2016 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 756 owner complaints filed for this model year. This is the 4th highest complaint count among 20 Optima model years with reports.
Of the 2016 reports, 27 involved a crash and 19 involved a fire. 21 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Latches/locks/linkages, trunk lid, latchAug 24, 2023
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
A person inside the trunk compartment may become trapped, increasing their risk of injury.
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.
Campaign 23V594000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJan 6, 2017
Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.
In the event of a crash, an air bag that does not inflate fully increases the risk of injury.
The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.
Campaign 17V007000 on NHTSA.gov
Power train, axle assembly, axle shaftOct 3, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.
If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.
Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.
Campaign 16V705000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.
If the second stage air bag does not deploy it increases the risk of injury or death.
Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.
Campaign 16V231000 on NHTSA.gov
Representative owner complaints
756 reports, newest first.
Electrical system, Sep 28, 2026
3 times windows different ones has stopped rolling up/down. 3 motors purchased and installed.
Fuel system, Gasoline, Engine, Sep 24, 2026
The contact owns a 2016 Kia Optima. The contact stated that while driving 25 MPH, the vehicle shut off without warning. Soon after the failure, the engine caught fire; however, the fire dissipated independently. The insurance agent was contacted and arrived at the scene to inspect the vehicle. The contact was initially informed that the vehicle was safe to drive; however, the engine failed to start after several attempts. Due to the failure, the vehicle was towed to a dealer where a mechanic discovered that the knock sensor was inoperable and had caused the fire. The contact was informed that the vehicle was included in NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine) and the vehicle was repaired under the recall. Nearly a month after the repair, the vehicle started consuming oil with the master warning light displayed. The vehicle was taken back to the dealer for an inspection; however, no fault was found with the vehicle. The manufacturer was notified of the failure, and the contact was referred to the dealer. After another inspection, the dealer agreed to replace the engine; however, the failure recurred after the repair.
Power train, Electrical system, Exterior lighting, Aug 25, 2026, crash
Vehicle was purchased in 2023. AC blower failure occurred for the first time in June 2024 and was repaired by PepBoys. On 4/2/2025 the ve3hicle had an active recall event when the engine seized on the highway because of a faulty oil pump/filter, Engine was replaced 4/17/2025 under that recall. Kia advised at the time that the wiring harness should be replaced due to electrical issues at the time but said that there was no recall for that work. At the time, there were no electrical failures of steering, brakes, all power etc. Nor did we know that those were a possibility. The wiring harness quote was $7,000, over the cost of the vehicle. It was decided to continue repairing the electrical issues as they came up, it was assumed that the fuses would blow before there because a safety or total vehicle failure, as automobiles are designed that way. 8/4/2026 the vehicle experienced a complete and total loss of power resulting in a traffic crash into another vehicle as the brakes felt like you were trying to push a wall rather than a pedal. There was minimal physical damage to the other car and the kia, the other driver got my husband's insurance information and then drove off. The car did startup after ~30 minutes or so and was driven home, but taken to the Kia dealership the next day. It was said that the blower motor overheated and melted a portion of the electrical junction box under the hood and that it was unsafe and dangerous to drive. Kia said that there were no active recalls for this work. NHTSA SC351 seems very similar to this issue that has plagued this car since the beginning. We would ask that Kia incorporate this vehicle and others outside of the year/model ranges in SC351 that have similar failure mechanisms as this seems common.
Electrical system, Service brakes, Engine, Aug 21, 2026
While driving at highway speeds on the freeway in San Diego, the engine of my 2016 Kia Optima catastrophically seized without warning. I instantly lost all power steering, brake assist, and electrical power, creating an immediate life-threatening emergency. The vehicle was towed to a Kia dealer. Corporate Techline and the dealership are refusing to perform the mandated settlement rod bearing test and are falsifying paperwork to deny the safety remedy.
