2007 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,003 owner complaints filed for this model year. This is the highest complaint count among 26 RAV4 model years with reports.
Of the 2007 reports, 53 involved a crash and 37 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: engine
236 reports, newest first. Show all
Engine, Mar 25, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE CONSUMED AT LEAST FOUR QUARTS OF OIL PER MONTH. THE OIL PRESSURE WARNING INDICATOR CONSTANTLY ILLUMINATED. THE CONTACT ALSO RECEIVED A NOTIFICATION FROM THE MANUFACTURER TO HAVE AN OIL CONSUMPTION TEST PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 124,413.
Engine, Mar 11, 2016
BURNING 1.5-2 QUARTS OF ENGINE OIL PER WEEK, THIS HAS BEEN AN ONGOING ISSUE FOR AT LEAST 2 YEARS. OIL CONSUMPTION TEST WAS DONE ON THE VEHICLE AND IT FAILED. THE DEALERSHIP HAS FAILED TO FIXED THE ISSUE.
Power train, Engine, Fuel/propulsion system, Feb 19, 2016
OIL BURNING RECALL. MY CAR RAV4 BURNS OIL AT LEAST ONE QUART PER 1200 MILES. THE DEALERSHIP REFUSED TO REPLACE ANY PART DUE TO THE 1200 MILES TEST DRIVING. TOYOTA SENT ME AN ENHANCEMENT WARRANTY NOTICE ABOUT THE PROBLEM OF OIL BURNING. THIS IS UNACCEPTABLE TO ME. WE PAID SO MUCH YET WHAT WE GET IS A DEFECT ENGINE IN A NEW RAV4. THIS SHOULD BE A RECALL AND TOYOTA IS RESPONSIBLE TO FIX THE RINGS AND OTHER PARTS THAT ARE REQUIRED TO REPLACE IN ORDER TO STOP THE PROBLEM.
Engine, Dec 27, 2015
2007 RAV4 USES AN EXCESSIVE AMOUNT OF OIL. I RECENTLY PURCHASED THIS VEHICLE USED WITH APPROXIMATELY 146,000 MILES. THE VEHICLE HAS BEEN DRIVEN APPROXIMATELY 4,000 AND I HAVE HAD TO ADD 2 QUARTS OF OIL TO THE ENGINE. I HAVE READ NUMEROUS COMPLAINTS ONLINE ABOUT THE SAME SITUATION AND TOYOTA IS DOING NOTHING TO FIX THE PROBLEM.
Electrical system, Exterior lighting, Engine, Dec 19, 2015
WHILE DRIVING THE CAR SUDDENLY LOSES ALL ELECTRICITY, ALL THE LIGHTS, EVERY LIGHT INDICATOR, THE RADIO ARE OFF. THE ENGINE STOPS RUNNING AND THE CAR STOPS IMMEDIATELY. THIS NORMALLY HAPPENS WHILE DRIVING ON CITY STREETS BUT ALSO HAPPENED ONCE WHEN THE CAR WAS PARKED AND THE KEY WAS OUT. AFTER I ENTERED AND TURNED THE KEY THE CAR WOULDN'T START AND THERE WAS NO ELECTRICITY IN THE CAR. NO LIGHTS, NO INDICATORS, ETC WERE ON. TOOK IT TO THE MECHANIC TO TAKE A LOOK BUT HE COULDN'T FIND ANYTHING. ALSO TOOK IT TO TOYOTA DEALERSHIP AND THE TECHNICIAN INSPECTED IT AND RAN A DIAGNOSTICS TEST BUT COULDN'T FIND THE PROBLEM EITHER.
Engine, Dec 18, 2015
HELLO, MY WIFE OWNS A 2007 TOYOTA RAV4 WITH 108,000 MILES ON IT. IT RECEIVED AN OIL CHANGE AT 103K MILES, AND I JUST BROUGHT IT IN TO THE DEALERSHIP FOR A SUSPICIOUS (AND LOUD) TOP END NOISE, AND THE ENGINE APPEARED TO BE EMPTY OF OIL WHEN THE DEALERSHIP CHECKED IT. THERE WERE NO WARNINGS, OTHER THAN THE CHECK ENGINE LIGHT COMING ON AT PRECISELY THE RIGHT TIME TO INDICATE THE NEXT OIL CHANGE. ALSO NO PUDDLES OF OIL IN THE DRIVEWAY. THIS APPEARS TO MAKE ME (AT LEAST POTENTIALLY) AN INTERESTED PARTY IN THE TOYOTA OIL CONSUMPTION DEFECT CLASS ACTION LAWSUIT , APRIL LAX, ET AL. V. TOYOTA MOTOR CORPORATION, ET AL., CASE NO. 14-CV-01490, IN THE U.S. DISTRICT COURT FOR THE NORTHERN DISTRICT OF CALIFORNIA. PLEASE LET ME KNOW IF YOU CAN RECOMMEND A COURSE OF ACTION FOR ME AT THIS TIME.
