2008 Toyota Highlander
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 404 owner complaints filed for this model year. This is the 3rd highest complaint count among 25 Highlander model years with reports.
Of the 2008 reports, 44 involved a crash and 14 involved a fire. 42 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 10V023000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
EquipmentMay 14, 2009
SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.
THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.
SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY/JUNE 2009. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT AT 1-800-301-6859.
Campaign 09E028000 on NHTSA.gov
EquipmentApr 27, 2009
TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.
THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.
TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT TOYOTA CUSTOMER EXPERIENCE CENTER AT 1 888-270-9371 MONDAY THROUGH FRIDAY, 5:00 AM TO 6:00 PM, SATURDAY 7:00 AM THROUGH 4:00 PM PACIFIC TIME.
Campaign 09E022000 on NHTSA.gov
Seat belts, rear/otherApr 18, 2008
TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.
HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.
DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 08V181000 on NHTSA.gov
Representative owner complaints
404 reports, newest first.
Seat belts, Sep 23, 2014
THE SEAT BELT WARNING LIGHT CAME ON. AS YOU KNOW AND ANNOUNCED BY TOYOTA THERE IS A RECALL FOR THIS CABLE. HOWEVER TOYOTA IS, I FEEL DRAGGING THERE FEET DOING ABSOLUTELY NOTHING. CAN YOU CONTACT TOYOTA AND FIND OUT WHAT IS BEING DONE. ALL I GET IS THE STANDARD ANSWER----WORKING ON IT. NO FIX YET. *TR
Engine, Sep 18, 2014
THE OIL COOLER HOSE ON MY 2008 HIGHLANDER SUDDENLY MALFUNCTIONED, CAUSING MOST OF MY CAR'S OIL TO SPILL OUT ON TO THE DRIVEWAY. APPARENTLY, THIS PARTICULAR RUBBER HOSE HAS BEEN THE SUBJECT OF RECALLS AND EQUIPMENT UPGRADES TO A METAL PIPE IN OTHER TOYOTA MODELS, BUT NOT THE HIGHLANDER. THIS IS A SAFETY ISSUE THAT TOYOTA IS NEGLECTING TO ACKNOWLEDGE IN ITS HIGHLANDERS. I CALLED MY LOCAL TOYOTA DEALERSHIP TO REPORT THE PROBLEM, AND ASK WHAT TOYOTA IS DOING TO FIX IT, AND THEY DENIED THERE WAS ANY KIND OF PROBLEM WITH THE OIL COOLER HOSES. A SIMPLE GOOGLE SEARCH IMPLIES OTHERWISE. *TR
Structure, Vehicle speed control, Aug 26, 2014, crash
ATTEMPTING TO PARK CAR IN A SHOPPING CENTER. SUDDENLY ENGINE ACCELERATED UNINTENTIONALLY. HIT CURB & TREE. DAMAGE TO CAR APPROXIMATELY $6000 TO REPAIR. *TR
Air bags, Aug 7, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 4 MPH, THE SRS WARNING SENSOR ILLUMINATED CONTINUOUSLY. THE DEALER STATED THAT THE SPIRAL CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V168000 (AIR BAGS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. UPDATED 9/18/14*CN
Wheels, Jul 22, 2014
THE CAR BEGAN TO SHAKE AND WAS UNCONTROLLABLE. MANAGED TO PULL OVER AND UPON INSPECTION FOUND THAT ALL OF THE LUG NUTS ON BOTH FRONT TIRES WERE VERY LOOSE. THE CAR WAS SERVICED BY GREENTREE TOYOTA GREENTREE SCION. COMMERCE DRIVE, BROOKFIELD CT THE DAY BEFORE AND A TIRE ROTATION SERVICE WAS REQUESTED. THE LUG NUTS WERE LOOSENED BUT NEVER TIGHTENED BACK UP. *TR
Engine and engine cooling, Equipment, Jul 10, 2014
MY 2008 TOYOTA HIGHLANDER SPORT OIL COOLER LINE JUST GAVE OUT. DURING MY RESEARCH I FOUND THIS HAS BEEN A PROBLEM IN THE PAST. MY CAR HAS BEEN IN THE SHOP FOR OVER TWO WEEK. ACCORDING TO THE TOYOTA DEALER, THE RUBBER HOSE IS BEING REPLACED BY METAL. TOYOTA DOES NOT HAVE AN ETA FOR THE PART. THE DEALERSHIP IS NUMBER 90 ON THE LIST.. THEY WILL NOT PROVIDE A CAR. *TR
Electrical system, Jul 3, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED AFTER TURNING ON THE AIR CONDITIONER, IT EMITTED HOT AIR THROUGH THE VENTS AND WOULD CONTINUE TO DO SO ONCE THE AIR CONDITIONER WAS TURNED OFF. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT OFFER A REMEDY. THE DEALER DIAGNOSED THAT A COMPUTER CHIP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WERE 63,000.
