2001 Kia Optima
Problems, recalls and owner-reported issues
Structure is the leading concern among 143 owner complaints filed for this model year. This is the 17th highest complaint count among 20 Optima model years with reports.
Of the 2001 reports, 15 involved a crash. 7 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Electrical system, starter assemblyMar 4, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 03V067000 on NHTSA.gov
Air bags, side/windowMay 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SIDE AIR BAG WIRE HARNESS FOR THE DRIVER POSITION COULD BE MIS-ROUTED, WHICH COULD RESULT IN IT BEING PINCHED OR CUT BY THE SEAT CUSHION TILT MECHANISM.
DAMAGE TO THE WIRE HARNESS COULD RESULT IN THE SIDE AIR BAG NOT DEPLOYING IN AN ACCIDENT.
DEALERS WILL CHECK FOR PROPER ROUTING OF THE SIDE AIR BAG WIRE HARNESS AND SECURE IT IN PLACE WITH A PLASTIC TIE-WRAP. IF THE WIRE HARNESS IS DAMAGED, IT WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 01V156000 on NHTSA.gov
Representative owner complaints
143 reports, newest first.
Service brakes, Hydraulic, Jun 22, 2005
DT: CONSUMER PURCHASED VEHICLE IN FEBRUARY , 2005 AND THE BRAKES SQUEALED WHEN VEHICLE WAS BOUGHT. CONSUMER TOOK VEHICLE TO DEALER AND HAD SOME REPAIR DONE, INCLUDING THE FRONT BRAKES. HOWEVER REAR BRAKES SQUEALED. DEALER CLEANED REAR BRAKES AND ADJUSTED THEM TWICE. ON LAST TRIP TO DEALER HE STATED THAT THERE WAS NOTHING THEY COULD DO, AND CONSUMER WOULD JUST HAVE TO DEAL WITH THE SQUEAL. DEALER SAID THAT THERE WAS A TECHNICAL SERVICE BULLETIN ON THE REAR BRAKE PROBLEM, AND DEALER STATED THEY COULD PUT NEW BACKING ON BRAKES FOR $269, BUT THIS MAY NOT FIX PROBLEM.*AK
Engine and engine cooling, Air bags, Latches/locks/linkages, Jun 22, 2005
03/06/02 PURCHASED A OPTIMA KIA 2001, STILL UNDER WARRANTY UNTIL 2/6/06. PROBLEMS WITH AIRBAG, ENGINE, AND LOCKS FROM THE DATE OF THE PURCHASE OF THIS CAR. CAR BROUGHT IN FOR AIRBAG LIGHT PROBLEM 14 TIMES SINCE 2002 TO PRESENT DATE 2005 AND STILL NOT FIXED AS WE SPEAK. ENGINE BROUGHT IN 6 TIMES, AND LOCKS WORK WHEN THEY WANT TOO. LAST TIME SERVICE ON AIRBAG WAS 6/5/05 LIGHT BACK ON. KIA KNOWS THIS CAR CAN NOT BE FIXED AND REFUSE TO GIVE ME A SAFE CAR FOR ME AND MY 11 YEAR OLD SON
Engine and engine cooling, Mar 1, 2005
DRIVER NOTICED THAT THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE PCV PIPE NEEDED TO BE REPLACED, AND REPLACED IT. HOWEVER, THE PROBLEM RECURRED. WHILE DRIVING 25 MPH VEHICLE STALLED. THE DRIVER WAS NOT ABLE TO RESTART VEHICLE, AND IT WAS TOWED TO A DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE CAM SHAFT POSITION SENSOR NEEDED TO BE REPLACED AND REPLACED IT. HOWEVER, THE PROBLEM RECURRED. *AK
Engine and engine cooling, Latches/locks/linkages, Jan 5, 2005
