2016 Kia Optima

What owners report most often

1. Engine425
2. Other or unspecified121
3. Electrical system103
4. Power train73
5. Fuel/propulsion system53
6. Exterior lighting47
7. Structure40
8. Visibility30

Recalls and investigations

1. Latches/locks/linkages, trunk lid, latchAug 24, 2023

   Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

   A person inside the trunk compartment may become trapped, increasing their risk of injury.

   Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.

   Campaign 23V594000 on NHTSA.gov

2. Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018

   Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

   A fuel leak in the presence of an ignition source can increase the risk of a fire.

   Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

   Campaign 18V907000 on NHTSA.gov

3. Air bags, frontal, driver side, inflator moduleJan 6, 2017

   Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.

   In the event of a crash, an air bag that does not inflate fully increases the risk of injury.

   The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.

   Campaign 17V007000 on NHTSA.gov

4. Power train, axle assembly, axle shaftOct 3, 2016

   Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.

   If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.

   Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.

   Campaign 16V705000 on NHTSA.gov

5. Air bags, frontalApr 21, 2016

   Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.

   If the second stage air bag does not deploy it increases the risk of injury or death.

   Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.

   Campaign 16V231000 on NHTSA.gov

Representative owner complaints: engine

442 reports, newest first. Show all

1. Fuel system, Gasoline, Engine, Sep 24, 2026

   The contact owns a 2016 Kia Optima. The contact stated that while driving 25 MPH, the vehicle shut off without warning. Soon after the failure, the engine caught fire; however, the fire dissipated independently. The insurance agent was contacted and arrived at the scene to inspect the vehicle. The contact was initially informed that the vehicle was safe to drive; however, the engine failed to start after several attempts. Due to the failure, the vehicle was towed to a dealer where a mechanic discovered that the knock sensor was inoperable and had caused the fire. The contact was informed that the vehicle was included in NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine) and the vehicle was repaired under the recall. Nearly a month after the repair, the vehicle started consuming oil with the master warning light displayed. The vehicle was taken back to the dealer for an inspection; however, no fault was found with the vehicle. The manufacturer was notified of the failure, and the contact was referred to the dealer. After another inspection, the dealer agreed to replace the engine; however, the failure recurred after the repair.

2. Electrical system, Service brakes, Engine, Aug 21, 2026

   While driving at highway speeds on the freeway in San Diego, the engine of my 2016 Kia Optima catastrophically seized without warning. I instantly lost all power steering, brake assist, and electrical power, creating an immediate life-threatening emergency. The vehicle was towed to a Kia dealer. Corporate Techline and the dealership are refusing to perform the mandated settlement rod bearing test and are falsifying paperwork to deny the safety remedy.

3. Power train, Engine, Aug 5, 2026

   The engine assembly completely seized and the vehicle is currently stored at an independent repair shop . While traveling at high speed on Interstate 4 on July 24, 2026, the vehicle suffered a sudden, catastrophic loss of power and stalled in live traffic, creating an immediate threat of a high speed rear end collision. An independent service center officially confirmed the engine seizure after a dealership failed to perform an inspection during an eight hour wait, and no law enforcement or insurance inspections have occurred. Prior symptoms included severe, recurring oil loss requiring constant manual additions of oil between regular service intervals (most recently serviced in June 2026 at a kia dealership), and eventually the car completely shutoff on July24.

4. Engine, Jul 29, 2026

   engine failure, i was driving home from work and i went to accelerate from 0 to 20 miles and the car hesitated and didn't want to move. I took the car to the dealer three days later and it was confirmed that i needed a new engine. I was told by the dealership i was outside of my warranty but i just found out that i was covered up to 120k miles. No lights came on at the time and there wasn't any prior warnings to this happening. I had just put oil into the car two days earlier as i know in between oil changes that i have to put oil into the car and or check the oil to see if it is low.

