2019 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 614 owner complaints filed for this model year. This is the 4th highest complaint count among 9 Model 3 model years with reports.
Of the 2019 reports, 60 involved a crash and 5 involved a fire. 30 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Equipment, other, labelsOct 10, 2019
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Failure to provide the air bag warning information increases the risk of injury.
Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Campaign 19V719000 on NHTSA.gov
Representative owner complaints: service brakes
63 reports, newest first. Show all
Service brakes, Jul 30, 2026
My brake lines have corroded to the point where half a liter of brake fluid has leaked out rendering the vehicle unsafe. Tesla admits that this is a design flaw but says that it does not affect this particular VIN number but the damage is exactly as described: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Service brakes, Apr 27, 2026, crash
The Tesla was hit on the passenger side by a Honda civic that ran a red light traveling more than 25 mph The Tesla spun 180 degrees after impact. No airbags deployed. Immediately after impact the Tesla turned on hazard lights. However the vehicle would not come to a stop after pressing on the brakes. After impact the vehicle was coasting backwards at probably less than 5-6 mph. It would not respond to brake presses. Oddly the vehicle had regen braking enabled which should have brought it to a stop, but it didn’t. The vehicle kept coasting backwards as if it was in neutral for about 20 meters until it hit a curb and stopped. BRAKES WOULD NOT WORK!!!
Service brakes, Dec 22, 2025, crash
Brakes failed to stop the car. The car sat at Tesla service center for one month with no action from Tesla.My wife rear ended another car. The air bags deployed. No one was injuryed and the other was not damaged. Both people could have been seriously hurt or killed. Car was finally towed to Classic Collision November 24 by State Farm Insurance for repair. Estimate to be repaired January 8, 2026.
Steering, Suspension, Service brakes, Jul 30, 2025
The vehicle’s front suspension began making loud squeaking noises and felt unstable while driving, especially when turning or going over uneven surfaces. At times, the vehicle does not make a proper turn and almost feels like it loses grip, which is extremely unsafe. I brought the vehicle to a Tesla service center. After inspection, Tesla provided a service estimate and documentation confirming the failure of the front lower lateral links — the exact part and condition described in NHTSA Safety Recalls 21V835000 and 23V235000, which cover defective front suspension lateral link fasteners on this vehicle make, model, and year. Despite the clear match, Tesla did not recognize the repair as recall-related and categorized it as a customer-pay service. This raises concern that some affected vehicles are being excluded from proper recall coverage, despite experiencing the same safety defects. There were no warning lights or alerts prior to the failure. The issue was confirmed by Tesla and the part is available for inspection upon request.
Service brakes, Back over prevention, Forward collision avoidance, Jul 7, 2025
[XXX]- [XXX]am. Trying to park in YMCA located in camp hill PA. Took soft right turn to park. Car accelerated instead of recognizing break, which I applied when I see it accelerating. Then I left break so it can take emergency break that didn’t happened it keep going and cross over the parking curb about six Torah inch high and went in a ditch. I did not hurt but car front damaged. Tesla was informed and they have the log of the time but told they don’t see any issue. My insurance is paying all the expenses. This was the third incident where car did not tool emergency break itself or recognized the break. I did reported last incident to Tesla. It only happened three times in last six years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle speed control, Service brakes, Forward collision avoidance, May 5, 2025
Phantom braking (as it's referred to by experts) happened to me twice on the highway using Traffic-Aware-Cruise-Control. Very scary. I was on cruise control going 60 mph when suddenly my car braked suddenly and inappropriately, losing at least 20 mph in a split second before I was able to slam on the accelerator and prevent an accident (rear-end collision). This happened TWICE in the course of 5 minutes on the same highway! There was no obstruction in the road, no cars moving into my lane, nothing but normal road conditions, when it occurred. From my research, this is a huge problem with Tesla vehicles that thousands of individuals are loudly complaining about online and now in court cases in the country. I see there are thousands of reports to your organization about this, but it says you have only complaints from 2021 and later years. However, I have a 2019 and it's happening to me. And it's happening to every single model year out there, just from researching and talking to Tesla owners. This is a major safety hazard, plain and simple. I was inches of being in a rear-end collision, and drivers behind me are extremely upset and vengeful on the road after an incident like this (understandably!). Because of this I fear for my safety and well-being on the road using Tesla's cruise control features. Very disappointing. Above for the ADAS option, I wasn't able to select 2 options, but "automatic emergency braking" is also applicable here as that is what happened. Somehow Teslas are falsely activating emergency braking during cruise control!
