2007 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,003 owner complaints filed for this model year. This is the highest complaint count among 26 RAV4 model years with reports.
Of the 2007 reports, 53 involved a crash and 37 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: suspension
125 reports, newest first. Show all
Suspension, Sep 15, 2025
The contact owns a 2007 Toyota Rav4. The contact stated that the vehicle could not be aligned. There were no warning lights illuminated. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 16V596000 (Suspension). The vehicle was taken to a tire shop, and the contact was informed that the rear tie rods were welded, and an alignment was impossible. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 182,342.
Suspension, Traction control system, Engine, Dec 9, 2024
The contact owns a 2007 Toyota Rav4. The contact stated while driving at various speeds, there was an abnormally loud sound coming from underneath the vehicle. The vehicle was taken to an independent mechanic, where the contact was informed that the sound was coming from the tires. The contact was informed that no issues were found. Additionally, the contact stated that the check engine warning light, the traction control warning light, and an unknown warning light were illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown. The VIN was not available.
Suspension, Structure, Oct 23, 2024
Subframe rusted in half, the only way I found it was when we put new shocks on it. It peeled off about 1/2 the tread on a brand new tire. Dangerous, if passengers side rear tire would've broke loose it would throw rear of car into oncoming traffic!
Suspension, Apr 24, 2023
The rear sub frame broke/ rusted, needing to be replaced unable to drive car safely
Suspension, Jan 24, 2023
The contact owns a 2007 Toyota Rav4. The contact stated while installing new tires on the vehicle, the mechanic stated that the wheel bearings fractured and that both front axles were rusted. The vehicle was taken to several independent mechanics, and it was confirmed that the wheel bearings were fractured and that the front axles were rusted. The vehicle was not repaired. The dealer was contacted, and the contact left a message. The manufacturer was not contacted. The failure mileage was 179,000.
Steering, Suspension, Engine, Jul 16, 2020
OIL BURNING. MASSIVE AMOUNTS OF OIL BURNING. A QUART EVERY 200 500 MILES ON AVERAGE.
Suspension, May 1, 2020, crash
WHILE DRIVING STRAIGHT DOWN THE HIGHWAY THE THERE WAS A POP SOUND IN THE BACK OF THE VEHICLE AND I WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE. THIS LEAD TO THE RAV4 COMING TO A STOP AFTER IMPALING ON GUARDRAIL FROM FREEWAY SPEEDS. UPON INSPECTION IT APPEARED THAT THE REAR LEFT WHEEL WAS THE CAUSE AND WAS AT AN ANGLE INSTEAD OF BEING PERPENDICULAR TO THE GROUND LIKE THE REST OF THE WHEELS.
Suspension, Feb 24, 2020
TL* THE CONTACT OWNS A TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING AT 30 MPH, THE VEHICLE EXPERIENCED A WOBBLE IN THE FRONT SUSPENSION. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO BOB TYLER TOYOTA LOCATED AT (7201 PENSACOLA BLVD, PENSACOLA, FL 32505) WHERE AN UNKNOWN RECALL REPAIR WAS PERFORMED. THE CONTACT STATED THAT THE REAR TOWING ROD BAR WAS FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE REAR TOW ROD BARS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000. *BF*JB
Suspension, Seat belts, Other or unspecified, Oct 16, 2019
TOYOTA HAS BEEN CLAIMING I HAVE NO OPEN RECALLS AND I LEARN I HAVE TWO. THEY CAN NOT LOCATE MY VIN TO REMEDY MY ISSUES ... SINCE I'VE OWN THE VEHICLE IN THREE STATES, AND AGAIN NOW HERE IN WISCONSIN. MY VEHICLE BODY IS LITERALLY FALLING APART (ON ITS OWN!) AND I CAN'T REPAIR IT OR GET RECALLS RECTIFIED. IT'S A 2007 WITH UNDER 70K MIKES! I PAID FOR AN EXTENDED WARRANTY AND THEY DID NOTHING BUT OIL CHANGES WHICH I PAID FOR.