Engine and engine cooling, Power train, Jun 28, 2014
WHILE DRIVING MY CARE ON THE HIGHWAY THE "LOW ENGINE PRESSURE" LIGHT CAME ON. I IMMEDIATELY EXIT THE HIGHWAY AND WENT TO THE GAS STATION. ALL THE OIL IN MY CAR LEAKED OUT. WE PUT 4 QUARTS OF OIL IN MY CAR AND WHEN YOU TURN ON THE CAR ALL THE OIL LEAKED OUT. I CALL FOR A FLAT BED TOW TRUCK AND DROP MY CAR OFF TO THE DEALER. TOYOTA HAS A RECALL 2GR-FEV6 LSC 90K, WHICH HAS THIS ISSUE. THE TOYOTA DEALER IS SAYING MY VEHICLE VIN # IS NOT EFFECTED BY THIS. HOW COULD THIS BEEN WHEN THE SAME EXACT THING HAPPEN TO MY CAR AND THEY ARE REPLACING THE PARTS THAT ARE PART OF THIS RECALL. THEY ARE CHARGING ME $900.00 TO FIX THE CAR. I NEED HELP. MY TOYOTA LIFE TIME WARRANTY DOES NOT COVER THIS!!!!!.....THIS IS A SERIOUS SAFETY ISSUE. I BELIEVE TOYOTA IS COVERING IT UP SO THAT THEY DO NOT HAVE TO HAVE ALL THE VEHICLES FIXED DUE TO THIS MALFUNCTION. *TR
Steering, Electrical system, Engine, Jun 17, 2014
WE WERE STARTING OFF TO GO ON VACATION WHEN WARNING LIGHTS CAME ON THE DASHBOARD AND INFORMATION PANEL WITH HYBRID SYSTEM WARNINGS AND BRAKE WARNINGS THEN THE CAR COMPLETELY STOPPED IN THE MIDDLE OF THE ROAD AND STEERING WAS LOST. WE WERE ABLE TO GET OFF TO THE SIDE ENOUGH TO PREVENT CAUSING AN ACCIDENT HOWEVER WE WERE ON A BUSY STREET. HAD IT TOWED TO THE LOCAL TOYOTA DEALER AND THE DIAGNOSIS WAS A FAILED COIL. THEY REPLACED ALL 3 COILS SAYING THAT IT WOULD BE PRUDENT AS THE ENGINE WAS ALREADY APART (I AGREE). THEY ALSO SAID THAT THIS IS A RELATIVELY COMMON OCCURRENCE WITH SOME OF THE HIGHLANDER HYBRIDS. I HAVE THE PART AND IT LOOKS LIKE THE TOP OF THE COIL BECAME OVER HEATED AND BLEW OUT THE TOP PLASTIC COMPOUND. I CONSIDER MYSELF VERY LUCKY THAT THIS DID NOT HAPPEN WHILE ON A HIGHWAY ON A RAINY DAY WHERE THE VEHICLE ABRUPTLY STOPPING WOULD CERTAINLY HAVE CAUSED ME TO BE IN AN ACCIDENT. THIS IS CERTAINLY A FLAW THAT TOYOTA SHOULD ADDRESS FOR SAFETY REASONS AND IT MAKES ME HESITANT TO WANT TO PURCHASE ANOTHER TOYOTA PRODUCT AGAIN. *TR
Air bags, Structure, Jun 17, 2014, crash
