2013 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,383 owner complaints filed for this model year. This is the highest complaint count among 20 Optima model years with reports.
Of the 2013 reports, 48 involved a crash and 114 involved a fire. 36 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 25, 2023
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Campaign 23V652000 on NHTSA.gov
Structure, body, roof and pillarsAug 1, 2022
Kia America, Inc. (Kia) is recalling certain 2012-2013 Optima vehicles. The right and left headliner plates may not be secured properly, which can result in the plates detaching in the event of a side curtain air bag deployment.
A plate that detaches during a crash may strike an occupant, increasing their risk of injury.
Dealers will secure the headliner plates, free of charge. Owner notification letters were mailed September 26, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC245.
Campaign 22V560000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 17, 2022
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.
A fuel leak can increase the risk of a fire.
Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed August 2, 2022. Owners may contact Kia customer service at 1-800-33-4542. Kia's number for this recall is SC228.
Campaign 22V093000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideMay 10, 2021
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
An electrical short in the HECU increases the risk of a fire while parked or driving.
Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.
Campaign 21V331000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideAug 27, 2020
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.
Campaign 20V519000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 21, 2020
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.
If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.
Kia will notify Owners, and Dealers will inspect the low pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, a heat-protective tape will be installed. Repairs will be performed free of charge. The recall began June 12, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC187.
Campaign 20V100000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, air bag/restraint control moduleJun 1, 2018
Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.
If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Kia will notify owners. For model year 2011 Sedona vehicles, Kia will instruct dealers to verify the ACU part number and, if necessary, install an extension wire harness kit between the ACU Connector and the Vehicle Harness Connector. For all other affected vehicles, Kia will instruct dealers to install the extension wire harness kit. The recall began September 28, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC165.
Campaign 18V363000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2017
Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Bearing wear may result in the engine seizing, increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.
Campaign 17V224000 on NHTSA.gov
Representative owner complaints
1,383 reports, newest first.
Service brakes, Hydraulic, Sep 18, 2026
The contact owns a 2013 Kia Optima. The contact stated that the vehicle was unable to start due to the battery being drained from the Hydraulic Electronic Control Unit (HECU) remaining on while the vehicle was turned off. After recharging the battery, the HECU made a buzzing sound while the battery was no longer charging. Additionally, the vehicle went into LIMP Mode while driving, and the ABS, traction control, and several other unknown warning lights were illuminated. A burning odor was inside the vehicle. The contact was concerned about a fire risk. The vehicle was taken to the dealer and determined that the HECU had failed and needed to be replaced. The dealer requested maintenance records for the vehicle. The manufacturer was notified of the failure by phone, and a case was filed. The failure mileage was approximately 111,000.
Fuel/propulsion system, Sep 18, 2026
Gas smell from under the hood. When taken to the dealership it was diagnosed as the high pressure fuel line. NOTE: The high and low fuel lines have recalls that impact this vehicle make, model, and year BUT not this VIN.
Electrical system, Exterior lighting, Other or unspecified, Aug 31, 2026
Module 1 7.5 amp fuse continues to short and blow over and over again. Known issues with auto headlamp leveling sensor. Problem continues to happen. Lose my highbeams, shift lock, rear defrost, rearview auto dimmer, steering wheel controls. Anytime the fuse blows
Other or unspecified, Aug 27, 2026
Both front door lock actuators failed within a one month period. It is a safety issue because the actuator is failing in a way that can prevent the door from opening, closing, properly latching and locking. The vehicle is available for inspection. I have taken it to a mechanic to confirm the failure.
Fuel system, Gasoline, Engine, Aug 20, 2026
The contact owns a 2013 Kia Optima. The contact stated that while driving or while the vehicle was parked, there was an abnormal fuel odor inside the vehicle. The vehicle was leaking fuel from the high-pressure pipe leading to the fuel pump. The contact associated the failure with NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine); however, VIN was not included in the recall. The dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not included in recall. The manufacturer was made aware of the failure but offered no assistance. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 250,000.