Suspension, Power train, Wheels, Aug 17, 2019
77000 MILE LOWER CONTROL ARMS WITH BUSHINGS WENT BAD ,LOWER BALL JOINTS BAD INNER & OUTER TIE RODS BAD , SWAY BAR END LINKS BALL JOINTS BAD.ALIGNMENT & RE-BALANCED TIRES AFTER REPLACEMENT .BEGAN SWAYING IN ROAD FIGHTING STEERING ON EVERY BUMP WITH DIPPING OF FRONT END & VIBRATION BADLY OF CAR ESPECIALLY STEERING WHEEL , WORN NEW TIRES ON OUTSIDES .COMPLETE RECORDS IN TOYOTA VEHICLE REPAIR SERVICE SITE.TOTAL COST SO FAR FOR THE ABOVE IS 158.00 PLUS 44.95 PLUS 1 WEEK DOWN TIME, DUE TO ALL JOINTS BAD AND VIBRATIONS AND SWAYING AROUND HAS CAUSED THE CV SHAFTS TO GET LOOSE GOOD SHAKE AND NOT IN TO OUT SIDEWAYS DIRECTION - UP TO DOWN THEY HAVE SLIGHT PLAY AND HEAR A CLUNK BOTH WAYS (TO BE REPLACED WHEN HAVE MONEY WILL BE ANOTHER 150 TO 195 BUCKS AND ANOTHER DAY OR 2 DOWN TIME, NOT SURE OF FRONT WHEEL BEARINGS YET OR THE REAR SWAY BAR ALL THEM LINKS , THIS IS HOW BAD THE SWAYING GOT SO NEEDS CHECKED ANY BACK PARTS WILL COST ME APPROX 240.00 -- REPLACED PARTS LOWER CONTROL ARMS WITH BALL JOINTS AND BUSHINGS ALONG WITH INNER PLUS OUTER TIE RODS ALONG WITH SWAY BAR LINKS WERE BOUGHT THROUGH AMAZON FROM DETROIT AXEL SELLER SO MAY BE ABLE TO GET RECEIPT IF NEEDED-- THE TIRE RE-BALANCED WAS DONE AT LYNN LAYTON FORD OF DECATUR ALABAMA 256-350-2120 CUSTOMER [XXX] INVOICE [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
Suspension, Dec 4, 2018
AFTER PROCESSING THE SAFETY RECALL ON THE REAR TIE RODS WHICH CONTROL THE TOE OF THE WHEELS, I DROVE 20K MILES AND THEN NEEDED TO DO ANOTHER ALIGNMENT ON THE REAR OF THE CAR. THE TOE OF BOTH WHEELS ARE OUT OF ADJUSTMENT TO THE LEFT BRINGING THE CAR'S STEERING OUT OF ALIGNMENT AND CAUSING PREMATURE TIRE WEAR. ACCORDING TO TOYOTA, AS THE SAFETY RECALL PROCESS WAS TO CAP THE TOE ADJUSTER BAR ON THE REAR TIE RODS AND FILL THEM WITH EPOXY, THE ONLY WAY TO FIX THIS WAS TO REPLACE THE TIE RODS AND REPEAT THE SAFTY RECALL BUT THIS TIME THEY WOULD CHARGE ME $720 DOLLARS. SO EVEN THOUGH THIS PART HAS HAD SEVERAL SAFETY RECALLS ON IT AND THAT THE FINAL SOLUTION BY TOYOTA WAS TO HOLD IT TOGETHER WITH GLUE. THEY ARE NOT WILLING TO STAND BEHIND THEIR PRODUCT AND FIGURE OUT A LONG TERM SOLUTION THAT ALLOWS FOR THE CAR TO RETAIN ITS ORIGINAL ABILITY TO DO A PROPER ALIGNMENT.
