2004 Subaru Forester
Problems, recalls and owner-reported issues
Fuel/propulsion system is the leading concern among 219 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Forester model years with reports.
Of the 2004 reports, 13 involved a crash and 4 involved a fire. 8 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, control arm, lower armSep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
Campaign 11V464000 on NHTSA.gov
Engine and engine coolingOct 1, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE COVER BOLTS FOR THE ENGINE OIL CONTROL VALVE MAY NOT BE SUFFICIENTLY TIGHTENED, ALLOWING OIL TO LEAK FROM AROUND THE COVER GASKET.
IF LEAKING OIL CONTACTS COMPONENTS OPERATING AT HIGH TEMPERATURES, A FIRE COULD RESULT IN THE ENGINE COMPARTMENT.
DEALERS WILL INSPECT AND RETIGHTEN THE OIL-FLOW CONTROL VALVE COVER BOLTS. THE RECALL BEGAN ON OCTOBER 8, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 04V473000 on NHTSA.gov
Representative owner complaints: gasoline
61 reports, newest first. Show all
Fuel system, Gasoline, Dec 15, 2013
STRONG SMELL OF FUEL WHEN OPERATING THE VEHICLE IN COLD WEATHER (AROUND 35 DEGREES OR COLDER). THE FUMES ARE SOMETIMES SO INTENSE THAT THEY CAUSE A HEADACHE AND CERTAINLY POSE A SIGNIFICANT FIRE RISK. *TR
Fuel system, Gasoline, Dec 10, 2013
I FIRST NOTICED A STRONG GAS SMELL IN THE VEHICLE ON THE COLDEST DAY OF THE YEAR, WHEN THE TEMPERATURE WAS BELOW 20 DEGREES. THE GAS SMELL ENTERS THE VEHICLE THROUGH THE VENTS WHEN THE HEATER IS TURNED ON AND THE CAR IS IDLING. WHILE THE VEHICLE IS TRAVELING AT A SPEED OF 10+ MPH, THE GAS SMELL IS NOT NOTICEABLE. WHEN THE HEATER IS TURNED OFF, THE GAS SMELL DOES NOT ENTER THE VEHICLE. WHEN I EXIT THE VEHICLE, I CAN SMELL GAS OUTSIDE OF THE VEHICLE ALSO. THE SMELL IS SO OVERWHELMING THAT I CANNOT RUN THE HEATER IN THE EXTREME COLD TEMPERATURES WHILE THE VEHICLE IS IDLING. I RAN THE VEHICLE THROUGHOUT THE SUMMER MONTHS AND THERE IS NO PROBLEM WITH THE GAS SMELL WHATSOEVER. I DO NOT TAKE MY CHILD IN THE VEHICLE WITH ME DURING THE WINTER MONTHS DUE TO THE STRONG GAS FUMES. I FEAR THAT I MAY BECOME STRANDED IN MY VEHICLE AND I WILL NOT BE ABLE TO IDLE MY CAR FOR HEAT. *TR
Fuel system, Gasoline, Dec 6, 2013
START VEHICLE IN THE MORNING AND CAN SMELL GAS FUMES OUTSIDE AND INSIDE EVEN WHEN DRIVING. THIS CAUSES BURNING OF NOSE AND THROAT. *TR
Fuel system, Gasoline, Jan 22, 2013
AFTER COMING HOME AND PARKING MY CAR IN THE GARAGE MY WIFE CAME IN FROM THE GARAGE AND SAID IT SMELLED LIKE GAS. I FOUND THE SOURCE TO BE MY 2004 SUBARU. I DROVE IT THE DEALER THE NEXT MORNING AND THEY SAID THAT THE FUEL LINES DUE TO THE COLD, AS IT WAS BELOW 20 DEGREE'S, PULLED AWAY FROM THE FUEL RAIL SO RAW GAS WAS POOLING ON THE MANIFOLD. THEY KEPT IT FOR A WEEK SAYING IT WAS NOT SAFE TO DRIVE, AND REPLACED ALL THE FUEL LINES AND CLAMPS FOR $850. THEY SAID IT WAS ONE OF THE WORST LEAKS THEY HAVE SEEN. I HAVE NOW READ NUMEROUS COMPLAINTS ON THIS ISSUE AND NOTICED THE 2003 WRX, SAME ENGINE, WAS RECALLED FOR THIS SAFETY ISSUE. I GUESS I AM LUCKY AS IT COULD HAVE CAUGHT ME, MY HOUSE OR WHO KNOWS WHAT ON FIRE IF IT HAS SPARKED.
