2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
704 reports, newest first.
Power train, Apr 26, 2017
WHEN TRYING TO BACK UP A HILL, THE TRANSMISSION POPS OUT OF GEAR AND THEN BACK INTO GEAR. WHEN IT POPS BACK INTO GEAR THE CAR LUNGES IN AN UNCONTROLLABLE MANNER. THIS IS VERY DANGEROUS! I HAVE READ THAT THIS IS CAUSE BY PREMATURE WEAR-OUT OF THE REVERSE CLUTCHES AND THE FIX IS A NEW $4000 TRANSMISSION. THIS IS A SAFETY ISSUE THAT TOYOTA SHOULD AT LEAST PROVIDE AN ASSISTANCE PROGRAM TO REPAIR. THE PROBLEM IS CONTINUOUS, IT WAS ALWAYS OCCUR WHEN TRYING TO BACK UP A HILL.
Engine, Apr 26, 2017
THIS CAR HAS THE INFAMOUS TOYOTA EXCESSIVE OIL CONSUMPTION ISSUE WITH THE 2.4 L I4 ENGINE. IT BURNS A QT OF OIL IN 2000 MILES OR LESS.
Electrical system, Electronic stability control (ESC), Engine, Apr 25, 2017
COMPUTER PROBLEMS CAUSING ALL THE LIGHTS TO COME ON THE DASHBOARD AND DISABLING THE SHIFTING SOLENOID. IT ALSO DISABLES THE SAFETY BRAKING AND FOUR WHEEL DRIVE. THIS CAUSES THE VEHICLE TO BE UNSAFE.
Engine, Apr 18, 2017
MY 2006 RAV4 HAS AN OIL CONSUMPTION PROBLEM. THE CAR WAS BURNING 1/2 QUART OF OIL EVERY 300 MILES. I AM PAYING $3500 TO HAVE THE PISTONS AND RINGS REPLACED.
Suspension, Other or unspecified, Apr 6, 2017
NTSB: 2006 TOYOTA RAV4 SECOND RECALL FOR REAR END SUSPENSION. *BF THE CONSUMER WAS STATED THE VEHICLE MALFUNCTIONED AFTER IT WAS REPAIRED UNDER RECALL. INFORMED THE STRUTS LOCKED UP BECAUSE THE VEHICLE WAS ON A LIFT FOR LONG PERIODS OF TIME. THE CONSUMER PAID TO HAVE THE VEHICLE REPAIRED. THE CONSUMER WOULD LIKE TO BE REIMBURSED THE COST OF THE REPAIRS. UPDATED 04/17/2017 *JS
Engine, Mar 28, 2017
WHILE DRIVING EAST ON I-490 FROM ROCHESTER TO I-90, THE CHECK ENGINE LIGHT CAME ON AND THE ENGINE WAS MISFIRING. WE EXITED THE FREEWAY AND THE CHECK ENGINE LIGHT STARTED TO FLASH, THE ENGINE SPUTTERED AND DIED. I PUT THE CAR IN NEUTRAL AND PARKED ON THE RIGHT CURB. FORTUNATELY THIS HAPPENED ON A CITY STREET AND NOT ON THE FREEWAY. POWER STEERING WAS OF COURSE LOST, SO THE MANEUVER WAS DIFFICULT. AAA TOWED THE CAR TO OUR REPAIR SHOP, AND THEY REPORTED 24 ENGINE CODES WERE THROWN, AND RECOMMENDED A COMPLETE ENGINE TUNE-UP, INCLUDING REPLACEMENT OF THE SIX IGNITION COIL PACKS, SPARK PLUGS, AND INTAKE MANIFOLD GASKETS. MUCH OF THE $1,000 EXPENSE WAS 4.5 HOURS OF LABOR, TO REMOVE THE INTAKE MANIFOLD (NECESSARY TO REACH THE REAR BANK OF CYLINDERS 1,3,5). THIS WAS NOT THE FIRST TIME THE IGNITION COILS HAVE FAILED ON THIS VEHICLE. IN OCTOBER 2012 (AROUND 50K MILES) ENGINE CODE P0354 WAS THROWN, AND I REPLACED THE COIL ON CYLINDER 4. IN JANUARY 2014 (AROUND 58K MILES) CODE P0356 