Service brakes, May 4, 2025
The brake lines have completely failed on my 2019 Tesla Model 3 due to rust / corrosion in the drivers side front wheel well. Fortunately failure was caught before an accident occurred. Had I not caught this failure, at highway speed this could have resulted in a very bad accident putting me and my family in danger. After the failure occurred the vehicle indicated it had low brake fluid and that it should be taken to a Tesla service center. I had two different Tesla service centers review the brake line failure, and inspect the remaining brake lines. Both service centers denied that the brake lines were covered under warranty. After connecting the second service center with a Tesla shop in the New England region the Tesla service center agreed to cover replacement under good will. While this is a positive outcome the failure of the brake lines has also identified massive corrosion issues on the battery, subframes, and bolts holding critical components together. I've been informed that removal of the sub-frames and battery may result in the battery being deemed faulty. This is due to corrosion found at the edges of the battery which may result in failure of the required battery pressure test. If the battery is faulty it will need to be replaced and is also not considered under warranty. The estimate for replacement is $23k which would mechanically total this vehicle. Battery corrosion is another safety issue, since the battery is designed to be sealed removing moisture from being able to penetrate the battery cells. Corrosion both on the battery pack and battery cells could contribute to failure of the battery pack while driving.
Vehicle speed control, Service brakes, Forward collision avoidance, Feb 18, 2025
When cruise control or self-driving systems are engaged, there have been numerous times when the automatic emergency braking system mistakenly slowed the car suddenly. At 70+ mph, this is incredibly dangerous. The AEBS apparently sees shadows as dangers. Fortunately, there has never been an instance when another vehicle has been close behind.
Service brakes, Forward collision avoidance, Nov 13, 2024
It brakes at highway speeds of 70 without reasons on cruise control and FSD. Happened three times on highway 46. It can be very bad if there was a car behind me. This happened to me through all these years since 2019.
Service brakes, Forward collision avoidance, Jul 13, 2024
The brakes of my car did not work on July 2023. I stepped on the brakes and the car did not stop. It accelerated. I almost crashed into another car as the car kept on going. The car beeped when getting close to another car & slowed. I had to maneuver the car to the side of the road to avoid a collision. It did not stop until the length of 2 cars. My husband checked my tesla car and saw there was an alert that the brakes did not work, however, he was unable to take a picture of the message and it did not re-appear. When I scheduled a Tesla service, at first it was a mobile service & they said it had to be checked at a service center. At the service center, I was told that nothing was wrong with my cars brakes and I was charged a $240 diagnostic fee. They state that they "test drove [the] vehicle and was unable to replicate customers concern. Using customers provided times stamp of 7/13/23 between 5:45 PM and 6 PM verified no brake related alerts where present. Technician inspected from and rear brakes, front and rear brake pad thickness was at 8MM. Customers stated about a recall related to loos brake caliper bolts, as of now there is no documentation available to service of any steps to take. For piece of mind technician torqued front caliper bolts to knuckled to 94NM and rear caliper bolts to knuckle to 83NM. Advise customer to monitor condition as it was a one time occurrence." - Component that failed were the brakes & the automatic emergency braking as it did not turn on quickly. - My safety was put at risk as I almost got into a car accident. - The Tesla Service Center at Buena Park "drove the vehicle and was unable to replicate" my concerns. - The vehicle was inspected by Tesla, but not by the police, insurance, representative or others. - There was a warning message that showed up when my husband went back to see if there were any messages and it stated that the brakes did not work. Of note, I do not recall seeing any messages before or during the incident.
Steering, Electrical system, Service brakes, Jun 10, 2024
I was driving my Model 3 when this alert occurred: ALERTS DRIVABILITY - VEHICLE MAY NOT RESTART/SERVICE IS REQUIRED ADDITIONALLY THE SCREEN STATED PULL OVER THE VEHICLE IMMEDIATELY SAFELY. I was in the middle of the road driving so it became dangerous. I could not steer the vehicle and the brakes were barely working. I could not immediately stop because I was in the middle of traffic. I pulled right over as soon as I could and shut down the vehicle. I believe this is a defect. When I spoke to Tesla repair personnel I was told they know about this and it is happening when the Model 3 reaches 40K. How can they not address this - why would someone wait until someone is in a serious accident? I called to set up an appointment for this emergency and was told I cannot get an appointment for 1 month and I should not drive my car. When an electric vehicle just shuts down you cannot control the vehicle - this is very very dangerous.
Steering, Service brakes, Forward collision avoidance, Apr 22, 2024
The following recalls have been pending on my vehicle: 23V-838; TC2023-657, 24V-051 Tesla is unable to push over-the-air (OTA) updates to my vehicle to remedy these recalls due to an issue with the onboard computer being unable to receive updates. This issue arose when Tesla pushed a software/firmware update to my vehicle which effectively "bricked" the Advanced Drive System portion of the computer. In other words, I am unable to safely receive an update to resolve the issues (solved by the recall) because Tesla's failed software update damaged the onboard computer.
