2003 Kia Optima
Problems, recalls and owner-reported issues
Latches/locks/linkages is the leading concern among 144 owner complaints filed for this model year. This is the 16th highest complaint count among 20 Optima model years with reports.
Of the 2003 reports, 8 involved a crash and 2 involved a fire. 6 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 12, 2004
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 04V180000 on NHTSA.gov
Representative owner complaints: air bags
17 reports, newest first. Show all
Air bags, Sep 9, 2016
AIR BAG LIGHT ON DASHBOARD IS LITE, FOR NO REASON! THE CAR HAS LESS THAN 48K MILES , NEVER BEEN IN AN ACCIDENT NOR HIT ANYTHING . I AM AFRAID TO DRIVE THE VEHICLE NOR HAVE ANYONE IN THE CAR WITH ME BECAUSE , IT'S WITHOUT AN AIRBAG THERE IS NO PROTECTION
Electrical system, Air bags, Engine, Nov 9, 2015
AFTER 60,000 MILES, WHILE DRIVING OR WITH THE ENGINE RUNNING, THE ENGINE LIGHT CAME ON AND STAYED ON. THIS HAS BEEN REPAIRED THREE TIMES BY REPLACING A MAIN FUSE. EACH TIME IT HAS BEEN REPAIRED, THE PROBLEM HAS REOCCURRED. IN CONNECTION WITH THIS PROBLEM, THE DOOR WILL LOCK AFTER THE DRIVER EXITS THE CAR. SOMETIMES, THE KEYS HAVE BEEN LOCKED IN THE CAR.
Air bags, Jun 10, 2015
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Air bags, May 29, 2015
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP FLASHED AND REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 11/04/15*LJ UPDATED 2/1/2016*JS UPDATED 04/05/16.*JB
Electrical system, Air bags, Oct 16, 2014
THE ENGINE LIGHT CAME ON. THE DOORS WOULD LOCK WITHOUT ANY PROMPTS. THE HORN WOULD HONK WHILE PARKED IN THE GARAGE. THE CAR WAS CHECKED OUT ON THE COMPUTER AND THE DRIVER'S AIR BAG NEEDS REPLACED AND THERE IS AN ELECTRICAL PROBLEM. *TR
Air bags, Structure, Aug 6, 2014
TL* THE CONTACT OWNS A 2004 KIA OPTIMA. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR FAILED TO UNLOCK. THE CONTACT STATED THAT IN ORDER TO GET INSIDE THE VEHICLE, HE HAD TO CLIMB OVER TO THE DRIVER SIDE. THE CONTACT ALSO STATED THAT THE "AIR BAG" WARNING LIGHT WAS ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC AND THE MECHANIC WAS UNABLE TO LOCATE A SOLUTION TO THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE APPROXIMATE FAILURE MILEAGE WAS 85,000.
Air bags, Latches/locks/linkages, Mar 26, 2012
DRIVERS SIDE DOOR LOCK LOCKS UNATTENDED, TRAPS DRIVER INSIDE CAR. CAN NOT OPEN WITH KEY OR SWITCH. SAFETY ISSUE. ALSO; AIR BAG SENSOR LIGHT ACTIVATED FOR THE SECOND TIME, HAS TO BE A DEFECT. *TR
Air bags, Jan 22, 2009
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE AIR BAG INDICATORS REMAINED ILLUMINATED IN HER VEHICLE. THE DEALER PERFORMED A DIAGNOSTIC, BUT NO CODES APPEARED. THE DEALER RESET THE COMPUTER AND THE INDICATORS REMAINED DIM FOR A FEW DAYS; HOWEVER, THEY WOULD EVENTUALLY ILLUMINATE AGAIN. THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE FAILURE MILEAGE WAS 70,000.
