2001 Kia Optima
Problems, recalls and owner-reported issues
Structure is the leading concern among 143 owner complaints filed for this model year. This is the 17th highest complaint count among 20 Optima model years with reports.
Of the 2001 reports, 15 involved a crash. 7 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Electrical system, starter assemblyMar 4, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 03V067000 on NHTSA.gov
Air bags, side/windowMay 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SIDE AIR BAG WIRE HARNESS FOR THE DRIVER POSITION COULD BE MIS-ROUTED, WHICH COULD RESULT IN IT BEING PINCHED OR CUT BY THE SEAT CUSHION TILT MECHANISM.
DAMAGE TO THE WIRE HARNESS COULD RESULT IN THE SIDE AIR BAG NOT DEPLOYING IN AN ACCIDENT.
DEALERS WILL CHECK FOR PROPER ROUTING OF THE SIDE AIR BAG WIRE HARNESS AND SECURE IT IN PLACE WITH A PLASTIC TIE-WRAP. IF THE WIRE HARNESS IS DAMAGED, IT WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 01V156000 on NHTSA.gov
Representative owner complaints: structure
35 reports, newest first. Show all
Structure, Sep 4, 2008
TL*THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT THE BRAKE LINE IN HIS VEHICLE WAS LEAKING. HE TOOK THE VEHICLE TO A LOCAL MECHANIC AND IT WAS DISCOVERED THAT THE K FRAME WAS SEVERELY RUSTED. THE PASSENGER SIDE OF THE VEHICLE IS MUCH MORE DAMAGED THAN THE DRIVER'S SIDE; HOWEVER, BOTH SIDES OF THE FRAME ARE RUSTING. THE MECHANIC ADVISED THE CONTACT TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS UNABLE TO ASSIST. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND CURRENT MILEAGE WAS 78,500.
Structure, Jun 16, 2008
SUBFRAME RUST THROUGH. I DISCOVERED A FIST SIZED HOLE DURING AN OIL CHANGE ON THE PASSENGER SIDE OF OUR 2001 KIA OPTIMA. FRAME HAS BEEN REPLACED AT OUR COST BY DEALER. *TR
Power train, Structure, Mar 11, 2008
CAR HESITATED ONCE OR TWICE UPON ACCELERATION, COULD NOT RECREATE PROBLEM. 1 WEEK AGO, WHILE TRYING TO PULL OUT OF THE GARAGE, CAR WOULD NOT GO INTO GEAR. WHEN CAR FINALLY WENT INTO GEAR CAR WOULD NOT MOVE UNLESS ACCELERATOR PEDAL WAS PUSHED TO THE FLOOR, AND EVEN THEN BARELY ANY MOVEMENT. TOOK CAR TO KIA DEALERSHIP, THREE DAYS LATER DEALERSHIP CALLED, THE TRANSMISSION NEEDS TO BE REPLACED. DEALERSHIP SAID IT HAD TO "FIGHT" WITH THE FACTORY REP TO HAVE THE TRANSMISSION COVERED UNDER THE WARRANTY, EVEN THOUGH I PROVIDED PROOF OF MAINTENANCE. DEALERSHIP ORDERED NEW TRANSMISSION, WHEN PREPPING CAR FOR THE NEW TRANSMISSION A "HOLE WAS FOUND IN THE SUBFRAME", THAT IS NOT COVERED UNDER WARRANTY AND THE TRANSMISSION CANNOT BE PUT IN THE CAR WITH THE HOLE IN THE SUBFRAME AT A COST OF $1,800.00. DEALERSHIP CANNOT EXPLAIN HOW A GARAGE KEPT 7 YEAR OLD CAR HAS A HOLE IN THE SUBFRAME. *TR
Suspension, Structure, Feb 12, 2008
ON FEBRUARY 12, 2008 MY CAR BEGAN TO DRIVE VERY ERRATICALLY WITH SNOW ON THE ROAD. IT WAS DIFFICULT TO KEEP THE CAR FROM STEERING OFF THE ROAD. IT WASN'T JUST ROAD CONDITIONS. I THOUGHT SOMETHING WAS BROKE. I TOOK THE CAR TO THE SHOP THE SAME DAY. INITIALLY THE TECHNICIAN STATED I NEED AND ALIGNMENT. I HAD JUST GOT 4 NEW TIRES AND ALIGNMENT IN DECEMBER 2007. I STATED THIS CONDITION JUST STARTED TODAY. THE TECHNICIAN WHEN BACK AND INSPECTED THE CAR IN MORE DETAIL. HE RETURNED AN SAID THAT THE ALIGNMENT COULD NOT BE DONE TO GET IT WITHIN SPECIFICATIONS. HE TOOK ME TO THE LIFT WHERE THE CAR WAS AND SHOWED ME WHY THE CAR COULD NOT BE ALIGNED. THE LOWER CONTROL ARM ASSEMBLY WAS SEPARATING FROM THE SUB FRAME OR ENGINE CRADLE OF THE CAR, BECAUSE THE FRAME WAS COMPLETELY RUSTED THROUGH. HE TECHNICIAN STATED THIS WASN'T IN A VERY SAFE CONDITION. HE ALSO NOTED A 7 YEARS OLD SHOULD NOT SHOW THIS TYPE OF DECAY IN A MAJOR STRUCTURAL COMPONENT. I ASKED THE TECHNICIAN TO GET THE ALIGNMENT AS CLOSE TO THE MANUFACTURERS SPECIFICATION SO I RETURN HOME SAFE. INTERNET RESEARCH SHOWS THE REPLACEMENT PART COSTING $1400. THE ENGINE AND STEERING COMPONENTS ATTACHED TO THIS PART. I WILL BE CONTACTING THE LOCAL KIA DEALER FOR A LABOR COST ESTIMATE. AN INTERNET SEARCH SHOWS THAT OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM. *TR
