2019 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 614 owner complaints filed for this model year. This is the 4th highest complaint count among 9 Model 3 model years with reports.
Of the 2019 reports, 60 involved a crash and 5 involved a fire. 30 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Equipment, other, labelsOct 10, 2019
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Failure to provide the air bag warning information increases the risk of injury.
Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Campaign 19V719000 on NHTSA.gov
Representative owner complaints: forward collision avoidance
169 reports, newest first. Show all
Air bags, Forward collision avoidance, Lane departure, Sep 21, 2026, crash
On September 12, 2026, at approximately 2:05 PM, while operating on Full Self-Driving (FSD v14.1 Lite) on Hardware 3 (HW3), the vehicle experienced a critical, unprompted loss of path control. While traveling on the highway, the vehicle sharply veered off the left side of the roadway, caught air, and violently impacted an emergency barrier, resulting in the destruction of 9 steel poles and causing physical injuries to both the driver and front passenger. Despite the severe frontal impact and structural collision, neither the front nor knee airbags deployed, raising serious concerns regarding the vehicle's crash-sensing algorithms, structural impact detection, and restraint system integration under this software version. This incident highlights major safety risks associated with running computationally heavy FSD stacks on legacy HW3 architecture: 1. Uncommanded Steering Deviations: The system abruptly executed a violent, unprompted hard turn away from the path of travel, indicating severe lane-detection or path-planning failure. 2. Restraint System / Safety Failure: Critical secondary safety systems (front and knee airbags) failed to deploy in a high-impact structural collision involving multiple steel barrier poles. 3. Hardware Constraint Risks: The compounding computational and thermal load on HW3 hardware running v14.1 Lite continues to manifest in erratic vehicle control, latency, and hazardous tracking behavior. This severe safety defect requires an immediate federal investigation into both FSD trajectory control on legacy hardware and secondary restraint deployment failures.
Other or unspecified, Forward collision avoidance, Lane departure, Jul 28, 2026
Tesla rolled out FSD 14 Lite to hardware, including to my vehicle and it’s become extremely unsafe.The past several days the vehicle will suddenly slow down/break causing people to almost crash into me, make sudden and indecisive lane changes, and constantly rocking the steering wheel left and right. I hope someone takes this seriously and has Tesla revert back to the old software or make changes before someone is killed.
Forward collision avoidance, Jun 4, 2026
I was using Full self driving (FSD), but I notice the autopilot gets "impatient" when (correctly) stopped for a "long" period of time (~2 minutes), but will then try to proceed in dangerous conditions. 1. I had FSD engaged while waiting to make an uncontrolled left turn. The street I'm turning onto is busy, so both lanes are going at a steady pace. After about 2 minutes of waiting, the autopilot decided to make the left turn while BOTH directions had cars approaching. It turned towards a motorcyclist (which might be why it thought the lane was "empty"), and cut off a rather large car behind the motorcycle which almost caused a collision. I was honked from both sides (rightfully so) and put in a very dangerous position as my car was now stopped in the middle of the row of both lanes. 2. I was at a red light intersection with no traffic coming from either side with FSD engaged. After about 2 minutes of waiting, the car tried to go on its own while the light was still red. After manually stopping the autopilot, the light naturally turned green a few seconds later.