Electrical system, Engine, Nov 27, 2015
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN AT APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT MENTIONED THAT ON SEVERAL OTHER OCCASIONS, THE FAILURE RECURRED WHEN THE RADIO OR TURN SIGNAL WAS ACTIVATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 111,000. THE VIN WAS NOT AVAILABLE.
Engine, Nov 16, 2015
MY VEHICLE HAS BEEN BURNING EXCESSIVE AMOUNTS OF OIL. IT HAS BEEN CHECKED AND THERE HAS BEEN A REPAIR @ A TOYOTA DEALER I ALSO WAS TOLD THERE IS A RECALL ON THE ENGINE BUT I NEED TO GET A GASKET FIXED AGAIN. I WAS TOLD THERE NEEDS TO BE A TEST DONE OF HOW MUCH OIL WAS BURNING WHICH I THINK IS A BUNCH OF CRAP BECAUSE THEY KNOW A PROBLEM DOES EXISTS AND TOYOTA NEGLECTS TO FIX IT. IN THE PAST FEW YEARS I HAVE BEEN GETTING OIL ADDED AT LEAST ONCE A MONTH AND MY VEHICLE ALSO SHAKES VERY BADLY WHILE WAITING AT LIGHTS OF JUST SITTING STILL. ALSO, A FEW YEARS AGO MY DOOR CAUGHT ON FIRE AND I WAS ACCUSED OF DOING IT WHICH I TRIED TO TELL THE STAFF AT TOYOTA OF BRAINTREE WHERE I PURCHASED THE VEHICLE THAT I WOULD NOT BURN UP MY CAR BUT THEY KEPT INSISTING I DID HORRIBLE THINGS TO MAKE THE DOOR CATCH FIRE, LIKE POURING WATER IN THE DOOR RIDING WITH THE WINDOW DOWN IN POURING RAIN PUTTING LIT MATCHES IN IT. THAT WAS HORRIBLE I HAD TO PAY OUT OF POCKET OVER $600.00 THEN FIGHT TO GET MY MONEY BACK AFTER 2 YEARS. WHEN I CONFRONTED THE DEALERSHIP, THEY TOLD ME TO COME IN AND THEY WOULD ACCOMMODATE ME; THEY WANTED ME TO GIVE BACK MY VEHICLE GET ANOTHER ONE AND HAVE A PAYMENT, WHICH I DIDN'T DO BECAUSE THAT IS NOT RIGHT TO SELL A DEFECTIVE PRODUCT. MY VEHICLE WAS PAID OFF IN 2 YEARS AND THIS IS THE SERVICE I GET FROM TOYOTA? ANOTHER PAYMENT? NO! THEN THE DRIVE SHAFT/SEAL NEEDED REPLACING, AND THEN THE WINDOW FELL OUT $300 + WHICH WAS ANOTHER OUT OF POCKET COST. NOW, I AM TOTALLY DISGUSTED WITH THIS VEHICLE AFTER ALL OF THESE PROBLEMS AND I BROUGHT IT NEW. IN LIGHT OF THAT, I HAVE DECIDED THAT I WILL NOW GO TO THE MEDIA TO SEE IF THERE IS ANY HELP I CAN GET BECAUSE THIS IS NOT FAIR THAT TOYOTA DOES NOT STAND UP TO ITS PRODUCTS AGAIN, THIS IS A PROBLEM THAT NEEDS TO BE FIXED AT NO COST TO MYSELF ASAP BECAUSE I HAVE PUT TOO MUCH MONEY IN A VEHICLE THAT SHOULD NOT HAVE THESE PROBLEMS
Engine, Nov 10, 2015
