2016 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 756 owner complaints filed for this model year. This is the 4th highest complaint count among 20 Optima model years with reports.
Of the 2016 reports, 27 involved a crash and 19 involved a fire. 21 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Latches/locks/linkages, trunk lid, latchAug 24, 2023
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
A person inside the trunk compartment may become trapped, increasing their risk of injury.
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.
Campaign 23V594000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJan 6, 2017
Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.
In the event of a crash, an air bag that does not inflate fully increases the risk of injury.
The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.
Campaign 17V007000 on NHTSA.gov
Power train, axle assembly, axle shaftOct 3, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.
If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.
Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.
Campaign 16V705000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.
If the second stage air bag does not deploy it increases the risk of injury or death.
Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.
Campaign 16V231000 on NHTSA.gov
Representative owner complaints: engine
442 reports, newest first. Show all
Engine, Oct 30, 2022
The oil is leaking into the engine, was taken to a kia dealer for repair $542.45 unsuccessful , I am putting oil in my car every 3 weeks. Purchased the car in April and over $2500 spent. The oil is still going into the engine, no leaks on the ground. Was told to deal with it and wait until my engine pops by Thomas kia of highland indiana
Engine, Oct 25, 2022
Engine stalled while driving on main highway. It is available for inspection Safety: was on major highway when vehicle stalled other cars on highway had to swerve around me to avoid hitting me. no it has not been confirmed no it has not been inspected no there were no warning light
Engine, Oct 17, 2022
10-17-2022 * failure is plugged coil or spark plugs due to heavy oil consumption. Vehicle is available for inspection * driving when vehicle completely stalled and would not restart while on a 4 line highway barely got off the road almost hit by other cars as the vehicle just stalled Has happened before, has heavy oil consumption have been told it is due to faulty piston rings * At this time it is at the garage for investigation of problem *No *No
Electrical system, Engine, Oct 16, 2022
Was driving my car and it just lost all power and cut off. It will not start now. It only has 1 click. The car has used a lot of oil since I've owed it. I do regular oil change and the oil lights still go off and on. I researched why it had power failure and replaced the starter but that didn't work. I started looking into the engines for 2016 kias n found out some have a recall. I hope my car falls in that recall bc I need it fixed . my car gave no warning signs that anything was wrong . just cut off all of the sudden and will not start . had to have it towed to my home
Engine, Oct 9, 2022
It burns a quart of oil every thousand miles shouldn’t be doing this
Electrical system, Air bags, Engine, Oct 5, 2022
I have a 2016 Kia Optima within the 2nd year all my window motors fail within a 6 month timeframe. My car in the 4th year started to burn oil quickly the oil light would not appear until I begin to hear a knocking sound. Also, in the 4th year of having my car there has been cracking in my passenger side (I think it is where the airbag is located). All of the areas could put my life in some type of danger or a family member if KIA doesn't see fit to remedy these areas. In 2018, my warranty was out and I didn't know until I received my bill the service person didn't advise me of this issue. So, I ended up paying $700 for a battery installment when I advised him that it was the issue, he insisted I get a diagnosis done.
Engine, Sep 29, 2022
Car has been burning oil since purchased. Over a quart in 1000 miles. Engine rattled during acceleration and sometimes stalls at red light. Every time I take it into Kia they state nothing is wrong. They performed an engine cleaning around 80,000 miles but won’t help me now that my car has 107,000 miles.
Power train, Engine, Sep 27, 2022
My car is experiencing excessive oil consumption, engine knocking and shifting delays, grinding or jumping during acceleration, the car jerking on the road.
Engine, Sep 26, 2022
Engine suddenly failed. Heard loud tapping sound and engine stopped working. No assistance from KIA,
Engine, Sep 20, 2022
I have a kia Optima Hybrid that has an Open Recall for the engine according to Kia's website' which they failed to address or informed me of it needing it on 07-30-2022 which was installing the KSD update for the engine. The engine started knocking on 09-12-2022. The informed me that they do not make the KSD sensor update available to customers anymore since it is passed the campaign in dates in 2021, and that is why it was not installed. Although the owners site shows the recall and asks if I want to make and appointment for it. They are doing this with multiple owners. I am also curious as to why my car doesn't show this recall on here and it shows on Kia's owner site as being and open recall along with another recall. Kia case #15050283
Engine, Sep 13, 2022
This car has developed P0010 code which stands for "A" Camshaft Position Actuator Circuit/open bank 1. Car idles roughly, shifts weirdly and has less power than before. I found that there is a TSB from KIA for the same issue but only for cars made in South Korea in 2016, mine was built in Dec. 2015 in Georgia plant so it doesn't qualify for this TSB and I'll have to pay out of pocket to fix this issue.
Engine and engine cooling, Sep 12, 2022
The contact owns a 2016 Kia Optima. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the oil level warning light was illuminated. The contact also noticed that while following while his wife was driving the vehicle, a blueish color smoke would emit from the tailpipe. The contact took the vehicle to the dealer where he was given an estimate for an oil consumption test. The contact then took the vehicle to an independent mechanic where they confirmed that the vehicle was consuming an excessive amount of engine oil. The contact attempted to notify the manufacturer of the failure but received no assistance. The vehicle was not repaired. The failure mileage was approximately 66,000.
Engine, Sep 9, 2022
extreme oil consumption. Burning oil like crazy and occasional knocking
Engine, Sep 8, 2022
My car was just confirmed by the dealership it is burning 2 quarts of oil every 1,000 miles. I am consistent with getting oil changes, and just recently, my check oil light would start flickering when I was needing an oil change. It slowly started happening sooner and sooner until the repair shop recommended me to go to the dealership. I was told by the receptionist that this issue did not involve my warranty (which conveniently just expired May 2021) and that I would get my engine replaced if the Oil Consumption test failed. I just brought it in for part 2 and was told this was incorrect and all the repairs would be 100% my responsibility. The service guy told me to constantly add more oil, and if my engine fails CATASTROPHICALLY, Kia might step in to help. I am afraid to drive my car and feel like no one is stepping up to help?!
Exterior lighting, Engine, Sep 5, 2022
My oil light would flash on when coming to a stop. I was notified my car was low on oil my last oil change. However I was not made aware as to how much. About 2000 miles afterwards when checking the oil it looked to be empty. The oil light would again flash on when coming to a stop but then go back off seconds later. The dipstick was dry. I added the appropriate amount of oil to show in the safe zone on dipstick and again about 1500 miles later the oil light is flashing on when turning/stopping. Separately, the headlights have randomly turned off while driving at night and set on auto on multiple occasions.
Engine and engine cooling, Engine, Aug 30, 2022
The contact owns a 2016 Kia Optima. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the oil level warning light was illuminated. The contact also stated that upon depression of the accelerator pedal, the vehicle would independently enter Limp Mode with the check engine warning light illuminated. The contact had the vehicle towed to Quirk Kia Manchester (1300 S Porter St, Manchester, NH 03103) where they initially updated the knock sensor. The contact stated that the failure persisted and the vehicle was towed back to the dealer where the knock sensor was replaced; however, the failure persisted. The contact then took the vehicle to KIA at Nashua (107 Daniel Webster Hwy, Nashua, NH 03060) where he was informed that engine oil had entered into the cylinder head and damaged the spark plugs. The contact was provided an estimate for a new engine. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 76,000.
Engine, Aug 28, 2022
Engine has no leaks but is consuming oil at an alarming rate. Oil must be added every 3 weeks
Engine, Aug 10, 2022
We're experience excessive oil burning. The oil is not leaking. Internet searches have led me to many others complaining of the same issue. The engine is at risk of seizing. This can cause accidents if it happens on the road and expensive damage to the engine. We get the low oil indicator lamp and we check the oil levels, it's a good quart or so low. I don't believe we're even getting 1000 miles before the lamp comes on again. We do have the dipstick to tell us it's low. We have not yet had it to a shop for futher investigation to see if a sensor is involved or not, but our mechanics have said burning oil is a common issue.
Fuel system, Gasoline, Engine, Jul 29, 2022
The contact owns a 2016 Kia Optima. The contact stated while driving 65 MPH, the check engine warning light illuminated and the vehicle stalled. The contact was able to veer to the side of the road. The contact was unable to restart the vehicle after several attempts. The contact also stated that she smelled an abnormal gasoline odor. The vehicle was taken to the dealer where it was diagnosed that an engine cylinder had failed. The dealer informed the contact that the vehicle could not repair under NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine) unless the engine was knocking. The vehicle was not repaired. The contact stated that the engine was misfiring while driving and the vehicle would not exceed 40 MPH. The vehicle was taken back to the dealer where it was diagnosed that the engine was misfiring and oil was leaking onto the spark plugs. The dealer informed the contact that she had to pay a repair fee for spark plug replacements, and then the dealer would determine whether the engine should be replaced under the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000. The VIN was not available.
Engine, Jul 27, 2022
Driving down the highway and lost power. check engine light came on the engine shut down and had to coast a mile down hill no shoulder to pull off to. came to a spot to pull over and tried starting it and it started but made a heck of a noise. took it to the dealership and it needs a new engine 60,234 miles on it no warning at all. just paid it off and received the title to it. in the mail the day before in the mail. lost power steering braking had too put it in neutral and coast down hill for a mile. this is mechanical engine failure and a safety issue. 2.4 liter GDI engine.
Engine, Jul 24, 2022
We purchased car used on 11/27/19. Within 3 days it was chugging, engine light started blinking, and we were broke down on side of the road. Federico Kia in Wood River IL had us tow car to service and told us then that there was an issue with these engines and they would be “replacing a part, and if it does this again, we would qualify for new engine. Would have been nice to know about issue with fires in engine prior to buying an 18000 car. After paying $400 for rental car they said it was fixed. Drove ok for another 9 months and then same thing happened yet this time we could smell something burning under hood. We were by dealership when this happened and due to it chugging and engine light, we took and dropped off again. We were then told spark plugs and needed oil change again after we had just changed ourselves 2 months prior. Said they were “flushing out engine” . Total cost was over $200 for us for oil change and flush. They said technically we were over our warranty time. SMH. It hasn’t been right since we bought it. We can’t afford to make their service dept rich, so we were told they would have to charge from them. We have had to replace same spark plugs 6 times as of today. We were just driving it after oil changes every 3 months even if miles driven were under 2000, and it’s chugging again and smoke and smell from under hood again. This engine is going to catch fire i fear. I won’t drive past 10 miles from my home because I have engine that chugs and overheats. Oil is not cheap and we put 2 qts in every 2 weeks or so. Dealership said there were no oil leaks they could see and yet puddle under car many times. Can someone please help us?
Power train, Electrical system, Engine, Jul 19, 2022
My name is E........ M........ and I'm writing this email/complaint in hopes it can be resolved or you can pass this email along to the appropriate person or persons to have this matter looked into. We purchased a used 2016 Kia Optima a few years back and have had nothing but trouble, from electrical issues, recalls, transmission issues, oil consumption, and smoke coming through the air vents!!!! and there's more, the last time we had an issue and took it to a dealer for problems shifting, hard shifts, loss of power, and smoking, we were told the dealer could not duplicate the problems while driving it and that was that, not a damn thing fixed because apparently everyone is stupid or blind and I was more than pissed. On 7/13/22 the car has been at the dealer again (for almost two weeks now, but they were so busy they just got to it today) so the car is there for the same exact things listed before only this time they state the turbo turbine is bad and it's gonna be $4000.00 to fix it. First off NO, and secondly NO, I will not let this happen! BTW, please pay close attention to the part of smoke coming through the air vents!!!! Currently, the car is at a KIA dealer still, the general manager was to call me on the 14th and NEVER DID today is the 19th, I called today and they are acting like they don't even know me. NO warning lamps, the car can be completely out of oil, and still no engine or oil light will come on. The fact that this car has smoke coming through the air vents is of most concern, I need help dealing with this issue and will contact a lawyer if needed or if you advise me to. BTW I emailed all head people at Kia corporate and NO response from them as well. Thank you The consumer stated the general manager has the approval to move forward with the repairs and would like to rescind the complaint.
Engine, Jul 19, 2022
The contact owns a 2016 Kia Optima. The contact stated while her daughter was driving at an undisclosed speed, the vehicle stalled. The contact was able to push the vehicle to the side of the road with the assistance of a police patrol. The vehicle was towed to the contact's residence. The vehicle was then towed to the local dealer where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as the contact failed to complete an unknown independent recall prior to the failure. However, the contact stated that she had not received the recall notification. The failure mileage was approximately 110,000.
Engine, Jul 19, 2022
The contact owns a 2016 Kia Optima. The contact stated while driving approximately 70 MPH, the vehicle decelerated independently. The contact stated that while attempting to accelerate the vehicle was vibrating abnormally. The oil level warning light was illuminated. The vehicle was previously taken to the dealer due to excessive oil consumption. The vehicle was towed to the local dealer and diagnosed with total engine failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 123,281.
Engine, Jul 17, 2022
check engine light lit up when I was driving on a freeway, causing vehicle stalling. knocking noise was present when it occurred.