2013 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,383 owner complaints filed for this model year. This is the highest complaint count among 20 Optima model years with reports.
Of the 2013 reports, 48 involved a crash and 114 involved a fire. 36 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 25, 2023
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Campaign 23V652000 on NHTSA.gov
Structure, body, roof and pillarsAug 1, 2022
Kia America, Inc. (Kia) is recalling certain 2012-2013 Optima vehicles. The right and left headliner plates may not be secured properly, which can result in the plates detaching in the event of a side curtain air bag deployment.
A plate that detaches during a crash may strike an occupant, increasing their risk of injury.
Dealers will secure the headliner plates, free of charge. Owner notification letters were mailed September 26, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC245.
Campaign 22V560000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 17, 2022
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.
A fuel leak can increase the risk of a fire.
Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed August 2, 2022. Owners may contact Kia customer service at 1-800-33-4542. Kia's number for this recall is SC228.
Campaign 22V093000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideMay 10, 2021
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
An electrical short in the HECU increases the risk of a fire while parked or driving.
Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.
Campaign 21V331000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideAug 27, 2020
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.
Campaign 20V519000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 21, 2020
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.
If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.
Kia will notify Owners, and Dealers will inspect the low pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, a heat-protective tape will be installed. Repairs will be performed free of charge. The recall began June 12, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC187.
Campaign 20V100000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, air bag/restraint control moduleJun 1, 2018
Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.
If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Kia will notify owners. For model year 2011 Sedona vehicles, Kia will instruct dealers to verify the ACU part number and, if necessary, install an extension wire harness kit between the ACU Connector and the Vehicle Harness Connector. For all other affected vehicles, Kia will instruct dealers to install the extension wire harness kit. The recall began September 28, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC165.
Campaign 18V363000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2017
Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Bearing wear may result in the engine seizing, increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.
Campaign 17V224000 on NHTSA.gov
Representative owner complaints
1,383 reports, newest first.
Electrical system, Engine, Fuel/propulsion system, Oct 7, 2022
Started with oil light flashing, then the other lights came on. Started losing speed, then lost all power to the engine, will not start back up with the engine, when trying to start it, the engine started smoking.
Exterior lighting, Sep 30, 2022
The chrome finish on the inside of the low beam headlight reflectors has disintegrated resulting in very dim, almost unusable headlight light output. The dealer states while the manufacturer has a tsp and warranty extension (WTY014) on Korean-built Optimas for this MY it does not apply to American-built Optimas - despite the headlight being manufactured in Korea on the US models and it having the exact same issue. This extension should apply to all Optimas during the covered MY that have this issue.
Electrical system, Exterior lighting, Sep 29, 2022
The vehicle’s headlights have been extremely dimmed for years and my wife has just “dealt with it”. We’ve had all the bulbs replaced and the issue persisted. Given recent medical conditions paired with this technical oversight, this could lead to severe injury or death if not resolved. Let me also add that the headlights no longer turn on as of this morning and Kia refuses to acknowledge or claim responsibility for this because “the issue stems from identical vehicles manufactured in South Korea and not Georgia” … even though the symptoms very identically line up to TSB Number: WTY014.
Engine, Sep 15, 2022
While driving the vehicle on a two lane highway passing an eighteen wheeler the car engine suddenly died prior to overtaking the truck. Very difficult and dangerous especially since the vehicle behind me followed to overtake the truck at the same time. This was a very uncomfortable situation especially since in the meantime there was oncoming traffic heading in the opposite direction that had to drive on the grass shoulder to avoid a head on collision since I had difficulty merging into now much faster moving traffic that was stacked up behind the eighteen wheeler. The reason the engine died was because it locked up due to oil starvation due to a known manufacturing defect that should have been covered by the extended warranty that was put into place from to a lawsuit from NHTSA. The vehicle is a 2013 Kia Optima with 60k miles. According to Kia customer care the extended warranty wont be honored because the car was previously involved in a collision to the right rear corner of the vehicle that took place years ago and thousands of miles ago. The service advisor advised against purchasing a used engine because they are all bad and they will all fail sooner or later and wants almost $6000 to replace the engine.