THE DRIVER'S SIDE DOOR DID NOT LOCK AND THE TIMING BELT AND TENSIONER WAS REPLACED TWICE. *SC *TC *JB
Engine and engine cooling, Dec 3, 2004
WHILE DRIVING 15 - 20 MPH VEHICLE JUST QUIT IN ITS TRACK. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER, WHERE CONSUMER WAS TOLD THAT THIS VEHICLE WAS BEING RECALLED FOR THE CRANK SHAFT POSITION SENSOR RECALL 03V067000. CONSUMER THEN CONTACTED THE MANUFACTURER, WHO INDICATED THAT THIS VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
Engine and engine cooling, Oct 6, 2004
VEHICLE STALLED INTERMITTENTLY WHILE DRIVING FROM 20 MPH. VEHICLE WOULD RESTART WITHIN A FEW MINUTES. VEHICLE WAS TAKEN TO THE DEALER ON 3 SEPARATE OCCASIONS, AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM.*AK
Air bags, Seat belts, Oct 6, 2004, crash
I WAS INVOLVED IN A CRASH ON NOV 02. I WAS BROADSIDED BY A TRUCK (F150 TYPE VEH.) IN AN INTERSECTION. AS A RESULT, MY ROOF BOWED AND THE ENTIRE DRIVERS SIDE FROM WHEEL WELL TO WHEEL WELL WAS CAVED IN LIKE A HALF MOON. THE FRAME WAS PINNED UP AGAINST THE DRIVERS SEAT. THE SEAT BELT DID NOT LOCK BUT RELEASED ME AND NONE OF THE AIR BAGS DEPLOYED. I SUFFERED BACK AND NECK INJURY AND WAS TRANSPORTED BY AMUBULANCE TO A NEARBY HOSPITAL. THE VEHICLE WAS IN STORAGE. I CONTACTED THE MANUFACTURER NUMEROUS TIMES AS DID MY ATTORNEY. ALL WE RECEIVED WAS THE RUN-AROUND FOR APPROX. SIX MONTHS. NO RETURN CALLS, EXCUSES, UNABLE TO GET A RELEASE TO HAVE A KIA AUDITOR LOOK AT THE CAR, ETC. MY INSURANCE COMPANY AND MY ATTORNEY SENT THEM THE RELEASE TWICE AND STILL NO RESPONSE. CONSEQUENTLY, I DEPLOYED OVERSEAS (MILITARY) AND UPON MY RETURN FOUND THAT THE CAR HAD BEEN DISPOSED OF (DESTROYED). I STILL SUFFER FROM MY INJURIES AND MY ATTORNEY IS STILL HANDLING MY CASE.*AK
Exterior lighting, Sep 15, 2004
WHILE DRIVING AT NIGHT, THE HEADLIGHTS WOULD DIM WHENEVER THE A/C OR THE HEATER WAS TURNED ON. THE DEALER/MANUFACTURER BOTH AGREED THAT WAS THE NORMAL CHARACTERISTIC OF THAT VEHICLE. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *JB
Engine and engine cooling, Electrical system, Equipment, Jul 21, 2004
I PURCHASED MY BRAND NEW CAR ON AUGUST 31,2001. I STARTED HAVING ELECTRICAL PROBLEMS 9 MONTHS AFTER I BOUGHT IT. I NOW HAVE A LIST OF PROBLEMS FROM ELECTRICAL TO CHECK ENGINE LIGHT, FUEL SENSORS, 2 NEW BATTERIES ETC. I HAVE A LONG LONG LIST OF REPAIRS THAT NOBODY CAN SEEM TO FIX. I AM TOLD THE PROBLEM HAS BEEN FIXED AND THEN MY CHECK ENGINE LIGHT COMES BACK ON AND I AM TOLD THERE ARE ADDITIONAL PROBLEMS. MEANWHILE, I HAVE BEEN STRANDED ON THE HIGHWAY DUE TO THESE PROBLEMS, I HAVE HAD TO BE TOWED OUT OF MY OWN DRIVEWAY TO DUE THE ELECTRICAL PROBLEMS. I HAVE TRIED NUMEROUS TIMES TO TELL KIA CORPORATION