2016 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 756 owner complaints filed for this model year. This is the 4th highest complaint count among 20 Optima model years with reports.
Of the 2016 reports, 27 involved a crash and 19 involved a fire. 21 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Latches/locks/linkages, trunk lid, latchAug 24, 2023
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
A person inside the trunk compartment may become trapped, increasing their risk of injury.
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.
Campaign 23V594000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJan 6, 2017
Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.
In the event of a crash, an air bag that does not inflate fully increases the risk of injury.
The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.
Campaign 17V007000 on NHTSA.gov
Power train, axle assembly, axle shaftOct 3, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.
If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.
Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.
Campaign 16V705000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.
If the second stage air bag does not deploy it increases the risk of injury or death.
Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.
Campaign 16V231000 on NHTSA.gov
Representative owner complaints: engine
442 reports, newest first. Show all
Engine, Nov 1, 2023
The contact owns a 2016 Kia Optima. The contact stated while driving at an undisclosed speed, the vehicle started shaking violently. The contact pulled into a parking area where the vehicle stalled and failed to restart. The contact also stated that the low-oil warning light was illuminated intermittently. The contact stated that frequent oil top off was needed. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic but was not yet diagnosed. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was 80,000.
Engine, Oct 31, 2023
The car fails to respond to throttle. It does it randomly every one in a while. It's very dangerous. There are no check engine lights or anything. The car can run for weeks beautiful and all of a sudden you hit the gas and the car doesn't move. It can take 3-4 seconds before it responds.
Power train, Engine, Oct 31, 2023
Vehicle Dash Check Engine Light came on 08/31/2023 Code P200A was found. Several weeks went by and vehicle started to hesitate pretty bad Vehicle was towed to Kia dealership on 10/04/2023 : Was told engine failure which needed replacement along with intake and several other required parts. Covered under Powertrain Warranty, vehicle was completed and ready for pick up on 10/17/2023 On 10/24/2023, on my way home from work, Dash Warning "Engine has overheated" has came on. Vehicle was towed back to original dealership. Kia reportedly found "air pocket" in cooling system. Vehicle was ready for pickup same day. On 10/30/2023, on my way to work, Dash Warning "Engine has overheated" has once again came on. Luckily I was able to get off the interstate and happened to be by a Kia dealership in the area. At this time, info is pending.
Vehicle speed control, Engine, Fuel/propulsion system, Oct 31, 2023
It started shaking really bad out of no where , then wasn’t going faster than 80 then down to 65 but wouldn’t go more than 80 with my foot all the way on the gas. As soon as I made it to work tonight the car cut off. I got a jump the car was still shaking & wouldn’t stay on if I let my foot off of the gas. I started it again without the cables but it cut right back off. I saw on cars.com it’s a recall for the similar thing, number Sc172. I have been having fuel leaks for a while and had my knock sensor replaced from a previous recall. Now I have no way home.
Engine, Oct 28, 2023
Car purchased in 11/2022 with roughly 60,000 miles. I have owned the car for about 11 months. When we took the car for its first oil change there was no oil registering on the dipstick. The engine began knocking before the second oil change was due and after checking the oil I needed to aff 4.5 quarts of oil. I took the car to my mechanic was informed that there was no oil leak and that KIA engines were known for oil consumption and engine failure. He recommended I take the car to a dealership. I spoke with KIA corporate at this point and they said the car needed an oil consumption test before they would possibly help me. I scheduled an appointment at a Kia dealer for the test and when I took the car on 10/26/2023. They started it and refused to do the oil consumption test stating that the engine was ruined and it wasn't safe to drive. They quoted me nearly $10,000 to replace the engine, and stated that while other 2016 Optimas were covered under a recall for the exact same problem, my car is not covered under the recall and is not warranted therefore they will not help me. I paid over $15,000 for this car 11 months ago and it is nearly worthless, with a 10K repair it is worth 10K.
Engine, Oct 27, 2023
The contact owns a 2016 Kia Optima. The contact stated that after driving approximately 60 MPH for 20-30 minutes, the vehicle would start shaking abnormally. While driving approximately 40 MPH or less, the check engine warning light would become illuminated. The contact took the vehicle to the dealer who noticed that there was no oil in the engine which caused engine failure. The contact stated the vehicle had received an oil change less than 3 months prior to the failure. The contact was informed that the KSDS sensor had failed and caused the engine failure. The contact was informed that the engine and KSDS sensor needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.