WAS THROWN, AND I REPLACED THE COIL ON CYLINDER 6. SINCE THE DANGEROUS INCIDENT OF LOST POWER AND REPLACEMENT OF ALL SIX COILS ON 14 JUNE 2016 (AROUND 80K MILES) ONLY NINE MONTHS AND 7K MILES LATER, CODE P0351 (BAD COIL ON CYLINDER 1) WAS THROWN ON 24 MARCH 2017, AND NOW CODE P0355 (CYLINDER 5) WAS THROWN ON 28 MARCH 2017. I HAVE ALREADY SPENT AROUND $1,200 TO DEAL WITH THIS PROBLEM, AND THE CAR IS TODAY BACK IN THE REPAIR SHOP TO HAVE TWO REAR BANK COILS REPLACED, FOR $229. THERE IS CLEARLY SOMETHING WRONG WHEN THESE COILS ARE FAILING UNDER NORMAL OPERATING CONDITIONS, ESPECIALLY AFTER ONLY 7K MILES. THIS IS NOT JUST A PROBLEM FOR US. OTHER REPAIR SHOPS HAVE SAID THIS ERA OF RAV4 IS KNOWN FOR THIS PROBLEM. SEE HTTP://WWW.CARPROBLEMZOO.COM/TOYOTA/RAV4/IGNITION-COILS-FAILURE-PROBLEMS.PHP AND YOU CAN FIND OTHER SIMILAR RECORDS OF THIS PROBLEM SEARCHING ONLINE.
Suspension, Mar 28, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT.
Electronic stability control (ESC), Mar 21, 2017
UPDATING THE RECENT COMPLAINT, WARNING LIGHTS:-CHECK ENGINE,VSC, TCS,BREAK,4WD LIGHTS ARE KEEP ON COMING , VEHICLE LOOSES ALL POWER ASSISTANCE. THIS IS THE 4TH TIME I AM EXPERIENCING THE SAME PROBLEM. THIS VEHICLE WAS WITH AUTO MECHANIC FEW DAYS AGO AND HE CHANGED THE BATTERY AND CHECK THE ALTERNATOR, ALL IN GOOD CONDITION. YESTERDAY MORNING I WAS ON THE WAY TO WORK,ALL WARNING LIGHTS CAME AND I HAD TO STOP THE CAR IN FREEWAY, I TURNED OFF THE ENGINE AND LEFT THE VEHICLE FOR FEW MINUTES,STARTED ENGINE AND ENGINE LIGHT WERE ON, BUT ALL POWER CAME BACK AND I COULD WENT BACK BACK TO MY HOME. I LEFT THE THIS CAR AT HOME AND TOOK MY 2ND CAR AND WENT FOR WORK. EVENING I CHECK THE CAR, MY CAR LOOKS NORMAL THERE WAS NO WARNING LIGHTS, IT WAS RUNNING NORMAL. I BELEIVE THIS CAR HAS SOME SERIOUS ELECTRONIC PROBLEM( UNABLE TO DETECT THROUGH DIAGNOSTIC MACHINE).WHICH I CHECK WITH 3 DIFFERENT MECHANICS.
Suspension, Mar 20, 2017
2006 TOYOTA RAV 4. LETTER FROM [XXX] RE 2006 TOYOTA RAV4 4WD 2.4 L, NHTSA SAFETY CAMPAIGN NO. 16V596000. *LD [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *PM *TR
Suspension, Mar 16, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT
Engine, Mar 14, 2017
EXCESSIVE OIL CONSUMPTION MY CAR'S ENGINE IS BURNING EXCESSIVE AMOUNTS OF OIL. WHILE I'VE HAD THE PROBLEM FOR YEARS, IT IS GETTING SIGNIFICANTLY WORSE AND I HAVE BEEN ADDING OIL MULTIPLE TIMES BETWEEN MY SCHEDULED SERVICES. SINCE I AM AWARE OF THE ISSUE I'VE BEEN DILIGENT ABOUT CHECKING MY LEVELS, BUT I FOUND OUT IT WAS AN ISSUE WHEN MY CAR TURNED OFF WHILE I WAS DRIVING (I WAS LUCKY TO HAVE BEEN IN A PARKING LOT AT THE TIME).