5. Other or unspecified, Engine, Fuel/propulsion system, Jun 16, 2026

   My 2016 Kia Optima equipped with the 2.4L DOHC I4 GDI engine began to experience progressive and severe oil consumption during the latter part of my ownership. The oil warning light began activating repeatedly, even after shortly getting the oil changed. Several certified mechanics and oil change service stations told me this was an ongoing issue with this car and engine and that there was nothing I could do but monitor it and keep it filled. At their instruction, I monitored and had it changed more frequently, often topping it off at the oil change station and at home when needed. Approximately 2 weeks after an oil change upon putting the car in reverse it started to shake uncontrollably. The car was towed to a mechanic who stated I needed an engine. I then towed it to an authorized Kia franchise dealership where the technician documented the oil consumption complaint, confirmed a Cylinder 2 misfire code, performed a borescope inspection, and found the Cylinder 2 exhaust valve burnt with a chunk missing. Engine replacement was recommended by the Kia dealership technician. Prior to my purchase, the engine had already been replaced at approximately 80,000 miles under recall-related circumstances. The replacement engine installed by a Kia dealership subsequently failed, exhibiting symptoms consistent with the documented widespread defect affecting the 2.4L DOHC I4 GDI engine in 2016 Kia Optima vehicles, including severe oil consumption, cylinder misfire, and catastrophic internal engine damage confirmed via borescope at a Kia franchise dealership. Kia America denied the claim based solely on mileage despite the damage being confirmed by their franchise technician. My vehicle became unsafe to drive due to this engine instability shortly after starting before becoming fully inoperable. My vehicle has been non-operational for approximately 5 months. Kia has not provided a substantive written determination despite a formal written demand submitted in March 2026.

6. Engine, Jun 16, 2026

   the engine. I was at a stop sign when the car stop responding to me pressing the accelerator and would not go. Upon further inspection it was noted that my car had no oil in it. I am diligent in getting my oil changed every 3 months or 3,000 miles. My engine had "seized" and i am being advised to purchase a new engine or purchase a new car. While trying to get my car to acclerate i was almost hit 4 times in a matter of 10 mins.

7. Other or unspecified, Engine, Fuel/propulsion system, Jun 8, 2026

   The car returned P1326 and had multiple misfires and audible knocking, the dealers will indeed fight the already existing class action warranties. Was sent home and told to “drive the fuck out of it”, to which the car did not make it home and blew gasoline into my cabin while driving on the highway. Almost passed out, and am still fighting Kia to actually address the defective rod bearings. I personally would fight tooth and nail over a 5 dollar problem, but this is something they do nationwide and can cause serious injury or death. If it weren’t a 200 LB man driving the gasoline shooting into the cabin would absolutely cause a knockout. To the time of this report they are still trying to disregard the rod bearing issue and send me home with fixes to problems caused consequentially.

8. Service brakes, Hydraulic, Vehicle speed control, Engine, Jun 3, 2026

   The contact owned a 2016 KIA OPTIMA. The contact stated that while driving at 30 MPH occupied with her husband the contact heard a noise coming from the rear of the vehicle and smoke coming from the rear of the vehicle as you looked in the drive side rear view mirror and while depressing the brake pedal attempting to come to a complete at the traffic light, the brakes failed to work a intended. No warning light illuminated. The contact mention she kept trying to depress the brake pedal, however the vehicle kept accelerating causing the vehicle to crash into a ditch, go around a telephone poll, crashing into a rock garden which allowing the vehicle to come to a complete stop. The vehicle was towed to a towing lot call interstate towing then the vehicle was then towed by insurance company to a collision center. No injuries were sustained. No medical attention. The fire department extinguished the fire. The contact stated a police report was filed. The vehicle was destroyed. The manufacturer was not made aware of the failure. The approximate failure mileage was 166,834.

9. Power train, Electrical system, Engine, May 29, 2026

   The Kia had a problem with the check engine light coming on and it gently went into limp mode. I had it repaired at Darlings Ford and it worked for about 600 miles. I had it repaired again and it worked for about 7,000 miles. The light recent came on and the car immediately hard banged andwent into limp mode. My wife was driving and shaking when she got home. The light went out and everything was fine. A couple of days later, on 5/27/26, we were on the interstate in traffic travelling 70 mph and it Violently hard bumped, the Cel came on and it went into limp mode. It was as if we hit deep pot holes with both front tires which we didn't as we were on a smooth highway. The light is still on and it's in limp mode.