Electrical system, Structure, Engine, Oct 23, 2023, fire
The body shop later informed me that there is a recall for engine fire recently,but my year/make is not listedin the info obtained online. The car started stalling while driving down the off. Smoke started coming through the vents. I pulled over to the side of the highway. A passerby told me that the car was on fire. Called 911. To note I had just picked the car up from Jim marsh Kia for battery replacement and problems with steering after the car was stolen in July. I had no previous issues with my car other than routine maintenance which I have records for.
Steering, Other or unspecified, Engine, Oct 21, 2023
I most recently started noticing that my oil changes were not lasting at around 46,174 miles. I found this to unusual in a car with low mileage. I had to result to buying oil from a local store. The light indicator started coming on when ever I apply the brakes. When I checked my oil, it was completely dry. So I started monitoring the oil intake, even after I had oil changes at the dealership in which I mentioned that it appears to be taking in an excessive amount of oil. What I noticed was that I was adding oil every week. I did not detect any outward appearance of a leak. In addition, I experienced on several occasion what felt like the car was having a seizure. As soon as I filled up the gas tank. The car froze up, steering wheel would not move and the car was in drive but not accelerating. I immediately shut the engine off, then restarted the car. That seem to alleviate the problem for that time. It then got really bad, that it shook and was running rough as if it was falling apart. So I drove it the dealership, explained the two problems I had, running rough and a high level of oil being used in between oil changes. I was given a diagnosis on cylinders misfiring and needing spark plugs replacement, and ignition coils. Nothing about the oil issue. I was later told that would be an additional diagnosis charge to check. I asked about engine warranty and possible complaints or recalls, and was told that my issues would not be covered under the warranty. I purchased the items they indicated needed to be addressed and took my car to someone else. That's where it was discovered, when the spark plugs were removed, that oil was sitting in each pocket or cup that holds the spark plugs. All of them were soaked in oil. Though the spark plugs have been replaced and the rough shaking of the car has subsided, the acceleration is still questionable and I'm still having to fill my car with oil weekly. I'm not due for oil change until 51,174 miles and I'm currently at 51, 098.
Service brakes, Engine, Oct 19, 2023
Emergency break stopped working. Engine misfires and heavy oil consumption or burning to quickly. Gets really really hot more than normal than any other car I owned.
Engine and engine cooling, Oct 18, 2023
Engine failure, high oil consumption, already failed to operate properly on interstate, dealership said nothing was wrong and charged me $160. Two months later, the vehicle failed again, but this time the engine sounded like it was going to blow and barely made it off the road.
Electrical system, Exterior lighting, Engine, Oct 12, 2023
At 95000 car had problem accelerating and then all of a sudden on the side of the road did that 2 had 2 engine rebuilds done no but the problem is still there and the fuses all look burnt and half my lights don't work.
Engine, Oct 4, 2023
Burning oil. Took to a mechanic. Blow by engine
Engine, Fuel/propulsion system, Oct 2, 2023
I have a 2016kia optima EX and I had a problem with it. I used to take it to the Kia dealership for oil change and services. So recently I have done the transmission fluid and oil change.! After that I have weird transmission problems like it finding hard to accelerate and even when I am changing the gear from park to drive or reverse it makes weird noise like clutching. I spoke with the dealership and they say we have changed the transmission fluid then it shouldn’t be the problem.! They don’t even find the exact problem.! I have been spending a lot on my car . Kia is messing up with the recalls.!
Engine, Sep 30, 2023, fire
I brought the car may 13 2023 and July 11th the car caught fire on the eway around 9-10am. I was trapped in the car due to the doors not unlocking and had to get help by others around. The car didn't have any problems. No check engine light no nothing. Happened unexpected
Engine, Sep 28, 2023
I bought my car in 2016 brand new. It now has 47,000 miles on it. I took it in in 2018 to address a recall. I took it in 2019 when it had 19, 776 miles on it because of lack of power and they determined the VCMA motor was faulty. The car is now rattling and consuming oil extremely fast. An oil change is only lasting 2 weeks before I have to top it off. I’ve had my spark plugs replaced. My mechanic (not Kia) has told me there may be an issue with the piston rings. The cost of repairing a car with less than 50,000 miles on it is getting ridiculous.