Electrical system, Aug 20, 2026
Blower motor is drawing excessive electricity, which in turn burns the fuse and junction pin, which in turn can start a fire in the car. Kia of Irvine suggested redoing all electrical wiring in the car, but that will not solve the issue. As soon as you turn on the AC, the blower motor will use so much electricity and amperage, so the blower motor fuse and junction pins on the fuse box starting to burn. Wanting to charge almost $7000 to fix this issue, which is double the price value of the car, and risking to end up in this situation again, as soon as you turn on the AC, does not make sense. KIA should do recall on this model and fix the root cause, which is excessive electricity and amperage usage by the blower motor.
Visibility/wiper, Aug 13, 2026
Window falls into the door. The rear two windows have been repaired 3 times. They are currently both broken again along with the front drivers side. I currently have three windows being help up by tape. They are taped to the frame of the door to stop the window from falling into the door. I don't know why this wasn't a recall. I see there is a TSB BOD300. The dealership repaired once but never informed me about the known defect.
Power train, Engine, Aug 5, 2026
The engine assembly completely seized and the vehicle is currently stored at an independent repair shop . While traveling at high speed on Interstate 4 on July 24, 2026, the vehicle suffered a sudden, catastrophic loss of power and stalled in live traffic, creating an immediate threat of a high speed rear end collision. An independent service center officially confirmed the engine seizure after a dealership failed to perform an inspection during an eight hour wait, and no law enforcement or insurance inspections have occurred. Prior symptoms included severe, recurring oil loss requiring constant manual additions of oil between regular service intervals (most recently serviced in June 2026 at a kia dealership), and eventually the car completely shutoff on July24.
Engine, Jul 29, 2026
engine failure, i was driving home from work and i went to accelerate from 0 to 20 miles and the car hesitated and didn't want to move. I took the car to the dealer three days later and it was confirmed that i needed a new engine. I was told by the dealership i was outside of my warranty but i just found out that i was covered up to 120k miles. No lights came on at the time and there wasn't any prior warnings to this happening. I had just put oil into the car two days earlier as i know in between oil changes that i have to put oil into the car and or check the oil to see if it is low.
Other or unspecified, Jul 13, 2026
NHTSA Bulletin TSB BOD300 My KIA 2016 Optima Turbo has all four windows impacted by the defective gear. I've opened a case with KIA and it's case number 25563361. None of my windows roll up or down. This presents several very serious safety issues. The dealer has had my vehicle for over 2 weeks. Why has KIA not been forced to issue a recall on these defective gears?
Other or unspecified, Jul 3, 2026
Code was on and off for a cylinder 2 misfire was off at this point (intermittent misfire) ecl was off car stalled out at 3rpms while driving, tiny puff of smoke once came from between the air intake and the engine, and also no crank no start but car has power. I’ve kept up with the oil changes every 3000 miles car had fluids in it and nothing looked bad all 4 spark plugs were burnt and i replaced them and still no success.
Other or unspecified, Jul 2, 2026, fire
I had just stopped at stop sign and I turned right. My speed was approximately 40 mph and there was a LOUD POP. I immediately hit the brakes and had NO BRAKES. I got car off road and smoke was already coming from under hood. It caught fire immediately and burned up. Total loss . About 6 months prior to it burning I had a good bit of front end work done on it with bearing issues. Also put a new set of tires at same time . The coils and plugs were changed often because it would misfire. I purchased car July 2025. All my documents were burnt also .
Visibility, Jun 23, 2026
The contact owns a 2016 Kia Optima. The contact stated that while driving 10 MPH, the front driver’s and passenger’s side windows lowered unintendedly. Neither the dealer nor an independent was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The rear driver’s and passenger’s side windows were replaced, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance since the VIN was not under recall. The failure mileage was 107,000.
