2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
704 reports, newest first.
Steering, Dec 1, 2017
PURCHASED VEHICLE IN NOVEMBER 2015 WITH THE NOISE/ISSUE ALREADY OCCURRING. IT IS A POPPING/CLICKING WHEN TURNING LEFT OR RIGHT WITH STEERING WHEEL. HAD DIAGNOSIS DONE AT REPAIR SHOP. IT IS THE INTERMEDIATE DRIVE SHAFT THAT IS WORN/DEFECTIVE. TOYOTA HAS HAD KNOWN TSB'S ON THIS PART SINCE 2008, BUT REGARDLESS OF SAFETY CONCERNS, REFUSES TO REPLACE OR REIMBURSE.
Air bags, Seat belts, Nov 24, 2017, crash
"TAKATA RECALL", I HAD AN ACCIDENT IN WHICH MY VEHICLE FRONT END COLLIDED WITH A TREE. MY AIR BAG DID NOT DEPLOY, AND UPPER SEAT BELT DID NOT LOCK CAUSING INJURY TO MY FACE. I WAS ON A CITY STREET IN MOTION. I WAS TAKEN TO HOSPITAL VIA AMBULANCE.
Fuel/propulsion system, Nov 20, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE FUEL IN THE VEHICLE WAS BURNING UP. THE CONTACT HAD TO REFUEL THE VEHICLE VERY FREQUENTLY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC (CASSADY AUTO REPAIR, 730 N CASSADY AVENUE, COLUMBUS, OH 43219) WHO STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Air bags, Oct 8, 2017
WHILE DRIVING THE CAR THE SRS WARNING LIGHT ILLUMINATED INDICATING THAT THE AIR BAGS HAD BEEN DEACTIVATED.PULLED OFF OF ROAD IMMEDIATELY AND TURNED THE ENGINE OFF.AFTER WAITING APRX. 5 MIN. PROCEEDED TO RESTART ENGINE AND LIGHT WENT OUT.AS I RETURNED TO THE ROAD AFTER 2 MIN. THE LIGHT ILLUMINATED AGAIN AND HAS REMAINED ON.
Engine, Sep 19, 2017
EXCESSIVE OIL CONSUMPTION. THREE WEEKS AGO, AUGUST 2017, AT 100,000 MILES I HAVE HAD TO ADD 1 QUART OF OIL EVERY OTHER WEEK.
Suspension, Sep 15, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING, THE REAR OF THE VEHICLE WOBBLED AND A CLINKING NOISE WAS HEARD. THE CONTACT TOOK THE VEHICLE TO TEAM TOYOTA OF PRINCETON, NEW JERSEY (2871 US HWY 1, LAWRENCEVILLE, NJ 08648; 609-883-4200 OR 1-800-521-0623) AROUND 8/15/2016 TO HAVE THE REAR LOWER SUSPENSION ARMS REPLACED PER NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). APPROXIMATELY ONE YEAR LATER, THE FAILURE RECURRED. THE CONTACT RETURNED THE VEHICLE TO THE SAME DEALER WHERE IT WAS DIAGNOSED THAT THE REAR LOWER SUSPENSION ARMS FAILED AND WERE CAUSING UNEVEN WEAR OF THE REAR TIRES. THE DEALER STATED THAT THE REAR LOWER SUSPENSION ARMS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 1709020227. THE MANUFACTURER WAS IN THE PROCESS OF DETERMINING WHO WOULD BE RESPONSIBLE FOR THE REPAIR. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
Suspension, Sep 13, 2017
VEHICLE WAS PART OF RECALL ID: 16V596000. THE REAR SUSPENSION ARMS THAT WERE INSTALLED AS A CORRECTIVE ACTION FAILED. THE VEHICLE WAS DIAGNOSED BY TEAM TOYOTA LOCATED IN LAWRENCEVILLE, NEW JERSEY. IT HAS BEEN ABOUT 4 WEEKS SINCE DIOGNOCED AND BOTH TOYOTA AND THE DEALER ARE TRYING TO FIND WHO IS RESPONSIBLE FOR THE NEEDED REPAIR. I THINK THIS PLACES THE DRIVER AND PASSENGERS AT RISK BECAUSE NEITHER PARTY WILL TAKE RESPONSIBILITY FOR THE IMPROPER PARTS AND/OR INSTALLATION.
