2020 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 451 owner complaints filed for this model year. This is the 5th highest complaint count among 9 Model 3 model years with reports.
Of the 2020 reports, 54 involved a crash and 2 involved a fire. 33 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Air bags, side/window, curtainOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021, 2023 Model 3 vehicles. The left and/or right side curtain air bag may have been improperly secured to the roof rail, which could result in a twisted air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 226, "Ejection Mitigation."
A twisted side curtain air bag may improperly deploy, increasing the risk of injury or occupant ejection during a crash.
Tesla Service will inspect and realign the left and right side curtain air bag as necessary, free of charge. Owner notification letters were mailed December 23, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-20-006.
Campaign 21V834000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Representative owner complaints
451 reports, newest first.
Forward collision avoidance, May 12, 2026
Tesla was on Full Self Driving following a curve in the road were traffic lights. Lights were red Car should have stopped but did not. Ran red light with no attempt to stop or slow down.
Suspension, Apr 30, 2026
The contact owns a 2020 Tesla Model 3. The contact stated that while driving at various speeds, the vehicle made an abnormal clunking sound while turning the steering wheel. The messages "Traction Control Disabled", "Lane Departure Avoidance Feature Disabled", "Automatic Vehicle Hold Disabled" and "Stability Control Disabled" were displayed. The vehicle was taken to a dealer, where it was discovered that the lateral link was not attached to the control arm due to a defective bolt. The contact was informed that the subframe and the front passenger’s side lower control arm needed to be replaced. The contact related the failure to NHTSA Campaign Number: 21V835000 (Suspension); however, the VIN was not included in the recall. The vehicle remained with the dealer unrepaired. The failure mileage was 46,124.
Forward collision avoidance, Apr 24, 2026
Driving S/B on Ann Arbor Saline Road. Had FSD on the Tesla engaged. Needed to make left turn onto Maple. Left arrow light to Maple was red. Traffic light to continue straight on Ann Arbor-Saline was green. Despite left arrow being red, Tesla did not slow and ran red light to make left turn onto Maple.
Seat belts, Seats, Apr 22, 2026
2020 Tesla Model 3 Standard Range Plus, VIN [XXX] restraint control module fault codes RCM_a056 and RCM_a058. Passenger front seat occupancy sensor failure triggering "Service Required" airbag system alert. September 2024: fault code RCM a056: Tesla repaired this issue under the Supplemental Restraint System Limited Warranty (5 years, 60,000 miles) at Tesla Service Latham NY (326 Old Niskayuna Rd, Latham NY 12110). January 10, 2026: Fault code RCM_a058. Reported in writing through the Tesla app. Tesla scheduled a service visit for January 13, 2026. Technician assessed the vehicle in person and declined to repair, verbally stating the fault may be a one-time occurrence and to monitor and return if it continued. April 2026: Fault continues recurring. Tesla Service Latham issued estimate #XXX dated April 18, 2026 for $1,076.32 customer pay. Repairs include resistive occupancy sensor replacement and seat back trim cover replacement. This is a safety-critical system governing airbag deployment. Tesla has documented this failure mode in internal service bulletins citing electrical interference in the seat harness as a design issue. Tesla repaired this under warranty, dismissed a related restraint fault for the same seat when reported within months of the repair, and is now billing the owner for a safety system that failed due to a known design defect. A recall is warranted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Wheels, Apr 12, 2026
Both front wheel and rear rims cracked under normal driving conditions. This is the third occurrence of rim failure on this vehicle. The most recent incident occurred in Ewing, NJ near Parkside Ave and Hillcrest Ave. There was no significant impact or major pothole at the time of failure. Multiple wheel failures indicate a potential structural durability issue. Cracked rims pose a serious safety risk due to the possibility of sudden tire pressure loss or blowout while driving. The vehicle has been operated under normal road conditions, and this repeated failure should not occur. The damaged wheels are available for inspection upon request.
Other or unspecified, Apr 2, 2026
My wife was cleaning the interior and wiped the center main display of her model 3. While doing that somehow she managed to Turn the heat on set the fan/temp controls to HI and popped the front frunk to open. When she exited and closed all doors, it looks like the heat kept running at max for more than 24 hours in the garage. When I entered the garage it was hot in there and inside temp of the car was at 87f. Not sure if there was a fire hazard due to heaters over heat. Just wanted to bring this to your attention.