Service brakes, Engine, Fuel/propulsion system, Aug 19, 2026, fire
On July 14, 2026, the vehicle's engine was replaced by an authorized dealership under an official Kia recall. On August 16, 2026, while driving on the highway, heavy smoke suddenly began emitting from the engine compartment. When attempting to slow down, the braking system suffered a total loss of power and failed completely. To stop the vehicle, it had to be steered into the highway median to intentionally scrape against it to force a stop. Immediately upon exiting the vehicle, heavy flames were observed under the engine compartment before completely engulfing the front of the car. The fire department extinguished the fire, and the vehicle is a total loss.
Engine and engine cooling, Aug 13, 2026, fire
The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 70 MPH with the cruise control activated, there was smoke coming from underneath the passenger’s side of the hood before the vehicle decelerated. The contact stated that moments later there were flames coming from the underneath the hood of the vehicle. The vehicle was parked on the side of the road and flames quickly engulfed the vehicle. The Fire Department was called to the scene and arrived and extinguished the fire. During the fire the vehicle was destroyed and was later towed to a nearby storage facility. While attempting to quickly exit the vehicle the contact fell to the ground and sustained an injured left leg and left side. The cause of the failure was not yet determined. The contact stated that the engine was recently installed related to a recall repair. No additional information was available. The manufacturer and local dealer were notified of the failure. The failure mileage was 140,000.
Steering, Aug 11, 2026
The contact owns a 2013 Kia Optima. The contact stated that while driving 30 MPH, the steering wheel was difficult to turn. There was an abnormal clicking sound coming from the vehicle and the vehicle was uncontrollable. The vehicle was towed to the local dealer, where it was diagnosed and determined that the coupling in the steering wheel needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no coverage under the warranty extension for the MDPS flexible coupling. The failure mileage was approximately 139,000.
Service brakes, Jul 23, 2026
I am writing to formally report a dangerous safety defect involving the braking system and the Hydraulic Electronic Control Unit (HECU) on my 2013 Kia Optima Hybrid. While operating the vehicle, severe warning lights illuminated on the dashboard indicating an immediate braking system and stability control failure. A diagnostic scan revealed active fault code C1237, pointing specifically to a primary pressure sensor signal failure embedded inside the internal HECU assembly.This issue presents a severe safety hazard. The failure compromises the vehicle's electronic brake assist, anti-lock braking system (ABS), and active stability systems. This results in unpredictable pedal feel and significantly increased stopping distances, drastically elevating the risk of a high-speed collision.Furthermore, this vehicle architecture relies heavily on clean voltage from the 12-volt battery system. Sudden drops in battery performance appear to trigger cascading communication faults within the HECU network, causing the vehicle to lose crucial safety systems without adequate warning.Kia is aware of severe electrical and internal component defects within the HECU modules of this generation, as evidenced by Safety Recall SC284 (NHTSA Campaign 23V652000) for HECU internal electrical shorts and engine fire risks. However, dealerships are treating related sensor failures inside the exact same HECU assembly (such as the internal primary pressure sensor) as customer-pay maintenance issues, rather than recognizing them as symptoms of a fundamentally defective or failing control unit. Dealership service centers are recommending piecemeal, expensive part replacements (like pedal travel sensors) that do not resolve the underlying safety risk of an internally failing HECU module.I request that the NHTSA investigate whether internal pressure sensor failures (Code C1237) and related electronic brake module collapses on 2011–2015 Kia Hybrid models are connected to the known sub-component defects wi
Fuel/propulsion system, Jul 21, 2026
I own a 2013 Kia Optima and I am experiencing recurring fuel system-related symptoms. The fuel gauge fluctuates even when the vehicle has a full tank of fuel, causing an inaccurate fuel level reading. In addition, the vehicle has begun to hesitate during operation, which raises concern that there may be an underlying fuel delivery or fuel system issue. I previously experienced a similar issue years ago, and I believe the vehicle was repaired during a Kia recall or service campaign. The problem has now returned, and I am concerned that the previous repair may not have permanently corrected the issue or that there may be a related defect affecting other vehicles. The combination of an inaccurate fuel level reading and engine hesitation could create a safety concern because the driver may not know the true amount of fuel remaining and may experience unexpected loss of power while driving. I am requesting that this issue be investigated to determine whether it is related to a previous recall repair, a fuel system defect, or another safety-related condition affecting the 2013 Kia Optima.