Forward collision avoidance, Lane departure, May 14, 2026
Tesla FSD on HW3 vehicles has become very unstable. Users complain the car ping pongs within the lane and occasionally will steer onto the left or opposite lane. This seems to have happened after a recent update between Feb/March 2026. Growing reports of the same issue reported on Reddit. Ping pong tesla fsd Sources: r/TeslaFSD, r/TeslaLounge, r/TeslaSupport Tesla FSD Ping Pong Effect Software Updates Recent Updates: Many users have reported that the ping-pong effect started after recent software updates, particularly 2026.8.6 and 2026.14.3. "Yes, this started for me after the update to 2026.8.6 and continued on 2026.8.6.1" HW3 Issues: Some users with Hardware 3 (HW3) have noted that FSD has become unusable due to this effect. "I'm HW3 Software 2026.14.3 FSD Software V12.6.4 Driving on the highway is completely unusable and would result in a crash if I kept it on." Troubleshooting Steps Camera Calibration: Several users have suggested recalibrating the cameras, which can sometimes help. "Try a camera housing cleaning and a camera calibration" DAS Reset: Performing a Driver-Assist System (DAS) reset has also been recommended. "Also reset the DAS" Cleaning Cameras: Ensuring the cameras are clean can improve performance. "Ask SC or mobile service to check camera alignment AND clean the front cameras, and recalibrate cameras." Hardware Issues IMU/Gyroscope: A few users have been told by Tesla service that the issue might be due to a failing gyroscope/IMU in the HW3 Autopilot computer. "The tech told me it might be a failing gyroscope/IMU inside the HW3 Autopilot computer." HW3 Replacement: Replacing the HW3 computer can be costly, and some users are considering waiting for a HW4 retrofit. "Their solution is to replace the entire HW3 computer — quoted around $2,500–$3,000." User Experiences Ping-Ponging on Highways: Many users have reported the ping-pong effect specifically on highways. "While using FSD on higher speed interstates (multiple) my car acts like a
Lane departure, Forward collision avoidance, Apr 3, 2026, crash
I was involved in a collision while driving my 2019 Tesla Model 3. The incident occurred on April 2nd 2026 in [XXX] Prior to the collision, the vehicle was operating normally The crash resulted in damage to the front driver-side of the vehicle, including a destroyed headlight and body panel damage. At the time of the incident, weather and traffic was light and normal. The vehicle was set and supposed to head straight when suddenly at the intersection it jerked right and headed straight into another vehicle. I attempted to take control but was unable to due to resistance on the wheel and how quickly the incident occurred. There was no warning or emergency braking which should've also been expected from my tesla. I am submitting this report to document a potential safety concern and request review. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Forward collision avoidance, Feb 2, 2026
What component or system failed or malfunctioned, and is it available for inspection upon request? The steering system failed due to corrosion and water ingress affecting both the steering rack and the associated steering wiring harness. These components were replaced by Tesla and are no longer available for inspection. How was your safety or the safety of others put at risk? The steering system is a safety-critical component. Corrosion and water intrusion created a risk of reduced or sudden loss of steering assist while driving, which could lead to loss of vehicle control and increase the risk of a crash. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Tesla service confirmed water ingress and corrosion affecting the steering rack and wiring harness and performed a full replacement of both components. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes. The vehicle and steering components were inspected by Tesla at a Tesla Service Center, which identified water ingress and corrosion as the cause of failure. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The vehicle displayed steering-related warning messages prior to repair, including reduced steering assist alerts, which prompted inspection by Tesla service. The warnings appeared shortly before the repair was performed.
