stop light, there was misfire coming from the engine, and the traction control activated, causing the brakes to become inoperable. The check engine warning light was illuminated. The “Service START/STOP System” message was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined there were metal shavings in the oil. The dealer recommended an engine replacement. The vehicle was not repaired. The manufacturer was contacted, and confirmed there was no warranty or recall coverage on the vehicle. The failure mileage was approximately 124,000.
Power train, Engine, Fuel/propulsion system, Apr 24, 2025
Had gas leak on lower part of engine leaking gas from the high pressure fuel line took it to a dealer ro so the repairs Jan 29th 2025 and my jeep is still not right ..it had no mechanical problems at all except the leak and now they have had to replace the reservoir for coolant due to broken damaged line and the vehicle has no power at all since the dealership has had possession of my vehicle ...it is the 2.0 liter turbo
Engine and engine cooling, Apr 7, 2025
The contact owns a 2020 Jeep Wrangler. The contact stated that while stopped in traffic, she observed a revving sound coming from the engine compartment. The message that the engine was overheating was displayed, and the temperature gauge remained on H(Hot). The contact stated that when the accelerator pedal was depressed, the message disappeared. The vehicle was taken to the residence, where the contact observed that there was no coolant in the coolant reservoir. The contact added coolant to the coolant reservoir but became aware that the coolant reservoir was empty after one week. The vehicle was not diagnosed or repaired. The contact stated that coolant was added to the reservoir. The contact believed that the failure was associated with Manufacturer Recall Number: 07-001-22REV-A. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.
Engine, Mar 31, 2025
The engine started to misfire due to bad components. The check engine light did not come on to indicate there was an issue until it was too late and the damage was done not only to the engine but other components as well. This was extremely dangerous as the issues resulted in loss of power while driving with my young children in the car as i had just picked them up from school. The vehicle has been inspected by a mechanic who believes that at this point the engine may need to be replaced entirely. My vehicle just passed 100,000 miles so is no longer covered by warranty and now I am stuck with over an $11,000 bill to replace my engine because it was built poorly to begin with, hence the class action lawsuit against Jeep for this particular motor.
Service brakes, Engine, Feb 10, 2025
When I pressed breaks the engine started to surge instead of breaking. After releasing and repressing the breaks the issue was over. Happened twice in one day, 2/7/2025, the weather was clear and dry, road conditions good. Did not reproduce since then. Not sure how this is even possible.