THAT I DO NOT FEEL SAFE DRIVING THIS VEHICLE ANY LONGER AND NOBODY IS LISTENING. THE GENERAL MANAGER OF THE DEALERSHIP I BOUGHT THE VEHICLE FROM EVEN AGREES AND FEELS THIS CAR TO BE VERY UNSAFE AND DANGEROUS TO DRIVE. I HAVE TRIED TO TALK TO JOE PETAZONI(SPELLING) WHO IS SUPPOSED TO BE A KIA REPRESENTATIVE THAT WOULD DECIDE WHAT TO DO, HE HAS BEEN NO HELP AT ALL. I FEEL THAT KIA CORPORATION SHOULD BUY BACK MY VEHICLE BECAUSE OF ALL THE UNSAFE ISSUES I HAVE HAD. I FEEL I BOUGHT A LEMON AND IF I CAN'T GET ANYWHERE WITH THE COMPANY, I WILL BE FORCED TO CONTACT THE STATES ATTORNEY'S OFFICE REGARDING THIS LEMON OF A VEHICLE!!!!! I HAVE LEFT MESSAGES FOR DEBBIE WOJCIECHOWSKII AND SHE WILL NOT RETURN MY CALLS. I HAVE TOLD THE PEOPLE AT 800-333-4-KIA HOW UNSAFE I FEEL AND NOBODY PUTS THAT INFORMATION INTO THE SYSTEM. *LA
Engine and engine cooling, Power train, Electrical system, Air bags, Structure, Jun 24, 2004
WHILE DRIVING AT ANY SPEED, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD INTERMITTENTLY. THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION, BUT THE DEALER WAS UNABLE TO RESOLVE THE PROBLEM. *AK THE BUTTON ON THE SHIFT LEVER POPPED OUT. THE WARNING LIGHT HAD COME ON DUE TO AN OPEN CIRCUIT AND THE SEAL ON THE GAS CAP WAS DEFORMED, THERE WAS A RATTLE COMING FROM THE REAR ASH TRAY, THE FRONT WINDOW WAS INOPERATIVE DUE TO A TANGLE WIRE IN THE DRUM, THERE WERE ENGINE/ELECTRICAL PROBLEMS DUE TO THE OXYGEN SENSORS AND CRANK SENSORS, THE ABS LIGHT HAD COME ON, THE CONSOLE LID WAS LOOSE DUE TO CRACKED SCREW HOLES, THERE WAS A BODY ELECTRICAL PROBLEM WITH THE DRIVER SIDE REGULATOR, THERE WAS POOR SOUND IN THE RADIO DUE TO AN OPEN CIRCUIT. *SC THE AIR BAG LIGHT ILLUMINATED. *JB
Latches/locks/linkages, Equipment, May 28, 2004
MY WIFE & I OWN A 2001 KIA OPTIMA WITH POWER LOCKS. TWICE THE POWER LOCKS HAVE FAILED. THE FIRST TIME, THE LOCKS FAILED IN THAT THEY WOULD UNLOCK BY REMOTE AND IMMEDIATELY LOCK BACK PREVENTING ACCESS TO THE VEHICLE. BY KEY, ONE DOOR WOULD OPEN WHILE THE OTHER HAD TO BE OPENED FASTER THAN THE CAR COULD RE-LOCK ITSELF. THE SECOND TIME IT FAILED CONCERNED ME GREATLY. THE DEALER, PARAMOUNT KIA OF HICKORY, HAD REPAIRED THE LOCK PARTS AND SAID HE HAD SEEN THIS BEFORE & THAT IT WAS NO BIG DEAL. A FEW MONTHS LATER, THE LOCKS FAILED AGAIN TRAPPING ME IN THE PASSENGER SIDE OF THE CAR. DESPITE ANY EFFORT ON MY PART, THERE WERE ONLY TWO WAYS OUT OF THE CAR: CLIMBING OVER THE SEATS TO ANOTHER DOOR OR BY HAVING MY WIFE MANUALLY UNLOCK THE LEFT FRONT DOOR WITH HER KEY WHILE OUTSIDE OF THE VEHICLE AND THE WHILE SHE HELD THE KEY IN THE UNLOCK POSITION, SHE HAD TO OPEN THE DOOR. AS SOON AS SHE RELEASED HER GRIP ON THE KEY, THE DOOR WOULD LOCK AGAIN. OBVIOUSLY THIS WAS A MAJOR SAFETY RISK & I WOULD NOT HAVE BROUGHT THIS TO YOUR ATTENTION HAD IT NOT HAPPENED TWICE TO THE SAME CAR. I CAN SEE THE POTENTIAL FOR A FAULTY PART AND WOULD HATE TO SEE SOMEONE TRAPPED IN AN ACCIDENT. THANK YOU FOR YOUR TIME. MY CONTACT INFORMATION APPEARS BELOW. LEE TRAXLER 103 LOVERS LANE MORGANTON, NC 28655 828-437-1360 *LA
Engine and engine cooling, Apr 16, 2004
CRANKSHAFT SENSOR FAILED. AS A RESULT, ENGINE STALLED. A RECALL WAS ISSUED. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
Air bags, Apr 5, 2004, crash
A LADY PULLED OUT IN FRONT OF ME TO MAKE A LEFT TURN, I TRIED TO STOP, BUT I COULDN'T, I HIT HER @ 20 MPH, MY FRONT BUMPER, DEAD CENTER INTO HER LEFT FRONT TIRE. MY AIR BAGS DIDN'T DEPLOY AND HERS DID. I HAVE A 2001 KIA OPTIMA LX. MY FEAR IS, IF THE CAR IS FIXABLE,WILL THE BAGS WORK OR WILL THEY COME OUT ON ME SOMETIME GOING DOWN THE ROAD. I'VE TALKED TO THE DEALER AND HAVE GOTTEN DIFFERENT STORIES ON WHERE THE SENSORS ARE LOCATED. NOW THE SAY THE AIR BAG SENSORS ARE RIGHT IN FRONT OF THE TRANSMISSION AND I DIDN'T GET HIT HARD ENOUGH TO MAKE THEM DEPLOY. WAS TOLD THAT IF I HAD BEEN GOING 80 MPH THEY WOULD HAVE DEPLOYED! *JB
Engine and engine cooling, Mar 22, 2004
VEHICLE STALLED 3 TIMES WHILE DRIVING ON THE HIGHWAY. VEHICLE WAS TOWED TO A DEALERSHIP, WHO INDICATED THAT THE TIMING BELT DISINTEGRATED, AND THE CRANKSHAFT POSITION SENSOR WENT OUT. THE RECALL 03V067000 WA SISSUED ON THE CRANKSHAFT POSITION SENSOR BUT ONLY FOR VEHICLES EQUIPPED WITH A V6 ENGINE. THIS VEHICLE WAS EQUIPPED WITH A V4 ENGINE. *AK
Engine and engine cooling, Mar 12, 2004
DRIVING AND CAR JUST DIED WITH NO WARNING. ENGINE IS SEIZED. GETTING A HARD TIME FROM DEALERSHIP BECAUSE WE DO OUR OWN MAINTENANCE. REP APPROVED TAKING THE ENGINE APART TO SEE WHAT PROBLEM IS. DEALER PUT 3 GALLONS OF ANTIFREEZE IN AND IT WENT RIGHT OUT THE TAILPIPE. OIL CHANGED AND ANTIFREEZE CHECKED A WEEK BEFORE INCIDENT. WANT ME TO PAY $7 A DAY RENTAL AND PUT ME IN A RIO OR SPECTRA. I HAVE AN OPTIMA NOT A LITTLE MATCHBOX CAR. I SHOULD GET A FREE LOANER BECAUSE TOP TECH IS OUT AND IT MAY TAKE LONGER THAN USUAL TO DO REPAIRS, IF REPAIRS ARE APPROVED.*JB
Power train, Electrical system, Visibility, Air bags, Latches/locks/linkages, Feb 19, 2004
THE AIR BAG LIGHT CAME ON. THE CONSUMER WAS INFORMED IF THE AIR BAG LIGHT WAS ON THE AIR BAGS WOULD NOT DEPLOY. THE CONSUMER EXPERIENCED PROBLEMS WITH THE ELECTRICAL SYSTEM AND THE TRANSMISSION DROPPING TO 3RD GEAR WHEN GOING UPHILL. *LA THE DEALERSHIP TOLD THE CONSUMER THE VEHICLE WAS NOT POWERFUL ENOUGH TO DRIVE UPHILL IN 3RD GEAR. THE DRIVER DOOR LOCK ACTUATOR AND LATCH WAS REPLACED BECAUSE THE DOOR WOULD NOT LOCK OR REMAIN UNLOCK, THE WINDOW MADE A CHATTERING NOISE WHEN IT WAS ROLLED DOWN. *JB
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Visibility, Equipment, Jan 15, 2004
I DON'T HAVE THE EXACT DATES OF THESE REPAIRS AS MY CAR IS AT THE DEALERSHIP RIGHT NOW BEING LOOKED AT AGAIN AND I AM GOING TO GET A HISTORY WHEN I PICK UP THE CAR, HERE ARE THE ISSUES I'VE HAD SINCE SPRING/SUMMER OF LAST YEAR. WE HAVE LOST TIME, MONEY, WAGES AND POSSIBLE EMPLOYMENT BECAUSE OF THESE PROBLEMS! 1. AIR CONDITIONER SEEMED VERY COOL, BUT NOT COLD. CHECKED TWO OR THREE TIMES, EACH TIME SERVICE DEPT. SAID IT WAS FINE. 2. CAR DIED AND WOULDN'T RESTART WITHOUT A JUMP 3 TIMES. CALLED TOWING TWICE. SERVICE COULD NOT "RECREATE THE PROBLEM." THIRD TIME THEY REPLACED THE BATTERY. SEEMED TO FIX THE PROBLEM TEMPORARILY. FOURTH TIME (CURRENT) CAR HAD TO HAVE THE HEADLIGHTS REPLACED ONCE A MONTH, WINDSHIELD WIPERS, DOOR LOCKS LOCKED AND UNLOCKED ON THEIR OWN WHEN ENTERING/EXITING THE CAR, WINDOWS ROLLED UP/DOWN SLOWLY, BLOWER ON AIR WENT UP AND DOWN WITH ENGINE SPEED, LIGHTS BEHIND CONSOLE GO OUT AND COME ON PERIODICALLY, CLOCK LOSES TIME, HEADLIGHTS DIM WHEN USING POWER, RADIO FLASHES ON AND OFF. TODAY TOTAL SYSTEM FAILURE, ALL ELECTRICAL SYSTEMS WENT DOWN WHILE DRIVING. TOWED CAR TO DEALERSHIP. HAVE TO PAY OUT OF POCKET RENTAL FEES. STILL WAITING ON RESULT. 3. LOUD RATTLING UNDERNEATH CAR PERIODICALLY. 4. WHISTLING IN ENGINE 5. CHECK ENGINE LIGHT CAME ON PERIODICALLY. 6. ANTENNA BROKE AND THEN FELL OFF. 7. SUSPENSION VERY POOR. 8. WHEN PURCHASING CAR, DEALER STATED AIR BAG RECALL HAD BEEN FIXED ON CAR. WHEN LOOKING ONLINE, FOUND ANOTHER RECALL ON THE CAR, CALLED KIA AND THEY SAID THE AIR BAG REPAIR HAD NOT BEEN MADE. I'VE ONLY HAD THIS CAR FOR 17 MONTHS AND HAVE HAD NOTHING BUT PROBLEMS. CURRENTLY IN CONTACT WITH LEMON LAW LAYWERS IN INDIANA TO GET TOTAL REFUND FOR CAR. ONLY PHYSICAL PROBLEM RIGHT DRIVER DOOR PANEL FROM SMALL NON-FAULT ACCIDENT, NO INTERNAL DAMAGE.
Air bags, Dec 30, 2003, crash
WHILE TURNING LEFT AT 3 MPH THE VEHICLE WAS INVOLVED IN A SIDE IMPACT COLLISION. NONE OF THE FOUR AIR BAG DEPLOYED. THE AIR BAG LIGHT WAS NOT ILLUMINATED TO PROVIDE ANY WARNING THAT THERE WAS A PROBLEM WITH THE AIR BAG. THE DRIVER WAS WEARING THE SEAT BELT. THERE IS A POLICE REPORT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Air bags, Seat belts, Equipment, Dec 30, 2003, crash
MY SON HIT A TRUCK FROM BEHIND AT 35MPH. HE WAS DRIVING MY 2001 KIA OPTIMA. THE SEATBELTS DID NOT LOCK WHEN HIT THE BRAKES AND THE AIR BAGS DID NOT DEPLOY. MY SON (DRIVER) HIT THE STEERING WHEEL AND WINDSHIELD. THE PASSENGER IN OUR CAR HIT THE WINDSHIELD. THE POLICE REPORT INDICATES THIS INFORMATION AND I HAVE PICTURES OF THE INSIDE AND OUTSIDE OF THE CAR. THE CAR WAS TOTALED.