Fuel system, Gasoline, Feb 16, 2012
MY 2004 FORESTER XT (TURBO) DEVELOPED A SLOW GASOLINE LEAK, WITH GAS SEEPING FROM HOSES/CLAMPS LOCATED UNDERNEATH MANIFOLD. GAS FUMES WERE ENTERING THE CAB OF VEHICLE, ESPECAILLY WHEN OUT-SIDE TEMPERATURES BELOW 40 DEGREES F. THIS IS A SAFETY AND HEALTH HAZARD FOR DRIVERS AND PASSENGERS. THIS APPEARS TO BE THE SAME PROBLEM AS OUTLINED IN RECALL OF SUBARU IMPREZA WRX TURBO (RECALL #WVK-21), BUT TO DATE THERE ARE NO RECALL FOR THIS ISSUE FOR FORESTERS. I REENTLY HAD THIS FIXED AT A COST > $500, COST WAS PRIMARILY TO TAKE MANIFOLD OFF IN ORDER TO GET TO HOSES & CLAMPS WHICH HAD TO BE REPLACED. *TR
Fuel system, Gasoline, Feb 12, 2012
STRONG GAS/FUEL SMELL INSIDE CABIN AND ENGINE COMPARTMENT DURING VEHICLE WARM UP IN DRIVEWAY WHEN TEMP WAS IN LOW 20'S. UNABLE TO LOCATE LEAKING FUEL BUT SMELL IS NOTICEABLY STRONGER ON PASSENGER SIDE OF ENGINE BAY. VEHICLE WILL BE TOWED TO DEALER IN THE MORNING AS VEHICLE IS UNSAFE TO DRIVE. GAS VAPORS ARE EXTREMELY FLAMMABLE/EXPLOSIVE. I HAVE FOUND MANY SIMILAR COMPLAINTS POSTED ON THIS WEBSITE AND OTHERS. THIS SUGGESTS THERE MAY BE AN INHERENT DESIGN FLAW SINCE THESE VEHICLES ARE MARKETED TO OWNERS IN COLD WEATHER LOCALES. I HAVE CONTACTED SUBARU OF AMERICA VIA E-MAIL ABOUT THIS INCIDENT. TODAY IS SUNDAY AND NOTHING IS OPEN. *TR
Fuel system, Gasoline, Dec 26, 2011
STRONG RAW FUEL SMELL IN CABIN OF CAR DURING COLD START/COLD WEATHER. IT APPEARS THAT THE FUEL LINES SHRINK IN COLD WEATHER AND PULL AWAY FROM THE METAL FUEL LINES CAUSING VAPOR LEAK AS WELL AS FUEL LEAKS. THE PROBLEM IS THAT THE FUEL LINES ARE LOCATED UNDER THE INTAKE MANIFOLD AND ARE IMPOSSIBLE TO TIGHTEN UNLESS THE MANIFOLD IS REMOVED. THIS IS A HUGE SAFETY HAZARD. *TR
Fuel system, Gasoline, Nov 22, 2011
ON THE FIRST GENUINE COLD DAY OF THE YEAR (BELOW 40 DEGREES F) I NOTICED A STRONG FUEL SMELL COMING FROM MY AIR VENTS WHILE DRIVING. AS IT'S NOW MID NOVEMBER AND AVERAGES BELOW 40 DEGREES F I GET A STRONG FUEL SMELL AT EVERY COLD START UNTIL THE CAR WARMS UP TO TOP OPERATING TEMPERATURE. AFTER RESEARCHING THIS SYMPTOM, I DISCOVERED THAT IT'S VERY COMMON FOR THE FUEL CLAMPS UNDERNEATH THE INTAKE MANIFOLD ON THE PASSENGER SIDE TO LEAK WHEN COLD ON 2004 SUBARU FORESTER XTS. UPON FURTHER INVESTIGATION I DISCOVERED THAT THIS IS HAPPENING WITH MY CAR, AND IS POOLING FUEL ON THE ENGINE UNTIL WARM. AVERAGE ESTIMATE FROM DEALER IS $500. *TR