Other or unspecified, Mar 31, 2026
The touch-screen only media center has an off-by-one error when using the media player for USB media. This results in unsafe conditions for the driver where the expectation of pressing "S" would navigate to music starting with "S", but instead navigates to music starting with "T". This creates momentary confusion for the driver, and pulls focus from the road. There is no mechanism to scroll through the music using non-touch related functionality. There is no warning to only use the media feature when stopped/parked. The manufacturer has acknowledged the issue, but refuses to provide any diagnostics or solutions without taking a downpayment for service.
Electrical system, Visibility/wiper, Lane departure, Mar 5, 2026
My Tesla Model 3 was brought to Tesla Princeton Service Center on February 27, 2025 for a 12V battery replacement. During the service visit, Tesla also replaced the rear glass, citing the rear defroster as the root cause of the battery drain — a repair that was added without prior discussion and increased the total invoice from an original estimate of $180 to a final charge of $1,730. Upon picking up the vehicle, the rear backup camera, blind spot cameras, navigation system, Sentry Mode, and windshield wiper sensor were all non-functional. None of these systems showed any malfunction prior to the service visit. Tesla Princeton’s service advisor denied responsibility without performing diagnostics, and in a subsequent message admitted he could not determine the cause with certainty without diagnostics — which have still not been performed. The vehicle was discharged from a licensed Tesla Service Center in a condition non-compliant with FMVSS 111. I have escalated this matter to Tesla executive leadership in writing and am filing this NHTSA complaint to create a federal record of this safety violation.
Forward collision avoidance, Feb 27, 2026
When adaptive cruise control is enabled (Autopilot, not equipped with Full Self Driving) car will sometimes brake hard as if there is an obstacle ahead, with the words "Curve Assist Active" flashing on the screen. Seems to happen most often on state highways, vs interstate. In one case last night car slowed from 65mph to 30mph, on a straight road, with no object ahead. Thankfully no cars were immediately behind or I would have been rear-ended. Happened 4 times in 500 miles of highway travel.
Other or unspecified, Feb 26, 2026
Issue 1: While using Full Self-Driving (Supervised) at night on a two-lane road with a straight lane and a turn lane, the vehicle crossed the white lane markings and drifted into the adjacent lane. I had to manually intervene to correct many times. This happens regulary at night. I clean the lenses on the cameras but it doesn't reslove the issue. Issue 2: While using Full Self-Driving (Supervised), the vehicle positioned itself in the incorrect lane when entering a roundabout, selecting the wrong entry lane for my intended exit. This happens at day and night about 50% of the time. I report the issue via the Tesla feedback, but they do not fix it.
Steering, Suspension, Feb 4, 2026
Sunday [XXX] downtown Sacramento, driving about 25 mph. Heard a loud bang—bolt sheared off front subframe. Steering felt lagging upon making a right turn vehicle proceeded in a very wide turn, pulled into parking lot. Wheel locked right as I exited [XXX] parking spot; steering went slack, brakes scraped rotor. Two witnesses saw hardware hit pavement. AAA tech removed tire: lower control arm bolt missing, no Loctite, subframe raw. Second bolt loose—single point of failure. Tesla missed this on six different service visits and during their one-twenty inspection before delivery. Recall 21V835 should’ve flagged it but service personnel assured me all clear on every visit . Vehicle towed to Tesla service center at 1104 Tinker rd, Rocklin, CA. Tesla shop manager Sal confirmed this failure as manufacturers defect, and poor assembly. Safety was seconds from total loss. Need probe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Forward collision avoidance, Feb 2, 2026
Incident Date: Feb 1, 2026, 2:45 PM PST Location: Camarillo, CA (Pleasant Valley Rd & Village Commons Blvd) Description: The vehicle (Tesla Model 3, FSD Supervised) attempted an unprotected left turn. The system identified a gap but paused excessively before initiating the maneuver. After the pause—when the gap was no longer safe—the system proceeded to turn anyway, directly into the path of a speeding oncoming vehicle. The system failed to abort the maneuver after its own hesitation. It also failed to accelerate with the urgency required to clear the path. I was forced to manually override with emergency acceleration and steering into an oncoming lane to avoid a high-speed T-bone collision. This appears to be a "stale data" failure where the car executed an old plan that was no longer valid.