Other or unspecified, Sep 1, 2017
DRIVER SIDE VISOR STARTED DROPPING DOWN IN FRONT OF MY FACE. WON'T STAY UP. BLOCKS DRIVERS VIEW AHEAD OF CAR. VERY DANGEROUS. STARTED @ 60,000 MILES.
Engine, Aug 22, 2017
THE CAR STARTED KNOCKING, WENT STRAIGHT TO A SHOP AND IT TURNS OUT IT HAD NO OIL IN IT. WAS DUE FOR AN OIL CHANGE BUT NOT TO THE POINT IT SHOULD HAVE BEEN OUT OF OIL AND HAD NOT SHOWN ANY SIGNS OF LEAKING.
Suspension, Aug 3, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. TOYOTA OF CARLSBAD, CALIFORNIA WAS MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Engine, Aug 1, 2017
IT SEEMS THERE IS A PROBLEM WITH THE OIL CONSUMPTION IN MANY DIFFERENT TOYOTA VEHICLE MODELS INCLUDING MINE. I BROUGHT MY VEHICLE IN FOR SERVICE ON THIS PARTICULAR PROBLEM AND THEY DID AN OIL CONSUMPTION TEST, WHICH WAS NOT PERFORMED AS I DROVE OVER THE REQUIRED 1200 MILES. HOWEVER, THEY TOLD ME I NEEDED TO HAVE THE BOTTOM PART OF THE ENGINE REBUILT. NOT ONCE DID THEY MENTION THE ONGOING PROBLEM. I TOLD THEM I HAD TO THINK ABOUT IT AND WAS TOLD TO CHECK THE OIL MORE OFTEN THAN NORMAL. AFTER GETTING HOME AND DOING RESEARCH ONLINE DID I FIND THAT MY ENGINE CAN SEIZE AT ANY TIME EVEN WITH OIL IN IT. ALSO, IF I PAY FOR THE REPAIRS, THIS CAN HAPPEN AGAIN. I DON'T HAVE THE MONEY FOR REPAIRS NOR ANOTHER VEHICLE. THERE SHOULD HAVE BEEN A RECALL ON THIS PROBLEM. I WOULD HAVE NEVER BOUGHT MY CAR IF I WOULD HAVE KNOWN. I DON'T KNOW WHAT TO DO. CAN YOU ADVISE?
Engine, Jul 20, 2017
2006 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE PROBLEMS. *SMD THE CONSUMER STATED THE VEHICLE FAILED WHILE BEING DRIVEN. IT WAS TOWED TO THE DEALER WHERE A HOLE WAS DISCOVERED IN THE ENGINE. THE CONSUMER REQUESTED TO BE ADVISED ON HOW A HOLE COULD FORM IN THE ENGINE. THE CONSUMER HAD THE ENGINE REPLACED. *JS
Engine, Jul 19, 2017
I TOOK MY VEHICLE IN FOR A RECALL. THE TECHNICIAN FOUND IT WAS LOW ON OIL AND FILLED IT. TWO WEEKS LATER I HAD MY MECHANIC CHECK AND IT WAS LOW 2 QUARTS OF OIL. I SET MY TRIP ODOMETER. IT HAS BEEN 2000 MILES AND I HAVE HAD TO ADD 4 QUARTS OF OIL TO MY ENGINE. I AM TOLD THIS EXCESSIVE OIL CONSUMPTION IS DUE TO BAD PISTONS THAT WILL NEED TO BE CHANGED. I UNDERSTAND THIS TO BE A COSTLY REPAIR.