Forward collision avoidance, Oct 1, 2025, crash
Vehicle in front stopped suddenly. The car gave NO alert AND did NOT stop whatsoever. The tesla collided with the vehicle in front. **I have dashcam footage of the incident
Forward collision avoidance, Sep 28, 2025, crash
Vehicle: 2019 Tesla Model 3 Dual Motor VIN: [XXX] Mileage: ~84,041 Software: v12 (2025.32.6 e575ed98d527), FSD Supervised v12.6.4 Date/Time: [XXX], ~[XXX] Location: [XXX] Incident Description: While operating Autopilot, I was stopped at a stop sign preparing to turn right. I lightly pressed the accelerator to prompt the turn. At that moment, the vehicle would not respond to steering or braking input. Despite applying full force on the steering wheel and brake pedal, the car continued straight ahead and struck a street sign. This represents a loss of manual override — I was completely locked out of steering and braking. Prior Behavior at Same Location: On prior occasions using Autopilot at this same intersection, the vehicle would attempt to make the turn but then immediately steer itself into the breakdown lane. I had learned to expect this and was prepared to take over. However, in this most recent incident, the vehicle did not allow me to take over at all, which created a far more serious hazard. Result: •Vehicle damage (front bumper, sensors) •Significant safety risk if pedestrians or cross traffic had been present •Demonstrates that Autopilot can both mis-execute turns and, critically, fail to relinquish control when the driver intervenes Action Taken: •Scheduled Tesla Service (Cherry Hill, NJ – Oct 7, 2025) •Requested Tesla to preserve all telemetry, camera footage, and Autopilot logs •Reported to my insurance carrier as a suspected manufacturer defect Request: I am reporting this as a serious safety defect. A system that prevents manual override of steering and braking is unsafe and could cause severe injury or death. Please investigate Tesla Autopilot’s behavior at this location and in similar right-turn scenarios. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Service brakes, Back over prevention, Forward collision avoidance, Jul 7, 2025
[XXX]- [XXX]am. Trying to park in YMCA located in camp hill PA. Took soft right turn to park. Car accelerated instead of recognizing break, which I applied when I see it accelerating. Then I left break so it can take emergency break that didn’t happened it keep going and cross over the parking curb about six Torah inch high and went in a ditch. I did not hurt but car front damaged. Tesla was informed and they have the log of the time but told they don’t see any issue. My insurance is paying all the expenses. This was the third incident where car did not tool emergency break itself or recognized the break. I did reported last incident to Tesla. It only happened three times in last six years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Forward collision avoidance, Jun 8, 2025
* The AEB engaged when it shouldn't have. Yes. * Yes * No. * Yes, Tesla remotely told me that the error codes in my service menu had nothing to do with the AEB engaging when it wasn't supposed to. The problem has been reported to Tesla. * None. On [XXX] a car stopped suddenly in front of me and my AEB engaged when it shouldn't have. My car is a Model 3 Performance and it can stop much faster than most cars. The car behind me came inches from hitting me and my dog and myself were thrown violently forward. This is a *MAJOR* safety hazard and could have caused an accident and has caused accidents in other cases. [XXX] This thread has videos of the incident. There was around 20 feet between my car and the car in front of me when the AEB stopped my car. My foot was already on the brake and I was in the process of stopping at a reasonable rate when the AEB suddenly engaged. I could feel the ABS engaging. This happened another time about a month ago. A white box van two cars in front of me slowed down and turned right and the AEB engaged even though there was no need for it. Tesla has the ability to turn off the AEB but you have to do it each time you drive. Please require Tesla to make the AEB on/off choice sticky so you don't have to turn it off each time you drive. Also please make Tesla fix their software or disable AEB on their cars. Recent accident where AEB caused an accident. [XXX] Other incidents where AEB engaged almost causing an accident or caused an accident: [XXX] [XXX] Please do Google searches to find the rest. Thanks! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Forward collision avoidance, May 28, 2025
For the last few weeks while driving, my car will automatically put itself into FSD with out me authorization. Mean I will we driving and the car will just put itself into FSD. This has happened about 15-20 times over the last 2-3 weeks. Tesla wants to clean the front camera? Which makes no sense and charge me for it. If the front camera was obstructed, like in the case of fog. The car would alert me that it could not due to being obstructed, which isnt the case.
Vehicle speed control, Service brakes, Forward collision avoidance, May 5, 2025
Phantom braking (as it's referred to by experts) happened to me twice on the highway using Traffic-Aware-Cruise-Control. Very scary. I was on cruise control going 60 mph when suddenly my car braked suddenly and inappropriately, losing at least 20 mph in a split second before I was able to slam on the accelerator and prevent an accident (rear-end collision). This happened TWICE in the course of 5 minutes on the same highway! There was no obstruction in the road, no cars moving into my lane, nothing but normal road conditions, when it occurred. From my research, this is a huge problem with Tesla vehicles that thousands of individuals are loudly complaining about online and now in court cases in the country. I see there are thousands of reports to your organization about this, but it says you have only complaints from 2021 and later years. However, I have a 2019 and it's happening to me. And it's happening to every single model year out there, just from researching and talking to Tesla owners. This is a major safety hazard, plain and simple. I was inches of being in a rear-end collision, and drivers behind me are extremely upset and vengeful on the road after an incident like this (understandably!). Because of this I fear for my safety and well-being on the road using Tesla's cruise control features. Very disappointing. Above for the ADAS option, I wasn't able to select 2 options, but "automatic emergency braking" is also applicable here as that is what happened. Somehow Teslas are falsely activating emergency braking during cruise control!