Suspension, Jan 30, 2026
The front suspension control arms on my 2020 Tesla Model 3 are squeaking and show premature wear. The noise occurs during normal driving and is accompanied by clunking, which concerns me about potential control arm failure and loss of vehicle control. My vehicle is only 40k miles and it’s a very common issue that Tesla gets to make money on. Kind of funny it happens to everyone right when the warranty ends. I am aware that this is a known issue affecting multiple Model 3 vehicles. Despite proper maintenance, the problem persists and may present a safety risk. I request that this be officially recorded as a safety complaint.
Suspension, Jan 19, 2026
Vehicle made thunking noise when driving over uneven surfaces such as bumpy roads, speed bumps, or railroad tracks. Diagnosis at Tesla service center showed front upper control arms assemblies (left and right), lower lateral link, and front lower compliance link (left and right) required replacement. Of note: upper control arm assemblies were previously replaced under warranty in November 2021 at 28000 miles. This short interval indicates defective suspension components leading to cascading failures putting driver safety at risk.
Forward collision avoidance, Jan 7, 2026, crash
Vehicle Information: 2020 Tesla Model 3 AWD (Leased) Full Self-Driving (FSD) enabled Summary of Safety Issue: While Full Self-Driving (FSD) was engaged, the vehicle failed to detect roadside infrastructure and collided with multiple fixed objects, including a route sign board, a walkway sign board, and an underground electrical cable. The system did not provide adequate warnings or corrective action before impact. System jerk the steering confirmed system is engaged but did not break and drive to non-drivable area and not given any disengagement warning and totaled the car. Incident Details: • Date of incident: [XXX] • Location: On [XXX] {XXX] Piscataway, NJ 08854 • Road type: [XXX] • Weather/visibility: Clear • Speed at time of incident: <40 MPH (under the speed limit) Description: As soon as i trigger the FSD it immediately tried to navigated left or right and failed and unexpectedly veered into roadside infrastructure. The system did not slow down, steer away, or alert the driver in time to prevent the collision. The impact caused significant damage to public property and the vehicle is totaled. No injuries occurred. Evidence Available: • Photos of the scene and damage • Police report (number: [XXX] • Tow documentation • Tesla collision center estimate Reason for Reporting: This incident suggests a potential safety defect in Tesla’s FSD system related to object detection, path planning, and collision avoidance. The failure occurred without driver input and raises concerns about the system’s reliability in detecting fixed roadside objects. I request that NHTSA review this incident as part of ongoing evaluations of Tesla’s driver-assistance systems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Other or unspecified, Jan 3, 2026
After loading our two children ages 2 and 5 in to vehicle and securing in car seats, the car doors were closed and would not reopen. The children were unable to open the doors themselves. The trunk and other entries did not open. There was no obvious way to open the doors or the issue the car was experiencing. The battery cover would not open. Eventually after I searched the Internet I determined that the 12V battery died (no warning whatsoever, doors worked before loading children) and this caused all occupants to be detained in vehicle as the emergency release is the mechanical means of opening the door and this emergency release is not intuitive or obvious. Within 20 minutes I was able to use an arcane hot wiring method to unlatch a door with a spare 12 V source and a hidden 12 V port not immediately obvious either. Thankfully not in setting of an emergency, not a sunny or excessively warm day and had internet access to research this event. If any of the above were true, life limb and property loss would easily have occurred.
Vehicle speed control, Jan 1, 2026
The newer versions of FSD do not allow driver control of the max speed. The current versions allow you to set a maximum speed with a scroll wheel on the steering wheel.
Seat belts, Seats, Dec 29, 2025
The car has message saying "Safety Restraint System issue" . There has been no event to cause this. No recent MVA or any stress or damaging incident to the seat belt or seat in general. Reviewing this on the internet, this is a common defect on Tesla's. The company won't fix it unless you pay them to do so which is crazy considering it is a defect in their safety system. And a well known one to them from my communication with their Tesla service centers which have a monopoly on fixing Tesla's. He said there would have to be a recall. So that is exactly what needs to happen from the NHTSA.