Service brakes, Forward collision avoidance, Mar 5, 2024
Thursday, 2/29/23 I was driving through a busy intersection. The car in front of me was slowing and I too slowed by gently easing the brake. This slow down was not unusual for steadily moving traffic. As my foot was resting on the brake, I felt the car pull the brake down below my foot hard, forcing my vehicle to abruptly stop and due to the force, my body was pushed into the steering wheel. No injury or accidents resulted however, if a car had been driving behind me, I would have been rear-ended. If my toddler had been with me, his car seat would have protected him but this would have been the greatest force ever placed on him. The car did not provide warning that the emergency brake would be activated. I am not aware of a publicly-notified defect at this time. I have scheduled the most soon appointment available with a Tesla service center in order to audit my software system with hope this glitch will be resolved.
Service brakes, Forward collision avoidance, Feb 24, 2024
I was driving on the road at night a few days ago and there was a car that was pulled over on the side of the road with hazard lights flashing. The Tesla slowed down and applied the brakes very hard. The Tesla also applied the brakes for no reason. It was on adaptive cruise control, and all of a sudden it would hit the brakes really hard and I would have to take it off the adaptive cruise control because I did not want to get into an accident. The system automatically applied the brakes in both cases which I would call it, “The “phantom braking”. The car had done this before but not to this extent on adaptive cruise control. This only happened when it was on cruise control. I have been very hesitant on putting it on adaptive cruise control because it acts up at times.
Steering, Suspension, Service brakes, Nov 2, 2023
Suspension lateral links attached to subframe became loose causing the lateral links to separate from the sub-frame. Wheel alignment shifted causing instability, which adversely impacted vehicle controllability and nearly caused a collision while driving. Problem was inspected, reproduced, and confirmed by the dealer/manufacturer/service center. Before the failure occurred, the primary symptoms were abnormal noises from steering/suspension area. Service center attempted to address these noises by inspecting and retightening the bolts, but unfortunately, this action did not resolve the issues and, eventually lead to a failure of the suspension system. It should be noted that parking brake functions and vehicle hold feature may have been affected by this failure. This incident may be associated with with the following recalls, NHTSA Recall: 23V-235 or Manufacturer Recall: SB-23-31-001. However, my VIN does not appear to be included.
Service brakes, Oct 27, 2023
The vehicle is supposed to automatically slow down (regen) when you let off the accelerator. Recently the car continues to coast or stay the same speed. The battery is not close to being full (will not regen). I will apply the brake and let go and the car will continue to move forward. It is dangerous.
Other or unspecified, Service brakes, Forward collision avoidance, Oct 23, 2023
The vehicle will randomly start emergency braking for no reason once so ever when using teslas full self driving. This is extremely dangerous as it can happen at any moment while the autopilot feature is in use. In my most recent instance autopilot was set to 70 mph, and with no vehicles are traffic control devices present what is known as “phantom braking” started to occur. Which requires me to quickly reassume control of the vehicle and bring it back up to speed.
Service brakes, Forward collision avoidance, Sep 16, 2023
The car is plagued by "phantom braking." It occurs when I am on the freeway - the car suddenly brakes and/or decelerates. (Sometimes it is a sudden braking and sometimes the cruise control just turns off.) This is very unsafe - I am fortunate that it has occurred when there is no car close behind me. I feel it happen and put my foot on the accelerator as soon as I can. It's happened as many as 3-4 times during a long (@500 miles) drive, and other times only once. It occurs in various kinds of weather and I have never been able to figure out why it happens. It has happened when there are no cars in front of or next to my car. I believe this problem has been reported many times before. I do not know what system or part is responsible for this. I have had the car since 2019 and this has been happening as long as I can remember. I have never received any kind of a warning or signal that the car would brake. NOTE: B/c the problem is ongoing, I did not put in an approximate date below.