Other or unspecified, Engine, Fuel/propulsion system, Jun 16, 2026
My 2016 Kia Optima equipped with the 2.4L DOHC I4 GDI engine began to experience progressive and severe oil consumption during the latter part of my ownership. The oil warning light began activating repeatedly, even after shortly getting the oil changed. Several certified mechanics and oil change service stations told me this was an ongoing issue with this car and engine and that there was nothing I could do but monitor it and keep it filled. At their instruction, I monitored and had it changed more frequently, often topping it off at the oil change station and at home when needed. Approximately 2 weeks after an oil change upon putting the car in reverse it started to shake uncontrollably. The car was towed to a mechanic who stated I needed an engine. I then towed it to an authorized Kia franchise dealership where the technician documented the oil consumption complaint, confirmed a Cylinder 2 misfire code, performed a borescope inspection, and found the Cylinder 2 exhaust valve burnt with a chunk missing. Engine replacement was recommended by the Kia dealership technician. Prior to my purchase, the engine had already been replaced at approximately 80,000 miles under recall-related circumstances. The replacement engine installed by a Kia dealership subsequently failed, exhibiting symptoms consistent with the documented widespread defect affecting the 2.4L DOHC I4 GDI engine in 2016 Kia Optima vehicles, including severe oil consumption, cylinder misfire, and catastrophic internal engine damage confirmed via borescope at a Kia franchise dealership. Kia America denied the claim based solely on mileage despite the damage being confirmed by their franchise technician. My vehicle became unsafe to drive due to this engine instability shortly after starting before becoming fully inoperable. My vehicle has been non-operational for approximately 5 months. Kia has not provided a substantive written determination despite a formal written demand submitted in March 2026.
Engine, Jun 16, 2026
the engine. I was at a stop sign when the car stop responding to me pressing the accelerator and would not go. Upon further inspection it was noted that my car had no oil in it. I am diligent in getting my oil changed every 3 months or 3,000 miles. My engine had "seized" and i am being advised to purchase a new engine or purchase a new car. While trying to get my car to acclerate i was almost hit 4 times in a matter of 10 mins.
Other or unspecified, Engine, Fuel/propulsion system, Jun 8, 2026
The car returned P1326 and had multiple misfires and audible knocking, the dealers will indeed fight the already existing class action warranties. Was sent home and told to “drive the fuck out of it”, to which the car did not make it home and blew gasoline into my cabin while driving on the highway. Almost passed out, and am still fighting Kia to actually address the defective rod bearings. I personally would fight tooth and nail over a 5 dollar problem, but this is something they do nationwide and can cause serious injury or death. If it weren’t a 200 LB man driving the gasoline shooting into the cabin would absolutely cause a knockout. To the time of this report they are still trying to disregard the rod bearing issue and send me home with fixes to problems caused consequentially.
Service brakes, Hydraulic, Vehicle speed control, Engine, Jun 3, 2026
The contact owned a 2016 KIA OPTIMA. The contact stated that while driving at 30 MPH occupied with her husband the contact heard a noise coming from the rear of the vehicle and smoke coming from the rear of the vehicle as you looked in the drive side rear view mirror and while depressing the brake pedal attempting to come to a complete at the traffic light, the brakes failed to work a intended. No warning light illuminated. The contact mention she kept trying to depress the brake pedal, however the vehicle kept accelerating causing the vehicle to crash into a ditch, go around a telephone poll, crashing into a rock garden which allowing the vehicle to come to a complete stop. The vehicle was towed to a towing lot call interstate towing then the vehicle was then towed by insurance company to a collision center. No injuries were sustained. No medical attention. The fire department extinguished the fire. The contact stated a police report was filed. The vehicle was destroyed. The manufacturer was not made aware of the failure. The approximate failure mileage was 166,834.
Power train, Electrical system, Engine, May 29, 2026
The Kia had a problem with the check engine light coming on and it gently went into limp mode. I had it repaired at Darlings Ford and it worked for about 600 miles. I had it repaired again and it worked for about 7,000 miles. The light recent came on and the car immediately hard banged andwent into limp mode. My wife was driving and shaking when she got home. The light went out and everything was fine. A couple of days later, on 5/27/26, we were on the interstate in traffic travelling 70 mph and it Violently hard bumped, the Cel came on and it went into limp mode. It was as if we hit deep pot holes with both front tires which we didn't as we were on a smooth highway. The light is still on and it's in limp mode.
Engine, May 28, 2026
This vehicle is eligible for Theta II class action settlement, and I cannot seem to get the Kia dealerships, or the Kia Corporate to honor the engine failure issue that I was told by the AAA mechanic should have been replaced. I have also been told by others, including another mechanic at a nationally recognized mechanic that it needs to be taken care of, and that they had the same vehicle and had there's taken care of without any issues.
