2018 Thor Motor Coach Palazzo
Problems, recalls and owner-reported issues
Structure is the leading concern among 12 owner complaints filed for this model year. This is the highest complaint count among 6 Palazzo model years with reports.
What owners report most often
Recalls and investigations
Equipment, recreational vehicle/trailerFeb 23, 2023
Thor Motor Coach (TMC) is recalling certain 2015-2023 Palazzo recreational vehicles. The front lower cap brackets that support the front fiberglass panel may become loose and detach from the vehicle while in motion.
A detached bracket can become a road hazard, increasing the risk of a crash.
Dealers will inspect and replace the front lower brackets, as necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000291.
Campaign 23V113000 on NHTSA.gov
Tires, valveSep 15, 2020
Thor Motor Coach (TMC) is recalling certain 2018-2021 Aria, Palazzo, Tuscany, and Venetian motorhomes built on a Daimler Trucks (DTNA) chassis. The tire valve stem extension for the inner wheel may contact the outer wheel rim opening and become damaged.
Extensive damage to the valve stem extension may result in a loss of tire pressure of the inner wheel, increasing the risk of a crash.
TMC will notify owners, and DTNA dealers will inspect the inner wheel valve stem stabilizers, and adjust as needed and/or replace the inner valve stem, free of charge. The recall began November 2, 2020. Owners may contact TMC customer service at 1-800-524-5210 extension 104 or DTNA customer service at 1-800-547-0712. TMC's number for this recall is RC000204. DTNA's number for this recall is FL-861.
Campaign 20V559000 on NHTSA.gov
Exterior lighting, brake lightsJul 20, 2020
Thor Motor Coach (TMC) is recalling certain 2017-2020 Aria, Venetian and Tuscany, 2017 Tuscany XTE and 2017-2019 Palazzo motorhomes vehicles that received an inspection-only remedy for recall 18V-763. The rear mounted Power Distribution Module (PDM) may have been damaged during manufacturing, possibly resulting in the rear marker lights, brake lights, or turn signals not functioning.
Non-functioning exterior marker lights can increase the risk of a crash.
TMC will notify owners, and Daimler Trucks dealers will replace the PDM, free of charge. Owner letters were mailed October 6, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000196.
Campaign 20V418000 on NHTSA.gov
Representative owner complaints: equipment
2 reports, newest first. Show all
Visibility, Equipment, Other or unspecified, Jul 2, 2025
The Thor motorhome has several windows. The windows they installed are laminated windows, with two panes of glass and a seal or glue which connects the outer glass to the inner glass. The attachment method for the outer glass is ineffective. As a result, the outer glass pane comes loose from the inner and is prone to fall off or fly off at highway speeds. The risk is that the pane could strike another vehicle and possibly cause an accident. Already Thor has replaced two of the window units on this unit around 2021, not under warranty but as a customer courtesy. I now have a third window unit that is experiencing the same problem. It is apparent to me Thor has acknowledged there is a risk present when they replaced the other units. In addition, Thor has issued a recall for several year models after my year model. It seems clear they are aware there is a risk of window failure in model years outside of the recall. Unfortunately, they are unwilling to address the risk and hazard.
Structure, Equipment, Dec 29, 2019
THE FRONT CABINET ABOVE THE FRONT DASH INCLUDING THE STEERING WHEEL AND OTHER OPERATOR CONTROLS DETACHED FROM THE CEILING AND BEGAN FALLING DOWN. THIS OCCURRED WHILE THE RV WAS IN MOTION. HAD IT COMPLETELY DETACHED CONTROL OF THE RV WOULD HAVE BEEN LOST. THE SCREWS HOLDING THE CABINET FRONT PULLED OUT OF THE WHERE THEY WERE SCREWED IN ALLOWING THE FRONT OF THE CABINET TO FALL.*DT THE CONSUMER PROVIDED PHOTOS. *TR*DT*JB*DT CONSUMER SAYS THAT THERE WERE NO RV DEALERS NEARBY SO THEY REFASTENED THE SCREWS AS A STOP GAP MEASURE. DEALER AND MANUFACTURER WERE NOT CONTACTED. *DL