Fuel system, Gasoline, Other or unspecified, Oct 26, 2011
GAS LINES LEAK ON 2004 SUBARU FORESTER XT WHEN AMBIENT TEMPERATURES FALL BELOW 30 DEGREES FAHRENHEIT. SIGNIFICANT AMOUNTS OF FUEL LEAK INTO THE ENGINE AREA, AND STRONG FUMES ENTER THE PASSENGER AREA. NHTSA HAS ALREADY ISSUED A TSB ON THE SUBARU WXT REGARDING THE SAME PROBLEM. CONCERNED ABOUT FIRE HAZARD AND INHALATION OF GASOLINE VAPORS. VERY STRONG ODOR. COULD NOT CONTINUE TO DRIVE. *TT
Fuel system, Gasoline, May 4, 2011
FUEL ODOR NOTED IN PASSENGER COMPARTMENT STARTING 4/9/11, (137218 MI) 55 DEGREE AMBIENT TEMPERATURE, VEHICLE RUNNING FOR 10+ MINUTES AND UP TO TEMPERATURE. AT STOP LIGHT WHEN ODOR BEGAN. CHILDREN IN THE VEHICLE BECAME NAUSEATED AND BEGAN RETCHING. WINDOWS DOWN TO VENT PASSENGER COMPARTMENT. ODOR IDENTIFIED IN PASSENGER COMPARTMENT AND ENGINE BAY ONLY, NO RAW FUEL ODOR IN EXHAUST OR SURROUNDING THE VEHICLE. 4/11/11, 52 DEGREES, 137463 MI 4/13/11, TIGHTENED ACCESSIBLE FUEL LINE CLAMPS IN ENGINE BAY 4/27/11, 40 DEGREES, 138113 MI 4/28/11, 53 DEGREES, 138215 MI 4/30/11, ISOLATED LEAK TO AREA IMMEDIATELY BELOW MANIFOLD, NEAR AIR FILTER ON LEFT SIDE (PASSENGER SIDE) OF ENGINE; ABLE TO VISUALIZE FUEL LEAKING ONTO ENGINE AT RATE OF 5 DROPS/10 SECONDS. 5/1/11 45 DEGREES, 138511 MI CONCERNS OVER SAFETY OF EXPOSED FUEL IN ENGINE BAY (EXPLOSION HAZARD), AS WELL AS EFFECT OF FUMES ON ADULTS/CHILDREN (TOXICITY), AND NON-COMPLIANCE WITH EPA STANDARDS. TO CONTACT SUBARU OF AMERICA TO DISCUSS OPTIONS FOR REPAIR/REPLACEMENT OF AFFECTED PARTS
Fuel system, Gasoline, Apr 1, 2011
IN VERY COLD TEMPERATURES (BELOW FREEZING), THE FUEL LINE UNDER THE INTAKE ON THE PASSENGER SIDE WILL OCCASIONALLY LEAK AT THE CONNECTION BETWEEN THE RUBBER HOSE AND STEEL LINE. IT WILL DRIP FUEL ONTO THE ENGINE BLOCK UNTIL IT WARMS UP. THE SMELL OF GASOLINE CAN BE DETECTED INSIDE THE VEHICLE AND AROUND THE ENGINE AREA. THE FUEL DRIPS AT A RATE OF ABOUT 1 DRIP PER 1-3 SECONDS UNTIL THE HOSE WARMS UP AND SEALS AGAINST THE STEEL LINE. THE DEALER COULD NOT DUPLICATE THE PROBLEM, BUT THEY OFFERED TO TIGHTEN THE FUEL LINE FITTINGS. THE INTAKE MANIFOLD HAD TO BE LIFTED AND THE COST WAS ABOUT $150, BUT THEY COULDN'T GUARANTEE A FIX. IT WILL HAVE TO BE RECHECKED IN COLDER WEATHER. THIS 2004 FORESTER XT HAS 70,000 MILES ON IT. *TR
