2015 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,008 owner complaints filed for this model year. This is the 2nd highest complaint count among 20 Optima model years with reports.
Of the 2015 reports, 31 involved a crash and 74 involved a fire. 23 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 25, 2023
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Campaign 23V652000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideMay 10, 2021
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
An electrical short in the HECU increases the risk of a fire while parked or driving.
Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.
Campaign 21V331000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideAug 27, 2020
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.
Campaign 20V519000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Representative owner complaints
1,008 reports, newest first.
Air bags, Mar 25, 2026
Airbag light on dash is on.
Service brakes, Hydraulic, Mar 24, 2026
The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the ABS warning light illuminated, and the vehicle went into LIMP Mode. The vehicle unintendedly decelerated to 5 MPH and started jerking abnormally. The contact referenced NHTSA Campaign Numbers: 21V331000 (SERVICE BRAKES, HYDRAULIC) and 20V519000 (SERVICE BRAKES, HYDRAULIC); however, the VIN was not included in recalls. The dealer was notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 158,872.
Engine, Mar 20, 2026
Was driving then suddenly the engine shut off I was able to pull to the side Tried to restart it I saw smoke coming out from the hood I did tow it to my apartment looks like the engine is locked I contacted kia they said I have a branded title they can’t do anything about it Even if the car title was branded to a rear ending collision And the engine had oil in it
Electrical system, Engine, Mar 17, 2026, fire
The contact owned a 2015 Kia Optima. The contact stated that while driving at 60 MPH, during a DoorDash delivery, the vehicle vibrated. The contact pulled to the side of the road and noticed smoke emitting underneath the vehicle from the right side. The contact exited the vehicle and noticed smoke emitting from underneath the hood. The state troopers were called. By the time the fire department arrived, the vehicle was engulfed in flames, and the engine had exploded. The fire department extinguished the fire. The contact was not injured. No police report was filed. The state troopers believed that the fire was caused by an electrical short. The contact stated that prior to the fire, the vehicle vibrated when idled. No warning lights were illuminated. The vehicle was towed to a towing yard. The insurance company was not notified about the fire. The contact was unaware that NHTSA Campaign Number: 21V331000 (SERVICE BRAKES, HYDRAULIC) was associated with the VIN. The manufacturer was not notified of the fire. The failure mileage was approximately 174,000.
Engine and engine cooling, Mar 3, 2026
The contact owns a 2015 Kia Optima. The contact stated that while driving at 40 MPH, there was smoke coming from underneath the hood, and the engine overheated. The check engine warning light was illuminated. The contact was able to pull over to the side of the road and add coolant to the coolant reservoir. The vehicle slowly started and was driven to the destination. The contact stated that the engine was overheating if driven for more than 10 minutes. The vehicle was taken to an independent mechanic, where it was determined that the vehicle was experiencing excessive coolant consumption, and coolant was added as needed. The mechanic determined that the failure might be related to the engine. The vehicle failed to start and was undrivable. The vehicle was not repaired. The dealer was contacted and referred the contact to the manufacturer for assistance. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 124,000.
Engine, Mar 2, 2026
On Friday, February 27, 2026. This vehicle is being driven and vehicle seized and disabled on the road. In the middle of rush hour, traffic in a dangerous spot, local police had to be called out to assist, as no location was identified for a tow truck to be able to pick it up... The police had to dispatch their own tow service. After being towed from location where a car was disabled, mechanic looked at vehicle identifying there was no oil in the car. However on, September 9, 2025 an oil change was performed on the vehicle at 139,969 the car seized at 143,369.. That is approximately 3,399 miles driven from the time of the oil change up until the time it seized... There was no indicator lights that ever identified that an oil change was needed or low on oil on the vehicle prior to the car disabling..
Engine, Feb 24, 2026
The vehicle started making a loud knocking/tapping noise while driving. The vehicle has randomly acted as if it was going to stall while driving prior to the knocking. Instantly the car was brought home and parked. A mechanic has assessed the vehicle and states the noise we are hearing is the rods. We also contacted another mechanic and they advised us to look up the VIN due to a recall for 2015 Kia optima’s and the failure of this exact issue but we learned it was only for hybrid models even though this model has had the same exact issues as that model. I then see there have already been complaints made for my same issue and model yet no recall campaign has been initiated. I am fearful to drive or try to sell this vehicle because what if someone else drives it and it does stall again during driving and injury or death occurs.