Vehicle speed control, Service brakes, Forward collision avoidance, Feb 18, 2025
When cruise control or self-driving systems are engaged, there have been numerous times when the automatic emergency braking system mistakenly slowed the car suddenly. At 70+ mph, this is incredibly dangerous. The AEBS apparently sees shadows as dangers. Fortunately, there has never been an instance when another vehicle has been close behind.
Suspension, Forward collision avoidance, Jan 7, 2025
Two major safety issues need to be reported: 1) The left front lower control arm falling off in the middle of driving, caused car wheel stuck on a traffic street (luckily it was off the freeway 5 minutes ago). The long bolts connected the lower control arms were loss due to the defective design (the bolts are screwed upward vertically, falling off is definitely just a matter of time). I found there was a class action against Tesla due to this problem (it is referred to Model X and S) 2) The other major safety issue I encountered as I turned on the “advanced autopilot “ feature, the car could break suddenly without warning on the freeway. There were no cars or obstacles in the front. I researched online and found many Tesla owners have experienced this so called “phantom breaking” problem as I had (I had experienced this unsafe auto breaking randomly since I have driven this car)
Forward collision avoidance, Nov 18, 2024, crash
Driving on Hwy 8 (Houston Beltway), going west, dog came out from left side, Tesla auto pilot was engaged and did not detect collision with the dog. Car did not stop, did not alarm, dog was hit, my front bumper was damaged, and car kept on going.
Electrical system, Forward collision avoidance, Nov 13, 2024
I’m at the Tesla service center and Tesla is refusing to perform recall work without payment/diagnostic time. Even though Tesla’s website and notices states that they will perform recall work free of charge they are in fact refusing to perform recall work free of charge. They are mandating that I be charged diagnostic fees for them to determine whether they will perform the recall work as of 11/13 at 7:15am per Marc the service advisor at Tesla Service Center Kearny Mesa.
Service brakes, Forward collision avoidance, Nov 13, 2024
It brakes at highway speeds of 70 without reasons on cruise control and FSD. Happened three times on highway 46. It can be very bad if there was a car behind me. This happened to me through all these years since 2019.
Service brakes, Forward collision avoidance, Jul 13, 2024
The brakes of my car did not work on July 2023. I stepped on the brakes and the car did not stop. It accelerated. I almost crashed into another car as the car kept on going. The car beeped when getting close to another car & slowed. I had to maneuver the car to the side of the road to avoid a collision. It did not stop until the length of 2 cars. My husband checked my tesla car and saw there was an alert that the brakes did not work, however, he was unable to take a picture of the message and it did not re-appear. When I scheduled a Tesla service, at first it was a mobile service & they said it had to be checked at a service center. At the service center, I was told that nothing was wrong with my cars brakes and I was charged a $240 diagnostic fee. They state that they "test drove [the] vehicle and was unable to replicate customers concern. Using customers provided times stamp of 7/13/23 between 5:45 PM and 6 PM verified no brake related alerts where present. Technician inspected from and rear brakes, front and rear brake pad thickness was at 8MM. Customers stated about a recall related to loos brake caliper bolts, as of now there is no documentation available to service of any steps to take. For piece of mind technician torqued front caliper bolts to knuckled to 94NM and rear caliper bolts to knuckle to 83NM. Advise customer to monitor condition as it was a one time occurrence." - Component that failed were the brakes & the automatic emergency braking as it did not turn on quickly. - My safety was put at risk as I almost got into a car accident. - The Tesla Service Center at Buena Park "drove the vehicle and was unable to replicate" my concerns. - The vehicle was inspected by Tesla, but not by the police, insurance, representative or others. - There was a warning message that showed up when my husband went back to see if there were any messages and it stated that the brakes did not work. Of note, I do not recall seeing any messages before or during the incident.
