2019 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 614 owner complaints filed for this model year. This is the 4th highest complaint count among 9 Model 3 model years with reports.
Of the 2019 reports, 60 involved a crash and 5 involved a fire. 30 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Equipment, other, labelsOct 10, 2019
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Failure to provide the air bag warning information increases the risk of injury.
Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Campaign 19V719000 on NHTSA.gov
Representative owner complaints: electrical system
91 reports, newest first. Show all
Electrical system, Air bags, Seats, May 22, 2024
The car has a feature which adjust the seats for easy entry and for a driver based on driver profile. This results in the drivers seat to automatically adjust per profile. It seems overtime this damages a cable or connection under the seat, resulting in a fault in the sensor which recognizes a driver being present in the seat in case of emergency, ie determines if it should deploy airbag. Right now our car is showing this error and it’s only present when the seat adjust for my partner who is a shorter driver. Tesla has stated previously that this would be around $250 to repair, could only do it in person at the repair center. Online I’ve seen reports of onsite techs making the repair in less that 5 minutes with no or minimal charge for a replacement sensor or cable.
Power train, Electrical system, May 7, 2024
Tesla Model 3 battery pack coolant connector design flaw. It is made by plastic and covered with very thin cheap plastic cover which can very easily create impact and break the battery pack connector when any small objects hit front wheels(both side) while driving that leads the following safety and hazard issues to driver and passengers. 1. When there is hit in the coolant connector while driving the coolant start leaking which put safety of car,driver,passengers and others in very high risk 2. When it happens the dashboard shows the car is running reduced power and not giving enough info to take immediate action 3. This issue can be easily reproducible just driving the car in freeway where the road has debris or due to work zone 4. This issue reported to Geico Insurance 5. There is no warning before it first appears 6. It leads to change the entire battery pack which cost ~ $20,000 7. Since this is very critical component it should be well protected which is not the case currently
Electrical system, Visibility, Back over prevention, May 1, 2024
The contact owns a 2019 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Apr 4, 2024
The contact owns a 2019 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System); however, the part to do the recall repair was not yet available. The local Tesla Service Center was contacted and informed the contact that the recall repair could not be performed on the vehicle due to the hardware of the vehicle. The dealer informed the contact that the recall repair required hardware 3.0; however, the vehicle hardware was 2.5. The dealer charged a fee to update the hardware. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and made the same assessment. The contact had not experienced a failure. VIN tool shows no open recall.
Electrical system, Mar 25, 2024
Since Summer/Fall 2023, 2019 Tesla Model 3 software appears to have been compromised. The vehicle shows entirely incorrect directions, at times having taken me 24 miles out of the way; shows a Subdivision in Baltimore, MD named "[XXX] Heights" and a business in Woodbridge, VA named "David's [XXX] Pole Waxing"; has removed all charging stops at certain times and then showed all charging locations in a Metropolitan area as "busy", has rolled down windows at random in 17⁰ weather to the point of having to hold the window toggle up with one hand while driving, is operating windows in reverse; shows an overlay on the screen where the white speed limit sign sometimes changes the size of the square; shows an overlay on the app, and has at times locked me out of the car entirely (seemingly remotely). The heated seats had overheated at other times and had left burns on my back. Tesla denies that the software and/or app have been compromised and claims that the currently-installed software is the original factory software without having inspected the car. Tesla twice now has declined to inspect it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Electrical system, Other or unspecified, Mar 19, 2024
Power steering and regenerative braking was intermittently work. Steering fully locked up while driving 70 m/hr on a freeway when I was on my way to service appointment. Very scary!! Service detected full steering rack replacement. When they took off the cable connectors water came pouring out. Water ingress caused corrosion to the body harness connector where it connects to the steering rack module. This seems to be an issue on online forums. Clearly this is a design flaw. How is water getting in and destroying all the electrical? Very unsafe and how is this issue going to be fixed so water doesn’t continue to get in
Electrical system, Visibility/wiper, Back over prevention, Mar 19, 2024
The rear view camera has not functioned properly for several months. We did have the rear harness recall work completed, but the camera was working fine at that time and stopped working in Nov sometime after a software update. This is VERY similar to 24V-035, except that is on 2023 year models only. Why is that campaign limited to 2023 only? There are a lot of complaints on the internet about this issue, and in some cases Tesla charging $3500 to replace a computer in the car. We also have the full automatic driving, same as in the 2023 models recalled. This issue seems to be related to this update, or one about that time period: [XXX]. [XXX] [XXX] I have tried all the wizardry and voodoo mentioned across the web and no results. The rear camera DOES work in live vire mode and in the service mode camera preview - so I know it works. It just does not work while driving/in reverse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Mar 19, 2024
Vehicles cabin heater High Current Failure after software update. Software Version: 2023.44.30.14 Vehicles cabin heater was functioning properly the morning of the software update. Over-the-air update was made and an electrical smell filled the cabin after update and heater no longer functioned. Alert codes indicate Resistive Heater Fault. I reported issue to Tesla and the repair cost is $1,055.80 and not covered. I have checked Tesla message boards and this update has caused other similar malfunctions.
