2007 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,003 owner complaints filed for this model year. This is the highest complaint count among 26 RAV4 model years with reports.
Of the 2007 reports, 53 involved a crash and 37 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: engine
236 reports, newest first. Show all
Suspension, Traction control system, Engine, Dec 9, 2024
The contact owns a 2007 Toyota Rav4. The contact stated while driving at various speeds, there was an abnormally loud sound coming from underneath the vehicle. The vehicle was taken to an independent mechanic, where the contact was informed that the sound was coming from the tires. The contact was informed that no issues were found. Additionally, the contact stated that the check engine warning light, the traction control warning light, and an unknown warning light were illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown. The VIN was not available.
Electrical system, Engine, Jan 22, 2023, fire
I was driving and the engine caught on fire. Thank God for people telling me that my car was having flames coming from under my car. By the time I pull over flames were coming out of my hood
Engine, Apr 22, 2022
The contact owns a 2007 Toyota Rav4. The contact stated that the vehicle was consuming an excessive amount of oil. The contact stated that the check engine warning light was illuminated. The contact stated that a quart of oil each was added each week. The vehicle was taken to the local dealer where it was diagnosed that the charcoal canister needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was notified of the failure however, no additional assistance was provided. The approximate failure mileage was 150,000.
Engine, Nov 29, 2021
The contact owns a 2007 Toyota Rav4. The contact noticed that his vehicle was consuming an excessive amount of oil upon inspection. The contact stated that he had to add two quarts of oil to the engine every five weeks. The contact went to a dealer where he purchased a PCV valve and a hose connection; the contact's neighbor performed the work on the vehicle. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 106,000.
Engine, Oct 10, 2021
Excessive oil consumption. Oil checked religiously every Friday. (Added 1-1.5 quarts weekly 500-700 miles). Vehicle owned 21 months. Oil checked and added on Friday 10/08, Saturday 10/09 Engine failed, no oil on dipstick and motor has a grinding sound.
Engine, Jun 21, 2021
this is a follow up email regarding my car 2007 toyota rav 4 FWD 4 cylinder ; oil consumption of this model is too much 1 quart every 250 - 300 miles. Toyota already know and acknowledge the problem but with my case when I went to the dealer they just told me that it passed the test. If NHTSA will help us voice our concern maybe toyota will consider this to become a recall
Engine, Apr 6, 2021
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED WHILE THE VEHICLE WAS BEING SERVICED, HE NOTICED THAT THE VEHICLE WAS CONSUMING OIL QUICKLY. THE CONTACT STATED THAT HE WOULD ADD A QUART OF OIL EVERY 500 MILES. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND REFERRED THE CONTACT TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.
Engine, Sep 9, 2020
VEHICLE CONSUMES HIGH AMOUNTS OF OIL. I DRIVE THE VEHICLE AROUND 300 MILES PER WEEK IT CONSUMES AROUND A QUART AND A HALF. ALSO THE ENGINE IS LOSING COMPRESSION. ALSO THE ENGINE IS LOSING COMPRESSION
Engine, Jul 29, 2020
THIS CAR BURNS ENGINE OIL DRAMATICALLY. I DID MY OIL CHANGE AT JIFFY LUBE AND I HALF WAY THRU TO THE NEXT OIL CHANGE THE MAINTENANCE REQUIRED LIGHT CAME AND WHEN I TOOK IT BACK TO THEM THEY HAD TO ADD ALMOST 2 QUARTS OF OIL. I THINK THAT'S UNACCEPTABLE. THERE ARE NO OIL LEAKS AND THIS IS HAPPENING EVERY TIME WE CHANGE OIL. WE GOT THE VEHICLE IN FEB 2019
Steering, Suspension, Engine, Jul 16, 2020
OIL BURNING. MASSIVE AMOUNTS OF OIL BURNING. A QUART EVERY 200 500 MILES ON AVERAGE.
Engine, Jul 7, 2020
SIGNIFICANT BURNING OF ENGINE OIL, ALMOST NOTHING APPEAR ON THE DEEP STICK WHEN I CHECK IT, NO LEAKED OR WHAT SO EVER FROM TOP TO BOTTOM OF THE ENGINE.
Engine, Jul 2, 2020
TOYOTA USES A SOY FOOD BASED PRODUCT IN THE INSULATION OF THE ENGINE WIRING. APPARENTLY IT ATTRACTS MICE THAT CHEW ON THE WIRING. THIS CAUSED THE ENGINE TO START MISFIRING FROM THE DAMAGE AND EVENTUALLY STOPPED RUNNING. THIS WAS AN EXTREME SAFETY HAZARD TO THE OCCUPANTS. THE DAMAGE COST ME $1,000 TO REPAIR. THESE CRUCIAL WIRES SHOULD NEVER HAVE BEEN MADE FROM A PRODUCT THAT IS FOOD FOR MICE. I UNDERSTAND FROM THE TOYOTA SERVICE MANAGER THAT THIS IS NOW A COMMON PROBLEM. MY CAR WAS ON A CITY STREET WHEN IT STALLED OUT. HOWEVER, MOST MILES ARE ON FREEWAYS.
Engine, Jun 22, 2020
MY VEHICLE HAVE A SEVERE OIL CONSUMPTION ISSUE, IT BURNS OIL AT A RATE OF 1 QUART PER 250-500 MILES. I UNDERSTAND THAT THERE WAS A TSB ISSUED IN 2016 BY MY VEHICLE WAS NOT INCLUDED IN THIS EVEN THOUGH IT FIT THE MODEL YEARS OF THE BULLETIN. *TR
Engine, Apr 26, 2020
2.4 LITER ENGINE HAD BEEN BURNING 1 QUART OF OIL EACH 800 TO 1000 MILES, AND HAS STEADILY GOTTEN WORSE. NOW WITH 192,000 A NICE CAR OTHERWISE HAS BEEN BURNING 1 1/2 TO 2 QUARTS EVERY 800 TO 1000 MILES. THIS HAS ADVERSELY EFFECTED SPARK PLUGS, OXYGEN SENSORS AND CATALYTIC CONVERTER. TOYOYTA TEST THE CAR IN 2016 BUT DEEMED THE PROBLEM AS ACCEPTABLE, BUT THIS IS A DESIGN FLAW WITH THE PISTONS AND RINGS, WHICH THEY HAVE SINCE ADMITTED IS A DESIGN FLAW. THESE ENGINES SHOULD BE RECALLED AND THE DESIGN FLAW CORRECTED.
Steering, Engine, Mar 28, 2020
FOR ENGINE, IT HAS EXCESSIVE OIL CONSUMPTION. I NEED TO ADD 1 QTR OF OIL AFTER 1.5K MILES DRIVE. FOR STEERING, IT MAKES CRACKING SOUNDS WHEN HAVING TURN THE STEERING IN A SLOW MOTION DRIVE BACKING UP FROM GARAGE.
Engine, Mar 12, 2020
IN 2015 OR 2016 TOYOTA SENT ME A LETTER TELLING ME TO TAKE THE CAR TO THE DEALER FOR A CHECK UP BECAUSE IT WAS BURNING OIL BUT THAT LETTER HAD AN EXPIRATION DATE WHICH DID NOT REALIZE I THOUGHT IT WAS A RECALL SO I TOOK THE CAR TO CHECK AND THEY STARTED A PROCESS THE CAR FAILED ALL THE TESTS THAT THEY DID AND BY THE END THEY TOLD ME THAT THEY COULDN'T FIX IT BECAUSE THE LETTER HAD EXPIRED. WHICH THAT IS NOT RIGHT FOR ME WHAT I NEED FROM TOYOTA IS IF THEY CAN OPEN THAT PROGRAM ONE MORE TIME SO THEY CAN FIX MY CAR BECAUSE IT IS BURNING A LOT OF OIL AND IT HARDLY HAS 50,000 MILES
Engine, Jan 27, 2020
OIL BURNING
Engine, Jan 6, 2020
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 10 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO CROWN TOYOTA OF LAWRENCE (3430 IOWA ST, LAWRENCE, KS 66046) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE PISTON RODS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 148,000.