Service brakes, Aug 29, 2023, crash
The NHTSA is forcing Tesla and other self-driving cars to come to a complete 0 mph stop at stop signs and according to Elon, only 0.5% of all drivers in their fleet actually do this and that seems inline with the general public also doesn't come to a 100% stop at every stop sign and as a result I got rear-ended because in a completely wide-open intersection the driver behind me thought I was going to do a rolling stop but didn't. The point of the NHTSA is to keep drivers safe and driving like a safe driver and not a robot that follows 100% of all road rules makes an unpredictable driver therefore an unsafe driver. The NHTSA has allowed car manufacturers like Volvo set max cruise control to 125 mph!!!! That breaks the speed limit on 99.999% of all roads in America but you've allowed it for years because everyone goes above the speed limit and that's ok with the NHTSA. Letting self driving cars slow to 1 or 2 mph before proceeding in an intersection where no other cars or people are present aligns with what over 99% of all drivers do so that would make them a predictable driver and therefore a safe driver. Not saying allow them to blow through intersections at 3+ mph but not come to a 100% stop, seriously no one does that!!
Steering, Service brakes, Aug 1, 2023
Recently I have been receiving warnings from my Tesla after hitting a pothole or bump in the road. ABS is disabled, power steering is disabled, power brake assist is disabled, forward collision warning and driver assistance features are all disabled. Upon a service visit to Tesla, they found that a fault within the ABS sensor circuit triggers these faults until the car is parked and shuts off to complete a reset cycle. Tesla claimed that this ABS cable was improperly placed and has caused damage to the sensor cable.
Vehicle speed control, Service brakes, Jul 27, 2023
I have a 2019 Model 3 and yesterday, while making a left turn and applying pressure to the brake, receiving feedback from the brake, my car lurched forward for about half a second. I thought I may have been rear ended, but no one was behind me. This has happened on the freeway before as well. I'll be accelerating at a totally even place and BAM, I'll jolt forward out of nowhere. On the rare occasions that I use the car's "autopilot" feature, I will also encounter phantom braking, but that's easily avoided by not using the feature, which I haven't since first encountering the problem. I haven't suffered any damages from this, but if my car is able to do this, that's extremely alarming. What if this tripped while I was parking?
Service brakes, Hydraulic, Jul 19, 2023
The contact owns a 2019 Tesla Model 3. The contact stated while approaching a stop, the vehicle failed to stop as needed. There was no warning light illuminated. The contact stated that the generator braking was able to stop the vehicle. The contact stated while driving to the residence, there was a spraying sound coming from the vehicle while braking. The contact became aware of fluid leaking from the brake when the vehicle was parked. The vehicle was towed to the dealer and the contact was informed that the front and rear driver’s and passenger’s side brake lines had ruptured and needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 58,000.
Other or unspecified, Service brakes, Forward collision avoidance, Jun 2, 2023
Unintended acceleration during public street and highway while approaching a stop to make a right turn on November of 2022 in Orange County California onto a highway I let go of the pedal ready to press the brake and while turning it made a unnecessary acceleration to speed up making steering difficult, another incident where I believe in February 2023 as I was driving in the right lane a truck made a sudden stop and the accident avoidance never deployed nor warn me and the acceleration maneuver my steering pedal as I felt it degrease on the brake and increase on the acceleration pedal this was very traumatic and scary knowing I might have bodily injuries or even death also while setting the speed limit I notice while using the regenerative braking the brake pedal would vibrate very aggressively also while using the back up cam and side views it would glitch a lot after a bug update I feel this is very concerning for me and my kids and a lot of reviews and even attorneys or aware of the situation most of all it's a safety issue for California
Vehicle speed control, Service brakes, Jun 1, 2023
Multiple extreme braking so much where today actually hurt my neck it stopped so abruptly up a hill miscalculating that a walker was about to be hit by my car, the man was nowhere near being hit and the auto braking skid to a halt whipping my head forward and my sweatshirt choked my Adams Apple area. It was extremely abrupt, scared me, the walker and nearly caused a rear end collision with the car behind me. This has happened a lot in the past 3 months yet I’ve had the car for over 4 years so I am assuming something is wrong with the software updates - it’s super scary not to have control of your own car. Also, I can opt out of auto braking on my car yet that’s not what I’m reporting, I’m reporting the fact that it’s phantom braking miscalculating street situations and causing dangers to me, my passengers and others like I’ve described above. Also noticed recently, when I hit the gas, it’s often the car doesn’t “go” it pauses and then may go with similar miscalculation of street situations like pedestrians on a adjacent sidewalk or motorcycles in between cars yet literally the Tesla won’t let me move…this isn’t safe.
Vehicle speed control, Service brakes, Forward collision avoidance, May 29, 2023, crash
On 10/17/2021 my son was killed along with his passenger in this Tesla. The car was thought to be going over 100 miles an hour on a city road Coconut Point Road in Estero Florida. The car was thought to have hit a tree with the rear tire and was sent flying through the air and hit another tree and split in half. My son knew this road well as it was close to his home and drove it on his way home from work. I feel strongly that this was an acceleration issue!! He has driven this car for 2 years, so knew the car well.