Steering, Sep 15, 2022
While driving there is a ticking noise in the steering column and it shakes badly. This make the vehicle a little less controllable. 2 Certified mechanics believes it is a coupling or possibly a U joint at the bottom of the steering column. No lights on the dash and no other symptoms prior to this issue. This problem started about on or about September 5th 2022. This occurs during low and higher speeds of travel.
Other or unspecified, Sep 10, 2022
Paint failed. After less than 3 years of having the vehicle the painted was peeling off. Took it to the dealership and they said they had no complaints that I would have to fix it. It became worse with a large section on the hood of the car and on the drive rear door above the window. After a hail storm I had chips all over. Had to get parts of the car repaired. The insurance did not cover all of the paint. The roof was still covered in chips. A few days ago on 9/6/2022 I went out to my car and noticed a very large portion of paint missing from my trunk lid. It was dark so after work in the morning I looked at it before going home. Almost the entire trunk lids paint was peeling off the car. I verified with the company that didn’t the paint job after the hail storm and they did not paint the trunk. I looked over the car and found a few more chips.
Other or unspecified, Sep 10, 2022
UNKNOWN
Electrical system, Engine, Sep 10, 2022
I was driving on the highway, and knocking noise came out form the engine. The engine began to lose power, and I had to immediately to pull over the car. This car has a theta II engine, and had gone bad due excessive connecting rod bearing damage. I brought the car to a dealership, and confirmed this is the case. The engine only has 77k on it, and will need replacement. These engines are not safe, and should be replaced by dealerships.
Steering, Sep 9, 2022
I HAVE A CLICKING SOUND TURNING WHEEL LEFT AND TO THE RIGHT. WHEN GOING OVER BUMPS ON ROAD. AFTER GOING ON LINE FIND OTHER KIA ALSO HAVE THIS PROBLE WITH THE RUBBER COUPLER. AND IT STILL GOING ON.
Structure, Other or unspecified, Sep 9, 2022
Car is available. I have a 2013 Kia Optima SXL that has paint that is randomly chipping. Took it to service department and this is a common problem for this car and paint color. I have repair estimate totaling 2501.55 not including windshield that he says would need to replaced if it cracks during repair due to it having to be removed.
Engine, Sep 1, 2022
The car stops in middle of road and turns off if I go over 20 MPH. It's happened twice in the middle of highway and I've had to get towed home. The engine light is on and blinking and I hear knocking sounds. My boyfriend has a code reader and he said when he hooked code reader up to car it showed the exact same code as the other kia optimas engine problems. This needs to be a recall!!
Engine, Aug 31, 2022
I was driving my 2013 Kia Optima when all of a sudden, the car stalled while on a highway. Luckily I was able to pull to the side, narrowly missing a tractor-trailer. After it wouldn’t start, I had it towed to my mechanic. He then diagnosed it as a seized engine. I had it towed to my local Kia dealer, and it’s been sitting there for 4 months, and i was told it can take another 6 MORE MONTHS to get the engine replaced, AND they ‘may not cover the cost’. They are giving me the run-around. This is ridiculous. There’s even a recall on the engine. What should I do? Thank you D.H.
Structure, Aug 23, 2022
Paint delaminating and chipping, started on the front driver and passenger pillar. Also spots on the front hood near the bumper.
Steering, Aug 22, 2022
The contact owns a 2013 Kia Optima. The contact stated that while driving at various speeds, the steering wheel was shaking and making a clicking sound. While attempting to turn, the steering column felt like it was slipping or felt loosened. The failure increase was more evident while driving 50 MPH or more. The contact had not taken the vehicle to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 160,000
Engine, Aug 18, 2022
Driving our car om a road trip on a busy canyon highway ,check engine started blinking and car died. Was able to get off on the shoulder and contact a tow. Towed to local mechanic, engine was blown. Towed it to local KIA Dealership. Dealership had our car almost 4 months. KIA approved engine, it was finally replaced. Got car back and the next day check engine light came on and car shut down again. Towed to KIA dealership.