Vehicle speed control, Forward collision avoidance, Jun 18, 2024
Tesla has combined cruise control with their Auto Pilot feature. Now there is no human override to what speed limit to use, Tesla determines the speed to used based on certain criteria. This puts the driver at risk who may want to lower or increase the speed limit based on certain conditions Tesla may not be able to detect. For me it was a 9 PM run to the store thru an area that had temporary road construction and known to be a speed trap zone.
Steering, Service brakes, Forward collision avoidance, Apr 22, 2024
The following recalls have been pending on my vehicle: 23V-838; TC2023-657, 24V-051 Tesla is unable to push over-the-air (OTA) updates to my vehicle to remedy these recalls due to an issue with the onboard computer being unable to receive updates. This issue arose when Tesla pushed a software/firmware update to my vehicle which effectively "bricked" the Advanced Drive System portion of the computer. In other words, I am unable to safely receive an update to resolve the issues (solved by the recall) because Tesla's failed software update damaged the onboard computer.
Forward collision avoidance, Lane departure, Mar 20, 2024
With the latest update of V12.3 FSD, the full self driving cannot predict the obstacles clearly, resulting in am incorrect left turn manuever, running over a central divider curb, and damaging tires. Not sure, what could have happened, if a human was standing there instead!
Service brakes, Forward collision avoidance, Mar 5, 2024
Thursday, 2/29/23 I was driving through a busy intersection. The car in front of me was slowing and I too slowed by gently easing the brake. This slow down was not unusual for steadily moving traffic. As my foot was resting on the brake, I felt the car pull the brake down below my foot hard, forcing my vehicle to abruptly stop and due to the force, my body was pushed into the steering wheel. No injury or accidents resulted however, if a car had been driving behind me, I would have been rear-ended. If my toddler had been with me, his car seat would have protected him but this would have been the greatest force ever placed on him. The car did not provide warning that the emergency brake would be activated. I am not aware of a publicly-notified defect at this time. I have scheduled the most soon appointment available with a Tesla service center in order to audit my software system with hope this glitch will be resolved.
Service brakes, Forward collision avoidance, Feb 24, 2024
I was driving on the road at night a few days ago and there was a car that was pulled over on the side of the road with hazard lights flashing. The Tesla slowed down and applied the brakes very hard. The Tesla also applied the brakes for no reason. It was on adaptive cruise control, and all of a sudden it would hit the brakes really hard and I would have to take it off the adaptive cruise control because I did not want to get into an accident. The system automatically applied the brakes in both cases which I would call it, “The “phantom braking”. The car had done this before but not to this extent on adaptive cruise control. This only happened when it was on cruise control. I have been very hesitant on putting it on adaptive cruise control because it acts up at times.
Forward collision avoidance, Feb 22, 2024
FORCED DISCONNET: Autopilot and Full Self Driving suddenly decelerated to 15 mph with no sign or road work signs. The curve onto Old Madison Pike means following traffic can not see the car suddenly creeping in the turn lane. The problem is reproducible. The problem has been reported to Tesla using their voice reporting system. There were no warnings. It has been going on since August 2022.
Forward collision avoidance, Lane departure, Jan 30, 2024
Ever since Tesla updated my vehicle to 2023.44.30.8, the autopilot has become effectively unusable. It now nags and beeps at me whenever I am not looking straight ahead. It is ridiculous that Tesla has ruined one of the best aspects of my car due to (ostensibly?) NHTSA pressure. Please allow their previous driver attentiveness system with the steering wheel to be reinstated. It is so miserable to have my car nanny camera flip out on me every time I look anywhere other than straight ahead. At the very least, every other manufacturer should be forced to have just as annoying a system if my Tesla had to be ruined. Its wrong to punish every Tesla owner because some people misused autopilot.