Suspension, Nov 10, 2018
MY VEHICLE WAS ONE OF APPROXIMATELY 750,000 VEHICLES INVOLVED IN TOYOTA'S 2013 CSJ SAFETY RECALL. HOWEVER, IT WAS EXCLUDED FROM THE AUGUST 2016 GOV SAFETY RECALL, AS WERE ABOUT 420,000 OTHER VEHICLES. ACCORDING TO TOYOTATALK.COM, SINCE SO MANY OF THESE RAV4S WERE EXCLUDED FROM THE G0V SAFETY RECALL WHICH CALLS FOR MANDATORY REPLACEMENT OF THE REAR SUSPENSION ARM MOUNTING HARDWARE, THIS MEANS THERE ARE HUNDREDS OF THOUSANDS OF AFFECTED RAV4 VEHICLES ON AMERICAN HIGHWAYS WITH EITHER: 1. POTENTIALLY RUSTING AND/OR CORRODING MOUNTING HARDWARE FOR THE REAR SUSPENSION ARM THAT HAS NOT BEEN REPLACED 2. THE INABILITY TO HAVE A REAR WHEEL ALIGNMENT WHICH COULD LEAD TO DANGEROUS TIRE WEAR THE TITLE OF THE ARTICLE ON TOYOTATALK.COM IS "THE DEFECTIVE TOYOTA RAV4 TUBE-STYLE REAR SUSPENSION ARM." IT WAS POSTED ON APRIL 28, 2018. HERE IS THE LINK: HTTPS://TOYOTATALK.COM/DEFECTIVE-RAV4-SUSPENSIONS/ ON NOVEMBER 5, 2018, THE OWNER OF DINSMORE TIRE IN MORGANTOWN, WEST VIRGINIA, INFORMED ME THAT ONE OF THE TIRES ON THE REAR HAD UNEVEN REAR. HE CITED A MECHANICAL DEFECT WITH THE VEHICLE AS THE REASON WHY. HE STATED THAT IF IT BECOMES NECESSARY TO SUBMIT A WARRANTY CLAIM ON MY VEHICLE'S TIRES PURCHASED THERE, THAT THE TIRE WITH UNEVEN WEAR WOULD BE EXCLUDED. A PHOTO OF THAT TIRE ACCOMPANIES THIS COMPLAINT. IN THE INTEREST OF SAFETY, ON NOVEMBER 9, 2018, AFTERMARKET REAR SUSPENSION ARMS WERE INSTALLED ON MY VEHICLE. THE INSTALLATION WAS PAID BY ME OUT OF POCKET. A REDACTED COPY OF THE RECEIPT ACCOMPANIES THIS COMPLAINT. SINCE RECALLS ARE VIN SPECIFIC, TOYOTA HAS NOTHING OF SUBSTANCE TO SAY ABOUT THESE CONCERNS. BE THAT AS IT MAY, A COMPLAINT WAS FILED WITH TOYOTA ON NOVEMBER 5, 2018. I AM VERY DISAPPOINTED WITH TOYOTA AND ITS LACK OF ACTION. IT IS MY DEEPEST HOPE THAT SOMETHING CAN BE DONE TO RESOLVE THIS PROBLEM.
Suspension, Oct 30, 2018
WE HAD RECALL GOV ON MY TOYOTA RAV4 ON 1/18/18 81000 MILES. AT THIS TIME I ALSO HAD NEW FRONT STRUTS AND REAR SHOCKS INSTALLED WITH A FRONT AND REAR ALIGNMENT. THEN 8000 MILES LATER AFTER THE FIX IN OCTOBER I NOTICED EXCESSIVE TIRE WEAR. I TOOK THE VEHICLE IN FOR NEW REAR BRAKES AND AN ALIGNMENT. AT THAT TIME WE WERE TOLD THAT THEY COULD NO LONGER PERFORM A REAR ALIGNMENT DUE TO THIS RECALL "FIX" THAT PERMANENTLY SEALED IT INTO ONE PLACE. WE WERE TOLD THAT IN ORDER TO GET THE CAR BACK INTO ALIGNMENT, WE WOULD HAVE TO REPLACE THE ENTIRE REAR TOE BAR. MY CAR WAS MANUFACTURED WITH AN ADJUSTABLE REAR TIE ROD, AND TOYOTA'S SOLUTION TO AN ENGINEERING FLAW IS TO MAKE THE REAR TIE ROD NO LONGER ADJUSTABLE, THUS COSTING THE CONSUMER HUNDREDS OF DOLLARS TO FIX A SIMPLE ALIGNMENT ISSUE. IT IS NOT FEASIBLE OR FAIR TO EXPECT THE CONSUMER TO PAY HUNDREDS OF DOLLARS FOR AN ALIGNMENT ISSUE, WHEN TOYOTA CREATED THE ISSUE WITH THEIR "FIX" INSTEAD OF CREATING A REPLACEMENT REAR TOE THAT IS ADJUSTABLE LIKE THE CAR WAS MANUFACTURED WITH WHEN I PURCHASED IT. THIS FIX HAS CREATED A NEW SAFETY ISSUE WITH TIRE WARE AND HANDLING ISSUES. BEFORE THE FIX I WAS EXPERIENCED NEITHER OF THESE ISSUES.