Engine, Aug 12, 2022
The contact owns a 2013 Kia Optima. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was towed to the contact's residence. The contact's boyfriend had retrieved an error code on the vehicle for engine failure. The local dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was 88,524.
Engine, Aug 12, 2022
The contact's son owns a 2013 Kia Optima. The contact stated while his son was driving approximately at 50 MPH and accelerating to highway speed, the vehicle shuddered, jerked and finally stalled. The check engine warning light was illuminated. The contact's son veered to the side of the road. The contact's son was able to restart the vehicle and drove to his residence. Additionally, the contact stated that there was an abnormal loud knocking sound coming from the engine. An unknown dealer was notified of the failure and informed the contact that the vehicle was experiencing bearing wear that could damage the engine and could cause the engine replacement. However, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 155,000.
Engine, Aug 4, 2022
I was driving my 2013 Kia Optima on the highway when all of a sudden the car stalled. I was nearly hit by a semi truck and several cars. I was finally able to coast to the shoulder of the road. I tried starting it and it would not. I had it towed to my mechanic and he diagnosed it as a ‘seized engine’, for no reason. I take good care of my car I change the oil every 3000 miles. Currently, I am trying to get it fixed through KIA, but they are giving me a hard time.
Electrical system, Exterior lighting, Aug 3, 2022
The issue is with the front turn signal harness. After, changing the right side turn signal bulb twice I brought my Kia to West Hills Kia in Bremerton, WA…The technician informed me that the front turn signal harness was not the correct harness for this type of vehicle. The service person at West Hills suggested that I contact Kia Corporation. I had emailed Vice President Mr. Shamit Choksey, Kia corporation for the above issue.
Structure, Jul 31, 2022
Pearl white paint chipping all over
Structure, Jul 28, 2022
My (pearl) white 2013 KIA Optima is peeling paint from its front hood and A-pillars. This has been happening since I first bought it in 2018. My car had 55K miles on it and has never been in an accident. I have taken it to the KIA dealership of Fishers with no success. THEY LIED TO ME! Each time, I was told that my car had been previously painted by someone else, and that business did a bad paint job. I have been to KIA of Fishers 3 different times about this concern. There are MANY, MANY sites and now several class action suites pending against KIA for this problem. I want my car repainted. https://m.facebook.com/DefectiveKiaPaint/photos/a.112101813622800/147796620053319/?type=3#
Structure, Jul 27, 2022
My paint has been peeling off over the years and it just really got bad to the point I could not take it any more. So I finally look to see if the was other vehicles within that year make and model had the same problems and this is why I am doing this.
Fuel/propulsion system, Jul 22, 2022
Driving on the highway of about 65 mph, a semitruck was moving into the shoulder. I accelerator to pass it. The car pulled forward, then all power was off. I coasted pass the truck heading for the shoulder also. The semi was stilling moving on the shoulder. The driver blowing the horn but there was nothing I could do. The semi was able to get back on the highway without crashing into us. An appt. has been made but the dealership says the part necessary to repair the recall service is unavailable. When the car died all service lights were on. After a 15 min. wait, I started it up and the check engine light was on and a slight smell of gasoline.
Air bags, Seat belts, Jul 21, 2022, crash
My son owned a Kia Optima built in June of 2013. He was in a motor vehicle accident where he was put in a pit maneuver and Then was T boned on the passengers side causing his body to lay across the front seats and died at the scene. His black box download showed that the seat belt pretensioner was off and both airbags in the front did not go off. I know there is a recall for optimas built before aug 31 of 2012. I believe there was an issue with this vehicle as well. I would hate for there to be anymore deaths or injuries with the later models of these vehicles. I do hope this is looked into further.
Chest clip, Buckle, Harness, Jul 20, 2022
Chest clips melted got all over car seat and my child