Engine, Mar 13, 2017
AFTER MY ENGINE OIL LIGHT FLICKERED BRIEFLY A FEW TIMES WHEN DRIVING. I HAD THE OIL CHECKED AND FOUND IT VIRTUALLY EMPTY, WE PUT A QUARTER IN AND TOOK IT TO THE DEALERSHIP WHERE THEY FILLED MY OIL AND TAPED THE OIL CAP AND HAD ME RETURN BETWEEN 1000 AND 1300 MILES. TODAY I TOOK IT IN AT 1200 MILES AND WAS 2 QUARTS LOW. HAVE HAD ALL OF MY OIL CHANGES DONE AT 3000 MILES AT THE SAME DEALERSHIP THE CAR WAS PURCHASED. THEY CLAIM A LETTER WAS SENT OFFERING A OIL CONSUMPTION TEST AND WOULD HAVE POSSIBLY COVERED REPAIRS IF I HAD AN ISSUE DURING THE 10 YEAR PERIOD THEY WERE OFFERING WARRANTY ENHANCEMENT. I NEVER SAW SUCH A LETTER. MY CAR NEVER HAD LOWE OIL RECORDED UNTIL MY ONE OIL CHANGE WHERE I WAS BASICALLY EMPTY. I HAVE FILED A CLAIM WITH TOYOTA, BUT THEY ARE SAYING THERE IS NOTHING THEY WILL DO FOR ME. THIS IS A WELL KNOWN ISSUE WITH MANY LAWSUITS AND SHOULD BE A RECALL. NEVER ONCE DID THE SERVICE PEOPLE EVER MENTION THIS ISSUE OR OFFER TO DO THE OIL CONSUMPTION TEST WHEN MY CAR WAS UNDER WARRANTY. THE ENGINE IS PROBABLY GOING TO REQUIRE A NEW PISTONS AND RINGS AND COST SEVERAL THOUSAND DOLLARS TO FIX. I THINK TOYOTA NEEDS TO STEP UP AND TAKE RESPONSIBILITY FOR THESE FAULTY ENGINES THEY PUT IN THEIR TOYOTAS.
Electrical system, Mar 9, 2017
I HAVE 2006 TOYOTA RAV4-BATTERY WARNING LIGHTS FLIPS AND GO,- WHEN I WAS DRIVING IN FREEWAY 68MPH, BATTERY WARNING SIGNALS FLIPS TWO TIMES WHILE I TRY TO ACCELERATE THE VEHICLE. AND ALSO ALL WARNING SIGNALS, CHECK ENGINE, TCS, VSC, 4 WD, BREAK, AND AIRBAG SIGNALS CAME AND VEHICLE LOST ALL ELECTRICAL POWER, STEERING BECOME HARD AND BREAK DIDN'T WORK, I HAD TO PULL OVER THE VEHICLE IN FREEWAY. IT HAPPED TWO TIMES, STILL THE BATTERY SIGNALS ARE FLIPS WHEN PUSH THE GAS. I HAD TO TOW THIS VEHICLE TWO TIMES. I CHECK THIS CAR WITH THREE MECHANICS AND AUTOZONE, THEY COULD NOT FIND OUT ANY PROBLEM,. THEY ALL SAID BATTERY AND ALTERNATORS ARE WORKING GOOD ( BATTERY AND ALTERNATORS ARE REPLACED TWO EARS AGO. I HAVE SEEN MANY 2006 TOYOTA RAV4 CUSTOMERS EXPERIENCING THE SAME PROBLEM. DRIVING THIS VEHICLE IS SCARY AND LIFE THREATENING. I HOPE HIGHWAY SAFETY IS; AWARE OF THIS PROBLEM AND THEY WILL MAKE AN ENQUIRY/ACTION.