Suspension, Electronic stability control (ESC), Oct 29, 2018
THE RECALL ON THE REAR SUSPENSION EPOXIED THE BAR IN PLACE. NOW IT IS NOT POSSIBLE TO DO AN ALIGNMENT. TIRES ARE WEARING UNEVENLY AND VSC LIGHT IS ON ALL THE TIME.
Suspension, Jun 27, 2018
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE WASHING THE VEHICLE, THE CONTACT NOTICED THAT THE REAR TIRES WERE WORN. THE CONTACT MENTIONED THAT THE REAR TIRES WERE REPLACED SIX MONTHS PRIOR TO THE FAILURE BEING NOTICED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED BY LITHIA TOYOTA OF KLAMATH FALLS (2675 WASHBURN WAY, KLAMATH FALLS, OREGON 97603) PER NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION); HOWEVER, THE REPLACEMENT PART UTILIZED BY THE DEALER HAD NO ADJUSTMENT ABILITY, WHICH WORE OUT THE REAR TIRES IN A SHORT PERIOD OF TIME DUE TO NO ALIGNMENT. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Suspension, Feb 6, 2018
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) BY KOONS TOYOTA (1107 WEST ST, ANNAPOLIS, MD 21401). THE CONTACT STATED THAT THE REMEDY PREVENTED THE REAR TIRES FROM REALIGNING WITHOUT REPLACING THE ENTIRE SUSPENSION ARM. THE DEALER STATED THAT THE CONTACT WOULD HAVE TO PAY TO REMEDY THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OPENED CASE NUMBER: 1802022112. THE FAILURE MILEAGE WAS 190,698.
Suspension, Jan 13, 2018
WE CONTINUE TO ENCOUNTER RESISTANCE WITH CAPITOL TOYOTA, 783 AUTO GROUP AVE NE, SALEM, OR 97301 (503) 399-1011 SCHEDULING AN APPOINTMENT FOR THE RECALL ON OUR VEHICLE. THEY TELL YOU THEY ARE REVIEWING YOUR FILE AND WILL GET BACK TO YOU AND REFUSE TO SCHEDULE. WE'VE ENCOUNTERED THIS SAME TACTIC WITH THIS DEALER ON PAST RECALL NOTICES.
Suspension, Power train, Jan 12, 2018
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 45 MPH, THERE WAS A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE NOISE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO TOYOTA OF ROCK HILL (640 GALLERIA BLVD, ROCK HILL, SC 29730) WHERE IT WAS DIAGNOSED THAT THE REAR DIFFERENTIAL COUPLING NEEDED TO BE REPLACED. THE DEALER STATED THAT THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 888-270-9371 AND STATED THAT NOTHING COULD BE DONE. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 141,203.
Suspension, Jan 10, 2018
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED TOYOTA PASADENA AT (626) 795-9787 (3600 E FOOTHILL BLVD, PASADENA, CA 91107) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Suspension, Dec 29, 2017
TOYOTA ISSUED A RECALL FOR THE REAR SUSPENSION AND SUBSEQUENTLY REPAIRED MY VEHICLE; HOWEVER, THE FIX IS INADEQUATE. AFTER THE REAR SUSPENSION ARM (TIE ROD) IS EPOXIED INTO A FIXED POSITION, THE REAR TIRES CAN NO LONGER BE REALIGNED WITHOUT REPLACING THE ENTIRE SUSPENSION ARM. THIS FIX IS INADEQUATE AND PLACES UNDUE FINANCIAL BURDENS ON THE RAV4 OWNERS.