10. Engine, May 28, 2026

    This vehicle is eligible for Theta II class action settlement, and I cannot seem to get the Kia dealerships, or the Kia Corporate to honor the engine failure issue that I was told by the AAA mechanic should have been replaced. I have also been told by others, including another mechanic at a nationally recognized mechanic that it needs to be taken care of, and that they had the same vehicle and had there's taken care of without any issues.

11. Other or unspecified, Engine, May 24, 2026

    While accelerating onto the highway in my 2016 Kia Optima 2.4L, the vehicle suddenly lost all engine power without warning. The vehicle would no longer accelerate and I was forced to coast and brake to safety. Immediately after the engine shut off, the check engine light, oil light, and battery light illuminated on the dashboard. After the incident, the vehicle would not restart or crank at all. The electrical systems, dashboard lights, and chimes still function normally, and the battery is new. The vehicle had proper oil level at the time of failure. No warning signs were present prior to the sudden loss of power. This failure created a serious safety hazard because it occurred during highway acceleration and left the vehicle unable to maintain speed or move out of traffic safely. Based on the symptoms and sudden engine shutdown, I am concerned this may be related to the known Theta II engine issues associated with Kia Optima vehicles.

12. Engine and engine cooling, May 22, 2026

    The contact owns a 2016 Kia Optima. The contact stated that while operating the vehicle a knocking and rattling noise coming from the engine and the check engine light had remained illuminated. The vehicle was towed to the local dealer who informed that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 150,000.

13. Power train, Other or unspecified, Engine, May 15, 2026

    Issue 1: High oil consumption in the engine due to poor engine design, according to the auto repair center. 5 quarts of oil are added to the engine once every 2-3 weeks. All oil leaks were previously repaired, but oil is still burning off. Issue 2: The engine has misfired more than once, with a puff of smoke coming out of the exhaust. Issue 3: Twice in the past 1.5-2 years, multiple spark plugs have failed, causing a breakdown. This is a Theta II engine, but it is not in the class action settlement.

14. Engine, May 8, 2026

    I purchased a Kia Optima 2016, in December of 2025. At the time the car wouldn't go over 60 mph. I hauled the car to Kia to have it inspected. The Kia dealership informed me that there is a recall on that particular car for an engine replacement. They tested the car and later informed me that they believed I purchased the car knowing it had a recall and wanted the engine replaced for free so I could sell the car. The car is not for sale, and I had/have no intentions on selling the car. I went ahead and paid $6100 for the engine to be replaced. I later did research and learned that if a car has a recall, it doesn't matter my intentions with the car. I felt that Kia denied a replacement engine because of their opinion of me and not for the recall. The car is registered and insured in my name and is being driven daily. At this time, I feel that I deserve a refund of the $6100. Can you guide me on which steps to take on this matter?

15. Engine, Apr 21, 2026

    The contact owns a 2016 Kia Optima. The contact stated that while driving 70 MPH, the check engine warning light illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed. The contact was made aware of a misfire coming from the engine. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 160,000.

16. Service brakes, Engine, Apr 14, 2026

    FOR THE PAST 3 YEARS, IVE BEEN HAVING PROBLEMS RELATING TO MY ENGINE BURNING OIL TO FAST, ENGINE SHAKING AND NOT ACCELERATING LIKE ITS SPPOSE TO... YOU HAVE A RECALL ON 2016 OPTIMAS BUT ONLY THE HYBRID (HEV). WHICH WE ALL KNOW ITS NOT RIGHT. WHY ONLY DO IT FOR CERTAIN OPTIMAS KNOWING WE ARE ALL (ALL OPTIMAS) ARE GOING THROUGH THE SAME THING!! SPENT THOUSANDS OF DOLLARS, IN AND OUT OF DEALERSHIPS AND AUTO SHOPS AND NOW IM MENTALLY DRAINED , UPSET, CONFUSED AND OVERALL FEEL MANIPULATED BY KIA... NICE CARS BUT DOES NOT KEEP ITS VALUE.. CAN SOMEONE FIX THIS PROBLEM

17. Engine, Fuel/propulsion system, Mar 27, 2026

    Car is not holding oil it acts like it's gonna cut off while driving and it jerking was diagnosed with colitic converter p0604