Structure, Jul 20, 2026
Paint began chipping/flaking off little by little everytime I washed the car. It’s a common occurrence with snowy white Kia paint in this year
Steering, Power train, Engine, Jul 19, 2026
the engine revs high and transmission wont shift and when you turn the steering wheel ya get a loud click and the steering wheels jumps
Steering, Jul 8, 2026
The steering column From the car has diminished causing dangerous shaking on highway at high speeds
Seat belts, Jun 18, 2026, crash
The contact owned a 2013 Kia Optima. The contact stated that while driving at an undisclosed speed on the main road of a T-intersection, the contact blacked out before another vehicle crashed into the front passenger's side of the vehicle. The contact stated that the front of the vehicle sustained severe damages, and there was more damage on the front passenger's side of the vehicle. The air bags deployed. The contact stated that the seat belt retracted excessively, causing the contact to be pinned in the seat and to sustain severe injuries. The contact was assisted out of the seat and was partially unconscious. The contact was unsure if any warning lights were illuminated after the crash. A Police report was filed. The ambulance transported the contact to the hospital. The contact sustained a fractured L2 and back, ruptured bowel, and intestines and internal bleeding in the stomach. The contact underwent surgery and physical therapy. The vehicle was towed and deemed totaled by the insurance company. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. A complaint was filed. The failure mileage was approximately 130,000.
Other or unspecified, Jun 9, 2026
Large delamination of paint on the vehicle.
Engine and engine cooling, May 22, 2026
The contact stated that while driving the vehicle began to unexpectedly slow and then stalled. The vehicle was unable to restart. No warning lights illuminated. The vehicle was taken to the dealer where it was not diagnosed or repaired. The manufacturer was notified of the issue. The approximate failure mileage 215,000.
Engine, May 14, 2026
I was driving on the high way and my car completely stopped I towed it to a shop and the engine seized
Engine, May 11, 2026, fire
My 2013 Kia Optima was running fine at 65 mph when suddenly the engine stalled. I then coasted to the shoulder and smelled burning plastic. As soon as I opened the hood the engine started being consumed in fire, it quickly went to a very large engine fire that consumed the front half of the car. There were no other vehicles involved with this incident. Vehicle is a total loss.
Air bags, Engine, Fuel/propulsion system, May 8, 2026
The vehicle is experiencing sudden engine stalling while in motion, a known safety hazard. Despite a documented maintenance history with no issues, the dealer (Bayside Kia) is attempting to deny a Theta II Settlement claim by shifting the narrative to 'engine sludge,' which only appeared as a symptom in June 2025( Walmart oil change) alongside engine performance issues. The vehicle has active codes P0014 and P0017, which are secondary symptoms of the internal bearing wear and metallic debris contaminating the oiling system. KDS Diagnostic tests showed Cylinder 1 at 0.16mm (approaching the 0.20mm failure limit). This clearance proves the connecting rod bearings are worn and reaching the failure threshold; this mechanical wear is the root cause of the engine's inability to operate safely. The presence of metallic debris in the oil is the definitive signature of the Theta II manufacturing defect. Furthermore, the dealer acted in bad faith by attempting to charge for Airbag repairs (Codes B1346/B1481) that are covered under the 15-year Clock Spring Warranty Extension (CS1102). The dealer has dismissed my qualifying maintenance documents, claiming they are 'not official,' which is a direct violation of the Magnuson-Moss Warranty Act. A manufacturer cannot deny a warranty claim because services were performed at third-party facilities, nor can they deny a claim without proving 'exceptional neglect.' I am reporting a refusal to honor a court-ordered safety settlement and an attempt to return an unsafe, stalling vehicle to the road.There is no evidence of engine abandonment or exceptional neglect. I’m considered "in compliance" if I can show I didn't go more than 14 months without servicing or a certain mileage between oil changes.The dealer's dismissal of verified third-party receipts and bank statements is a bad-faith attempt to ignore an inherent manufacturing defect documented by a 0.16mm BCT result and metallic debris.
