2003 Kia Optima
Problems, recalls and owner-reported issues
Latches/locks/linkages is the leading concern among 144 owner complaints filed for this model year. This is the 16th highest complaint count among 20 Optima model years with reports.
Of the 2003 reports, 8 involved a crash and 2 involved a fire. 6 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 12, 2004
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 04V180000 on NHTSA.gov
Representative owner complaints: fuel system
9 reports, newest first. Show all
Fuel system, Gasoline, Latches/locks/linkages, Oct 19, 2016
MY MAIN ISSUE IS THE DOOR LOCK ON THE DRIVERS SIDE. I CAN NOT OPEN MY DRIVERS SIDE DOOR FROM INSIDE OR OUTSIDE THE VEHICLE. THIS IS A MAJOR ISSUE AND THE PROBLEM HAS BEEN ALL OVER THE INTERNET FOR YEARS. EVERYONE THAT I KNOW THAT HAS A 2003 AND 2004 KIA OPTIMA HAS THE SAME PROBLEM. I BET EVERY VEHICLE KIA SOLD FOR THESE YEARS HAS THIS PROBLEM. MY OTHER ISSUE IS I AM UNABLE TO FILL MY FUEL TANK AS I NORMALLY COULD DO. I HAVE TO TRICKLE THE FUEL IN THE TANK BECAUSE IF I PUMP IT TOO FAST THE PUMP WILL CUT OFF. I'VE EVEN HAD THE FUEL SPILL OUT OF THE TANK BEFORE THE TANK WAS EVEN FULL (IT WAS AT ABOUT 3/4 FULL). PLEASE DEMAND THAT KIA RECALL THESE PROBLEMS. I CAN'T BELIEVE IT'S TAKING THIS LONG FOR THIS RECALL TO BE ISSUED. I JUST FOUND OUT ABOUT THIS FORM AND THAT IS WHY I HAVE TAKEN SO LONG TO PROCESS THIS FORM. THANKS AND I HOPE THAT YOU CAN HELP ASAP. [XXX] PS. AS OF TODAY MY VEHICLE HAS APPROXIMATELY 53,000 MILES. I'VE DRIVEN IT IN ONE WINTER SO FAR (LAST WINTER) AND IT STARTED HAVING THE DOOR LOCK PROBLEM AT AROUND 33,000. THE FUEL ISSUE STARTED AROUND 2 YEARS AGO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Electrical system, Latches/locks/linkages, Dec 26, 2013
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVERS SIDE DOOR LOCKED AND SHE WAS UNABLE TO UNLOCK IT MANUALLY OR BY USING THE KEY FOB. SHE WAS FORCED TO CLIMB INTO THE BACK SEAT IN ORDER TO EXIT THE VEHICLE. WHEN THE FAILURE RECENTLY RECURRED ALL OF THE DOORS FAILED TO UNLOCK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE TECHNICIAN REPLACED THE LOCKS; HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 90,000. UPDATED 2/11/14*CN THE CONSUMER STATED THE TRUNK AND IGNITION WOULD NOT UNLOCK. THE IGNITION AND TRUNK LOCK WAS REPLACED. ALSO, THE ALTERNATOR, FUEL TANK SENSOR AND TIMING BELT WERE REPLACED. THE HIGH BEAM LIGHTS WOULD COME ON, WHEN SHE MADE TURNS.
Fuel system, Other, Latches/locks/linkages, Jun 27, 2010
HAVE 2003 KIA OPTIMA. CAR STOPS WHILE RUNNING.LOOKS INTO GOOGLE. IS COMMON PROBLEM. CAMSHAFT POSITION SENSOR. ALSO LOCKS ON THE DRIVER SIDE NOT WORKING ,LOCKS SELF INSIDE THE CAR. *TR
Fuel system, Other, Jul 16, 2009
EXCESSIVE CHECK ENGINE ON.....ALL TESTS WERE DONE ON FUEL SYSTEM AND EVERYTHING WAS DIAGNOSED AS FUNCTIONING. *TR
Fuel system, Gasoline, Electrical system, Jun 5, 2008
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE CANISTER CLOSE VALVE FAILED, WHICH CAUSED THE FUEL GAUGE TO DISPLAY INACCURATE READINGS. THE CHECK ENGINE LIGHT ILLUMINATED AND THE DEALER STATED THAT A VAPOR HOSE ATTACHED TO THE FUEL CANISTER CRACKED. THE DEALER REPLACED THE CANISTER CLOSE VALVE AND LEVER FENDER. THE REPAIR COSTS TOTALED $104; HOWEVER, THE REPAIRS DID NOT CORRECT THE FAILURE. THE DEALER IS NOW SUGGESTING THAT THE CLUSTER PANEL WILL NEED TO BE REPLACED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V180000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) AND WOULD NOT ASSIST. THE FAILURE MILEAGE WAS 58,671. UPDATED 07/29/08 *BF THE CONSUMER STATED WHILE FILLING THE GAS TANK, THE PUMP CLICKED, BUT THAT GAS GAUGE ONLY SHOWED 1/2 TANK OF GAS. UPDATED 08/05/08
Fuel system, Gasoline, Power train, Sep 19, 2007
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. WHILE DRIVING 35 MPH, THE VEHICLE DECELERATED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT STATED THAT THE GAS MILEAGE WAS POOR AS WELL. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE AIR FILTER AND OIL WERE REPLACED, HOWEVER, THE FAILURE REMAINED. THE CURRENT MILEAGE WAS 82,591 AND FAILURE MILEAGE WAS 82,002. UPDATED 12-12-07. *KB UPDATED
Fuel system, Gasoline, Vehicle speed control, Aug 16, 2006
IT TOOK 3-4 ATTEMPTS TO GET THE CONSUMER'S 2003 KIA OPTIMA TO START AND THE CONSUMER ALSO HAD TO PUMP THE GAS PEDAL. WHILE DRIVING 45 MPH THE VEHICLE ACCELERATED SUDDENLY WITHOUT WARNING. *KB WHILE ATTEMPTING TO ACCELERATE FROM A STOP THE VEHICLE WOULD NOT MOVE. THE CONSUMER HAD TO PUMP THE GAS PEDAL IN ORDER TO GET THE VEHICLE TO ACCELERATE. THESE PROBLEMS HAVE BEEN PRESENT SINCE THE DATE OF PURCHASE. *NM
Fuel system, Gasoline, Jul 24, 2006
DT*: THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER THEORIZED THAT THE CAUSE OF THE PROBLEM WAS A FAULTY FUEL INJECTION SYSTEM. THERE HAVE BEEN NO REPAIRS MADE.
Fuel system, Gasoline, Electrical system, Nov 22, 2004
THE ENGINE AND AIR BAG LIGHT WOULD COME ON AND OFF. THE ENGINE OXYGEN SENSORS WERE REPLACED. THE AIR BAG ASSEMBLY NEEDED TO BE REPLACED. THERE WERE SEVERAL OTHER PROBLEMS. *BF THE CONSUMER WAS INFORMED THAT HE GAS CAP WAS THE PROBLEM. REFERENCE TO RECALL#04V180000. THE DOOR ON THE DRIVER SIDE CONTINUED TO LOCK WITHOUT PRESSING. *SC