2013 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,383 owner complaints filed for this model year. This is the highest complaint count among 20 Optima model years with reports.
Of the 2013 reports, 48 involved a crash and 114 involved a fire. 36 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 25, 2023
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Campaign 23V652000 on NHTSA.gov
Structure, body, roof and pillarsAug 1, 2022
Kia America, Inc. (Kia) is recalling certain 2012-2013 Optima vehicles. The right and left headliner plates may not be secured properly, which can result in the plates detaching in the event of a side curtain air bag deployment.
A plate that detaches during a crash may strike an occupant, increasing their risk of injury.
Dealers will secure the headliner plates, free of charge. Owner notification letters were mailed September 26, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC245.
Campaign 22V560000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 17, 2022
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.
A fuel leak can increase the risk of a fire.
Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed August 2, 2022. Owners may contact Kia customer service at 1-800-33-4542. Kia's number for this recall is SC228.
Campaign 22V093000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideMay 10, 2021
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
An electrical short in the HECU increases the risk of a fire while parked or driving.
Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.
Campaign 21V331000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideAug 27, 2020
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.
Campaign 20V519000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 21, 2020
Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.
If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.
Kia will notify Owners, and Dealers will inspect the low pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, a heat-protective tape will be installed. Repairs will be performed free of charge. The recall began June 12, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC187.
Campaign 20V100000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, air bag/restraint control moduleJun 1, 2018
Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.
If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Kia will notify owners. For model year 2011 Sedona vehicles, Kia will instruct dealers to verify the ACU part number and, if necessary, install an extension wire harness kit between the ACU Connector and the Vehicle Harness Connector. For all other affected vehicles, Kia will instruct dealers to install the extension wire harness kit. The recall began September 28, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC165.
Campaign 18V363000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2017
Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Bearing wear may result in the engine seizing, increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.
Campaign 17V224000 on NHTSA.gov
Representative owner complaints
1,383 reports, newest first.
Fuel system, Gasoline, Sep 15, 2021
The contact owns a 2013 Kia Optima. The contact stated that while driving at an undisclosed speed, fuel odor was detected but the contact did not see fuel leaking onto the ground. The contact's cousin, an independent mechanic, inspected under the engine cover and saw that there was fuel leaking on top of the engine block from a cracked fuel line. The dealer was made aware of the failure and scheduled an upcoming appointment for diagnosis. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.
Other or unspecified, Sep 14, 2021, fire
On 9/13/2021 about 8:10 pm my neighbor knocked on my door and told me my parked car was smoking and appeared to be catching fire. Black smoke was everywhere I yell for my son to go out to see what was happening while I call fire department seconds later the car begin to go up in flames. Fire department Arrived to put out fire on my 2013 Kia Optima.unsure of cause but from the smell it smelled like some thing electrical . It has been reported to insurance .No recalls have been issued on said vehicle. No previous warnings were issued before fire started .This could have cause a lot of damage to all vehicles parked in front and back of my vehicle had it not been put out in timely matter.
Power train, Sep 13, 2021
The contact owns a 2013 Kia Optima. The contact stated while driving 45 MPH, the TPMS warning light illuminated. The accelerator pedal was depressed however, the vehicle failed to respond. The vehicle then lost motive power and stalled. The contact slowly pulled the vehicle over to the side of the road and attempted to restart the vehicle however, the vehicle failed to restart. The contact had the vehicle towed to her residence. Several days later the vehicle was towed to the local dealer to be diagnosed. Due to the dealer being short staffed, the vehicle was not yet diagnosed. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,581.
Engine, Sep 9, 2021
My car said warning ️ do not drive and my brakes went out when I was able to stop I cut off the car then back on and it wouldn't move .I was on the highway when this happened.
Engine, Aug 30, 2021
The components in which failed in my vehicle are unknown at this time. The only thing that I know is my emergency check engine light was flashing and my car proceeded to go into limp mode. Reason for that was the rod knock sensor went off. My main concern is that a few minutes following my engine had completely shut down in the middle of the Highway. I was nearly hit by several vehicles following behind me. The problem has not been confirmed but has been identified with the SAME exact issue as other 2013 Kia Optima owners. No police reports or investigations were conducted. I am not the only person that had their safety at risk due to Kias negligence. This is clearly a reoccurring issue with many owners of the same make and model. I would think that Kia would have investigated this issue.
Engine, Aug 24, 2021
Total Engine failure while driving at 70mph on interstate. 67,555 miles Only warning was at time of engine failure check engine light came on. I purchased car used from my father in law who passed away due to COVID-19. Never any problems until now. I have seen many issues online with engines for this model year and I know that some Kia's have had engines replaced free of charge. It seems to be widespread issue to all 2013 Optimas and other models including multiple years. What was Kia's countermeasure to correct the issue? What is the RPN number for their internal PFMEA and DFMEA? If it was machining burrs remaining in the engine at time of assembly-what is detection method? -Visual inspection (not 100%)? - machine vision? -added process (brushing operation)? -added shot blast peening of crankshaft forging before machining? -added deburring of main bearings? etc. Consumer stated vehicle was towed and taken to a dealer. Still has not been repaired.