Fuel system, Gasoline, Mar 3, 2011
GAS LINES LEAK ON 2004 SUBARU FORESTER XT WHEN AMBIENT TEMPERATURES FALL BELOW 20 DEGREES FAHRENHEIT. SIGNIFICANT AMOUNTS OF FUEL LEAK INTO THE ENGINE AREA, AND STRONG FUMES ENTER THE PASSENGER AREA. NHTSA HAS ALREADY ISSUED A TSB ON THE SUBARU WXT REGARDING THE SAME PROBLEM. CONCERNED ABOUT FIRE HAZARD AND INHALATION OF GASOLINE VAPORS. *TR
Fuel system, Gasoline, Feb 11, 2011
1ST ISSUE WITH 2004 FXT 4AT . COLD START EMITTING RAW FUEL SMELL BOTH IN AND OUTSIDE OF CAR. LOCAL SHOP DIAGNOSED AS WEAK CONNECTIONS ON FUEL FILTER. FILTER NEEDED REPLACEMENT IN 5,000 MILES, SO OPTED TO SWAP OUT TO A NEW OEM FILTER. NEXT DAY SMELL STILL PRESENT. TEMPS BELOW FREEZING FOR PAST 6 WEEKS (MICHIGAN), BUT PROBLEM ONLY STARTED 1 WEEK AGO. SINCE PROBLEM PERSISTS, DOING MORE RESEARCH, AND WILL CONTACT SOA AND LOCAL SUB DEALER FOR ASSISTANCE AND PLAN. NO OTHER FUEL COMPLAINTS (KNOCK, STALL, ROUGH IDLE, ECONOMY ISSUES). CURRENT MILEAGE 109,000. *TR
Fuel system, Gasoline, Vehicle speed control, Feb 2, 2011, crash
WE OWNED A 2004 SUBARU FORESTER FOR 6 YEARS. 2 YEARS AGO I EXPERIENCED AN INCIDENT WHERE STARTING OUT THE ACCELERATOR STUCK AT AN ADVANCED RATE OF SPEED. I WAS ABLE TO QUICKLY GAIN CONTROL AND BRAKE THE VEHICLE AND THOUGHT IT WAS AN ABERRATION. RECENTLY ON STARTING OUT FROM A FERRY BOAT THE ACCELERATOR AGAIN STUCK AT AN ADVANCED RATE OF SPEED. I AVOIDED PEOPLE AND MANY CARS BUT DID COLLIDE WITH A WALL AND 1 CAR, FINALLY STOPPING THE SUBARU BY DRIVING UP A HILL, OVER A CURB AND INTO A FENCE. I HAD MECHANICS CHECK THE ACCELERATOR SYSTEM. THEY SAID THEY COULD FIND NO DEFECT IN THE SYSTEM BUT THAT OTHER FACTORS COULD CONTRIBUTE TO "STICKING" SUCH AS FAULTY FLOOR MATS OR PLACEMENT OD BRAKE AND/OR ACCELERATOR PEDALS. I AM NOT AN EXPERT BUT MY EXAMINATION INDICATES (1) THERE IS APPROXIMATELY 2 INCH GAP BETWEEN THE FRONT OF THE ACCELERATOR PEDAL AND THE FLOOR (2)THAT T HE BRAKE AND ACCELERATOR PEDALS ARE QUITE CLOSE TOGETHER; AND THAT A FOOT COULD BECOME "HUNG UP" OR LODGED BECAUSE OF EITHER OR BOTH OF THESE THINGS. THIS POSSIBILITY COULD BE INCREASED BY LARGER FEET, ALTHOUGH I DO NOT CONSIDER MY SIZE 11 WIDTH EE SHOE SIZE TO BE OVERLY LARGE. MY NON-EXPERT OPINION IS THAT THESE PEDALS SHOULD BE RE-ENGINEERED SO THAT (1) THERE IS NO GAP OF THE ACCELERATOR TO THE FLOOR (2)THERE IS A CLEAR SEPARATION OF THE BRAKE AND ACCELERATOR PEDALS. *TR