Vehicle speed control, Jul 13, 2017, crash
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE THE VEHICLE WAS AT A TRAFFIC LIGHT, IT ACCELERATED ON ITS OWN AND CRASHED INTO ANOTHER VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (PRESTIGE TOYOTA LOCATED AT 1096 NJ 17 RAMSEY, NJ 07446 844-838-7075) WHERE IT WAS DIAGNOSED, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE CONTACT CALLED THE MANUFACTURER AND PROVIDED CASE NUMBER: 1707072335. NO FURTHER ASSISTANCE WAS OFFERED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 76,000.
Visibility/wiper, Jul 8, 2017
DRIVER SIDE SUN VISOR, WON'T STAY UP, BLOCKS MY VIEW WHEN I'M DRIVING, HAVE TO DUCK DOWN TO SEE FARTHER THAN THE FRONT OF MY RAV4......IT SEEMS THERE IS A LOT OF PEOPLE THIS HAS HAPPENED TO, THAT THE SUN VISOR GAVE OUT, I THINK THIS IS A DRIVING HAZARD, SINCE IT BLOCKS A GOOD PORTION OF YOUR VIEW WHILE DRIVING.
Suspension, Air bags, Other or unspecified, Jul 4, 2017
SUSPENSION RECALL BY TOYOTA DEALERSHIP KEEPS ON BEING DELAYED. DEALER CONTINUES TO USE THE EXCUSE THAT THE PARTS ARE NOT AVAILABLE AND ARE SLOW TO TAKE ACTION.
Engine, Jun 28, 2017
MY RAV4 HAS BEEN CONSUMING EXCESSIVE OIL AND WHEN I TOOK IT TO THE TOYOTA SERVICE STATION, I AM TOLD IT NEEDS ENGINE OVERHAUL TO INCLUDE PISTON AND QUOTED 5258$. WHEN ENGINE OIL SIGN ON DASHBOARD HAS BEEN GOING ON SINCE JUNE 2016, AND EVERY 5000 MILES THE SERVICE CENTER TOPS THE OIL IT GOT FIXED. AND INTERMITTENTLY, I HAD TO TOP THE OIL. THE MATTER HAS GONE UNDIAGNOSED UNTIL 6/28/17. WHEN I LOOK BACK IT WAS A GLOBAL ISSUES WITH TOYOTA HTTP://WWW.TOYOTAPROBLEMS.COM/TRENDS/EXCESSIVE-OIL-CONSUMPTION/ I DID NOT RECEIVE ANY LETTERS FROM TOYOTA ABOUT THIS ISSUE. TOYOTA SAYING THE WARRANTY EXTENSION PROGRAM EXPIRED IN OCTOBER 2016 AND THEY WILL NOT PROVIDE ANY ASSISTANCE AND NOW I AM FACED WITH A BIG BILL.
Engine, Jun 15, 2017
ENGINE STARTED EXCESSIVELY BURNING OIL AT APPROX 110,000 MILE MARK. TOOK TO DEALER. WARRANTY WAS STILL VALID. ENGINE WOULD BE ALMOST DRY AT 3,000 MILE MARK. THEY DID A CONSUMPTION TEST, SAID IT PASSED. WHEN I ASKED HOW THAT COULD BE SINCE IT SHOULDN'T BE DRY AT 3,000 MILE MARK. THEY TOLD ME TO WATCH IT AND COME BACK. WHEN IT HAPPENED AGAIN, WAY BEFORE NEXT OIL CHANGE WAS NEEDED, 3,300 MILES, BONE DRY, THEY SAID MY WARRANTY WAS EXPIRED. INTERNET SHOWS THIS IS A PROBLEM WITH MY MAKE, MODEL AND YEAR CAR, THEY KNOW IT, BUT REFUSE TO RECALL DUE TO COST. THEY REFUSE TO FIX THE ENGINE.