Suspension, Structure, Nov 6, 2007
ON NOVEMBER 3, 2007 MY WIFE AND DAUGHTER BROUGHT OUR 2001 KIA OPTIMA TO ATLANTIC KIA IN LINDENHURST NY FOR AN OIL CHANGE AND WHEEL ALIGNMENT. AFTER WAITING SEVERAL HOURS, MY WIFE WAS TOLD THAT THE ALIGNMENT COULD NOT BE DONE ON THE CAR DUE TO A PROBLEM WITH THE TIRES, AND TO BRING THE CAR BACK TO WHERE THE TIRES WERE PURCHASED. THE TIRES ARE 4 MONTHS OLD. SHE THEN BROUGHT THE CAR TO PEP BOYS IN PATCHOGUE, NY. THEY SAID THEY WOULD INSPECT THE TIRES AND OFFERED TO DO THE ALIGNMENT. AFTER SEVERAL MORE HOURS, A TECHNICIAN BROUGHT MY WIFE TO THE LIFT WHERE THE CAR WAS AND SHOWED HER WHY THE CAR COULD NOT BE ALIGNED. THE LOWER CONTROL ARM ASSEMBLY WAS SEPARATED FROM THE FRAME OF THE CAR, BECAUSE THE FRAME WAS COMPLETELY RUSTED THROUGH. THE ONLY THING HOLDING THE RIGHT SIDE OF THE CAR UP WAS THE TIRE. THE TECH THEN TOLD HER THAT THE CAR SHOULD NOT BE DRIVEN AND ASKED WHERE THE DEALER WAS LOCATED. SINCE THE DEALER IS LOCATED ABOUT 20 MILES FROM THAT SHOP, MY WIFE WAS TOLD THAT SHE COULD NOT DRIVE IT THERE, THE CAR WAS VERY UNSAFE. ATLANTIC KIA WAS NOTIFIED OF THIS ON SUNDAY, NOVEMBER 4TH. SHE WAS TOLD TO CALL BACK ON MONDAY THE 5TH. SHE DID, AND WAS GIVEN RUDE AND UNACCEPTABLE TREATMENT FROM THE SERVICE MANAGER. SHE WAS ALLOWED TO DRIVE A HAZARDOUS VEHICLE FROM THE DEALER AND THEN IN TURN WAS TREATED VERY BADLY. ATLANTIC KIA WANTS TO TAKE NO RESPONSIBILITY FOR THE CAR EVEN THOUGH IT HAS BEEN THERE FOR OTHER PROBLEMS IN THE PAST. *TR
Engine and engine cooling, Power train, Electrical system, Air bags, Structure, Jun 24, 2004
WHILE DRIVING AT ANY SPEED, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD INTERMITTENTLY. THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION, BUT THE DEALER WAS UNABLE TO RESOLVE THE PROBLEM. *AK THE BUTTON ON THE SHIFT LEVER POPPED OUT. THE WARNING LIGHT HAD COME ON DUE TO AN OPEN CIRCUIT AND THE SEAL ON THE GAS CAP WAS DEFORMED, THERE WAS A RATTLE COMING FROM THE REAR ASH TRAY, THE FRONT WINDOW WAS INOPERATIVE DUE TO A TANGLE WIRE IN THE DRUM, THERE WERE ENGINE/ELECTRICAL PROBLEMS DUE TO THE OXYGEN SENSORS AND CRANK SENSORS, THE ABS LIGHT HAD COME ON, THE CONSOLE LID WAS LOOSE DUE TO CRACKED SCREW HOLES, THERE WAS A BODY ELECTRICAL PROBLEM WITH THE DRIVER SIDE REGULATOR, THERE WAS POOR SOUND IN THE RADIO DUE TO AN OPEN CIRCUIT. *SC THE AIR BAG LIGHT ILLUMINATED. *JB
Structure, Aug 13, 2002
INSIDE TRUNK RELEASE WAS FAILING TO OPERATE. DEALER WAS NOTIFIED, AND MADE REPAIRS. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
Structure, Aug 13, 2002
POWER LOCKS ON BOTH DOORS WOULD FAIL TO OPERATE. VEHICLE BEEN TO THE DEALER ON THREE OCCASIONS, AND PROBLEM STILLOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
Electrical system, Structure, Aug 17, 2001
POWER DOOR LOCKS WOULD LOCK AND UNLOCK BY THEMSELVES TRAPPING THE DRIVER. THE ENGINE WOULD STALL. BOTH WOULD OCCUR INTERMITTENTLY/SIMUTANEOUSLY. VEHICLE WAS TAKEN TO DEALER SHOP, AND HAD COMPUTER MODULE REPLACED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS MATTER. *AK
Structure, May 17, 2001
POWER LOCKING MECHANISM FOR DOORS OPERATE ERRATICALLY. CONSUMER CANNOT UNLOCK DRIVER'S SIDE DOOR WITHOUT LOCKING ALL OF DOORS AT THE SAME TIME. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK