2002 Kia Optima
Problems, recalls and owner-reported issues
Structure is the leading concern among 110 owner complaints filed for this model year. This is the 19th highest complaint count among 20 Optima model years with reports.
Of the 2002 reports, 16 involved a crash and 5 involved a fire. 12 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 12, 2004
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 04V180000 on NHTSA.gov
Electrical system, starter assemblyMar 4, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 03V067000 on NHTSA.gov
Representative owner complaints: latches/locks/linkages
12 reports, newest first. Show all
Electrical system, Latches/locks/linkages, Oct 27, 2014
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE ACTUATOR DOOR LOCKS FOR THE FRONT DRIVER AND PASSENGER DOORS FAILED. THE CONTACT STATED THAT THE WINDOW WAS USED IN ORDER TO ENTER THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE THE FRONT PASSENGER ACTUATOR WAS REPAIRED PREVIOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Structure, Latches/locks/linkages, Mar 14, 2014
FRONT DOOR FAILS TO UNLOCK AFTER MULTIPLE ATTEMPTS. DOOR MUST BE UNLOCKED WITH A KEY, USING THE POWER LOCKS OR MANUALLY FLIPPING THE DOOR LOCK DOESN'T DO IT, AND THE KEY ONLY UNLOCKS IT APPROXIMATELY 1 OUT OF EVERY 20 TRIES. THERE ARE MULTIPLE COMPLAINTS ABOUT THIS ONLINE, SEE FOR INSTANCE: HTTP://WWW.KIA-FORUMS.COM/1G-2G-2001-2006-MAGENTIS-OPTIMA/47179-2004-OPTIMA-DOOR-LOCK-FAULT.HTML. *TR
Latches/locks/linkages, May 28, 2013
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE DOOR WOULD NOT UNLOCK WITH THE KEY FOB OR MANUALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THE DOOR LOCK MOTOR WOULD HAVE TO BE REPLACED. AFTER THE REPAIR, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. *TR
Latches/locks/linkages, Jul 29, 2011
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THE FRONT DRIVERS SIDE DOOR WOULD NOT OPEN AFTER IT WAS LOCKED. THE DRIVER WAS FORCED TO ENTER AND EXIT THE VEHICLE BY CLIMBING OUT OF THE WINDOW. THE DEALER WAS NOTIFIED; HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGE WAS 43,000. ONCE THE DRIVER SIDE DOOR IS LOCKED IT CANNOT BE UNLOCKED FOR THE INSIDE OR USING A KEY FOR THE OUTSIDE. AFTER WORKING THE LOCK FOR SOMETIME IT MAY UNLOCK OR STAY LOCKED. WHAT WE DO NOW IS TO LEAVE THE CAR UNLOCKED WHICH IS NOT THE BEST IDEA. THE PROBLEM IS NOT GETTING INTO THE CAR BUT GETTING OUT. NO RECALL FROM KIA. UPDATED 10/26/2011 *LN *TR
Latches/locks/linkages, May 24, 2011
DOOR LOCKS WHEN USING THE DOOR HANDLE TO OPEN THE DOOR AFTER THE DOOR HAS BEEN UNLOCKED USING KEY OR KEYLESS ENTRY. SO FAR ONLY BEEN LOCKED OUT OF THE CAR, BUT CONCERNED I WILL BE LOCKED IN THE CAR AT SOME POINT. *TR
Latches/locks/linkages, Jan 11, 2011
TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVERS SIDE DOOR WOULD NOT UNLOCK BY USING THE KEY OR THE KEYLESS ENTRY. THE CONTACT HAD TO ENTERED THROUGH THE PASSENGER SIDE OF THE VEHICLE IN ORDER TO UNLOCK THE DRIVERS SIDE DOOR. THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS CONCERNED ABOUT THE SAFETY ISSUE BEING ADDRESSED BY THE MANUFACTURER. THE FAILURE MILEAGE WAS 25,000.
Latches/locks/linkages, Jan 12, 2009
WAS LOCKED INSIDE VEHICLE. AFTER CLIMBING OUT WINDOW, WAS LOCKED OUT OF VEHICLE. THE DOOR WOULD UNLOCK WITH KEY THEN WHEN YOU TRY TO OPEN DOOR IT LOCKS ITSELF, EVEN WITH KEY STILL IN DOOR. WHEN THIS HAPPENS DOOR WILL NOT OPEN BY MANUAL USE OF LOCKS EITHER. *TR
Fuel system, Gasoline, Power train, Air bags, Latches/locks/linkages, Equipment, Dec 10, 2008
AFTER BUYING THE VEHICLE FROM A AUTO DEALER BETWEEN JULY 2 AND JULY 5 ...THIS VEHICLE BEGAN TO HAVE MANY PROBLEMS LIKE THE AUDIO RECEIVER SWITCH FROM RADIO TO CD ON ITS OWN,DOORS LOCKS ON ITS OWN,RPM RUNS TO 4000 GOING 45MPH AFTER A HARD JERK ASSUMING THAT I WAS HIT BY A OTHER CAR THE AIR BAG LIGHT CAME ON AFTER THAT 2 HARD JERKS WHILE DRIVING,,(THEY DIDN'T EVEN DEPLOYED) CAN NOT PUMP GAS DUE TO FUEL KEEPS OVER FLOWING WHEN ITS BARELY EMPTY ....ITS BEEN A LIVING ?!@#$% AND I'M STILL PAYING FOR THE CAR....IS IT LEGAL FOR A DEALERSHIP TO SELL A VEHICLE LIKE THIS. *TR
Latches/locks/linkages, May 26, 2008
2002 KIA OPTIMA -- WHEN YOU UNLOCK THE DOORS EITHER MANUALLY OR WITH KEY FOB AND ATTEMPT TO OPEN THE PASSENGER DOOR IT IMMEDIATELY LOCKS AND DOES NOT ALLOW YOU TO EXIT THE VEHICLE. IT LOCKS FROM BOTH INSIDE AND OUTSIDE OF VEHICLE. THIS INCIDENT HAS HAPPENED IN THE PAST APPROXIMATELY APRIL OF 2005 WITH THE EXCEPTION IT ALSO INCLUDED THE DRIVER DOOR. HAD TO CLIMB OUT OF WINDOW TO EXIT VEHICLE. *TR
Latches/locks/linkages, Feb 21, 2008
VEHICLE MODEL IS A 2002 KIA OPTIMA 4 DOOR SEDAN AND THE PROBLEM IS REGARDING THE DRIVERS LEFT DOOR. THE POWER LOCK DOOR LOCKS ON ITS OWN IMMEDIATELY AFTER THE DOOR IS UNLOCKED USING THE KEY. THE CAR WAS THEN TAKEN TO GET FIXED ON 05/24/02 AND OUNCE AGAIN THE SAME PROBLEM OCCURRED ON 01/31/08 THIS TIME COST TO FIX IS $233.16. AFTER THE PROBLEM WAS FIXED, AGAIN FOR THE SECOND TIME, IT OCCURRED AGAIN. I AM CONVINCED THAT THE POWER LOCKS ARE DEFECT AND DANGEROUS RISKS OF BECOMING TRAPPED IN THE CAR. THIS PROBLEM IS UNPREDICTABLE IT OCCURS FROM TIME TO TIME, AND I AM UNABLE TO GET IT FIXED BECAUSE MECHANICS MUST BE THERE TO SEE WHEN PROBLEM OCCURS IN ORDER TO TRY TO FIX IT. IN ONE INCIDENT I WAS FORCED TO CRAWL OUT OF THE WINDOW IN ORDER TO GET OUT OF THE CAR. I FEEL VERY INSECURE AND UNSAFE IN CASE OF AN ACCIDENT IF I WOULD BE ABLE TO GET OUT OF THE CAR WHICH IS WHY I AM RAISING AWARENESS OF THIS PROBLEM. *TR
Latches/locks/linkages, Jun 6, 2005
DT: CONTACT STATES WHEN HE LOCKS THE DOORS ON VEHICLE IT WILL NOT UNLOCK.*AK
Latches/locks/linkages, Jun 1, 2004
DOOR LOCKS DON'T LOCK CONSISTENTLY. THE MASTER SWITCH HAS BEEN REPLACED TWICE.*AK