Electrical system, Engine, Oct 15, 2019
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE CONSUMED AN EXCESSIVE AMOUNT OF OIL. THE CONTACT ADDED ADDITIONAL OIL AND THE ENGINE WAS COLD. IN ADDITION, THE CHECK ENGINE, SLIP TRACTION CONTROL, AND 4WD WARNING INDICATORS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO BREWER AIRPORT TOYOTA (8900 UNIVERSITY BLVD, MOON, PA 15108, (412) 357-5503), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: [XXX]. THE FAILURE MILEAGE WAS 115,000 *BF *JS PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Engine, Sep 11, 2019
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE USED AN EXCESSIVE AMOUNT OF OIL, INCLUDING TWO QUARTS OF ADDITIONAL OIL. IN ADDITION, THE MAINTENANCE REQUIRED WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE AND IT WAS DETERMINED THAT THE OIL WAS LOW. THE VEHICLE WAS TAKEN TO CONICELLI TOYOTA OF SPRINGFIELD (860 BALTIMORE PIKE, SPRINGFIELD, PA 19064, (877) 740-4031) WHERE THE CONTACT WAS INFORMED ABOUT THE VOLUNTEER SERVICE PROGRAM AND WARRANTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 1909110525. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 108,267.
Engine, Jul 16, 2019
TOYOTA PERFORMED AN OIL CONSUMPTION TEST ON MY RAV4 "FOLLOWING TOYOTA POL14-12". TO QUOTE THE SERVICE CENTER REPRESENTATIVE, IT "FAILED THE TEST MISERABLY". THE OIL WAS REPORTEDLY DRY AFTER LESS THAN 1200 MILES. NO MAINTENANCE LIGHT APPEARED. TOYOTA HAD A WARRANTY ENHANCEMENT FOR THIS ISSUE. THE CAR IS WELL UNDER THE MILEAGE LIMIT, BUT THE TIME HAS EXPIRED. THE COST TO FIX THE PROBLEM IS $4897.79 PLUS TAX. I CALLED TOYOTA AT 800-331-4331 AS SUGGESTED BY THE SERVICE CENTER REPRESENTATIVE TO REPORT THE PROBLEM AND INQUIRE ABOUT ASSISTANCE. TOYOTA CORPORATE REFUSED TO PROVIDE FURTHER ASSISTANCE.
Engine, Jul 10, 2019
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 30 MPH, THE LOW OIL PRESSURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO WOBURN TOYOTA (LOCATED AT 394 WASHINGTON ST, WOBURN, MA 01801, (781) 933-1100) WHERE IT WAS DIAGNOSED THAT FOUR PISTON RINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
Engine, Jul 10, 2019
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 30 MPH, THE LOW OIL PRESSURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO IRA TOYOTA OF DANVERS (LOCATED AT 99B ANDOVER ST, DANVERS, MA 01923, (978) 739-8300) WHERE IT WAS DIAGNOSED THAT FOUR PISTON RINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.
Engine, Jul 4, 2019
DRY START. TOLD BY MECHANIC ENGINE WILL FAIL WITHOUT $3000 REPAIR
Engine, May 6, 2019
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING VARIOUS SPEEDS, A LOUD ABNORMAL NOISE WAS DETECTED COMING FROM THE REAR DIFFERENTIAL. THE VEHICLE WAS TAKEN TO TOYOTA OF BROOKFIELD (20655 W CAPITOL DR, BROOKFIELD, WI 53045, (262) 236-7992) WHERE IT WAS DIAGNOSED THAT THE COUPLING NEEDED TO BE REPLACED. THE CONTACT MENTIONED THAT THAT SAME PART WAS REPLACED THREE YEARS AGO. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000. *TR*JB