I WAS DRIVING NORTH ON A DIVIDED ONE WAY STREET. A 2006 MINIVAN WAS TRAVELING SOUTH ON THE OTHER SIDE OF THE DIVIDED STREET. HE MADE A LEFT HAND TURN, RAN THROUGH THE YIELD SIGN AND BROADSIDED ME ON THE DRIVER SIDE. I SAW HE WAS NOT GOING TO STOP AND TURNED THE WHEEL TO THE RIGHT, NOT IN TIME. TOOK OUT THE LEFT SIDE OF THE HIGHLANDER FROM THE FRONT WHEEL TO THE REAR PANEL. HIS FRONT AIRBAG DID DEPLOY. MY SIDE AIRBAG DID NOT DEPLOY AND I KNOW MY HEAD BOUNCED AGAINST THE SIDE WINDOW TWICE. I ASKED THE BODY SHOP TO LOOK AT THE AIRBAG AND THEY SAID THAT IT APPEARED OK AND APPARENTLY THE STRIKE DID NOT WARRANT AIRBAG INFLATION. THE HIGHLANDER IS 4 WHEEL DRIVE, 20" WHEELS. BOTH LEFT DOORS HAD TO BE REPLACED AND DAMAGE WAS LOW ON DOORS. WHEELS ALSO REPLACED. I THINK THE SIDE AIRBAG SHOULD HAVE DEPLOYED. *TR
Engine, May 28, 2014
I NORMALLY RIDE A VANPOOL, BUT DUE TO FLASH FLOOD WARNINGS TODAY I DECIDED TO DRIVE MY CAR INTO THE OFFICE. MY HUSBAND CALLED ME AT WORK TO TELL ME HE NOTICED A BIG OIL SPOT ON THE GARAGE AFTER I LEFT FOR WORK. HE TOLD ME TO PULL OVER AND NOT DRIVE MY HIGHLANDER IF IT STARTED CLACKING OR SMOKING ON MY WAY HOME. MY HUSBAND JUST CHANGED THE OIL IN MY CAR A FEW DAYS PRIOR. BEFORE I COULD MAKE IT HOME THE CAR WAS SMOKING, KNOCKING, AND SHIFTING VERY LOUDLY. MY HUSBAND SAID I WAS LUCKY THIS DIDN'T LOCK UP THE ENGINE. HE DISCOVERED OIL SPLATTERS ALL OVER THE TIRE AND NEAR THE ENGINE. WE HAD NO ISSUES AT ALL PRIOR TO TODAY. WE ARE GOING TO TRY REPLACING THE OIL LINE AS DENOTED IN OTHER PEOPLES COMMENTS. THEIR EXPERIENCES WITH THIS ISSUE MIRROR MY EXPERIENCE. I'M DISAPPOINTED TO HEAR TOYOTA ISSUED A SERVICE BULLETIN ABOUT THIS AND NOT A SAFETY RECALL. THIS COULD HAVE BEEN A HUGE SAFETY ISSUE AS I'M HAULING KIDS TO/FROM DAYCARE DURING RUSH HOUR TRAFFIC NOT TO MENTION LOCKING UP THE ENGINE. THIS CAME OUT OF THE MIDDLE OF NOWHERE. *TR
Air bags, May 27, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER 14V168000 (AIR BAGS) HOWEVER, THE CONTACT WAS NOT ABLE TO HAVE THE VEHICLE REPAIRED SINCE THE PARTS NEEDED WERE CURRENTLY UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED THE FAILURE.