7/24/2015 TRAVELING FROM WISCONSIN TO FLORIDA IN 2007 RAV4. DRIVING ON FREEWAY WHEN ENGINE LOST POWER. UNABLE TO RESTART ENGINE ON THE SIDE OF THE FREEWAY EXIT RAMP. HAD CAR TOWED BACK HOME. LATER THAT WEEK HAD CAR TOWED TO MECHANIC. MECHANIC DISCOVERED CATASTROPHIC DAMAGE TO ENGINE. THE ENGINE HAD SEIZED. THE METAL ON THE PISTONS MELTED AND OTHER ENGINE PARTS WHERE SCORCHED. REPLACED ENGINE WITH A REBUILT. ONLY HAD 136,000 MILES ON RAV4. THE RAV4 HAD REGULAR OIL CHANGES AND ROUTINE MAINTENANCE. NOW I AM SEEING ON THE NHTSA WEBSITE THAT TOYOTA KNEW ABOUT ENGINES PROBLEMS. I DID NOT RECEIVE NOTICE OF THIS ISSUE AND I AM OUT THE COST OF A REBUILT ENGINE AND THE COST OF A RENTAL CAR WHILE THE ENGINE WAS REPLACED. IS THIS SAME THING GOING TO HAPPEN TO MY REBUILT ENGINE? TOYOTA HAD ME SUBMIT DOCUMENTATION OF WHAT MECHANIC FOUND AND DID TOLD ME THAT THEY WOULD REVIEW DOCUMENTS AND THAT I WAS ELIGIBLE FOR REIMBURSEMENT UNDER THE CSP ZE7 PROGRAM. ON OCT 19 WRITTEN NOTICE RECEIVED, STATES REIMBURSEMENT FOR REPLACING THE ENGINE DENIED. RECEIVED NOTICE FROM TOYOTA REGARDING WARRANTY ENHANCEMENT ZE7 AFTER ENGINE FAILED THAT RAV 4 HAD AN EXCESSIVE OIL CONSUMPTION PROBLEM. ATTACHED ARE PICTURES OF MELTED ENGINE PARTS OF AN ENGINE THAT HAD REGULAR OIL CHANGES.
Engine, Oct 14, 2015
2007 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO VEHICLE HAS A DEFECTIVE ENGINE. *SMD THE CONSUMER STATED HE HAS BEEN WAITING SINCE APRIL FOR PARTS. THE CONSUMER WAS INFORMED BY TOYOTA, THE PARTS WERE UNAVAILABLE NATIONWIDE. *JB
Engine, Aug 25, 2015
7/24/2015 TRAVELING WITH FAMILY FROM WISCONSIN TO FLORIDA IN MY 2007 RAV4. DRIVING ON FREEWAY WHEN ENGINE LOST POWER. COASTED OFF FREEWAY DOWN EXIT RAMP. UNABLE TO RESTART ENGINE ON THE SIDE OF THE FREEWAY EXIT RAMP. HAD CAR TOWED BACK HOME. LATER THAT WEEK HAD CAR TOWED TO MECHANIC. MECHANIC DISCOVERED CATASTROPHIC DAMAGE TO ENGINE. THE ENGINE HAD SEIZED. THE METAL ON THE PISTONS MELTED AND OTHER ENGINE PARTS WHERE SCORCHED. REPLACED ENGINE WITH A REBUILT. ONLY HAD 136,000 MILES ON RAV4. THE RAV4 HAD REGULAR OIL CHANGES AND ROUTINE MAINTENANCE. NOW I AM SEEING ON THE NHTSA WEBSITE THAT TOYOTA KNEW ABOUT ENGINES PROBLEMS. I DID NOT RECEIVE NOTICE OF THIS ISSUE AND I AM OUT THE COST OF A REBUILT ENGINE AND THE COST OF A RENTAL CAR WHILE THE ENGINE WAS REPLACED. IS THIS SAME THING GOING TO HAPPEN TO MY REBUILT ENGINE? TOYOTA HAS NOT RESPONDED TO MY NOTIFICATION TO THEM OF THE CATASTROPHIC ENGINE FAILURE.
