2018 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 1,025 owner complaints filed for this model year. This is the highest complaint count among 9 Model 3 model years with reports.
Of the 2018 reports, 102 involved a crash and 4 involved a fire. 44 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Representative owner complaints: electrical system
168 reports, newest first. Show all
Electrical system, Feb 14, 2025
Power Coversion System (PCS) failed on vehicle Causing issues with charging No User facing errors to alert of issues prior to problem (hidden in service menu) - preventing owners from claiming under basic 50k mile warranty. Stated as not part of HV Battery warranty and replacement is ~$2000 Advised to replace or could leave car unusable.
Electrical system, Seat belts, Jan 20, 2025
Warning message appeared on center screen stating: "Front left safety restraint system fault". This appears to be a safety related problem , Tesla dealer wants $500 to repair because the vehicle is "out of warreanty" . This is the second Model 3 we have had. Previous version also experienced this fault. Is this a safety problem and if so should the car manufacturer be responsible to repair at no cost to owner? I have receoved a notice from NHTSA dated 5-31-2024 stating recall 24V376 may affect my vehicle - Seat Belt warning Sustem. I have not receoved a specific recall from tesla for this recall. Is it the same as the fault referenced above?
Electrical system, Air bags, Dec 21, 2024
Passenger Safety Restraint system fault. Faulty wiring under the seat. Cost of repair is $1000. Passenger airbag requires replacement.
Electrical system, Vehicle speed control, Other or unspecified, Dec 17, 2024
I’m not exactly sure what’s wrong, the screen keeps failing on my car. It’s been taken to Tesla to service this issue 4 times. With the most expensive repair costing $2,200. Its poses a safety hazard because when the screen fails. You can’t see anything, speed, gear. You can’t adjust windshield wipers, seat or mirror positions.
Power train, Electrical system, Dec 6, 2024
Power conversion system (PSC) failure. Only charges at 16 amps. I know other Tesla owners have had this problem as well.
Suspension, Electrical system, Seat belts, Nov 25, 2024
1. I had my car for only 6 years, and the main monitor would randomly go black. I have to do multiple hard resets to get it to work again. 2. I'm getting a Front left safety restrain system fault, on a car that I had only for 6 years. Compared to my Prius that I had more than 10 years, which I had no problems AT ALL, Tesla is junk. 3. Front suspension is squeaking when making turns at slow speeds. Review of YouTube indicates that this is a very common problem. Tesla should fix this for free instead of charging $800.
Power train, Electrical system, Other or unspecified, Nov 15, 2024
ISSUE: PTC Heater failed at 63,617 miles after 6 years of use WARNING MESSAGE: "Vehicle may not restart" CONTACT: [XXX] [XXX] main contact for owner [XXX] . VIN: [XXX] MAKE: MODEL 3 YEAR: 2018 REPAIR QUOTED: $1,104.18 LINE ITEMS: PTC HEATER DUALZONE(1088218-00-I) HVAC, PTC SERVICEASSY(1107677-00-A) LABOR & DIAGNOSTICS SUMMARY: TESLA Model 3 Electric Vehicle shut down into "Asleep mode" and will not respond (turn back on). Locked out. Will not wake up. Will not respond to software nor car keys. All systems turned off. Will not charge. Will not release charger from charge port. Issue suddenly happened after [XXX] software load (deemed to not be the cause of issue). Dealership diagnostic shows PTC Heater failure which cuts off the battery. Dealership quoted estimated repair (see below). This could have happened while driving causing the vehicle to be uncontrollable, and a major safety issue. Fortunately, my incident happened after I parked the car in the garage. Overnight there was a software install (supposedly not causing the problem). In the morning the vehicle would not turn on. PRECEDENT: There were several small claims filings in Canada for same issue. This was deemed a design flaw, and safety issue. (See [XXX] ) DIAGNOSTICS: On-line debugging is pointing to resistance issue with 1 of the 5 heating elements in the PTC Heater. PTC Heater cuts off supply to PCS which charges the 12V battery when there is an issue with the heater. This allows the 12v battery to drain, and the EV becomes unresponsive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Nov 11, 2024
RECALL NEVER COMPLETED FOR MY CAR. WAS FROM 2021. WORRIED THAT REAR CAMERA MAY FAIL AND CREATE A DANGEROUS SITUATION.
Electrical system, Other or unspecified, Service brakes, Oct 3, 2024
Seems that when brake pedal sensor can trigger a "pressed" reading when not actually being pressed. The only way to turn off the car manually is defeated by, you guessed it, depressing the brake pedal. This causes the vehicle to remain on and unlocked. Even if you are able to leave the vehicle in a locked park state, at any point, the sensor can register a "pressed" reading and essentially unlock and turn on the vehicle. I see this as a extremely serious safety issue. The issue seems to occur randomly at first and then more frequently. It can be confused with a known seat sensor issue which seems to also cause the same symptoms.