Engine, May 21, 2014
TOYOTA'S T-SB-0201-1 SHOULD TRIGGER A RECALL!! MY WIFE WAS DRIVING HER '08 HIGHLANDER, WITH 2 CO-WORKER PASSENGERS, TO A FUNERAL. ON 95N IN DANVERS, MA, A MOTOR BIKER PULLED ALONGSIDE & FLAGGED MY WIFE TO PULL OVER ASAP AS THERE WAS SMOKE COMING FROM THE ENGINE COMPARTMENT AND UNDER THE CAR. AFTER STOPPING THE CAR & WAITING FOR THE SMOKE TO DISSIPATE,HE CHECKED & FOUND THERE WAS NO LONGER ANY OIL IN THE ENGINE, THE OIL HAD EMPTIED FROM THE ENGINE THE LAST FEW MILES WHILE ON THE HIGHWAY. I ARRIVED LATER THAT MORNING TO INVESTIGATE, TO DISCOVER THAT THE OIL WAS BELOW THE DIPSTICK. THE BOTTOM OF THE ENGINE & ENTIRE UNDERSIDE OF THE VEHICLE, INCLUDING THE EXHAUST SYSTEM, SPARE TIRE, WHEEL WELLS, RIGHT WHEELS & TIRES & REAR LIFTGATE WERE COATED IN ENGINE OIL. THE SMOKE APPARENTLY WAS FROM OIL SPLASHING ONTO THE HOT EXHAUST SYSTEM, & VAPORIZING DUE TO THE HIGH TEMP, CREATING A POTENTIAL FIRE HAZARD. WE HAD THE CAR TOWED TO THE NEAREST TOYOTA DEALERSHIP. THEY DETERMINED THAT AN OIL COOLER LINE EXTERNAL TO THE ENGINE - PART OF A TOWING OPTION PACKAGE THE CAR HAS - HAD RUPTURED! THE ENGINE'S OIL HAD BEEN PUMPED OUT BY THE OIL PUMP. WE HAVE SINCE DISCOVERED THAT TOYOTA HAD ISSUED A TECHNICAL SERVICE BULLETIN - T-SB-0201-11 - IN DECEMBER 2011 WHICH ADDRESSED "OIL SEEPAGE" FROM THIS EXACT OIL LINE. NOW WE ARE $480 POORER, & WE COULD HAVE EXPERIENCED A $10 K ENGINE FAILURE DUE TO SEIZING, & POSSIBLE INJURY OR LOSS OF LIFE DUE TO THIS. THIS TSB WAS NEVER PERFORMED ON OUR CAR AS WE HAD NEVER SEEN SPOTTING IN OUR DRIVEWAY FROM THIS LEAK. THE NEW PART INSTALLED WAS REDESIGNED AS SOLID METAL TUBING TO FIX THE ORIGINAL RUBBER HOSE WITH CLAMPS. INSTEAD OF RECALLING ALL OF THE AFFECTED VEHICLES TO REPLACE THIS POTENTIAL LIFE TAKER, TOYOTA SIMPLY SWEPT IT UNDER THE RUG AND ONLY REPLACED THEM WHEN SOMEONE SAW A LEAK AND ONLY WHEN THEY STILL WERE BELOW THEIR 36,000 MILEAGE WARRANTY. CRAZY! *TR
Electrical system, May 20, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THE ELECTRICAL SYSTEM FAILED TO WORK. WHEN THE VEHICLE WAS TURNED ON NONE OF THE ELECTRICAL COMPONENTS WOULD WORK. THE FAILURE OCCURRED INTERMITTENTLY OVER A PERIOD OF SIX YEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC; HOWEVER, THE DIAGNOSES WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 19,000. UPDATED 8/12/14*CN UPDATED 8/28/2017*CN