Engine, Aug 10, 2015
I PURCHASED A USED 2007 TOYOTA RAV4 IN LATE FEBRUARY 2015. ACCORDING TO MY TRUSTED AND LOYAL CAR REPAIRMAN, THE CAR IS A LEMON. IN THE SHORT TIME I HAVE OWNED IT, I HAVE ACCRUED WELL OVER $6000.00 IN REPAIRS WHICH DID NOT REFURBISH THE VEHICLE AND NOW THE VEHICLE IS NOT DRIVEABLE AS THE ENGINE MALFUNCTIONED. THE DEALERSHIP WHERE I PURCHASED IT IS REFUSING TO HELP ME SINCE I PURCHASED THE VEHICLE WITHOUT A WARRANTY. IT IS MY UNDERSTANDING THAT ILLINOIS DOES NOT HAVE LEMON LAWS FOR CONSUMERS OF USED VEHICLES, HOWEVER, THE FEDERAL GOVERNMENT MAY HAVE LEMON LAW PROTECTION FOR ME. I AM NOW SEEKING FREE LEGAL CONSULTATION TO SUCCESSFULLY RESOLVE THIS MATTER TO RECOUP THE PURCHASE PRICE, ALL SUBSEQUENT REPAIRS, LEGAL FEES, AND DAMAGES FOR BEING STRANDED ON THE HIGHWAY DURING A LONG DISTANCE VACATION MILES FROM HOME. THE CAR HAD NO WARNING LIGHTS COME ON WHATSOEVER. HAD THE CAR DIED ANY SOONER, WE WOULD NOT HAVE MADE IT TO THE SHOULDER RISKING A HIGH-SPEED MULTIPLE CAR ACCIDENT PILEUP ON THE HIGHWAY.
Engine, Jul 7, 2015
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE OIL WARNING INDICATOR ILLUMINATED BEFORE THE REGULAR MAINTENANCE OIL CHANGE TIME. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS ADVISED BY THE MECHANIC THAT THEY WERE CONDUCTING AN OIL CONSUMPTION TEST. THE MECHANIC ALSO STATED THAT THERE MAY BE AN ISSUE WITH THE PISTONS AND THE ENGINE. THE CONTACT WAS INFORMED TO CHECK THE OIL EVERY WEEK TO MAKE SURE IT WAS TOPPED OFF. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,600.
Engine, Jul 2, 2015
CERTAIN CARS FROM TOYOTA HAVE A KNOW EXCESSIVE OIL CONSUMPTION PROBLEM. MY CAR IS ONE OF THEM. MY CAR, WHILE OLDER, HAS LESS THAN 56K MILES ON IT. LAST YEAR, THE MILEAGE DROPPED PRECIPITOUSLY-- BY 10 MPG, IN FACT. SINCE THEN, MY LOW OIL LIGHT INDICATOR CAME ON IN LESS THAN 3,000 MILES. TOYOTA WON'T FIX THE PROBLEM. THEY HAVE REDEFINED WHAT IT MEANS TO BURN EXCESSIVE AMOUNTS OF OIL-- 1 QUART EVERY 1200 MILES ISN'T A PROBLEM ACCORDING TO THEM. THOUSANDS OF TOYOTA OWNERS NOW FIND THEMSELVES WITH CARS THAT BURN OIL, HAVE REDUCED MPG, AND NO RECOURSE WITH TOYOTA. MY CAR HAS BEEN TO THE DEALER 5 TIMES SINCE LAST YEAR-- ALL BECAUSE OF THE OIL ISSUE. THIS CAR IS NOT WHAT I BOUGHT. I BOUGHT A CAR THAT WAS ECONOMICAL, ENVIRONMENTALLY FRIENDLY, AND GOT GOOD MILEAGE. TOYOTA SHOULD NOT BE ABLE TO REDEFINE WHAT ACCEPTABLE OIL CONSUMPTION IS! I NOW FIND MYSELF IN THE UNFORTUNATE SITUATION OF HAVING TO CARRY A QUART OF OIL WITH ME EVERYWHERE I GO BECAUSE I DO NOT KNOW WHEN MY CAR WILL RUN OUT OF OIL. OF COURSE, I'M NOW STOPPING EVERY 190 MILES OR SO TO PUT GAS IN THE CAR BECAUSE OF BAD MILEAGE (USED TO BE AROUND 350 MILES). WHY IS NTSA LETTING THIS GO?
Engine, Jun 12, 2015
THIS IS AN ONGOING ISSUE OF EXCESSIVE OIL CONSUMPTION. IT HAS BEEN AN ISSUE SINCE MY VEHICLE WAS PURCHASE NEW. I NOTICED THAT I HAD TO GET MY OIL CHANGED EVERY 3000 MILES AND COULD NOT MAKE IT TO 5000 MILES AS RECOMMENDED BY MY MECHANIC FOR OIL CHANGES. THIS HAS GOTTEN WORSE AS MY CAR HAS AGED. I NOW RUN OUT OF OIL (OIL INDICATOR LIGHT COMES ON AND NOT A DROP ON THE DIPSTICK) EVERY 1200-1300 MILES. I HAVE TO CARRY QUARTS OF OIL IN MY CAR ALL THE TIME TO BE SURE I DON'T GET STUCK WITH A SEIZED ENGINE AND I NEED TO TOP OFF MY OIL AT LEAST TWICE IN BETWEEN 3000 MILE OIL CHANGES. I HAVE SPOKEN WITH OTHER RAV OWNERS AS WELL AS MY OIL CHANGE ESTABLISHMENT AND I UNDERSTAND THIS IS A COMMON AND KNOWN ISSUE FOR RAVS. TOYOTA NEEDS TO ADDRESS THIS.
