2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
704 reports, newest first.
Engine, Dec 21, 2016
10/26/15 WAS SERVICED BY GERMAIN TOYOTA, NAPLES, FL, OIL TANK WAS EMPTY AND ENGINE WAS OVERHEATED. THE CAR HAD BEEN DRIVEN 3711 MILES SINCE LAST OIL CHANGE (THERE WAS NO LEAK). I PUT A QUART OF OIL IN SO THAT I COULD DRIVE IT TO THE DEALER. THEY PERFORMED THEIR VERSION OF AN OIL CONSUMPTION TEST AND CLAIMED IT PASSED THE TEST. 3/11/16 OIL TANK WAS EMPTY AND CAR WAS OVERHEATED. IT HAD BEEN DRIVEN 2496 MILES SINCE THE PREVIOUS OIL CHANGE. THEY SAID IT HAD PASSED THE PREVIOUS TEST & ALL WAS OK. 10/7/16 OIL TANK WAS EMPTY, HAD BEEN DRIVEN BUT I HAD PURCHASED 3 QTS OF OIL AND ADDED IT TO THE EMPTY TANK. PRIOR TO ME ADDING THE OIL, CAR WAS EXTREMELY OVERHEATED AND I GOT BURNED TRYING TO GET THE HOOD UP. I COULD NOT TOUCH ANY PART OF THE ENGINE OR WOULD HAVE BEEN SEVERELY BURNED. THE CAR NOW FAILED A NEW OIL CONSUMPTION TEST. THEY ADVISED THEY COULD NOT FIX IT BECAUSE AS OF 4/3/2016 IT WAS OUT OF THE THEIR EXTENDED 10-YR WARRANTY FOR OIL CONSUMPTION PROBLEM. THEY TOLD ME IT IS NOW MY RESPONSIBILITY TO CONTINUALLY ADD OIL. IF A SAFETY HAZARD SHOULD OCCUR THEY SAID IT WOULD BE MY FAULT AND NOT THEIRS. IN ALL CASES ABOVE THE ENGINE WAS ON, VEHICLE IN MOTION ON CITY STREETS WHEN THE INDICATOR LIGHT CAME ON OR CAR OVERHEATED. THERE WAS NO OIL ON THE DIP STICK WHEN CHECKED IN EVERY ONE OF THE CASES.
Steering, Structure, Service brakes, Dec 16, 2016
VEHICLE FRAME CHASSIS CORROSION UNSAFE DEFECTS.
Suspension, Dec 10, 2016
THIS COMPLAINT IS IN REGARDS TO TOYOTA'S FAILURE TO REMEDY REAR LOWER SUSPENSION ARM ASSEMBLIES DEFECT WITHIN A REASONABLE TIME. TOYOTA OF ORANGE HAS MADE MULTIPLE APPOINTMENTS FOR THE REMEDY, HOWEVER WHEN VEHICLE IS BROUGHT IN FOR SERVICE, PARTS ARE NO LONGER AVAILABLE. ATTEMPTED TO HAVE RECALL SERVICE DONE AT LONGO TOYOTA, HOWEVER URGENT SAFETY RECALL IS NOT A PRIORITY ON SUNDAYS AND REQUESTS FOR SERVICE ARE REJECTED.
Tires, Wheels, Dec 2, 2016
I BOUGHT A 2006 RAV4 OVER THE WEEKEND AND THE UNDERINFLATION LIGHT IS ON. I CHECKED THE 4 TIRES ON THE GROUND AND THEY WERE ALL OK. I DECIDED TO CHECK THE SPARE AND AFTER ABOUT 30-45 MINUTES OF FRUSTRATION, I GAVE UP TRYING TO REMOVE THE COVER. I CALLED SERVICE AND THE TECH SAID, SOMETHING LIKE, "YEAH, THOSE ARE HARD TO GET OFF AND EVEN HARDER TO GET BACK ON." ANYWAY, THIS IS THE COVER WITH THE HARD SHELL AND THE VINYL WITH ELASTIC AROUND THE BACK--IT DOES NOT HAVE THE LATCH. I FINALLY GOT THE VINYL COMPLETELY PULLED TOWARDS THE BACK AND AROUND THE HARD SHELL BUT I YANKED, PULLED AND PRIED AND COULDN'T GET THE HARD SHELL TO BUDGE. IT WAS COLD IN THE GARAGE AND MY HANDS PROBABLY WEREN'T WORKING SO WELL BUT IT SHOULD BE EASIER. THE QUESTION IS: WHAT IF I HAVE A FLAT TIRE WHILE IN HIGHWAY, FIRST OF ALL REMOVING THIS COVER IS NOT EASY AT ALL FOR MEN, WHAT ABOUT WOMEN? ALSO, STOPPING ON THE HIGHWAY SHOULDER FOR LONG TIME TRYING TO REMOVE THIS COVER IS NOT A SAFE OPTION. I SAW ANOTHER RAV4 WITH THE SAME SHAPE OF THIS COVER BUT WITHOUT THIS VINYL. IT'S LIKE A BODY FROM BACK AND THE SHELL CAP OVER IT. THIS ONE TAKES LESS THAN A MINUTE TO REMOVE IT. I BELIEVE THAT TOYOTA SHOULD RECALL THIS TYPE OF SPARE TIRE COVER AND CHANGE IT WITH THE NEWEST BODY AND SHELL ONE. *TR
Steering, Nov 10, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT HEARD AN ABNORMAL LOUD NOISE PROGRESSING FROM THE AREA OF THE STEERING WHEEL WHILE THE VEHICLE WAS IN MOTION, REVERSING, OR MAKING A TURN. THE DEALER TEST DROVE THE VEHICLE, BUT WAS UNABLE TO REPLICATE THE FAILURE. FURTHER DIAGNOSTIC TESTING WAS REQUIRED. AN INDEPENDENT MECHANIC ALSO INSPECTED THE VEHICLE, BUT PROVIDED NO SPECIFIC DIAGNOSIS TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Engine, Oct 31, 2016
EXCESSIVE ENGINE OIL BURNING AND ITS CONSUMPTION
Engine and engine cooling, Electrical system, Oct 27, 2016
2006 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO DISAPPOINTMENT WITH ALTERNATOR REPAIR WORK AT DEALERSHIP. *SMD THE CONSUMER STATED SHE DID NOT THINK SHE NEEDED AN ALTERNATOR REPLACEMENT. AFTER THE ALTERNATOR WAS REPLACED, THE BATTERY LIGHT ILLUMINATED. ACCORDING TO THE INVOICE, THE DEALER REPLACED THE SHORT ENGINE BLOCK. THE DEALER NOT CHARGE THE CONSUMER FOR THE REPLACEMENT OF THE ALTERNATOR AND ENGINE SHORT BLOCK. HOWEVER, THERE WAS A CHARGE FOR AN ENGINE GASKET AND CYLINDER. *JB
Other or unspecified, Sep 20, 2016
SLOWING DOWN AT AN INTERSECTION AND BRAKES START TO FAIL WHEN I'M ALMOST FULLY STOPPED AND THEN THE CAR CONTINUES TO MOVE FORWARD WHEN GOING LESS THAN 5MPH
Steering, Suspension, Engine, Sep 11, 2016
GOOD DAY ' PLEASE: APPRAISE UNSAFETY DEFECTS. THANKFUL.
Engine, Aug 31, 2016
EXCESSIVE OIL CONSUMPTION. - TOYOTA WON'T FIX
Suspension, Aug 18, 2016
ON AUGUST 11, 2016, TOYOTA ANNOUNCED A RECALL FOR REAR SUSPENSION NHTSA 16V596 TO AGAIN REPLACE REAR SUSPENSION ARMS AND THEN EPOXY THEM TO PREVENT CORROSION. THIS DENIES THE OWNER TO ALIGN THE REAR WHEELS IN THE FUTURE. TOYOTA AND OTHER MANUFACTURERS HAVE BEEN BUILDING CARS FOR YEARS THAT HAVE NOT REQUIRED EPOXYING OF PARTS TO PREVENT CORROSION SO WHAT IS THE PROBLEM HERE. HAS TOYOTA USED INFERIOR MATERIALS? ISN'T THERE SOME WAY FOR TOYOTA TO MAKE THE REPAIR AND STILL ALLOW FOR PROPER ALIGNMENT EVEN IF IT COSTS A SMALL AMOUNT MORE? IMPROPER ALIGNMENT WILL RESULT IN INCREASED TIRE WEAR AND DECREASED FUEL ECONOMY AND POSSIBLY DECREASED CONTRO WHILE DRIVING. MY CAR NOW HAS 91,500 MILE ON IT AND I INTEND TO KEEP IT FOR MANY YEARS. WHY SHOULD I BE DENIED THE ABILITY TO PROPERLY MAINTAIN THE CAR?
Steering, Electrical system, Engine, Aug 13, 2016
UNSAFE DEFECTS MALFUNCTION
Seat belts, Aug 10, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V096000 (SEAT BELTS) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Suspension, Jul 18, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT EXPERIENCED EXCESSIVE WEAR ON THE REAR TIRES. PRIOR TO THE FAILURE, THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED PER NHTSA CAMPAIGN NUMBER: 13V383000 (SUSPENSION). PRIOR TO THE RECALL, THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT ONCE THE VEHICLE FELL OUT OF ALIGNMENT, THE TIRES COULD NOT BE ADJUSTED DUE TO THE EPOXY. THE REAR SUSPENSION ARM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 225,000.