Air bags, Dec 4, 2008
2003 KIA OPTIMA HAS A PROBLEM WITH THE AIR BAG INDICATOR LIGHT STAYING ON. CONSUMER STATES THAT THE VEHICLE HAS BEEN SERVICE FOR THIS ISSUE BUT IT KEEPS RECURRING. *NJ
Air bags, Apr 16, 2007, crash
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. WHILE DRIVING APPROXIMATELY 30 MPH THE VEHICLE WAS STRUCK FROM THE DRIVER'S SIDE. THE VEHICLE CRASHED INTO A WOODEN FENCE AND ROLLED OVER THREE TIMES. THE DRIVER WAS INJURED BECAUSE THE AIR BAG FAILED TO DEPLOY. THE FIRE AND POLICE DEPARTMENTS ARRIVED AT THE SCENE AND FILED A FULL REPORT. THE CRASH OCCURRED IN DRY CONDITIONS. THE CONTACT CALLED THE MANUFACTURER ABOUT THE AIR BAG FAILURE, AND WAS TOLD THAT THE SIDE IMPACT WAS NOT STRONG ENOUGH TO DEPLOY THE AIR BAGS. THE CURRENT AND FAILURE MILEAGES WERE 84,000.*AK THE CONSUMER HAS PROVIDED MULTIPLE PICTURES OF THE ACCIDENT. UPDATE 05/10/07*TR
Air bags, Oct 4, 2006
2003 OPTIMA AIR BAG DEPLOYED WHEN SWERVING TO AVOID A MANHOLE. *TS WHEN THE VEHICLE WAS PLACED ON A DIAGNOSTIC MACHINE IT REGISTERED THAT THERE HAD BEEN A COLLISION. THE MANUFACTURER SENT A DISTRICT PARTS AND SERVICE MANAGER TO INSPECT THE VEHICLE. THE MANAGER CONCLUDED THAT THE DRIVER'S SIDE IMPACT AIR BAG PROPERLY DEPLOYED IN THE INCIDENT EXPERIENCED BY THE CONSUMER. *NM
Air bags, Jul 7, 2006, crash
DT*: THE CONTACT STATED, WHILE TRAVELING THROUGH AN INTERSECTION AT 25 MPH., THE VEHICLE WAS STRUCK ON THE DRIVER'S FRONT DOOR BY A POLICE VEHICLE RUNNING A RED LIGHT, WITHOUT THE EMERGENCY LIGHTS ON. BOTH FRONTAL AND SIDE AIRBAGS FAILED TO DEPLOY. INJURIES WERE INCURRED IN THE COLLISION. A POLICE REPORT WAS FILED AND PICTURES WERE TAKEN AT THE SCENE. THE AIRBAG SENSOR LIGHT WAS REPLACED BY A SERVICE DEALER, APPROXIMATELY ONE-YEAR PRIOR TO THE ACCIDENT.
Air bags, Aug 11, 2005
DT: THE CALLER STATED THAT AIR BAG LIGHT WAS ON ALL THE TIME. DEALER CLAIMED THAT THE DRIVER'S SIDE AIRBAG WAS DEFECTIVE, AND DID NOT HAVE THE PART TO FIX IT. MANUFACTURER SAID DID NOT HAVE THE PART ANYWHERE. *AK
Air bags, Jul 9, 2005, crash
I WAS INVOLVED IN AN ACCIDENT WHERE THE FRONT AND SIDE AIRBAGS FAILED TO DEPLOY. MY CAR WAS A 2003 KIA OPTIMA. THE SITE OF IMPACT WAS ON THE LEFT FRONT END BUT SUBSTAINED MAJOR DAMAGE TO THE ENTIRE FRONT OF THE VEHICLE. I HAVE SEVERAL PHOTO'S OF THE CAR, WHICH WAS TOTALED BY MY INSURANCE ADJUSTER. MY CONCERN IS IF THERE IS A DEFECT WITH THIS CAR REGARDING THE AIRBAGS. A CLOSE MALE FRIEND, WHO WAS A MECHANICAL ENGINEER FOR CHYSLER, COULD NOT EXPLAIN/UNDERSTAND WHY THE AIRBAGS FAILED. PLEASE HELP ME GET TO THE BOTTOM IS THIS MATTER.
Air bags, Oct 4, 2004
AIR BAG LIGHT IS ON. DEALER ORDERED THE PART. HOWEVER, THEY HAVE BEEN UNABLE TO OBTAIN THE PART, THIS MAKES DRIVER'S SIDE AIR BAG INOPERABLE. *AK
Air bags, Jul 15, 2004, crash
THE CONSUMER REAR ENDED ANOTHER VEHICLE. THE CONSUMER WAS WEARING HIS SEAT BELT, HOWEVER THE AIR BAGS DID NOT DEPLOY. THE DEALER CLAIMED THAT THE COLLISION WAS UNDER THE TRUCK'S BUMPER. THE CONSUMER'S VEHICLE WAS TOTALED. THE CONSUMER SUFFERED SHOULDER AND HEAD INJURIES IN THE COLLISION. *JB
Air bags, Feb 24, 2003, crash
THE AIR BAG SENSOR WAS DEFECTIVE.*AK *JB