Engine, Jun 7, 2015
ENGINE HESITATES/STUMBLES AND RPM NEEDLE FLUCTUATES AT SPEEDS UNDER 60MPH
Steering, Electrical system, Engine, Jun 7, 2015
THE CAR FAILED TO START, THE BATTERY WAS EXTREMELY HOT AND HAD NOT WATER IN IT. CHANGED THE BATTERY, THE CAR STARTED PROPERLY; HOWEVER, ONCE SET TO DRIVE IT HESITATED A BIT, AS IF IT WERE CHOCKING FOR LACK OF GAS BUT IT HAD GAS. DROVE ON AND AT ABOUT SPEED OF 40 MPH STEERING BECAME HARD TO HANDLE, AC AND ENGINE CUT OFF. RESTARTED IT DROVE BACK HOME... JUST MADE THE LAST PAYMENT ON THE CAR, CAR WAS REGULARLY SERVICED AT THE DEALER.
Engine, May 30, 2015
I HAVE BEEN HAVING REGULAR OIL CHANGES AT MY LOCAL AAA SHOP AS SCHEDULED FOR MY 2007 TOYOTA RAV4. WHEN MY MAINTENANCE LIGHT CAME ON I TOOK IT IN TO AAA WITHIN THE NEXT FEW DAYS. I WAS TOLD IT HAD ONLY BEEN 3000 MILES SINCE MY LAST OIL CHANGE, BUT THAT THERE WAS ONLY 1 QT. OF OIL LEFT IN THE CAR. THERE WERE NO LEAKS DETECTED AND THEY SAID THE CAR WAS NOT SMOKING TO INDICATE IT WAS BURNING OIL. TWO MOS. LATER I TOOK THE CAR TO MY TOYOTA DEALERSHIP FOR AN INSPECTION STICKER. I TOLD THEM THE CAR WAS RUNNING ROUGH AND TO CHECK IT OUT. THEY REPLACED SPARK PLUGS AND VALVE COVER GASKET. SHORTLY THEREAFTER I RECEIVED NOTICE FROM TOYOTA ABOUT EXCESSIVE OIL USE FOR MY MODEL. I TOOK IT IN FOR THE EXCESSIVE OIL CONSUMPTION TEST. DURING THE 1000 MI TEST IT BURNED ANOTHER QUART AND A HALF OF OIL. THEY DISREGARDED MY COMPLAINT ABOUT BURNING ALL BUT 1 QT. WITHIN 3000 MI. AND SAID THE CONSUMPTION WAS NORMAL. CAR CONTINUES TO RUN ROUGH.
Engine, May 11, 2015
MY 2007 TOYOTA RAV 4 IS EXPERIENCING EXCESSIVE OIL USAGE WHICH TOYOTA KNOWS IS A PROBLEM WITH VEHICLES THAT HAS A 2AZ ENGINE. IT IS BELIEVED THAT IF THE ENGINE SIEZES DUE TO THIS EXCESSIVE OIL USAGE FOR A VEHICLE THAT IS IN MOTION, THE BRAKES AND STEERING FAILURE COULD CAUSE LOSS OF CONTROL AND RESULT IN A CRASH. AS SUCH, I BELIEVE TOYOTA SHOULD BE FORCED TO ISSUE A SAFETY RECALL TO CORRECT THIS ISSUE IMMEDIATELY.