Suspension, Jun 1, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ABNORMAL RATTLING NOISE WHICH INCREASED WHILE REVERSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE LOCAL TOYOTA DEALER IN ATLANTA (LOCATED AT 2345 PLEASANT HILL RD IN DULUTH, GA 30096) PREVIOUSLY PLACED A SAFETY NOTICE STICKER ON THE REAR SUSPENSION ARM WITHOUT NOTIFYING THE CONTACT. THE FAILURE MILEAGE WAS 64,000.
Suspension, May 29, 2017
I WAS DRIVING HOME FROM A BUSINESS TRIP ON AN INTERSTATE HIGHWAY, TRAVELLING ABOUT 70 MPH. OVER A SHORT PERIOD OF TIME THE CAR BECAME MORE DIFFICULT TO CONTROL. EVEN THE SMALLEST BUMP WOULD CAUSE THE REAR OF THE VEHICLE TO FEEL AS IF I WAS LOSING TRACTION AND "FISH-TAILING." I WAS ABLE TO GET HOME SAFETY BY REDUCING MY SPEED TO ABOUT 50 MPH. WHEN I TOOK IT TO MY LOCAL TOYOTA DEALERSHIP SERVICE DEPARTMENT I WAS TOLD THAT THE REAR RIGHT LOWER SUSPENSION ARM NEEDED TO BE REPLACED AND THAT IT WAS UNSAFE TO DRIVE. MY VEHICLE HAD BEEN INCLUDED IN TWO PREVIOUS RECALLS FOR THE IDENTICAL DANGEROUS CONDITION. THERE IS PRESENTLY A THIRD RECALL (SAFETY RECALL GOV) FOR THE SAME PROBLEM AGAIN AND INCLUDES SOME VEHICLES THAT HAVE BEEN PREVIOUSLY REPAIRED UNDER THE TWO EARLIER RECALLS. TOYOTA CUSTOMER CARE COULD NOT OR WOULD NOT EXPLAIN TO ME WHY MY PARTICULAR VEHICLE WAS EXCLUDED FROM THE GOV SAFETY RECALL EVEN THOUGH IT HAD BEEN INCLUDED IN THE FIRST TWO RECALLS. OTHER VEHICLES OF THE SAME MAKE, MODEL, AND YEAR AS MINE ARE INCLUDED IN THE GOV RECALL. IT APPEARS TO ME THAT RECALL GOV NEEDS TO BE EXPANDED. I HAD NO CHOICE BUT TO PAY FOR THE REPAIR OF THIS DEFECT OUT OF POCKET.
Steering, Suspension, Engine, May 21, 2017
I HEAR A RIDDLING NOISE FROM THE ENGINE EACH TIME I START THE CAR. CLICK SOUND WHEN I TURN THE WHEEL.
Suspension, May 11, 2017
TOYOTA SENT ME A RECALL NOTICE (NHTSA RECALL # 16V-596) IN EARLY OCTOBER 2016 SAYING I NEEDED TO BRING MY RAV4 IN TO INSPECT AND REPAIR THE REAR LOWER SUSPENSION ARM DO TO POSSIBLE EQUIPMENT FAILURE "RESULTING IN LOSS OF CONTROL AND INCREASED RISK OF A CRASH". I CALLED TO MAKE AN APPOINTMENT AND THEY SAID THE PARTS WERE NOT IN YET. I HAVE CALLED BACK EVERY MONTH FOR THE PAST 8 MONTHS AND THEY SAY THE PARTS ARE ON BACK ORDER WITH NO ETA. THIS SEEMS EXCESSIVE AND RIDICULOUS. IF THIS IS TRULY A SAFETY ISSUE, WHY DOESN'T TOYOTA MAKE NEW PARTS OR SEND OUT A LETTER SAYING THIS WAS NO BIG DEAL AND THERE IS NOT A REAL SAFETY CONCERN. DRIVING AROUND FOR 8 MONTHS WORRYING ABOUT A SUSPENSION FAILURE AND POSSIBLE ACCIDENT IS CAUSING MY PTSD TO FLAIR UP. I WOULD LIKE AN OFFICIAL RESPONSE FROM A TOYOTA EXECUTIVE EXPLAINING WHY THEY ARE TAKING SO LONG TO GET A SIMPLE PART AND GIVE ME SOME ASSURANCE THAT THEIR RECALL IS NOT JUST A JOKE.
