2016 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 756 owner complaints filed for this model year. This is the 4th highest complaint count among 20 Optima model years with reports.
Of the 2016 reports, 27 involved a crash and 19 involved a fire. 21 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Latches/locks/linkages, trunk lid, latchAug 24, 2023
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
A person inside the trunk compartment may become trapped, increasing their risk of injury.
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.
Campaign 23V594000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJan 6, 2017
Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.
In the event of a crash, an air bag that does not inflate fully increases the risk of injury.
The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.
Campaign 17V007000 on NHTSA.gov
Power train, axle assembly, axle shaftOct 3, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.
If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.
Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.
Campaign 16V705000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.
If the second stage air bag does not deploy it increases the risk of injury or death.
Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.
Campaign 16V231000 on NHTSA.gov
Representative owner complaints: engine
442 reports, newest first. Show all
Engine, May 26, 2023
The vehicle has 64155 miles. Sense about 40000 miles the car cannot make it 3000 miles without needing oil with dry dip stick. I see there is alot of complaints of this. NTSA please issue a recall.
Engine, May 24, 2023
My vehicle is a 2016 Kia Optima, I keep regular oil changes. In between oil changes I have to add 5 to 8 quarts of oil because of loss. There is no dripping, no smoking. I am told it is a engine problem in all Kia models. But this is getting expensive and tiresome. I hope someone can resolve this issue.
Engine, May 24, 2023
Even following recall procedures, our 2016 Kia Optima EX is experiencing all of the issues outlined by other owners with massive oil consumption, all four windows failing, along with our antenna fin flying off on a highway post inspection. No recall on a 2000$ repair job to replace the window motors? Kia letting everyone pass 100k on their Optimas before claiming no warranty to fix the engine they broke? Help!
Engine, May 19, 2023
The contact owns a 2016 Kia Optima. The contact stated that while driving at various speeds, the vehicle shifted into LIMP Mode and decelerated with the check engine warning light activated. The vehicle was taken to the local mechanic who diagnosed that the knock sensor code was present. The code was cleared and later while driving the vehicle stalled. The vehicle was towed to the local dealer who diagnosed that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 99,340.
Engine, May 19, 2023
This car we still owe 20000.00 on and the rings are no good we took the car to kia who said the engine is no good but our extended warranty place denied the claim. The oil consumption is a problem in all kia's. I know we are not the only owners complaining about this issue.
Engine, May 15, 2023
Several times, while driving, the vehicle light panel starts flashing, the car looses power & starts shutting down. The car was taken to the dealer and they said it has to do with oil being low, it a way to protect the engine. This has happened several times, they have done an oil consumption test & they SAY it is within specs. However, the last time the DEALER completed the oil & it was "full" it was at 77121. Now, the mileage is 78360 and the oil it 2 quarts low. This oil issue has been going on for 2 years & they refuse to accept any responsibility and will not repair or replace anything.
Engine, May 15, 2023
The contact owns a 2016 Kia Optima. The contact stated while driving 2 MPH, the vehicle shuddered with an abnormal sound coming from the front of the vehicle. The contact stated that no warning lights were illuminated. The vehicle was taken to the dealer however, the mechanic found no failure. The contact stated that the shuddering had been an issue for the past three years. The contact stated that most recently the vehicle had been shuddering with an abnormal ticking sound upon starting the vehicle, and while driving. The vehicle was taken to an independent mechanic who stated that the failure was an internal engine failure and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact stated that the manufacturer advised them to call the NHTSA Hotline to file a complaint. The approximate failure mileage was 70,000.
Engine, May 14, 2023
The engine on my vehicle failed while driving it. I was in the middle of the freeway when it seized up. It was also around a bend so it put my life and others at risk. It is sitting out front of my house and can be inspected at anytime. It has been confirmed by an independent service center that my vehicle is not drivable until the engine is replaced. There was no warning lamps until the vehicle was seizing up while driving. It first appeared that day only.
Engine, May 13, 2023
2016 kia optima lx 2.4l 4cyl got car brand new started using a qt.of oil at about 50000 miles at every 800-1000 miles took to dealership they did there testing and said it needed a new motor free because it was under 100000 warrant now with new motor same problem about 65000 a qt. or more every 1000 miles i take very good maint. on my car on time by the book including oil changes every 4000 mile.I think is a waste money when i' adding a qt. every 1000 mile . being they all ready replace the motor once do i still fall under a new warrant or lemon law being its the same problem any and all help will be greatly appreciated.