Other or unspecified, Aug 21, 2021
My SWP paint is peeling and chipping in multiple spots. Ive noticed it since I bought it back in November of 2019 but its only gotten worse
Structure, Aug 12, 2021
The paint on my car is peeling on the molding around the front windshield on the right and left side.
Engine, Aug 10, 2021
Drove the vehicle on the interstate next warning lights came on stating Hybrid system warning safety stop and do not drive I pulled over popped the hood and saw oil leaking everywhere and the vehicle was inoperable so I towed to my home called the Kia dealership stating there was a recall on my vehicle a 2013 Kia optima hybrid and advised what to do they told me to tow it to the dealership and there is it
Structure, Aug 9, 2021
Around approximately 76,000 miles on the vehicle, I noticed paint (snow white pearl) started bubbling and coming off the hood. I assumed it was from a rock chip. The paint bubbling and chipping is now occurring all over the vehicle. I've spoken with two different KIA dealers (in Charlotte, NC and Salisbury, NC) and they've both said there are no recalls from KIA and there's nothing they can do but offer to repaint the car for THOUSANDS of dollars. I'm finding new spots every month. There are now 93,000 miles on the car, and I do NOT feel like the paint should be failing like this at all. I will attach pictures if allowed. I doubt I can upload all of the places on my car that have chips at this point.
Engine, Aug 9, 2021
Drove car all of a sudden the engine started knocking and missing and burning oil out the exhaust I parked the car until Kia can look at it
Structure, Aug 7, 2021
I own a 2013 Kia Optima. The paint in chipping and peeling on various parts of the car.
Seat belts, Aug 4, 2021, crash
The contact's ex husband owned a 2013 Kia Optima .The contact stated while her ex-husband was driving at an undetermined speed a 2009 Jeep Liberty cross the center line and crashed into the vehicle. The driver succumbed to his injuries at the scene. There was a report of the driver being located leaning towards the front passenger seat. The air bags deployed. The seat belt was extended and locked but, was torn. The contact stated the driver of the Jeep was intoxicated however there were no reported injuries. The vehicle was towed to a police lot. A police report was filed. The local dealer was not contacted. The manufacturer was not notified. The failure mileage was unknown.
Engine, Aug 4, 2021
My car recently cut off I replace the camshaft sensor A and B My engine is currently knocking
Engine, Jul 31, 2021
Rod Bearing caused the engine to Cease , my Car was at Ray Skillman from 6/28/21 diagnosed 7/28/21 KIA denied claim, after all recalls have been performed on vehicle. Engine still should've been under warranty to replace engine a 2nd time. Engine replaced 3/2015 at 38,905 before recall in 2017 ceased 6/28/2021 we had towed to Dealership Able to get to safety on side of interstate 65 could've been a bad situation on highway if in middle of road No lights or warnings came on prior to car stalling
Other or unspecified, Engine, Jul 26, 2021
Vehicle starts smoking from under hood after driving for awhile. Not sure if its coming from the turbo or another part.
Engine, Jul 26, 2021
Driving down highway and lost engine power. The gas engine seized up causing the vehicle to stop suddenly. Towed to Kia and the said the engine is seized up.
Structure, Jul 19, 2021
The Snow White Pearl paint is peeling off of the hood and roof of the car (delamination).
Other or unspecified, Jul 14, 2021
The paint on my PEARL WHITE optima is chipping like crazy!
Electrical system, Engine, Jul 11, 2021
The motor failed while I was driving. I was at a stop sign and was turning the corner and my car shut off. I tried to start the car and smoke was coming from the engine. I had to have my car towed home. No warning lamps came up prior to the engine shutting down.
Structure, Jul 11, 2021
Pealing paint on hood and along windshield area
Electrical system, Engine, Fuel/propulsion system, Jul 10, 2021
My oil light has been coming on and blinking then disappearing. Current on oil change and oil level is full on dipstick. Noticed little oil stain on driveway but oil level remains good and full. A couple times now my car has lost acceleration. One time on the highway and once in my neighborhood. When I press the gas it does not accelerate. It will lose speed and after a few times of stepping on the gas will eventually get to speed.
Engine, Jul 9, 2021
Engine began making very loud noised while driving on an expressway. Pulled off of the road and engine would not start. Had to get towed to a local repair shop. I found out that my engine is blown. There have been recalls on the Theta II engine, but, mine was not involved in the recall. There are many reports of these engines that were not involved with the recall having MAJOR issues. Please investigate further into these engines.
Engine and engine cooling, Jul 6, 2021
The contact owns a 2013 Kia Optima. The contact received notification of NHTSA campaign number: 17V224000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Engine, Jul 3, 2021
We believe the connecting rod bearing in the engine is bad and needs to be replaced. The vehicle is available for inspection upon request. When the engine failure occurred, luckily we were in a neighborhood and not traffic because the engine speed was drastically reduced and the vehicle failed to accelerate in a reasonable manner. The vehicle has not been reproduced or confirmed by a dealer, but a home computer diagnostic was done on the vehicle giving a "Cylinder 3" misfire code. The vehicle has not been seen by anyone other than the owners of the vehicle, we are currently in the process of trying to get an appointment with a kia dealership. There were no warnings prior to the failure, but as soon as the failure occurred, the check engine light turned on and was blinking.