Other or unspecified, Forward collision avoidance, Feb 23, 2026
Nothing
Engine, Feb 22, 2026
Engine seized and won’t turn at all
Engine, Feb 22, 2026
Engine failure while driving on freeway. Almost hit by semi truck. Towed to Dealership. Engine check light flashing complete loss of power. Kia refusing engine replacement under settlement.
Other or unspecified, Feb 17, 2026
Paint is peeling off all over my car. I see this is a known issue with the white paint and nothing is being done about it. I have touched up a few spots but it is only getting worse
Power train, Engine, Feb 13, 2026
On December 27, 2025, at approximately 150,556 miles, my 2015 Kia Optima Hybrid experienced sudden engine knocking, power loss, and failure while driving at 65 mph on a highway. The vehicle dropped into limp mode and I had to pull off the highway. The car required towing to the dealership as it would not drive safely. Diagnostics revealed a knock sensor error (P1326 code) and failing connecting rod bearings via Bearing Clearance Test, consistent with the known Theta II engine defect (manufacturing debris causing oil starvation and premature bearing wear). This follows earlier symptoms: Intermittent 'Check Hybrid System' warnings in early December 2025 at 148,665 miles (dealership unable to reproduce, but historical codes noted). The Knock Sensor Detection System (KSDS) software update was performed in February 2022 during prior CHS warnings. Despite onset of issues under the 150,000-mile extended warranty limit per the Kia E2 Settlement, Kia denied coverage due to the minor mileage overage and directed me in a loop between Consumer Assistance and the Settlement Administrator. The defect poses a serious safety risk: potential for sudden engine seizure, stalling while driving, or engine compartment fire (as seen in related Theta II recalls and thousands of NHTSA complaints). No crash, injury, or fire occurred in my case, but the failure left the vehicle undrivable and unsafe on the road. I have service records and diagnostic reports to support this.
Fuel system, Gasoline, Feb 11, 2026
The contact owns a 2015 Kia Optima. The contact stated that while attempting to start the vehicle or while driving at undisclosed speeds, there was an abnormal fuel odor inside the vehicle after the vehicle was serviced by the dealer. The contact stated that the vehicle received an undisclosed engine repair. The vehicle was not taken to an independent mechanic or the dealer to be diagnosed. The manufacturer was not notified of the failure. The failure mileage was 123,323.
Engine, Feb 9, 2026
Valve cover leaking and oil dripping oil on exhaust at 114k miles. Risk of engine fire.
Structure, Feb 2, 2026
The contact owns a 2015 Kia Optima. The contact stated that while driving at various speeds, the driver's side and passenger's side doors' exterior trims separated from the vehicle. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the repair was not covered because the VIN was not included in an unknown related recall. The failure mileage was approximately 120,000.
Engine, Jan 29, 2026
The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the engine seized, and the vehicle stalled. The vehicle was able to coast to the side of the road. The check engine warning light and several other warning lights were illuminated. The contact raised the hood, and there was a burning odor coming from the engine. The vehicle was towed to the place of employment. A mobile mechanic arrived at the place of employment and used a handheld code reader to diagnose the vehicle, but no DTC was retrieved, and no cause for the failure was determined. The starter was replaced; however, the vehicle failed to restart. The vehicle was towed to an independent mechanic, who diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that the vehicle was purchased six months prior to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 96,000.
Steering, Electrical system, Jan 25, 2026, fire
Yesterday, [XXX], My 2015 kia optima engines reved up wothout me pushing the gas & within seconds later a loud noise and metal fell from under the hood. After pulling over, popping the hood on the passenger side and under the engine a fire had started. My daughter was seated in the back passenger side her door had locked, thankfully the passenger door was left opened bc within minutes the entire car was filled with smoke and engulfed in flames. Prior to this the steering wheel would jerk even while at a red light. This car just did have 100,000 miles & no knowledge this prior. Thank god i was able to get my daughter out of this vehicle & this didnt end in a tragedy due to negligence if this was a prior known fact. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jan 25, 2026
I've had car for not very long and rid bearings now all of a sudden went out and engine is bad at this point and don't understand why my vehicle wouldn't be included in all the different recalls for 2015 optima because it's one of the years of theta 2 engine being recalled and mine says 0 recalls why is that?