Engine, May 7, 2026
We were told by the mechanic that the engine was locked up after the car refused to drive faster than approximately 23 mph. We had to have the car towed from Boone, NC which was about 200 miles. The car is at our house and is available for inspection upon request. I have made repeated calls to different Kia dealers asking for a call back to assist me with direction but there will never be a returned phone call. As far as I know, there has been no inspection of the engine or vehicle.
Engine, Apr 30, 2026
The contact owns a 2013 Kia Optima. The contact stated that while driving at an undisclosed speed, the engine unexpectedly seized without warning. The contact stated that after the vehicle lost motive power, several unknown warning lights illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had seized and needed to be replaced. The vehicle was not repaired. The vehicle was then towed to the dealer but was not diagnosed or repaired. The contact was informed that no diagnostic trouble codes were found. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.
Electrical system, Other or unspecified, Engine, Apr 30, 2026
Code : P1777 Transmission- oil pump A issue with the Valve cover gasket leaking into the engine causing a misfire. Making the car suddenly stop while driving which is very unsafe. I took the car to the dealership and they want to charge me for the repairs. I have 2 kia optima hybrid and both cars have the same issue around the same mileage. There were no warning lights during the time it was at the shop. I believe later down the line the engine will stall out and it should be fixed now while under warranty. However I received no help from the dealership unless I am willing to pay upfront. In addition to this there are electrical issues the front seats aren't moving immediately when the button is pressed. The steering wheel buttons barely work along with the radio. This is a huge problem that needs to be fixed.
Engine, Apr 29, 2026
The contact owns a 2013 Kia Optima. The contact stated while driving 75 MPH, the vehicle went into LIMP Mode and failed to exceed 60 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the knock sensor and the harness had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred on several occasions, and the vehicle was driven or towed to the dealer as needed. The dealer cleared the diagnostic trouble codes and informed the contact that a recall repair would not be completed unless the engine made loud knocking sounds or seized. The contact stated that while driving at an undisclosed speed, the engine made an abnormally loud sound and seized. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where the contact was informed that the engine was not eligible for replacement due to a lack of maintenance records because the contact did not have all the oil change service records available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 297,000.
Steering, Apr 23, 2026
Clanking noise is steering column and very loose steering.
Steering, Suspension, Other or unspecified, Apr 23, 2026
While driving my KIA Optima on the interstate the rear subframe suffered catastrophic structural failure, resulting in the steering wheel going out of alignment, the rear passenger side wheel tilting with the bottom of the tire being far out compared to the top. This resulted in the rear of the vehicle swaying side to side and being difficult to maintain in a straight path. This vehicle was previously serviced under KIA Campaign SC141 (internal subframe corrosion) at Griffin KIA on April 27, 2017. Despite this safety remedy being performed the subframe rotted through and snapped. This is a remedy failure. The anti-corrosion was applied by the manufacturer failed to prevent the exact structural failure it was designed to mitigate. I have physical evidence (Repair Order #92144) proving the remedy was performed and photographic/video evidence of the subsequent structural break. The manufacturer (KIA) has denied assistance, claiming the failure is "unrelated" to the corrosion campaign despite the part being the exact component covered by the campaign." SC141 involved the inject of wax into the metal components of the subframe of the vehicle and was KIA's response to the NHSTA's concerns about the metal components of their vehicles being unable to withstand salt in the Rust Belt states. The campaign only was for the vehicles in the rust belt states. KIA was very aware this was a safety issue and attempted to avoid a recall by issuing this campaign. The campaign failed and as a result my life was put at risk. I asked KIA for a good will repair of the rusted subframe but they refuse indicating the believe the part that clearly broke due to rust is unrelated to the safety campaign. Several of their employees stated it was very clear the part broke due to rust with one indicating he had a list of rusted parts needing replaced. I'd like the NHTSA to review this failed campaign and ensure the safety of all vehicles relying on this failed safety measure.