Electrical system, Oct 2, 2024
Tesla model 3 Power Conversion System failure which will now limit the car charging to 16 amps (half the normal charge rate). This is a common failure which should be recalled
Electrical system, Aug 31, 2024
The car's horn has stopped working. A car was entering my lane almost running me off the road and I could not alert the other driver because the horn wouldn't work. The car has not been inspected by the dealer, police or insurance yet. I received no warning lights or messages before the failure. problem was recognized on 8/30/24. This seems to be a known issue that Tesla has not addressed. Estimate they have given for repairs is $195.00
Electrical system, Seats, Aug 27, 2024
RCM_a021 Front left safety restraint system fault RCM_a056 Front passenger safety restraint system fault I have been noticing this error on my Tesla Model 3. Also, I researched on it and found out numerous people are having same problem. So, since it’s safety related issue there should be recall to fix it.
Electrical system, Seat belts, Seats, Jul 8, 2024
getting a "front left safety restraint fault" warning when moving the driver seat...is a known issue in tesla forums where the seat wiring harness is not secured properly and either a wire is crimped by the seat mechanicals or a wiring harness is pulled loose...
Electrical system, Air bags, Seat belts, Jul 3, 2024
Starting Jun 15 2024 an error came up saying "Left Restraint System fault" after a remote software update for Model 3 2018 Tesla The Alert comes up intermittently & Tesla requires $359.50 to change First Row Seat Harness Assembly - Left
Electrical system, Jun 17, 2024
The contact owns a 2018 Tesla Model 3. The contact stated that while driving at various speeds, the vehicle independently accelerated with an unknown message displayed on the Phone APP but not on the instrument panel. The contact also stated that a screw had detached from the undercarriage which resulted in an abnormal, squeaking noise coming from the vehicle while driving at various speeds. Additionally, the contact also stated that the automatic walk-away lock feature intermittently failed to operate as needed; as a result, the vehicle remained unlocked while away from the vehicle. The vehicle had been taken to a Service Center for repair; however, the failures persisted. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
Electrical system, Visibility/wiper, Jun 1, 2024
1. There is an open recall since Dec 2021 (21V-00D) which Tesla has still not fixed! 2. The automatic wiper system on the car is unsafe as it takes a long time to activate when its raining, and sometimes it activates without any rain!
Electrical system, Air bags, Seats, May 9, 2024
While driving normally, an error warning was received that stated "Front Left Safety Restraint System Error" and the icon for an airbag fault would come in simultaneously. This error would disappear and reappear, sometimes up to 10 times per minute, creating a driver distraction due to the loud error chime. The error code identified for the fault when checked on the Tesla service screen corresponded to pretensioner wire harness. The pretensioner harness connects the seat sensors for driver weight and positioning to the car's airbag control system, which then classifies passengers and ensures that the airbags fire correctly in the event of a collision. For example, if a smaller female driver was operating the car but was incorrectly classified as male, the airbag could fire with excessive force and cause injury. The set of symptoms occurs commonly in Tesla Model 3s and are caused by the wear over time of a poorly designed wiring harness, which chafes as the seat is moved forward and backward until it breaks. This is a known problem by Tesla and they have a specific service bulletin designed to address it, which I have attached below. When taken in to address the issue, Tesla performed the procedure in the attached bulletin and identified a damaged harness, which was subsequently replaced. I retained the damaged harness for inspection. The invoice for this service is attached. No other defects were identified that could have caused the issue. This is a safety related issue occurring due to a manufacturing related defect and should be a mandatory recall with complimentary repair.
Steering, Electrical system, Apr 14, 2024
I have a 2018 Tesla Mode 3. It is one of the early Model 3 on roads. I have had around 10 issues in the car over the past 6 years of ownership; and most of them were fixed during warranty. My car has no accidents, no water damages (only hand washed), single driver driven and well maintained. Around a month ago, I got an alert in the car “Condition Detected with Controller”. Tesla Service did remote check and stated that VCFRONT (Front Body Controller) needs to be replaced for $900. I took the car for this fix and then heard that VCFRONT Controller is fine, but I need a replacement of Harness and Steering Rack for $4200, as they see corrosion. I told them that I have no issues with driving or anything else, as $4200 is around 25% of the value of the car. I was advised, pay for this amount or take the car. I got my car without fix. My concern include (i) if this is corrosion issue (Model S 2018 and before also had the same issue and there was a recall), then is it their part quality or design quality issue or is it a normal car’s aging issue? (ii) I see malpractice of charging exorbitant $4200 for something I do not see any issues in driving or anything else, and importantly, not sure how are my future repairs going to look like $$ wise. I have request for NHSTA – can I show my car to any entity like yours (and not Tesla Service) to get an advise whether (a) this is a corrosion issue by manufacturer or normal car’s aging issue (b) is it critical car to replace one or both parts (c) is this a malpractice to burden owners with this high cost of maintenance, once it is out of warranty? (Please note that Tesla never offered extended warranty for my car)
Electrical system, Exterior lighting, Mar 21, 2024
The turn signal stalk does not differentiate between a partial (lane change) press or a full turn press. The signal will remain on until the stalk is moved in the opposite turn direction. This sometimes results in the opposite turn signal activating. This entire process is intermittent while driving. This happens mainly on the highway where an intermittent (half press) of the stalk is performed to switch lanes. When switching lands I have no idea whether it'll work as designed or fail to register a half press or full press of the stalk.
