2019 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 614 owner complaints filed for this model year. This is the 4th highest complaint count among 9 Model 3 model years with reports.
Of the 2019 reports, 60 involved a crash and 5 involved a fire. 30 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Equipment, other, labelsOct 10, 2019
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Failure to provide the air bag warning information increases the risk of injury.
Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Campaign 19V719000 on NHTSA.gov
Representative owner complaints: suspension
82 reports, newest first. Show all
Suspension, Sep 13, 2024
The suspension front control arm and lower links were all bad and had to be replaced. One day, our car started making this terrible clunking sound, so we brought it in. They charged us $1,800 to replace the whole control arm/link system. I have seen that this is a common problem. I have heard that the issue is known by Tesla as a defect because they put in bad control arms in the early models of Tesla that are known to go bad. We were told that if we did not get them replaced, they could go out while driving and cause us to lose control of our vehicle.
Suspension, Sep 10, 2024
Front control arms have zero to very little grease, this causing components to friction and cause loud squeaking sound. Tesla is charing nearly $300 to change out the control arms which are the same as what's currently in my vehicle. This incident will occur again and Tesla will benefit from it.
Suspension, Jul 8, 2024
The front wheels suspension are squeezing. For a relatively new and low mileage car I don’t think this should be happening. I understand there’s been a lot of complaints about this issue. We believe it should be recalled. Thank you!
Steering, Suspension, Other or unspecified, Jun 20, 2024
Customer concern confirmed there is a creaking noise coming from the front of the car while turning, I performed a visual inspection and found that both RF lower control arm bushings are torn and the LF frontward lower control arm bushing are torn but this is not the cause of the noise the cause of the noise is the upper control arms I took the load off of the upper control arms and the noise went away I also had someone turn the wheels while I looked for the cause of the noise and found that the noise is coming from the upper control arms, recommend replacing upper and lower control arms to fix all safety concerns.
Suspension, Jun 3, 2024
The upper control arm on the driver's side of my Tesla Model 3 has started making a loud squeaking noise. After researching, I discovered that many owners have experienced this issue. Tesla Service Centers acknowledge it as a known defect but refuse to issue a recall, only addressing it upon customer request. Since my vehicle is out of warranty, they have quoted me over $500 for the repair. This defect poses a significant safety risk if the upper control arm fails. Please look into this matter. Thank you!
Suspension, May 21, 2024
The car is just out of warranty and has been driven about 62,000KM. The suspension and both frond and back control arms started to squeak badly during low speed driven, turning, back-in etc.
Suspension, Mar 9, 2024
Heard rattling in the front of the car over a period of weeks. Finally checked and saw a bolt that secures the front wheel hinge to the body frame was very loose. Then I tried turning the wheel (while stationary) to test the front steering. After a few times, the bolt came completely loose and hanging, as in one of the pictures included. After the bolt came completely loose and hanging, the affected wheel is completely unaligned. Since the bolt is hanging, I simply removed it, as shown in one of the attached pictures.
Suspension, Feb 22, 2024
Both the front left and right lateral linkages have failed after 4 years of normal use. This is similar to an issue experienced in other Model 3 vehicles that were recalled. This vehicle is not covered by that recall but appears to have the same build quality issues. These links should not fail at such an early vehicle age. Replaced Left Front Lower Lateral Link. Replaced Right Front Lower Lateral Link.
Suspension, Feb 16, 2024
The upper control arms on this vehicle are a known chronic issue where the ball joints fail anywhere from 15,000 miles and up. Tesla is charging for this replacement if vehicle has more than 50,000 miles
Suspension, Jan 18, 2024
When driving the car and turning the wheel there was a creaking noise at low speeds. Upon inspection at the service center the issue was diagnosed to be suspension part issues. The compliance link assemblies, lower lateral links, and control arms require replacement. This issue could have resulted in the car wheels breaking off while driving, causing a safety issue for myself and others.
Suspension, Jan 10, 2024
Upper control arms and linkage on left and right needed to be replaced. Tesla charging $600 labor.
Suspension, Jan 9, 2024
The front upper control arms on the vehicle failed at around 50,000 miles. The control arms failed with the same symptoms described in Tesla's service bulletin [XXX] ). However, despite the service bulletin stating that the correction was to reseal the area around the ball joints, Tesla's service team told me that they no longer do that because they found out that the problem would reappear if they only reseal them. That they instead replace the front upper control arms with a newer version. They billed me $181.44 for that work despite having a service bulletin for the issue and despite it being a widespread issue with the early failure of those control arms. I was lucky that I had this issue addressed when it only made noise and did not wait for the suspension component to structurally fail, which would have resulted in a crash. I have the invoice and the written communication between myself and Tesla. However, when submitting this incident form on NHTSA's website, the Upload Files section wasn't working in Chrome or Firefox on Windows. Clicking the "Upload Files" button on this web form just made the button disappear and nothing else happened. If it is helpful, I'd be happy to share the invoice and written communication between myself and Tesla with NHTSA. Please let me know if that's needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Dec 29, 2023
I had to replace the Front Upper Control Arm Assemblies (Left and Right). As part of this (I believe) I also had to replace Lower Lateral Links (Left and Right) and the Front Lower Compliance Links (Left and Right). My car had 53,536 miles on it at the time (so just outside the warranty). The total cost was $1,259.63.