Suspension, Nov 10, 2017
THIS VEHICLE HAD THE REAR SUSPENSION ARM RECALL (NHTSA 16V596000) . WHEN THE DEALERSHIP DID THE RECALL THEY SEALED THE PARTS IN EPOXY, THE CAR IS OUT OF ALIGNMENT AGAIN IN LESS THAN I YEAR. I TOOK IT BACK TO THE DEALERSHIP AND WAS BEING TOLD THAT IT WILL COST $700 TO GET THE ALIGNMENT DONE. THE SUSPENSION HAS TO BE REPLACED BECAUSE OF THE EPOXY. THIS IS NOT COVERED UNDER THE ONE YEAR WARRANTY OF THE RECALL. TOYOTA SHOULD BE PAYING FOR THIS SINCE THEY DID NOT CORRECT THE ISSUE PROPERLY DURING THE RECALL AND NOW THE CAR CAN NOT HAVE REAR WHEEL ALIGNMENTS. I CANNOT GET A ROUTINE ALIGNMENT BECAUSE OF THE EPOXY USED DURING THE RECALL. THIS IS OUTRAGEOUS.
Suspension, Oct 24, 2017
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN UNKNOWN NOISE UNDERNEATH THE DRIVER SIDE OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.
Suspension, Sep 2, 2017
THIS VEHICLE HAS HAD THE REAR CONTROL ARM RECALL THAT SEALS THE PART IN EPOXY, MAKING REAR TOE ADJUSTMENT IMPOSSIBLE. THIS VEHICLE IS OUT OF TOLERANCE ON REAR TOE AND WILL COST $685 TO REPAIR. TOYOTA SHOULD BE PAYING FOR THIS SINCE THEY RENDERED THE SUSPENSION PART NON ADJUSTABLE.
Suspension, Sep 1, 2017
TOYOTA REFUSED TO HAVE THE REAR TIRES OF MY CAR BE ALIGNED. SINCE I SUBMITTED THIS CAR FOR THAT REAR LOWER CONTROL ARM RECALL, I ALWAYS HAVE ISSUES WITH REAR TIRE MISALIGNMENT WHICH TOYOTA OFFERED NO REMEDY. I BELIEVE DRIVING A MISALIGNED WHEELS IS A SAFETY ISSUE.
Suspension, Power train, Seat belts, Aug 27, 2017
FOUND BY MAIL ABOUT RAKATA AIR BAGS, AND MY SERVICE FOR OIL,FILTER WAS CALLED BY REPAIR SHOP,TIME FOR SERVICE, FINISH THE CAR SERVICE , BEFORE LIVED I ASK A QUESTION ABOUT, THE RECALL AND HE LOOK THE SCREEN,TOOK 30 SECONDS (FLAHS) AND SAYS, YOU CAR, DON'T HAVE ANY RECALL, WHY? NO IM CURIOUS, WHAT ABOUT THE REAR SUSPENSION ARM 1, AND HEARD ABOUT SEAT BELTS,SAFETY RECALL, AND MOST OF INFO.STILL IN CHINESE OR JAPANES, AND SOME ONE PUT NEW BUT COMO N THEY LOOK CHEAP AND HAVE A TACOMA TOTALLY DIF. FOUND 11 RECALLS, NOW TRASMISSION AUT,BURN OUT,AT 100000 MILES, SORRY BUT LOOK LIKE THE REPAIR SHOPS DON'T CARE ABOUT "US" THE WANT TO SELL CARTS, BUT MAKE A OT OF MISTAKES AND WE PAY TO GET KILL IN CAR ACCIDENT,CAUSE DEFECT OF FACTURY,THEY FIXED THE CARS,BUT LIFE AND FEW THURS AND DLLS DON'T RETURN WIFES,SONS,HUSBAND,GONE SO WHY CARS COMPANIES ARE IN SO MUCH IN A HURRY NOT EASY TO PAY A LOAN OF 60,000 IN 5 YEARS, AND 3 YEARS LATER WANT YOU TO LEAVE THE CAR AND AGAIN,AND AGAIN,AAIN BY T M, PAS,CA #1