Engine, May 12, 2014
THE OIL LINE HAS DEGRADED, CAUSING TOTAL LOSS OF ENGINE OIL AND POSSIBLE ENGINE DAMAGE. *TR
Power train, Apr 14, 2014
FOLLOWING A OIL CHANGE AT LOCAL TOYOTA DEALER, A LARGE PUDDLE OF OIL (2 FOOT X 2 FOOT PLUS) FOUND UNDER CAR. I SUSPECTED OIL FILTER OR STRIPPED OIL PAN PLUG. *JS VEHICLE TOWED TO DEALER FOR INSPECTION. THEY STATED IT WAS COMPLETE FAILURE OF THE AWD TRANSFER BOX AND THAT IS WAS NOT COVERED BY WARRANTY. ESTIMATED COST TO REPAIR - $5,000.00+ NOTE - DURING A PREVIOUS OIL CHANGE AT APPROXIMATELY 63,000 MILES TOYOTA DEALER STATED THERE WAS A POSSIBLE SMALL LEAK ON THE AWD TRANSFER BOX AND THAT THEY WOULD MONITOR THIS DURING FUTURE OIL CHANGES. I WAS NEVER INFORMED, OF ANY ADDITIONAL LEAKAGE DURING ANY OIL CHANGES AT THE SAME TOYOTA DEALER. (CAR DID NOT LEAK ANY OIL PRIOR TO FAILURE OF THE AWD TRANSFER BOX)
Seat belts, Apr 10, 2014
I BELIEVE THERE IS A MANUFACTURING FLAW IN THE 2008 TOYOTA HIGHLANDER SEAT BELTS. WHEN I INITIALLY PURCHASED MY HIGHLANDER (NEW), THERE WAS A CHILD SAFETY SEAT IN THE REAR PASSENGER-SIDE SEAT, WHICH USED THE LATCH SYSTEM FOR INSTALLATION (DID NOT REQUIRE USE OF SEAT BELT). WHEN I FIRST WENT TO INSTALL A BOOSTER SEAT IN THAT POSITION, WHICH WOULD REQUIRE THE SEAT BELT TO BE USED, THE SEAT BELT DID NOT WORK (COULD NOT EXTEND BELT, WOULD NOT RETRACT, ETC.). THE BELT HAD NEVER BEEN USED AND DOES NOT WORK. I HAVE FILED SEVERAL COMPLAINTS WITH TOYOTA, BUT THEY SAID THEY WOULD NOT COVER THE REPLACEMENT OF MY SEAT BELT, BECAUSE I WAS OUTSIDE OF MY WARRANTY TIME (# OF MILES). FIRST, THE BELT HAD NEVER BEEN USED (BECAUSE A CHILD SAFETY SEAT HAD ALWAYS BEEN IN THAT POSITION SINCE I PURCHASED THE VEHICLE). SECOND, THE # OF MILES DRIVEN HAS NO DIRECT CORRELATION TO HOW OFTEN A REAR SEAT BELT IS USED. IT MAY HAVE A DIRECT CORRELATION TO HOW OFTEN THE DRIVER'S BELT IS USED, BUT NONE OF THE OTHER POSITIONS. NOW, THE OTHER SIDE REAR SEAT BELT IS STARTING TO HAVE PROBLEMS...OFTENTIMES IT DOES NOT RETRACT PROPERLY/GETS LOCKED WHEN IT SHOULDN'T, ETC. THE FRONT BELTS ALSO LOCK-UP VERY EASILY AND ARE HARD TO GET UNLOCKED ONCE LOCKED. I BELIEVE THERE TO BE A FLAW IN THE MANUFACTURING/COMPONENTS OF THESE BELTS AND FEEL TOYOTA SHOULD COVER REPLACING THEM. THIS IS A SAFETY ISSUE!!! *TR
Air bags, Service brakes, Apr 2, 2014, crash