Fuel system, Gasoline, Feb 1, 2011
STRONG SMELL OF GAS INSIDE THE CAR IN COLD WEATHER. REPLACED AND TIGHTENED FUEL CLAMPS, TO NO AVAIL. A RECALL WAS ISSUED FOR THE SAME SYSTEM ON THE WRX, WHY NOT THE FORESTER? *LN
Fuel system, Gasoline, Jan 23, 2011
STRONG ODOR OF RAW GASOLINE IN CABIN DURING COLD WEATHER WHEN VEHICLE IS STOPPED. SEEMS TO BE THE FUEL LEAK IN THE ENGINE COMPARTMENT THAT MANY OTHER SUBARU FORESTER XT OWNERS ARE EXPERIENCING. *LN
Fuel system, Gasoline, Jan 13, 2011
2004 SUBARU FORESTER LEAKS FUEL DIRECTLY ONTO MANIFOLD IN CONDITIONS OF COLD AMBIENT TEMPERATURE. RESEARCH REVEALS THE PROBLEM IS ENDEMIC TO VIRTUALLY ALL SUBARUS MODEL YEARS 2002 - 2004. IN 2009, SUBARU ISSUED A RECALL FOR 2002 IMPREZA WRX MODELS SOLD IN CERTAIN STATES, BUT THE ENGINE IS THE SAME DESIGN FOR THE OTHER MODELS. STRONG ODOR OF FUEL IN PASSENGER COMPARTMENT IS SYMPTOMATIC. STRONG RISK OF FIRE. ODOR ABATES WHEN ENGINE AND/OR AMBIENT TEMPERATURES RISE. *TR
Fuel system, Gasoline, Jan 5, 2011
1. NOTICED STRONG GAS ODOR AFTER DRIVING CAR. UPON INSPECTION, NOTICED GAS POOLED ON ENGINE TOP, PASSENGER SIDE, UNDER INTAKE MANIFOLD. 2. APPEARS THAT FUEL LINE IS LEAKING. UNABLE TO ASCERTAIN EXACTLY WHERE, BECAUSE LEAK IS BEHIND INTAKE MANIFOLD. OCCURS DURING VERY COLD WEATHER. 3. REPAIRS FORTHCOMING. *TR
Fuel system, Gasoline, Dec 28, 2010
STRONG GAS ODOR WHEN CAR IS STARTED IN COLD TEMPERATURES. *TR
Fuel system, Gasoline, Dec 22, 2010
RAW FUEL SMELL IN CABIN DURING COLD START. TOOK TO MECHANIC AND HE SEES FUEL LEAKING FROM THE FUEL LINE UNDER PASSENGER INTAKE MANIFOLD. TO RESOLVE ISSUE HE WILL HAVE TO PULL THE INTAKE, REPLACE FUEL LINES AND USE BETTER CLAMPS. THE CLAMPS AND HOSE USED BY SUBARU IS FAULTY AS I SEE A TON OF COMPLAINTS ONLINE ABOUT THE SAME ISSUE. THEY EVEN DID A RECALL ON THE WRX WHICH HAS THE SAME MOTOR AS THE FORESTER.
Fuel system, Gasoline, Dec 15, 2010
TL*THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT AS THE TEMPERATURE STARTED TO DROP HE NOTICED FLUID LEAKING FROM THE ENGINE. HE INSPECTED THE VEHICLE AND REALIZED THAT THE HARD FUEL LINE WAS LOOSE. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.