Tires, Mar 8, 2017
GOODYEAR 225/65R17 102T SL ASSURANCE FUEL MAX TL
Steering, Suspension, Service brakes, Mar 2, 2017
TOYOTA DEFECTS
Fuel/propulsion system, Mar 1, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THERE HAD BEEN EXTENSIVE SMOKE COMING FROM THE MUFFLER, STRONG FUMES AND A LOUD NOISE PROGRESSED. A POLICE OFFICER CAUTIONED THE CONTACT TO GET THE VEHICLE REPAIRED OR THAT HE MAY BE POTENTIALLY TICKETED WITH THIS BEING A SAFETY HAZARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE MUFFLER. THE CONTACT LATER RECEIVED A SPECIAL SERVICE COVERAGE CAMPAIGN LETTER IN WHICH THE MANUFACTURER STATED THAT THE DEALER WAS TO REPLACE THE MUFFLER. THE DEALER REFUSED TO SERVICE THE VOLUNTARY CAMPAIGN FROM THE MANUFACTURER. THE CONTACT WAS UNCERTAIN AS TO WHY THE MANUFACTURER AND THE DEALER HAD NOT COMPLIED TO REPLACE THE PART WITH A NEWLY DESIGNED OEM MUFFLER. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Steering, Other or unspecified, Service brakes, Feb 20, 2017
TAKATA RECALL, NOISE FROM RIGHT SIDE OF THE ENGINE. VERY, VERY LOUD NOISE.ALSO, HARD TO TURN THE STEERING WHEEL.
Suspension, Feb 15, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Suspension, Feb 7, 2017
MANUFACTURER HAS NOT MADE PARTS AVAILABLE FOR RECALL #16V596 DATED 8-10-2016 AND THERE IS NO KNOWN DATE WHEN IT WILL BE AVAILABLE. YOUR LETTER EXPLAINS SAFETY RISK IF NOT REMEDIED COULD RESULT IN A LOSS OF VEHICLE CONTROL. MY CAR IS 11 YEARS OLD AND I AM CONCERNED. TRIED TO SCHEDULE REPAIR TODAY AND PARTS STILL ON BACKORDER
Steering, Feb 1, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT UPON TAKING THE VEHICLE TO THE DEALER FOR ROUTINE SERVICING, A SERVICE MECHANIC AT THE DEALER NOTICED AN ABNORMAL NOISE. THE VEHICLE WAS DIAGNOSED AND THE STEERING SHAFT NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THERE WAS AN ABNORMAL NOISE WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS PENDING A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Electrical system, Jan 30, 2017
TRANSMISSION HARSH SHIFT, NO ACCELERATION, EXTREAMLY DANGEROUS TO DRIVE, ECU NEEDS REPLACED, POOR QUALITY VEHICLE.
Engine, Jan 28, 2017
THE CAR IS BURNING OIL AND I WAS TOLD TO BRING IT IN FOR CONSUMPTION TEST WHEN I GOT THERE THE DEALER TOLD ME IT IS NO LONGER UNDER WARRANT. BUT I KNOW BY DOING RESEARCH THAT IT IS.
Engine, Jan 11, 2017
BAD ACCELERATION,ENGINE WILL NOT PICK UP FAST, IF I TRY TO ACCELERATE ENGINE SOUNDS HIGH, THE CAR WILL NOT PICK UP THE SPEED UP FOR FEW SECONDS AND IT JUMPS IN THE TRACK. ALL ENGINE LIGHTS CAME,VEHICLE LOST THE POWER AND I LOST CONTROL OVER THE VEHICLE,I HAD TO STOP IN FREEWAY AND CALL TOW TRUCK.THIS CAR BURNS OIL SO FAST EVERY 1000 MILES I HAVE TO PUT NEW OIL ON THIS CAR.
Suspension, Jan 3, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE CONTACT STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 03/03/17*LJ *TR
Engine, Dec 27, 2016
OIL COMPSUMTION RECALL HAS NOT BEEN HONORED.