Engine, May 9, 2015
MY CAR HAS HAD EVERY OIL CHANGE AND CHECK UP AS PRESCRIBED. I WAS ABOUT 500 MILES AWAY FROM NEXT REQUIRED OIL CHANGE. I NOTICED WHEN I STEPPED ON BRAKE THE OIL LIGHT CAME ON. PULLED INTO GAS STATION AND WAS TOLD THERE WAS NO OIL IN THE CAR. THEY ADDED 3 QUARTS OF OIL. I CALLED TOYOTA AND BROUGHT CAR IN. THEY ADDED 4/5 QUARTS OF OIL, AND TAPPED UP EVERYTHING INCLUDING DIP STICK SO I COULD NOT CHECK THE OIL. TOLD ME I HAD TO DRIVE 1,100 TO 1,300 MILES AND THEN COME BACK. I WAS QUITE UPSET, BECAUSE I WAS UNABLE TO KNOW IF OIL WAS LEAKING AGAIN, SINCE THEY TAPED THE DIP STICK. CALLED CORPORATE WAS TOLD TO TAKE TAPE OFF DIP STICK. HAVE NOT DRIVEN THE 1,100 MILES BUT OIL IS A LITTLE BELOW THE 2 DOTS. I CALLED TOYOTA, TOLD THEM I HAD TO BE IN RALEIGH FOR WORK AND ASKED THEM TO JUST FIX THE PROBLEM. THEY SAID I HAD 2 CHOICES, DELAY MY EMPLOYMENT UNTIL I HIT THE 1,100 MILES FOR A RE CHECK OR LEAVE FOR RALEIGH AND IF OIL LIGHT COMES ON HAVE CAR TOWED TO TOYOTA. REALLY, I AM 62 AND TRAVELING WITH 2 BIRDS IN THE HEAT OF THE SUMMER. THEY TOLD ME IF I GET TO 1,100 MILES AND OIL IS LOW IT DOES NOT MEAN THEY WILL FIX THE PROBLEM. THEY WILL ADD MORE OIL SO I CAN GET TO RALEIGH AND THEY WILL CALL TOYOTA TO SEE IF THEY WILL BE RESPONSIBLE FOR REPAIRS. REALLY? I HAVE TO LEAVE FOR RALEIGH THE 19TH OF MAY THANKS
Electrical system, Engine, May 5, 2015
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT IT HAD OIL CONSUMPTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.
Engine, Apr 14, 2015
I WAS DRIVING ON THE HIGHWAY WHEN I NOTICED MY OIL LIGHT COMING ON, I PULLED OVER TO CHECK KNOWING I JUST RECENTLY HAD THE OIL CHANGE ABOUT A MONTH AGO BUT I DO DRIVE ALOT, WHEN I CHECKED MY DIPSTICK I FOUND NO OIL ON IT. THIS ENGINE SEEMS TO BE GOING THROUGH OIL CONSUMPTION AT A VERY RAPID PACE. *TR
Engine, Apr 9, 2015
OVER THE LAST FEW YEARS. MY 07 RAV4 HAS BEEN USING EXCESSIVE OIL. THOUGHT IT WAS A LEAK FROM BELOW. BUT NO DRIP ON DRIVEWAY WAS VISIBLE. NO SIGNS OF A LEAKS. WHEN THE OIL WAS CHANGED, OVER THE COURSE OF THE YEARS. THEIR IS VERY HEAVY BLOW-BY WHEN THE ENGINE IS RUNNING AND THE OIL FILLER CAP IS REMOVED. COUPLE OF MECHANICS HAVE SAID, THIS IS INCORRECT. *TR
Engine, Mar 27, 2015
V6 ENGINE MAKES A RATTLE NOISE AT STARTUP. IT HAS BEEN IDENTIFIED BY THE DEALER AS THE VVT CAMSHAFT GEAR. TOYOTA HAS A TECHNICAL SERVICE BULLETIN (T-SB-0094-09) IDENTIFYING THE CAUSE AS THE INTAKE OR EXHAUST CAMSHAFT VVT ASSEMBLY. HOWEVER THE LEXUS DIVISION OF TOYOTA HAS A RECALL FOR THIS EXACT PROBLEM ON IS AND GS MODELS (REFERENCE NHTSA CAMPAIGN NUMBER: 13V395000). THE CONSEQUENCE IS THAT THE LOOSE BOLTS COULD CAUSE THE VVT GEAR HOUSING AND SPROCKET TO SEPARATE AND RESULT IN THE ENGINE STOPPING WHILE THE VEHICLE IS BEING DRIVEN, INCREASING THE RISK OF A CRASH. IF THIS IS DANGEROUS ENOUGH TO CAUSE A CRASH FOR A LEXUS CUSTOMER, THEN WHY ISN'T THIS DANGEROUS ENOUGH TO ISSUE A RECALL FOR A TOYOTA CUSTOMER. THESE ARE THE SAME MOTORS AND THE CUSTOMERS SHOULD BE TREATED AS SUCH. *TR
Power train, Engine, Mar 13, 2015
TRANSMISSION STARTED TO WHINE,. BEARINGS. *TR