Steering, Dec 23, 2025
Steering wheel covering delaminates and peels during normal use, creating loss of grip and distraction while driving.
Other or unspecified, Dec 18, 2025
I recently purchased a 2020 Tesla Model 3 Long Range AWD (VIN [XXX] internal systems and service records show that all recalls for this vehicle have been completed and closed. However, the NHTSA VIN lookup still shows seven open recalls. This is causing a major issue because I am participating in a California clean transportation incentive program (Replace Your Ride), which requires that all recalls be shown as closed specifically on the NHTSA website. Tesla states that the recalls are complete but has not updated the recall status with NHTSA. NHTSA customer service informed me that recall data can only be updated by the manufacturer. I am requesting that NHTSA notify Tesla’s regulatory or safety compliance team so they can update the recall reporting for this VIN. The outdated recall data is preventing my state incentive from being processed and is causing significant financial harm. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Air bags, Dec 16, 2025, crash
Air bags did not deploy during crash. It is available for inspection upon request My face smashed into the steering wheel resulting in black eyes, swollen nose, cuts on my face and a concussion. Yes, the airbags clearly did not deploy during crash No No
Electrical system, Visibility, Back over prevention, Dec 15, 2025
The contact owns a 2020 Tesla Model 3. The contact stated that while the vehicle was parked, the trunk became inoperable. The contact stated that the trunk latch failed to open when the trunk release was engaged using the mobile application, the instrument panel, or the trunk release button. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention). The vehicle was taken to the dealer, but was not diagnosed. The contact was informed by the dealer that the cable harness was not repaired and that a zip tie was placed on the cable harness. The vehicle was not repaired. The contact stated that after the dealer visit, the trunk failure persisted. The manufacturer was made aware of the failure. The approximate failure mileage was 69,125.
Steering, Suspension, Dec 8, 2025
My Tesla Model 3 is experiencing premature suspension failures involving the lower lateral links and stabilizer links. These components were already replaced once, and they are failing again in less than 30,000 miles. This is not normal wear for suspension parts on a modern vehicle. These failures cause clunking, instability, and looseness in the front end—conditions that affect the vehicle’s ability to track straight and maintain control, especially over uneven pavement or during emergency maneuvers. This isn’t an isolated case. There are extensive reports from other Tesla owners across multiple models (Model 3 and Model Y in particular) showing the same premature wear on these suspension links. Many owners have parts failing even earlier. Once the car is out of warranty, Tesla charges thousands of dollars to replace these components, despite clear indications that the suspension was under-engineered for the weight of the vehicle. Tesla knows this is a recurring issue but refuses to issue a recall or goodwill repairs. A repeated failure of critical suspension links in such low mileage suggests a defect. These parts should not be wearing out this fast, and the resulting instability poses a real safety risk. I’m requesting NHTSA investigate these premature failures.
Service brakes, Forward collision avoidance, Nov 24, 2025
While driving my Tesla Model 3 with self-driving engaged in excellent conditions, the car suddenly braked to a full stop. There was no apparent reason to do so and the driver did nothing. The road ahead was free of traffic, and no obstacles, pedestrians or animals were visible. It was possible to resume driving by turning self-driving off. Tesla forums online show many instances of others reporting similar problems in various Tesla models over several years. A rear end collision will ultimately be the result of this flaw if it hasn’t yet occurred.
Service brakes, Oct 16, 2025, crash
The complaint was filed on behalf of the contact's daughter. The contact's daughter owned a 2020 Tesla Model 3. The contact stated that while the contact's daughter was driving at 35 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the contact's daughter stated that the brake pedal felt spongy and unusual. The contact's daughter stated that the brake pedal was depressed to the floor; however, the vehicle still did not stop. The contact's daughter enabled the emergency braking system; however, the vehicle still did not stop. The contact's daughter beeped the horn to alert the nearby driver, and the dash cam independently activated. The contact stated that because of the failure, the contact's daughter's vehicle rear-ended the vehicle in front of the contact's daughter's vehicle. The air bags did not deploy. The contact stated that after the crash, the emergency braking system failure warning light was illuminated. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss by the insurance company. A Police report was filed. The contact's daughter was treated at the local hospital on the following day. The contact's daughter sustained headaches, whiplash, and a concussion. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000.