Suspension, Dec 28, 2023
The contact owned a 2019 Tesla Model 3. The contact stated that while driving at various speeds, there was a squeaking sound coming from the front end of the vehicle. The vehicle was driven to the local dealer who diagnosed that the front suspension system was faulty and needed to be replaced. The front suspension system was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The VIN was not available. The failure mileage was 93,000.
Steering, Suspension, Dec 15, 2023
The contact owns a 2019 Tesla Model 3. The contact stated that while turning the steering wheel to the left or the right, there was an abnormal creaking sound. The failure occurred at various speeds and occurred intermittently. The vehicle was taken to the dealer who diagnosed and determined that the creaking sound was coming from the front upper control arm while turning the vehicle and the front lower control arm while in reverse. The dealer also diagnosed that the latter link was torn. The contact was informed that the control arms and suspension nuts and bolts needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 49,000.
Steering, Suspension, Service brakes, Nov 2, 2023
Suspension lateral links attached to subframe became loose causing the lateral links to separate from the sub-frame. Wheel alignment shifted causing instability, which adversely impacted vehicle controllability and nearly caused a collision while driving. Problem was inspected, reproduced, and confirmed by the dealer/manufacturer/service center. Before the failure occurred, the primary symptoms were abnormal noises from steering/suspension area. Service center attempted to address these noises by inspecting and retightening the bolts, but unfortunately, this action did not resolve the issues and, eventually lead to a failure of the suspension system. It should be noted that parking brake functions and vehicle hold feature may have been affected by this failure. This incident may be associated with with the following recalls, NHTSA Recall: 23V-235 or Manufacturer Recall: SB-23-31-001. However, my VIN does not appear to be included.
Suspension, Oct 6, 2023
Issue with control arm and compliance links. Poor design causes corrosion problem.
Suspension, Aug 24, 2023
I previously had asked Tesla to check my front suspension as I was noticing a unusual sound which they did however the technician assessment was that all was fine. Today, just 4 months out of warranty (but still under the 50k), the front control arm just fell off while I was driving. This resulted in the control arm to brake as well as my front fender (it hit the tire in motion). To my disbelief there was nothing put in place to keep that control arm up, if I were driving on the freeway it would have resulted in a catastrophic accident. I’m emailing you to see if there is anything that can be done to hold Tesla accountable for this major flaw. Online forums have plenty of other tesla drivers with similar issue as well as an official recall which unfortunately my vin did not fall under. Please advice on how to proceed. Thank you.
Steering, Suspension, Aug 3, 2023
Loud squeaking noise inside cabin while driving started immediately after warranty expires and software update. Steering shakes with bumps. Almost felt like something is falling apart. Tesla service said known problem and since out of warranty customer will be charged. Wonder why all problems started immediately after warranty expires. Pls investigate if this part ( control arms and suspension) cause any safety issues. Also, software updates should be investigated as well.
Suspension, Jul 14, 2023
The contact owns a 2019 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormally loud sound. No warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed that the front suspension lateral link was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 23V235000 (Suspension)however, the VIN was not included in the recall. The failure mileage was approximately 56,000.
Suspension, Jun 22, 2023
Left and right lateral links were blown. Increases the chance of a vehicle crash. Tesla has identified the issue in my vehicle and replaced both parts. There were no symptoms, the technician found it by inspecting the suspension due to an unrelated noise reported by me, the customer. There have been multiple recalls in the past for the Model 3 and Model Y manufactured in 2018 and 2019. Tesla has not issued any recalls for my vehicle. Now that my vehicle is off warranty, I was charged $803.50 plus taxes to replace both parts that should have been part of a larger recall. I suspect this is a recurring issue that Tesla is not addressing. The chances of having a similar issue on one side is already low. In this case, it is on both sides, which reinforces my suspicion.
Steering, Suspension, Apr 24, 2023
At just 10 days over 4 years of ownership, which is out of warranty, and at about 44,360 miles, I noticed noise when going over small bumps, moving from stop to go and while turning the steering wheel. It appears that the upper control arm, a recall on about 3000 Tesla Model 3 and Y, was the culprit. I contacted the service center and right away, over the Tesla Mobile App, the knew it was the control arm going bad. They said it was safe to drive, however, it is a bit scary to hear the squeaking and noises when driving and turning the steering wheel, especially at highway speeds. The problem was fixed by Tesla's service center, however, because I was 10 days or so out of my 4 year/50,000 miles warranty, I was charged about $190 for the repair. I feel that since this is a know issue and has happened to many other non-recalled vehicles by Tesla, this would/should be a know defect and safety concern that should have been repaired under warranty.
Suspension, Structure, Other or unspecified, Feb 28, 2023, crash
I was driving using beta full self driving feature, and the vehicle was involved in a collision
Suspension, Feb 23, 2023
The front control arm fails just 58k mile mark this known issue on car. Multiple time brought to there attention no action was taken
Steering, Suspension, Oct 1, 2022
Front upper control arm is failing, making an awful noise and can be felt grinding inside the car while driving. Reported to Tesla service and they denied the repair. It is a known issue, they need to recall all effected vehicles for repair.