WHILE DRIVING DOWN HIGHWAY 17 SOUTH TOWARDS SANTA CRUZ, CALIFORNIA ON A RAINING WEDNESDAY MORNING, I SUDDENLY FELT MY VEHICLE LOOSING CONTROL IN A SLIPPERY DOWNHILL HIGHWAY AND I HIT THE CENTER DIVIDER WITH THE LEFT FRONT OF VEHICLE AND CAR SPUN MULTIPLE TIMES AND HITTING THE LEFT REAR BUMPER TO THE WALL FACING THE ONCOMING TRAFFIC. THERE ARE 4 OF US IN THE VEHICLE ALL WEARING SEAT BELTS AND SUFFERED INJURIES. THE AIRBAGS DID NOT DEPLOY AND THE ANTILOCK BRAKE SYSTEM DID NOT ACTIVATE. MY INSURANCE COMPANY DECLARED THE VEHICLE TOTAL LOST. I WAS ADVISED TO CONTACT TOYOTA DEALERSHIP IN FREMONT TO INVESTIGATE THE REASONS WHY THE AIR BAG AND ABS DID NOT ACTIVATE. I AM ABOUT TO CALL THE DEALERSHIP ONCE THEY OPEN IN FEW MINUTES. *TR
Air bags, Apr 1, 2014
VEHICLE AIRBAG LIGHT ON WITH AN INDICATION OF B1801. I WAS TOLD THE AIRBAG MAY NOT DEPLOY IN AN ACCIDENT. TOYOTA HAS RECALLED OTHER MODELS FOR SIMILAR REASONS. CAR FORUMS RESEARCH HAS UNCOVERED MANY OTHER OWNERS WITH SAME ISSUE. AIRBAGS ARE A TRUE SAFETY CONCERN AND TOYOTA, NOT THE CUSTOMER SHOULD FIX ISSUE. *TR
Air bags, Apr 1, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE SRS WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO NOTICED THAT THE SRS AIR BAG SPIRAL CABLE WAS FAULTY. THE TECHNICIAN STATED THAT THE DEFECT COULD SUSPEND THE AIR BAG DEPLOYMENT DURING A CRASH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.
Engine, Mar 24, 2014
DRIVING IN PARKING LOT AT APPROXIMATELY 5MPH WHEN SMELLED BURNING OIL. PARKED CAR AND NOTICED SMOKE FROM UNDER THE HOOD. TURNED OFF CAR AND CHECKED UNDER THE HOOD AND NOTICED OIL OVER ENGINE. SEARCHED ONLINE AND SAW ISSUE WITH OIL-COOLER LINE "TOYOTA: ON SOME VEHICLES, THE ENGINE OIL COOLER PIPES MAY EXHIBIT AN OIL SEEPAGE. INFORMATION HAS BEEN PROVIDED REGARDING THIS ISSUE". THIS DID TURN OUT TO BE THE ISSUE. FORTUNATELY THIS EVEN OCCURRED WHEN WE WERE IN A PARKING LOT AND NOT DRIVING DOWN THE HIGHWAY WITH KIDS IN THE BACK. THIS IS A SIGNIFICANT ISSUE THAT COULD RESULT IN A FIRE AND/OR ENGINE DAMAGE. THE DEALER STATED THEY WERE AWARE OF THIS SERVICE NOTICE BUT NO OFFICIAL RECALL HAD OCCURRED. THIS HAS THE POTENTIAL TO BE A SIGNIFICANT ISSUE TO BOTH THE CARS AND PASSENGERS AND I HOPE THAT A RECALL WOULD OCCUR. *TR
Engine, Mar 20, 2014