Engine, May 10, 2023
The contact owns a 2016 Kia Optima. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the vehicle was consumer 3 quarts of oil every 1,000 miles. The contact related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Engine, May 9, 2023
Vehicle is using excessive amounts of oil and only has 80000 miles and KIA dealership says it is probably due to bad rings.
Engine, Fuel/propulsion system, May 9, 2023
1. The engine seized and went into Limp Mode. I was driving and randomly the power to my vehicle was low and had to drive slowly to my house (1 mile) going 20mph. It is available for inspection upon request. 2. I was driving off the highway going 40mph off the ramp at the time with cars in front and behind. I was truly scared and worried that I would end up in an accident due to the vehicles performance. 3. KIA Dealership confirmed the issue is the engine, but is trying to blame me for the issue due to oil issue with the car. This doesn't make sense as I have had the car serviced at 79k miles for an oil change, and the dealership is saying that there wasn't oil in the vehicle. The vehicle was at 82k miles at the time of this incident. How did the car go through all the oil in 3k miles? On top of that, the oil light never went off once, as a consumer I should be able to rely on the vehicle to tell me when issues are coming up so I can do this to fix said issue. 4. If KIA Dealership counts as manufacturer, then yes, if not, then no. 5. No, the first issue of warning lamp was when the Check Engine Light started flashing the same time my car seized and went into Limp Mode. With all this happening, KIA is saying that it is not their responsibility and not covered under the warranty of the engine of the vehicle and want me to pay $13k for a new engine. This is ridiculous. The car is worth the same as a new engine?
Engine, May 8, 2023
I have been having problems with my vehicle since 2020 (when it was still under warranty). My engine is burning oil and there has always been carbon build up on the engine parts. I followed their recommendation and did the combustible engine clean and was never given a pass or fail result. Since 2021, I have replaced cylinder 4 spark plug 7 times. My warranty was up in December 2021 and now the problems are just getting worse. I have been told that I have a bad engine but until a knock sensor comes on or my engine fails, Kia will not do anything about it. I am driving an unsafe car as I have no way of knowing when the engine will fail. When my spark plug fouls, I am unable to drive the vehicle and have to have the car towed to the dealer (which has now been five times). I am now replacing the same spark plug (cylinder 4) every three days because of carbon buildup. The dealership has no solution or fix for this problem besides replacing the engine. My engine is still burning oil and they have no solution for that either, besides replacing the engine. Kia is doing nothing about this problem, when they know that these engines are bad.
Engine and engine cooling, May 5, 2023
The contact owns a 2016 Kia Optima. The contact stated while driving 45 MPH, the vehicle started making an abnormal metal to metal squealing sound. The contact pulled the vehicle off the roadway and the vehicle stalled. The contact stated that the vehicle lost power steering and braking functionality during the failure. The contact stated no warning light was illuminated. The contact had the vehicle towed back to her residence. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The failure mileage was approximately 170,000.
Engine, May 2, 2023
Burning oil at a rate of 4 quarts per 300 miles. The vehicle has had all the required oil changes and has even had a $400 top clean to help the oil burning problem, nothing has helped. Now the car is malfunctioning while driving wo codes.
Engine, Tires, May 2, 2023
The contact's daughter owns a 2016 Kia Optima. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that while her daughter was driving at an undisclosed speed, the TPMS warning light illuminated. Additionally, the vehicle stalled. The vehicle was towed to the dealer, who informed the contact's daughter that the engine needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 53,000.
Exterior lighting, Engine, Apr 26, 2023
I was driving at night when both of my lower beam headlights went out at the exact same time. My high beams work but not the low beams and it wasn't a blown fuse. Also, my engine has been consuming 2 quarts of oil every 1,000 miles since it hit roughly 58,000 miles. The excessive oil consumption started about 2,000 miles before my next oil change was due. The oil indicator light never came on to indicate my engine was low on oil. The oil indicator light flashed on and off one time as I was slowing down to turn which is what prompted me to check my oil because I knew something wasn't right that the oil indicator only flashed but didn't stay on.
Engine, Apr 23, 2023, fire
I got the car oct 2022, car drove fine for months. Got oil changes regularly. On or about late Dec my car started getting this code "check active air flap" it didn't stay on it was quickly flashed on my dash and went away. So I thought it wasnt important, then it came on again really quick and disappeared again. So then I start to worry and start searching what exactly was a air flap. I found out it was something that allows air flow to the engine. So I parked my car and didn't use it so I could get them money to take it in to have it looked at. On Jan 4h me and my 2 sons were on our way to have it looked at and while on the way there my car was making a weird like ticking noise which I didn't know what it could be so I am still driving just being more cautious and Bam my car is on fire! Freaking out cause no one would let me over to safely pull off the road. No check engine light ever came on no oil light nothing but air flap check.