Other or unspecified, Engine, May 24, 2026
While accelerating onto the highway in my 2016 Kia Optima 2.4L, the vehicle suddenly lost all engine power without warning. The vehicle would no longer accelerate and I was forced to coast and brake to safety. Immediately after the engine shut off, the check engine light, oil light, and battery light illuminated on the dashboard. After the incident, the vehicle would not restart or crank at all. The electrical systems, dashboard lights, and chimes still function normally, and the battery is new. The vehicle had proper oil level at the time of failure. No warning signs were present prior to the sudden loss of power. This failure created a serious safety hazard because it occurred during highway acceleration and left the vehicle unable to maintain speed or move out of traffic safely. Based on the symptoms and sudden engine shutdown, I am concerned this may be related to the known Theta II engine issues associated with Kia Optima vehicles.
Engine and engine cooling, May 22, 2026
The contact owns a 2016 Kia Optima. The contact stated that while operating the vehicle a knocking and rattling noise coming from the engine and the check engine light had remained illuminated. The vehicle was towed to the local dealer who informed that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 150,000.
Air bags, Structure, Other or unspecified, May 18, 2026, crash
UNKNOWN THE AIRBAGS DIDN'T DEPLOY WHEN THE CAR HIT OTHER DRIVER FROM BEHIND.
Power train, Other or unspecified, Engine, May 15, 2026
Issue 1: High oil consumption in the engine due to poor engine design, according to the auto repair center. 5 quarts of oil are added to the engine once every 2-3 weeks. All oil leaks were previously repaired, but oil is still burning off. Issue 2: The engine has misfired more than once, with a puff of smoke coming out of the exhaust. Issue 3: Twice in the past 1.5-2 years, multiple spark plugs have failed, causing a breakdown. This is a Theta II engine, but it is not in the class action settlement.
Engine, May 8, 2026
I purchased a Kia Optima 2016, in December of 2025. At the time the car wouldn't go over 60 mph. I hauled the car to Kia to have it inspected. The Kia dealership informed me that there is a recall on that particular car for an engine replacement. They tested the car and later informed me that they believed I purchased the car knowing it had a recall and wanted the engine replaced for free so I could sell the car. The car is not for sale, and I had/have no intentions on selling the car. I went ahead and paid $6100 for the engine to be replaced. I later did research and learned that if a car has a recall, it doesn't matter my intentions with the car. I felt that Kia denied a replacement engine because of their opinion of me and not for the recall. The car is registered and insured in my name and is being driven daily. At this time, I feel that I deserve a refund of the $6100. Can you guide me on which steps to take on this matter?
Structure, Apr 22, 2026
I am submitting a defect complaint regarding the paint on my vehicle, which has been progressively deteriorating. The issue begins as small bubbles in the paint, which eventually lead to peeling and complete paint loss in affected areas. This condition is currently present on the trunk, roof, and rear sides of the vehicle, and early signs are now appearing on the hood. This defect is more than cosmetic. As the paint peels, it exposes the underlying metal panels to environmental elements, increasing the risk of corrosion and rust. Over time, this can compromise the structural integrity of the vehicle. Additionally, significant peeling—particularly on surfaces like the roof or hood—can create glare or release debris, posing a potential safety hazard and distraction to both myself and surrounding drivers. I initially brought this issue to a Kia dealership, where the manager advised me to contact Kia Customer Affairs. Upon doing so, I was informed that the issue falls outside the warranty timeframe. However, after speaking with other Kia owners experiencing similar problems—especially with the same paint color—it appears this may be a widespread manufacturing defect rather than normal wear and tear. Furthermore, a professional paint specialist evaluated the condition and indicated that the bubbling and peeling are consistent with poor paint adhesion or a defective clear coat/mid-coat application during manufacturing.
Engine, Apr 21, 2026
The contact owns a 2016 Kia Optima. The contact stated that while driving 70 MPH, the check engine warning light illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed. The contact was made aware of a misfire coming from the engine. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 160,000.