Fuel system, Gasoline, Dec 8, 2010
I OWN AND DAILY DRIVE A 2004 FORESTER XT. IT HAS RECENTLY DEVELOPED WHAT I CONSIDER TO BE A SEVERE SAFETY RELATED ISSUE. LAST NIGHT, AFTER DRIVING APPROXIMATELY 30 MINUTES, THERE WAS AN OVERWHELMING SMELL OF RAW FUEL IN THE CABIN. THIS SITUATION HAPPENED AGAIN THIS MORNING WHILE SITTING IN TRAFFIC, AT A RED LIGHT. THE SMELL OF GASOLINE WAS SO STRONG, I FELT LIGHT HEADED AND HAD TO ROLL DOWN THE WINDOWS WHEN THE TEMPERATURE OUTSIDE WAS 24 FAHRENHEIT. I FOUND THAT SUBARU OF AMERICA (SOA) ISSUED A RECALL FOR THE SAME PROBLEM ON WRX MODELS WHICH PRODUCED THIS SYMPTOM. UPON INSPECTION OF MY ENGINE, I CAN BOTH SEE AND SMELL RAW FUEL SEEPING FROM ONE OR MORE OF THE FUEL LINES. I CONTINUED MY RESEARCH AND FOUND THAT THERE ARE MANY REPORTS OF THIS ISSUE COVERING MANY YEAR MODELS OF THE FORESTER AND THE LEGACY MODELS. DUE TO THE VOLATILITY OF GASOLINE AND THE INHERENT DANGERS TO HUMANS IN VAPOR FORM, I FEEL THIS IS A CRITICAL SAFETY ISSUE. I HAVE READ MANY REPORTS AND NOTICED THE APPARENT LARGE POPULATION OF AFFECTED VEHICLES. THIS IS VERY DISCONCERTING. I AM CONTACTING SOA TO REPORT THIS PROBLEM AND TO REQUEST THEY COVER THE FAILURE UNDER GOODWILL. *TR
Fuel system, Gasoline, Dec 1, 2010
TL*THE CONTACT OWNS A 2004 SUBARU FORESTER XT. THE CONTACT STATED THAT DURING COLD WEATHER HE WOULD SMELL GASOLINE FUMES INSIDE OF THE VEHICLE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED STATED THAT HE HAD A LEAK IN HIS FUEL LINE FROM THE HOSE ON THE FUEL RAIL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000. THE VIN WAS UNAVAILABLE. UPDATED 02/02/11 *CN
Fuel system, Gasoline, Mar 1, 2010
DURING THE BEGINNING OF THE YEAR, A VERY STRONG FUEL SMELL FILLED THE CABIN OF THE CAR. IT WOULD SOMETIMES GO AWAY AFTER A HALF HOUR OF DRIVING. IT SEEMED TO COINCIDE WITH THE OUTSIDE TEMPERATURE BEING BELOW FREEZING. BROUGHT CAR IN FOR SERVICE. THEY TIGHTENED FUEL CLAMPS AND REPLACED A SMALL FUEL LINE. A FEW WEEKS LATER THE SMELL RETURNED EVEN MORE INTENSE. IT WAS SCARY TO DRIVE, ESPECIALLY WITH MY TODDLER IN THE CAR! TOOK CAR IN FOR SERVICE AGAIN. THEY REPLACED ALL FUEL INJECTORS/ORINGS/SEALS AND INTAKE AND EXHAUST GASKETS. REPAIRS TOTALED OVER $1,000. PROBLEM FIRST OCCURRED AT 105,000 MILES. (ONE MONTH EARLIER THE TURBO HAD TO BE REPLACED...A REPAIR TOTAL OF $3,300. FOR OVER A YEAR THERE'S ALSO BEEN A PROBLEM WITH THE CAR CONSTANTLY NEEDING OIL, BUT THERE'S NO LEAK.) I'VE READ COMPLAINT AFTER COMPLAINT FOR THE FUEL SMELL PROBLEM ON MANY SUBARU FORUMS. WHY HASN'T THERE BEEN A RECALL FOR THIS SAFETY HAZARD?? *TR
Fuel system, Gasoline, Feb 26, 2010
EVERY TIME THE TEMPERATURE DROPS BELOW FREEZING A STRONG FUEL SMELL FILLS THE INTERIOR. SOMETIMES THE SMELL GOES AWAY WHEN THE ENGINE WARMS UP, SOMETIMES IT DOESN'T. NOTHING HAS BEEN DONE TO FIX THE PROBLEM. *TR