Engine, Apr 20, 2023
I have been continuously having the car checked because it burned oil and all mechanics even outside of dealership brushed it off. turns out it was a cylinder leak from the exhaust valve and now a new engine is needed. given Kia's history with Engine problems on the Optima i wanted to report this as this seems like it could have been a caused because of engine block, crankshaft, and bearings, connecting rods and bearings, and pistons issues that then ultimately led to the exhaust valve issue. But of course my issue falls right out of the lifetime warranty
Engine, Apr 17, 2023
The engine failed as I was driving and the car stopped accelerating and slowed to a stop on a busy road at night. I purchased the vehicle from Parkside Kia in Knoxville in December 2020. I was notified in March 2021 by my personal mechanic to take the car to Kia for high oil consumption rates and future engine failure but Kia told me nothing was wrong with it. I had the KSDS update in June 2022 after it went into creep mode/stopped accelerating on the highway when I was out of town in Asheville, NC, and the spark plugs went bad a few months later because of the same faulty oil consumption issue. Kia is manufacturing bad engines and putting their customer’s safety at risk. They ignore when asked and act like they don’t know anything about the engine settlements. They are playing dumb and not being forthcoming with information or safety notices. Parkside Kia in Knoxville sold me a lemon which was a safety risk from the moment they sold it to me in December 2020, after the recalls and updates were issued to the first owners. I never was notified and found out by an unsafe situation driving alone on a busy highway.
Engine, Apr 14, 2023
After just purchasing this car from dealer. I was driving on Christmas Eve to my mother-in-law's. I noticed the car was smoking. I had checked the oil before we left been about a 45-40 minute drive. Went to pull off the road and it would had to be towed back to my house. I had both my children in the car and my fiance and the smoke was coming through the cabin. It had not been running correctly for a while and went to take it to the mechanics to find out that the engine had seized.
Engine, Fuel/propulsion system, Apr 11, 2023
I submitted a report on this already but haven't had any response and it's a huge safety concern. I see 388 others have reported issues with this vehicle as well and most seem to pertain to the engine like mine so not sure how many need to file before a recall or Kia is held accountable for making an engine that burns oil and locks while driving. I've received zero support from them and they are denying replacing engine which had an oil change 6 weeks prior and only 109k miles on it. With all the complaints and prior class action suit which requires them to cover engine up to 150k I'm very confused how they can deny this and how this vehicle with these engines are safe for the road.
Engine, Apr 7, 2023
Engine is rapidly burning oil. At a sudden stop or on an sharp incline I noticed the 'oil warning light' come on. I checked the dipstick and it was showing no oil. If the engine seized and stopped the vehicle on a highway this could be a safety issue. It appears others have had the same issue, yet Kia does not offer any help. It is listed as an issue with premature O-ring failure. Vehicle has under 59,000 miles on it.
Engine, Apr 3, 2023
Heavy Oil consumption and adding oil every week
Engine, Apr 2, 2023
The car has had issues for a long time. It had gone into limp mode multiple times and they fixed it and then would do it again later. Not long ago, it was acting badly again like it was going to die and they had me spend over $1,000 on new coils and plugs. Then the oil light was coming on. Took it in for check and did oil change at valvoline. They said it was empty. It was under 3k miles or just at I believe. Then 3k miles or less light comes on again. I took it to Kia they did new oil change and said I had to do 1k mile test. I brought it back at 1k miles and they said it was 2 quarts low. Said I should spend 700 or more cleaning the engine. I said I just spent over 1k fixing it and no one mentioned anything about cleaning. I do all suggested maintenance and recalls and oil changes with synthetic at about 3k. So they said someone would call me and didn’t give me a paper. They also had said the engine was most likely bad. At the time I spoke with three employees one of which works in the garage. I never got a call. I emailed and messaged and never heard back- except to get the paper simply saying to check at 1k miles. It also had an employees name who I had not talked to. I took it back 1 k later and new guy said was quarter of a quart low. He showed me a dip stick with oil on it and said I should spend hundreds to clean it. Wouldn’t explain why suddenly oil fine. Now at about 800 miles oil out. Took it to valvoline and oil out. Last Kia I drove engine blew. This feels unsafe. I have no other car. I don’t trust them telling me there is oil and pushing more expensive needless things. The engine is obviously bad. It is just under 100k and have a letter saying engine extension until 120k. Original owner.