Other or unspecified, May 6, 2017
THE SUN VISOR WILL NOT STAY UP. THIS IS A SAFTY ISSUE WHILE DRIVING.
Suspension, May 4, 2017
REAR NO. 1 SUSPENSION ARM ASSEMBLY RECALL WAS PREFORMED AND THEY STATED THAT THE REAR TOE WAS LOCKED IN PLACED AND IS NON ADJUSTABLE. NOW WHEN I TOOK THE VEHICLE FOR TIRES, THE REAR TOE IS OUT OF ALIGNMENT AND TOYOTA WILL NOT COREECT IT.
Power train, Apr 28, 2017
I BOUGHT THE CAR BACK IN AUGUST 2006 AT TOYOTA DEALER. THERE WERE CLUNKY SOUNDS FROM THE STEERING WHEEL WHEN AFTER COUPLE MONTHS OF PURCHASE. I BROUGHT THE CAR BACK TO DEALER TO REQUEST FOR A FIX BUT I WAS TOLD THAT THE CLUNKY SOUNDS FROM THE STEERING WHEEL SHOULD BE CONSIDERED AS NORMAL AS THE WAY THE IT CAME FROM TOYOTA FACTORY. THERE WAS NO FIX TO CORRECT THAT CLUNKY NOISES FROM STEERING WHEEL ON THAT DAY. I HAD TRUSTED TO TOYOTA'S ADVICE ON THAT DAY AND KEPT DRIVING THE CAR UNTIL OTHER MECHANICS AND FRIENDS TOLD ME THAT MY CAR NEEDED TO BE FIXED WITH THE STEERING WHEEL SINCE THERE HAD BEEN CLUNKY NOISES WHEN THEY TESTED DRIVE ON MY CAR. THE SOUNDS ALWAYS CAME UP WHEN I MOVED THE STEERING WHEEL. I CALLED TOYOTA SERVICE AROUND 06/2014 ABOUT THE CLUNKY NOISE SINCE THE CONDITION GOT WORSE. I WAS TOLD THAT MY CAR IS OUT OF WARRANTY SO THERE IS NOTHING FROM TOYOTA TO HELP FIXING THE PROBLEM. TOYOTA TOLD ME THAT THERE WOULD BE RECALL IF THERE HAD BEEN NUMEROUS COMPLAINTS WITH THE SAME PROBLEM I HAD. I WAS ADVISED TO WAIT FOR A RECALL. FOR SAFETY CONCERN, I BROUGHT THE CAR TO TOYOTA DEALERSHIP AFTER MY CONVERSATION WITH TOYOTA CUSTOMER SERVICE ON 06/2014. TOYOTA DEALERSHIP HAD QUOTED WITH A FIX FOR $600 FOR THE PART NOT INCLUDING THE LABOR. THE CLUNKY NOISE WAS CAME FROM THE INTERMEDIATE STEERING WHEEL SHAFT. I COULD NOT AFFORD TO FIX BECAUSE THE PRICE WAS TOO EXPENSIVE SO I HAD TO KEEP THE CAR CONDITION AS IT WAS. TOYOTA SHOULD FIX THE PROBLEM WHEN I BROUGHT IT IN. THERE HAVE BEEN SO MANY COMPLAINTS FROM 2006 TOYOTA RAV4 OWNERS WHO HAVE THE SAME THIS INTERMEDIATE STEERING SHAFT. I DON'T KNOW IF THERE HAS BEEN ANY ACCIDENT INVOLVED THIS ISSUE OR NOT BUT I AM VERY SURE THAT THIS IS A SERIOUS MATTER SINCE THIS INTERMEDIATE SHAFT IS RELATING TO THE CONTROLLING CAR'S FRONT WHEELS. FOR THE SAFETY CONCERN, PLEASE HELP TO LOOK INTO THIS COMPLAINT.