Electrical system, Other or unspecified, Latches/locks/linkages, Mar 19, 2024
I am unable to open my rear passenger car door from the outside or the inside. Also the rear passenger door also lacks a manual release like the front doors have. This, coming off of [XXX] 's death, and Tesla's service apathy and insistence on first collecting money before solving this problem is incredibly dangerous. So I am now driving a death trap, and this is my only car, and Tesla should have to pay for the fix, yet they are insisting I pay for the full price because my car is now "out of warranty." But with this kind of LIFE-THREATENING failure of a door that should honestly just work, is reprehensible. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Mar 12, 2024
The contact owns a 2018 Tesla Model 3. The contact was made aware of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention). The contact attempted to schedule an appointment for a recall repair on the Tesla App however, the app displayed an error “Unnecessary to schedule an appointment; You will be notified when parts are available" since June of 2023. The local dealer was contacted but confirmed that the recall repair needed to be scheduled via the Tesla App. The contact attempted to reach out to the manufacturer but was unable to reach a representative. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Back over prevention, Mar 8, 2024
The contact owns a 2018 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention), 23V838000 (Electrical System), and 24V051000 (Electrical System); however, the dealer stated that to perform the upgrades, the contact needed to purchase a new computer before the software could be updated. The contact called the manufacturer and was informed that it would be necessary to complete the updates. The contact stated that the manufacturer was unreasonable in determining that to complete the software updates that he needed to purchase a new computer. The contact stated that the back over prevention camera image intermittently was blank. Additionally, the on-board cabin camera ceased to function as needed, causing the autosteer feature to become inoperable. The failure mileage was approximately 130,000. Parts distribution disconnect.
Power train, Electrical system, Other or unspecified, Feb 26, 2024
PTC Heater failed. This is a critical component that helps to maintain the battery's temperature within safe operating range. The only alternative is to replace this PTC Heater. Till the replacement is done, EVs battery may not maintain safe operating temperature range and could cause the car - not drive able. I consider this a significant safety risk. Cabin temperature cannot be maintained as well. Cause for PTC Heater failure is known - "change in temperature" could cause this item to fail per Tesla. i.e. when cold air blows over the heating element. Not sure if enough has been done to fix this from occurring for such a critical component with some hardware or hardware recall for several vehicles on the road. Else these cars must be considered for sales only for few states in the USA which have a stable operating temperature ranges for their PTC heaters to not run into the risk of failure due to big change in temperature.
Power train, Electrical system, Feb 25, 2024
The High Voltage Service Panel is part the battery which is part of the manufacturer warranty and drivetrain. A lot of Tesla cars had this problem and they are being charged $1800 to $2000 to “fix” this common failure. The problem is that the battery stop receiving the full amperage to charge the battery appropriately. In my case, I started charging more frequently on Superchargers during a long trip to different locations without a Level 2 homecharger and stopped several times into the Superchargers of Tesla. A diagram of the drivetrain and Battery system placed the High Voltage Service Panel as part of the battery. I had the problem since the past 2 years and did not fixed it, after I was sent an estimate cost of “repair”. I said that it was part of the battery system and they refused to accept it. As of 2024, I have search about this problem and most of the cars after 3-4 years are having the same problem. I am not sure what the repair consist of, but it might be a full battery replacement, and maybe opening the battery unit. In terms of safety, I feel unsafe about the possibility of the car catching fire during a supercharger session or even when plugged into my house Level 2 charger at 220 volts. Please inquire more about this frequently ongoing problem and safety, or any TSA related to this common issue. I included a picture found on the internet and the service panel is just on top of the battery
Electrical system, Other or unspecified, Feb 20, 2024
The steering wheel horn stopped working about a month or so ago. I can use the Tesla app to make the horn sound but not by pressing the steering wheel. Fortunately, no safety of others or myself have been experienced. No one else has inspected it yet, though I am due to have my state inspection tomorrow and I don't think that it will pass. There were no warning lamps for messages prior to the failure. I think I first noticed that it wasn't working about a month or so ago. I reported the bug on the car texting service but have not heard from Tesla nor received a software update to fix the problem.