Latches/locks/linkages, Nov 6, 2003
POWER LOCK DOORS FAILED, WHICH TWICE TRAPPED THE DRIVER INSIDE THE VEHICLE. I HAD TO RESTART THE ENGINE, ROLLED DOWN THE POWER WINDOW, TAKE THE KEY OUT AND INSERT IT INTO THE DOOR TO UNLOCK IT FROM THE OUTSIDE. *AK
Fuel system, Other, Oct 23, 2003
APPROXIMATELY 2 MONTHS AFTER PURCHASE, THE GAS DIAL WOULD NOT READ FULL EVEN WHEN THE TANK WAS PRACTICALLY OVERFLOWING WITH GAS. TOOK TO THE DEALER WHO SAID IT WAS CORRECTED, HOWEVER PERIODICALLY IT WILL GO WEEKS WITHOUT READING A FULL TANK OF GAS. CHECK ENGINE LIGHT COMES ON PERIODICALLY FOR NO REASON AT ALL. HAVE TAKEN TO DEALER WHO CAN NOT FIND PROBLEM IN SYSTEM. *LA
Engine and engine cooling, Oct 12, 2003
2001 KIA OPTIMA WITH APPROXIMATELY 57,000 MILES HAS BEEN REGULARLY MAINTAINED AT KIA DEALERSHIPS SINCE PURCHASE IN JAN 2002 (USED). SINCE JUNE 2003 CAR HAS BEEN SERVICED FOR NUMEROUS RECALL ITEMS. CAR HAS HAD MANY PROBLEMS SINCE THEN. CHECK ENGINE LIGHT CONTINUOUSLY LIT. ENGINE SURGES OR STALLS WHILE DRIVING. CAR FAILS TO ACCELERATE THEN SURGES. VERY HIGH RPM WITH NO ACCELERATION. ENGINE COILS MISFIRE. DIFFICULTY STARTING OCCASIONALLY. AFTER FOUR MONTHS OF FREQUENT TRIPS TO DEALERSHIP SERVICE AREA, (JUNE-OCTOBER 2003) SERVICE MANAGER CALLS TO TELL OWNER TO CONTACT INSURANCE COMPANY BECAUSE THERE IS SAND/SUGAR IN GAS TANK THAT HAS CAUSED ALL OF THESE PROBLEMS. THEY CLAIM THE CAR FALLS OUT OF WARRANTY BECAUSE OF THIS. CUSTOMER DISAGREES THAT SAND/SUGAR IS CAUSE BECAUSE PROBLEMS HAVE PERSISTED FOR FOUR MONTHS. CAR CURRENTLY IN SHOP FOR PAST 10 DAYS. DEALERSHIP SERVICE AREA WILL NOT DO ANY MORE WORK UNTIL INSURANCE PEOPLE COME. NEEDLESS TO SAY THE CUSTOMER IS NOT HAPPY. *LA
Vehicle speed control, Sep 30, 2003, crash
WHILE DRIVING ABOUT 55 MPH ON THE HIGHWAY AND WITHOUT WARNING CONSUMER'S VEHICLE SUDDENLY ACCELERATED UP TO 75 MPH OR MORE, RESULTING IN A COLLISION WITH ANOTHER VEHICLE. DRIVER SUSTAINED MINOR INJURIES, WAS NOT TRANSPORTED BY AMBULANCE NOR WAS THERE ANY FATALITY. *AK
Electrical system, Sep 15, 2003
PROBLEMS WITH BATTERY, ALTERNATOR AND ELECTRICAL SYSTEMS.*MR CONSUMER HAD NUMEROUS FAILURES AND REPAIRS AND THE RESULTS DIDN'T WORK. ONCE THE ELECTRICAL SYSTEM FAILED, THE CONSUMER WAS TRAPPED INSIDE THE VEHICLE FOR ONE AND A HALF HOURS BECAUSE THE DOORS LOCKS MALFUNCTIONED DUE TO THE ALTERNATOR SHUTTING DOWN. THE DOORS WOULDN'T UNLOCK. THE CONSUMER WOULD LIKE A REFUND. *PH *JB
Visibility, Aug 23, 2003
WINDSHIELD WIPERS DO NOT WORK IN SNOW MUST BE REPAIRED OFTER .WINDOWS REGULATORS NEED TO BE REPLACED HOWEVER DEALER THAT IS SUPPOSE TO FIX THESE PROBLEMS SEEMS TO BE UNABLE TO DO SO .KIA NEEDS TO FIND SOMEONE WHO WILL REPAIR THESE PROBLEMS . VEHICLE HAS BEEN PLACED IN SHOP 5 TIMES FOR THE SAME PROBLEM.*AK