Electrical system, Feb 14, 2024
The contact owns a 2019 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.
Electrical system, Feb 12, 2024
I am writing to express my serious concern and to file a formal complaint regarding a critical issue with my Tesla vehicle, specifically related to the Power Conversion System (PCS). I have recently been informed by Tesla’s diagnostic team that the PCS in my vehicle has malfunctioned and requires replacement. This is particularly alarming given the vehicle's relatively low mileage and my previous history of reporting charging issues. For your reference, the key details are as follows: Vehicle and Issue Identification: The vehicle in question, which I took delivery of in May 2019, is now experiencing a significant reduction in charging capability, only charging at 16A instead of the expected 32A. This issue has persisted despite earlier assurances that the problem was with the wall charger, a claim which now seems inaccurate. Mileage and Usage: My vehicle has only covered approximately 29,000 miles, which casts doubt on the wear-and-tear argument for such a critical component failure. Safety and Recurrence Concerns: While I am currently not aware of any direct safety issues, the recurrence of this problem among other Tesla owners is worrying and suggests a potential pattern of technical shortcomings. Cost of Repair: I have been quoted a repair cost of $1,808/- by Tesla, which is a substantial amount, especially considering the vehicle's age and mileage. Given these points, I request a thorough re-evaluation of this matter. I strongly believe that this issue should be covered under warranty, or as a goodwill gesture, considering the vehicle's low mileage and the history of charging issues reported shortly after purchase. Furthermore, I urge Tesla to investigate if this is a wider issue affecting more vehicles, as it raises concerns about the reliability and durability of critical components in Tesla vehicles. The vehicle is available for inspection at your convenience. I expect a prompt response to this complaint, and I hope for a swift and satisfactory resolution.
Electrical system, Air bags, Feb 12, 2024
The car is showing a system failure of the passenger restraining system, including the airbag. Car is only five years old with 67,000 miles. This condition should be repaired by Tesla at no cost to the consumer for this early failure. Also, the air conditioning compressor has failed, it is part of the battery cooling system which may create hazard of overheating The battery. This repair should also be covered by Tesla since it is a safety feature. These two failures seem to be very common among Tesla owners as evidence by the multiple social media post on these failures, a safety recall should be implemented to provide these repairs, and no cost to the consumer. Thank you so much.
Electrical system, Other or unspecified, Feb 7, 2024
Error comes up replace auxiliary battery low voltage. And then it says vehicle may not start. I was told by the dealer where I bought the car that their a recall and I wanted to see if my vehicle is qualified. Which the dealer said it is. I can't drive my car and I do ride share with it please can you help me.
Electrical system, Feb 7, 2024
Twice in a span of six weeks my 2019 Tesla Model 3 simply stopped operating - dead stop. First incident was on a road trip over the Christmas holidays ([XXX]). We had stopped in suburban Chicago before continuing our trip home. The vehicle control screen went black and the vehicle ceased almost all operations. The vehicle could not be started nor put into a gear for towing. All functions accessed through the screen (virtually every function) was rendered inoperable. I called Tesla who told me that according to their computer systems the vehicle was active. The mercifully nearby service center said no fault was recorded by the computer log. They were able to get the screen reactivated and we continued our trip with no further incident and they weren't able to explain what happened. On Friday [XXX] the same thing happened in our garage. The vehicle was towed to Tesla. They diagnosed the issue to an electrical fault in the steering column which shuts the vehicle down. The remedy is a replacement of the entire steering column at a cost of $2100 plus labor. I don't know if this is a typical remedy for other manufacturers but this is quite a expensive solution for an issue unrelated to the steering function. From a safety perspective this was an astounding occurrence. If this winter was colder or we were in a more remote place we would have been in pretty big trouble not being able to activate the heat or any other function of the vehicle. I believe the totality of the shutdown makes this fault an extraordinary concern with an extraordinary price tag for Tesla drivers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Air bags, Seats, Jan 21, 2024
In July 2023 we started receiving airbag fault messages on the main screen, “Front Passenger Safety Restraint System Fault". Based on our research this meant that in the event of an accident the airbag would most likely not deploy. We tried to schedule service and due to a "bug with the recent update" we could not get the invoice through their app or schedule the actual service for over a week. After contacting Tesla multiple times we got scheduled and had to drive to a service center instead of mobile service coming to us. This turned out to be a known fault due to the lack of an Occupant Classification System (OCS) Filter Module on the 2017-2019 Model 3. We were charged $165.89 to install what should have been provided for free on a recall to all affected model years. Upon arrival to the center they told me it could end up costing thousands of dollars if they had to replace the airbags, wiring harnesses and other components. That car was about 4 years and 1 month old, and just under 70K miles at the time, so the airbag system should not be failing. Those costs could be prohibitive for some owners, causing them to drive with an unsafe car. Luckily the service center tried the cheapest option first, which was installing the filter that is now standard equipment on all 2020 model years and later. The fact that Tesla now installs that filter as standard shows that it is necessary, and should have been provided to all previous model years as a free recall. Details can be found in the service bulletin that Tesla has already submitted to NHTSA at [XXX] . If that link doesn't work it is [XXX] from [XXX], 2019. This is a known issue for the affected year models that is fixed with an OCS filter module on newer models, that can be installed in a short time on older models. The lack of that module puts users at risk of the airbags not deploying as designed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Jan 5, 2024
The contact owns a 2019 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System). The contact stated that the recall to be performed would not disable the "Auto-steer" function, however the Over the Air software update had disabled the auto steer. The contact stated that the manufacturer advised that to restore the auto steer feature the contact had to pay to do so. The contact stated that the manufacturer was not following the recall as stated. The manufacturer was made aware of the issue. The contact had experienced a failure of the auto steer function on the vehicle. The failure mileage was 71,817. Parts distribution disconnect.