Steering, Electrical system, Engine, Jul 14, 2016, crash
TOYOTA DEFECTS MALFUNCTIONING
Engine, Jun 30, 2016, crash
CONSUMING A LOT OF OIL, WHEN VEHICLE ARE IN MOTION,I DID OIL CHANGE AND NOT RUN EVEN 1000 MILE AND IT WHEN TO LOWER POINT WHEN I CHECK IT IN THE MORNING BEFORE START THE CAR, I COMPLAINT TOYOTA AGENCY NOTHING SOLVE I DO NOT WHAT TO DO, PLEASE HELP, THANKS IN ADVANCE FOR ANY HELP.
Visibility/wiper, Jun 21, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V689000 (VISIBILITY); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Seat belts, Jun 15, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V096000 (SEAT BELTS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 08/30/16*LJ
Engine, Jun 5, 2016
VEHICLE BURNS OVER ONE QUART OF OIL EVERY 1,000 MILES OR LESS. THIS WAS FIRST OBSERVED IN 2015 AFTER THE VEHICLE HAD ABOUT 120,000 MILES. THROUGHOUT IT'S LIFE THE VEHICLE HAS RECEIVED REGULARLY SCHEDULE MAINTENANCE. THIS PROBLEM CAN CREATE AN UNSAFE CONDITION AND POTENTIALLY SUDDEN ENGINE FAILURE IF NOT REGULARLY CHECKED.
Seat belts, Jun 2, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V096000 (SEAT BELTS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Engine, Jun 2, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING AT ANY SPEED, THE VEHICLE CONSUMED OIL EXCESSIVELY. THE VEHICLE WAS DRIVEN TO THE DEALER AND PASSED THE OIL CONSUMPTION TEST. AT 2,500 MILES, THE VEHICLE BURNED ALMOST THREE QUARTS OF OIL. THE WARRANTY WAS EXTENDED THROUGH TO OCTOBER OF 2016. THE CONTACT STATED THAT THE TEST WAS INACCURATE. THE FAILURE MILEAGE WAS 112,100.
Steering, Electrical system, May 26, 2016
WHILE SITTING IN SLOW 5-10MPH TRAFFIC ON THE FREEWAY, THE POWER STEERING SEIZED AND THE AIRBAG DASHBOARD WARNING LIGHT CAME ON AT THE SAME TIME (FOR ABOUT 2-3 SECONDS AT A TIME). A FEW MILES LATER, OTHER WARNING LIGHTS (VSC, SLIP, ABS, ENGINE, BATTERY) ALL ILLUMINATED ON AND OFF RANDOMLY. TOOK IT TO THE MECHANIC TO HAVE IT LOOKED AT. THEY REPLACED THE BATTERY, BUT THE PROBLEM HAPPENED AGAIN ABOUT 12 HOURS LATER. THE ALTERNATOR IS A YEAR OLD AND THE BATTERY, TIRES, ALIGNMENT, AND ENGINE COILS ARE ALL BRAND NEW. AFTER HALF A DOZEN CALLS TO THE DEALERSHIP, COME TO FIND OUT, THE PROBLEM IS THE COMPUTER THAT CONTROLS THE POWER STEERING... A PROBLEM WHICH HAS BEEN ACKNOWLEDGED AND RECALLED FOR 2014-15 MODEL YEAR RAV4S. THIS IS A SERIOUS SAFETY FLAW, AND IT IS INSULTING AND NEGLIGENT THAT TOYOTA IS PRETENDING THIS ISN'T A SERIOUS PROBLEM FOR OTHER MODEL YEARS.
Steering, Apr 25, 2016
STEERING COLUMN CLUNKING NOISE WHEN TURNING THE WHEEL. ON-GOING ISSUE SINCE DECEMBER 2015.
Seat belts, Tires, Electronic stability control (ESC), Fuel/propulsion system, Apr 21, 2016
DEAR, NHTSA DATABASE: TOYOTA ? MOTOR SALES (TMS), U.S.A. INC.; MOTOR CREDIT CORPORATION (TMCC); FINANCIAL SERVICES SECURITIES USA CORPORATION; GOODYEAR TIRE & RUBBER COMPANY (GOODYEAR.COM) UNSAFE:TOYOTA 2006 RAV4 (VIN) [XXX]. DEFECTS UNREPAIRABLE: 4 .JPG; UNREPAIRABLE RECALLS SAFETY RISK:1 .PDF; PROTECT SAFELY & SAFEGUARD ? PLEASE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Visibility, Apr 5, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE WINDOW WAS ACTIVATED, BUT FAILED TO FUNCTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 16V096000 (SEAT BELTS), 15V689000 (VISIBILITY), 13V383000 (SUSPENSION), AND 11V113000 (VEHICLE SPEED CONTROL). THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.