Service brakes, Hydraulic, Jan 20, 2026, fire
The contact is calling on behalf of her grandson for a 2015 Kia Optima. The contact stated that while he was driving at approximately 35 MPH, the vehicle was making an abnormal sound and stalled. The contact stated he restarted the vehicle and was able to shift to drive (D), but the vehicle again stalled. The contact stated that he observed that white smoke was coming from under the hood. The contact stated that he pulled over and stopped the vehicle, opened the hood, and saw that smoke and flames had formed under the engine. The contact stated that he called the fire department. The fire was extinguished using foam. The vehicle was towed back to the contact's residence. The contact had not called a dealer or the manufacturer. The vehicle was not diagnosed or repaired. The contact had researched online and related the failure to NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic). The contact stated that her grandson had not received a recall letter from the manufacturer. The failure mileage was 158,006.
Other or unspecified, Jan 20, 2026
**This complaint isn't directly related to the safety of the car** However, due to outstanding number of similar cases i've witness online. I would like to formally make a complaint for the defective White paint on my Kia vehicle. Like many other "white" Kia and Hyundai vehicles, the white paint is bubbling and peeling from multiple areas of my vehicle all at once. I have always taken care of and hand washed my car, so i know the paint isn't peeling because of user/owner damage. Road debris would also only cause paint damage on the front bumper and/or hood, which doesn't explain the bubbling and peeling happening on all the other parts of my car.
Electrical system, Exterior lighting, Other or unspecified, Jan 17, 2026
I’ve gotten my vehicle fixed four times now thinking it was an electrical issue, not aware of the recall. Did my research this fifth time when my brake lights completely went out and smoke at some point in times come through my air-conditioning. I’ve spent more money trying to fix the vehicle with no idea that there were issues already about it.
Other or unspecified, Jan 8, 2026, fire
My Kia OptimaLX had no check engine light not running any different no warning or light indicators turned on but car caught on fire while parked after only driving less than 5mins less than 1 mile from home. Entire front dash burned all the way to the gear shift. Every recall notice recieved was taken care of as soon as I was notified that there was a recall and they had the part to change it out. The engine was part of the recall and was replaced and a fuse module box was replaced 1 month or less from the time of the fire. Car is considered a total loss from insurance company.
Steering, Engine, Jan 7, 2026
Engine seized
Steering, Electrical system, Service brakes, Jan 2, 2026
My 2015 Kia Optima has a failing ABS/HECU module consistent with the Kia ABS fire recall. The brake lights stay on constantly even when the brake pedal switch is unplugged. If I unplug the ABS/HECU module, the brake lights immediately turn off, which confirms the ABS module is back-feeding power into the brake light circuit. I also previously experienced the ABS pump running with the vehicle turned off. Currently the ABS, ESC, EPS, and Brake warning lights are illuminated and all stability/ABS functions are disabled. This is a clear safety hazard affecting braking, electrical safety, and vehicle fire risk. I have already been to the Kia dealer twice and they dismissed the issue after only checking the recall fuse. They refused to address the ABS module itself even though the vehicle is unsafe. The recall appears insufficient because the module has now failed. I need Kia to replace the ABS/HECU module under recall safety remedy.
Other or unspecified, Lane departure, Dec 29, 2025
The car is experiencing the same problem reported on technical service bulletin SA187 (Blind spot detection (BSD) system logic improvement (SA 187)) BUT KIA states my VIN number is not listed under the service bulletin and therefore I have to pay $189 to get a software upgrade done. The "Check BSD system" illuminated in the instrument cluster has been cleared twice by my mechanic and still comes back after a few days. To me this issue should have been made a recall because of its criticality... the BSD system is a core safety feature of cars and reduces accidents substantially. There was no way for me to know my car has this problem unless it is made a recall. I have NOT had any accident related to this issue but i had to pick an incident date to complete this complaint. I have called KIA customer service at 1-800-333-4542 twice to find out whether the VIN number should be included in the service bulletin and the answer was no and whether i should report this to NHTSA with the possibility that certain VIN numbers were left out of the service bulletin in error. No answer as to what to do to investigate this was given by KIA. That's why i'm reporting this on here. The service bulletin has been attached to this complaint. My question to NHTSA is whether certain vehicles were left out of the service bulletin in error and whether the manufacturer is liable for the repair at no cost to the consumer. If NHTSA finds out the manufacturer is liable will you notify them to pay on a case per case basis or will you make this service bulletin a recall? Again this is SAFETY HAZARD that can cause crashes and accidents. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)