Engine, Sep 25, 2023
I bought my car in August of 2022 with roughly 66,000 miles on it. It now has 71,000 miles on it which per the manual would only needed one oil change. I’ve had to do three and top off my oil every 500-700 miles with 1.5-2qt of oil each time. Which is way over the criteria for KIA’s “normal” oil consumption. This has caused my spark plugs to foul out costing me more money in repairs. I have only put 5,000 miles on this car in the whole year I have owned it.The oil consumption rate of this car is insane.
Engine, Sep 22, 2023
The contact owns a 2016 Kia Optima. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle lost motive power. The check engine warning light was illuminated. The contact stated he had scheduled a service appointment for an unknown recall repair on the fuel pump. The contact stated that the dealer informed him that the recall repair could not be completed until the fuel neck was repaired. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 77,700.
Electrical system, Engine, Fuel/propulsion system, Sep 21, 2023
The engine was has blown twice the first day 95000 miles and again at under 6000 miles. And there is still a bad knock and major vibration and ticking noise coming from the car. We told the car we no longer have faith in this car and didn't want it no more and all he did was see if he could get us another loan to trade it in. We're now scared to really ride in to and can't get no one to help us on this my man is about to lose his job over this car
Engine and engine cooling, Sep 13, 2023
Vehicle purchase July 20th 2023 with new oil change per Carvana. On August 7th 2023, check engine light appears. Car was taken to a local shop. No oil and some other issues found. "Issues fixed.". On September 13th oil light comes on. Again, taken to car shop, no oil. Oil topped off again. Car is not maintaining oil.
Power train, Engine, Sep 6, 2023
My car has been consuming oil and has locked up and will not operate. This issue has been reported to the manufacturer by several other customers, and my car is not a part of the recent recalls. This issue could have caused me serious harm, had I been on a highway, or busy intersection. My car engine now doesn't work.
Engine, Engine and engine cooling, Aug 31, 2023
Oil started leaking from the car and checking underneath it looked as though it was leaking from the plug so i replaced the plug, which did not fix the issue, and accidentally forgot to put the gasket back on. took it to the local shop was given a gasket and an oil change. the car started leaking oil worse than before so i took the car back. The oil pan had a little over an inch long crack on the corner/edge where the oil pan plug is. Mechanic told me he’d never seen or heard of a steel oil pan cracking before. $400 for a new oil pan made from below par steel.
Service brakes, Engine, Fuel/propulsion system, Aug 31, 2023
My 2016 Kia Optima has been consuming oil every 1.5months. I have multiple times had to replace my oil because my oil light kept coming on. I’ve checked it every single time and it is barely anything there. I have my breaks mess up and not work as properly with my safety and others being comprised. I have brought this up to my Kia dealership but they have just brushed it off and charged me for an oil change. I have seen and heard many cases like mine and it has happened worse to them to the point where the car stops in the middle of the highway. My car has been checked by others and they have all noticed the same thing - the oil levels extremely low only after 1 and a half months or way prior to when my next oil change should be made. Having this happen is expensive and life threatening when the brakes don’t work as they should or when my could possibly bust. I have received no help and would like to make this known .
Engine, Aug 26, 2023
This 2.4ltr engine burns 1 quart per 1000 miles! 53769 miles, Kia claims not under warranty and wants over 600 dollars for an engine flush! KIA OF PORT CHARLOTTE FL. They filled my oil too much! It is at least a half a quart above full! They also filled the Kia with 5-30, I do understand that from book and temp. Ranges. Found PCV valve partially defective and replaced that... Can you help me understand why I have no warranty under 54,000 miles and why engine is not covered under 100,000 miles? Also, is this defect acceptable to the NTSB? It has caused multiple accidents due too engine failure and seizing Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Aug 25, 2023
Knock sensors
Air bags, Engine, Fuel/propulsion system, Aug 24, 2023
Crack in dash along outline of airbag. Burns oil so it has to be refilled monthly Now mechanic says compression and combustion are problems Can’t get into Kia until February when warranty will probably be expired