Electrical system, Other or unspecified, Jan 2, 2024
Climate control unavailable. Unable to heat cabin. Ran test and received a PTC heater faulty. Vehicle is over 50K miles and no longer under warranty. Through research online. Many heating issues become available. Software and numerous PTC failures especially older vehicles that had similar issues with 30K, 40K, and 50K miles.
Electrical system, Air bags, Nov 7, 2023
Front right safety restraint system fault. Rear right safety restraint system fault.
Steering, Electrical system, Forward collision avoidance, Nov 1, 2023
Loss of steering power while driving on the highway. Came out of nowhere
Electrical system, Sep 30, 2023
After leaving my neighborhood, my car stopped working while I was turning. Everything went black, and I was unable to turn my hazards on and had to exit the vehicle using the emergency lever to open the door. The car was towed to Tesla. It had to be forced onto the tow truck, as you can only shift the gear to neutral if the car is on. We asked Tesla what the problem was in the service chat, and they said "Yes the rear drive inverter went out on it that goes to the rear drive unit." I have never heard of such a malfunction with Tesla. There was no warning to pull over. If this was on a highway or busy street, the car would have just died, which could have caused a major or fatal accident. This matter should be investigated promptly, as it is a major safety issue. There could have been a fatality if this had happened on a busy highway with speeding cars. When I say it stopped working without warning, I truly mean it. I was unable to turn on my emergency lights. The Tesla was totally unresponsive. I am truly scared to drive the car again, even if it gets repaired. The car only has around 20k+ miles. This should never have happened, and Tesla failed to give me a warning before the major malfunction occurred. Truthfully, I do not know if I will ever drive my Tesla again. I no longer trust the vehicle.
Power train, Electrical system, Aug 26, 2023
I have had multiple compressor issues since the car was made in 2019 and already replaced once. Now it is failing again and as the compressor is used to cool the powertrain it can degrade performance and who knows when my car could fail while on the road due to lack of cooling capacity.
Electrical system, Latches/locks/linkages, Aug 24, 2023
The contact owns a 2019 Tesla Model 3. The contact stated that upon entering the vehicle and closing the driver's side door, the doors locked and failed to open because the vehicle was experiencing an electrical failure. The contact stated that he engaged the driver's side door emergency door release lever, but the lever failed to operate as needed. The contact stated that the vehicle became hot, and he exited the vehicle through the trunk. The vehicle was towed to a Tesla Service Center, where it was determined that the 12V battery needed to be replaced. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was 23,969.
Electrical system, Visibility, Back over prevention, Jun 12, 2023
The contact owns a 2019 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Forward collision avoidance, Electrical system, Apr 24, 2023
The contact owns a 2019 Tesla Model 3. The contact stated that while driving at various speeds with the Autonomous Self Driving or Adaptive Cruise Control feature activated, the vehicle experienced phantom braking, causing the vehicle to abruptly stop in the middle of the roadway. The contact stated that the failure had occurred on several occasions without any other vehicles or objects nearby. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 28,000.
Electrical system, Visibility/wiper, Mar 19, 2023
The rear view camera of my car it’s failing intermittently some days work some days don’t. So I found that there is a recall related to this specific issue. NHTSA Recall Number 21V-00D then I scheduled a service with Tesla indicating that I’m sending the car for them to honor the recall. They accepted and scheduled the service appointment through the app at $0 cost because obviously it’s their responsibility. Well for my surprise when I arrive to the Tesla Service Center in Coral Gables Florida, the person in charge refused to honor the recall saying that the car it’s not in warranty and that they don’t perform services on recalls even though I was showing them that the recall it’s on my VIN number at the NHTSA website. Now I’m worried that I may cause an accident because the car may malfunction due to this safety issue with the rear camera. Find attached screenshots of the conversations I had with them where they are basically refusing to properly perform the service for this recall that includes the full inspection of the coaxial cable to see if it’s too damaged and the replacement of the part.
Electrical system, Feb 19, 2023
the PTC heater fails on a lot of the older cars leaving them stranded. The % of cars effected is alarming. This should be recalled to prevent people from being stranded in the cold.