18. Steering, Electrical system, Engine, Mar 11, 2026

    I purchased a vehicle from Banter Auto here in Wichita, Kansas. I reviewed the Carfax beforehand and nothing stood out that scared me so I signed off and purchased the vehicle. I have had nothing but problems since buying which was 7 months ago and have spent 9000 on repairs. I’ve been told by several mechanics the last 5 times I’ve been in and out of mechanic shops it’s evident my car sat in deep water for a long period of time. I finally took it to an electrical auto specialist here in town and while he said it is evident my vehicle sat deep water for a period of time and while the corrosion hasn’t quite started to cause an electrical problem that it very well could down the road. I’ve given the man who owns the dealership and opportunity to make this right however he stopped responding. I believe that is illegal and I’ve been told it should’ve been a “flood title”. I will know for sure after seeing a I will know for sure after seeing an attorney this week. That was not disclosed to me or I would definitely would have not purchased the car. When I first got the car, the locks and windows were going insane flickering all over the place and Kia dealership told me it was quite crazy and nothing they had seen before, however, they were able to fix it. I strongly believe that when my car was flooded it caused something to happen that I’m only going to have to keep paying for overtime. I’m already in debt from the 9000 I’ve had to getting personal loans. This is causing me enormous emotional distress. Please help.

19. Power train, Engine, Mar 9, 2026

    These cars have a known issue for burning oil the motor thats in my car was recalled for same issue but they are not trying fix my car under that recall of the bad motor that they did recall

20. Engine, Mar 5, 2026

    2016 Kia Optima engine locked up, vehicle stalled on interstate,heard a rod bearing sound, left me in limp mode trying to get out the way of 18 wheelers traveling behind me. Towed into Kia dealership which confirmed the engine locked up which has a recall #PI1802B KSDS, but denied to cover it because I didn't have this recall done. I also called Kia Customer Service, they denied me too and just gave me a case #[XXX]. I explained to them that I never received notice of this recall. So how could I prepare for something like this to happen while traveling from Texas to Louisiana to visit my grand kids. The dealership gave me a Quote of $9735 for parts and labor, which I don't have, I am still making payments on this vehicle. Now I am stuck in Louisiana with my vehicle, also it's going to cost me even more to have it towed back to Texas. Please help me understand why the dealership won't stand behind a safety recall or what one person I spoke with called a campaign recall, which ever! That I never received notice about this recall. I hope the "President" or the "President of the Company" will step up and help, after all we as Citizens don't have a problem spending our hard working money on purchasing these vehicles from the dealerships, to have things like this to happen out of our control. Thanks for at least Listening. GOD BLESS...INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

21. Engine, Mar 3, 2026

    Engine oil light doesn’t work. Oil light flashed a couple of times in separate instances. Checking oil dip stick which smells like burning oil and dip stick hardly showed any oil left.

22. Engine, Feb 21, 2026

    engine light start blinking out of no where and speed started to reduce while on the highway. my fix finder gave me code P1326

23. Engine, Feb 17, 2026

    The contact owns a 2016 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle shuddered. No warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the knock sensor needed to be installed prior to the failure for the engine replacement to be covered under warranty. The failure mileage was approximately 143,000.

24. Fuel system, Gasoline, Engine, Feb 17, 2026

    The contact owns a 2016 Kia Optima. The contact stated that while driving at 60 MPH, the vehicle stalled with the check engine light illuminated. The brake pedal was depressed, and the steering wheel seized. The contact was able to pull over to the side of the highway and contacted the Highway Patrol for assistance. The contact associated NHTSA Campaign Number: 18V907000 (FUEL SYSTEM, GASOLINE, ENGINE); with the failure; however, the VIN was not included in the recall. The vehicle was towed to the residence. The dealer was not notified. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 105,000.

25. Engine, Feb 10, 2026

    My vehicle’s engine was previously approved for replacement under the lifetime engine warranty associated with the settlement, confirming that my vehicle falls within the covered class. However, I am now experiencing significant difficulty obtaining assistance regarding secondary damage that directly resulted from the engine failure, specifically the failure of the starter and related operability issues. Despite multiple attempts to resolve this matter through the dealership and warranty channels, I have been repeatedly redirected without meaningful assistance or clear resolution. I have also encountered discrepancies within the online settlement VIN verification tool, which appears inconsistent with Kia’s prior acknowledgment of my vehicle’s settlement-related coverage.