HIGH PRESSURE OIL COOLER LINE FAILURE OF RUBBER HOSE SECTION DUMPED 5 QTS OF ENGINE OIL SOAKING UNDERCARRIAGE AND SPRAYING ONTO NEARBY HOT EXHAUST PIPE AND RIGHT REAR TIRE. NO INDICATION OF LOSS OF OIL PRESSURE ON VEHICLE MONITORING SYSTEM. NOTICED A FAINT SMELL OF BURNT OIL WHEN VEHICLE WAS PARKED. RETURNED LATER TO START VEHICLE AND HEARD AUDIBLE ENGINE NOISE AND TURNED OF ENGINE TO INVESTIGATE UNDER HOOD, A NOTICEABLE PUDDLE OF OIL HAD ACCUMULATED UNDER CAR. VEHICLE TOWED FOR DIAGNOSES AND REPAIR. *TR
Air bags, Mar 19, 2014
SPIRAL CABLE FAILED AT ABOUT 78 000 MILES ON MY 2008 TOYOTA HIGHLANDER BASE MODEL CAUSING AIRBAG WARNING LIGHT TO ILLUMINATE. I TOOK IT IN TO BE LOOKED AT AND I WAS TOLD OF FAILURE OF AIRBAG SYSTEM CREATING INCREASED RISK OF INJURY IN THE EVENT OF A CRASH. THE LIGHT RANDOMLY CAME ON AND WAS NOT CAUSED BY AN ACCIDENT. I AM SUSPICIOUS THAT THE FAILURE IS A MANUFACTURING AND/OR DESIGN DEFECT WHICH HAS ALSO BEEN SEEN IN OTHER TOYOTA VEHICLES THAT HAVE BEEN RECALLED FOR SIMILAR SPIRAL CABLE FAILURE. I WAS TOLD BY TOYOTA SERVICE THAT IT WOULD BE OVER $500 TO REPLACE THE CABLE SINCE IT IS NO LONGER UNDER WARRANTY. AFTER DOING A BIT OF RESEARCH ON THE INTERNET, I AM NOT THE ONLY PERSON WHO IS EXPERIENCING THIS PROBLEM. I AM HOPEFUL THAT A RECALL CAN BE DONE SO THAT MY AIRBAG CAN DEPLOY IF NEEDED. THERE WAS NOTHING I COULD HAVE POSSIBLY DONE TO CAUSE DAMAGE TO THE SPIRAL CABLE WHICH IS HOUSED INSIDE THE STEERING COLUMN; THEREFORE I BELIEVE THE MANUFACTURER SHOULD BE RESPONSIBLE FOR REPAIRING. *TR
Air bags, Mar 19, 2014
AIR BAG WARNING LIGHT LIT, TOOK TO DEALER AND FOUND OUT SPIRAL CABLE WAS THE ISSUE AND NEED REPLACED. THIS IS A HUGE SAFETY ISSUE WHICH I BELIEVE SHOULD BE RECALLED BY TOYOTA AS THEY ALREADY DID ON OTHER MODELS. AS A LOYAL TOYOTA CUSTOMER ALONG WITH THE REST, I WOULD LIKE TO CALL UPON TOYOTA TO STEP UP TO THE PLATE AND DO THE RIGHT THING--RECALL THIS AIR BAG ISSUE. THANK YOU!! *TR
Air bags, Feb 27, 2014
AIRBAG SENSOR IS ALWAYS LIT NOW. TOOK HIGHLANDER INTO TOYOTA DEALERSHIP THIS MORNING FOR OTHER TOYOTA RECALLS AND HAD THEM CHECK SENSOR. I WAS TOLD MY 2008 HIGHLANDER NEEDED A NEW SPIRAL CABLE AND COST WAS 557.00 TO INSTALL. I JUST FOUND MORE COMPLAINTS LIKE THIS AND WONDER WHY IT IS NOT A RECALL CONSIDERING OTHER TOYOTAS SUCH AS CAMRYS, TACOMAS & VENZAS HAD SAME PROBLEM BUT WAS A RECALL. WHAT DOES IT TAKE TO HAVE 2008 HIGHLANDERS INVOLVED IN A HUGE SAFETY ISSUE. APPARENTLY, I WON'T HAVE ANY AIRBAGS WORKING UNTIL THIS IS FIXED. *TR