2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: engine
160 reports, newest first. Show all
Engine, Jun 2, 2019
BOUGHT THE CAR NEW, AT ABOUT 85K MILES I NOTICED IT BEGAN TO USE MORE OIL. THE ENGINE NOW USES ABOUT 2 TO 3 QUARTS BETWEEN OIL CHANGES (EVERY 3K)
Engine, Feb 4, 2019
I HAVE A TOYOTA RAV4 2008 WITH A 4 CYLINDER ENGINE. TOYOTA HAS ACKNOWLEDGED THAT THIS ENGINE HAS AN OIL CONSUMPTION PROBLEM AND HAD A WARRANTY RECALL. I NEVER RECEIVED ANY NOTICE. I ALWAYS HAVE THE OIL CHANGED FROM THE DEALER WHERE I BOUGHT THE CAR. THEY NEVER MENTIONED THIS RECALL UNTIL IT HAD EXPIRED BY SIX WEEKS. I NOTICED THAT IT WAS LOSING OIL SO I TOOK IT TO THE DEALER AND TOLD THEM ABOUT IT. THEY INSPECTED THE CAR AND TOLD ME THEIR WAS NO VISIBLE SIGNS OF OIL LEAKING OUT AND THEN TOLD ME ABOUT ABOUT THE RECALL. THEY SAID I COULD SPEND 2500.00 DOLLARS TO GET IT REPAIRED. MY QUESTION IS IF TOYOTA MANUFACTURED A DEFECTIVE ENGINE THAT LOSES OIL (MOST LIKELY BURNING IT) THEN WHY IS THIS A TIMED EVENT? IF I HAVE THIS VEHICLE WITH THIS ENGINE THEN THEY SHOULD CORRECT THE RECALLED ISSUE AT NO CHARGE TO ME LIKE EVERYONE ELSE THAT HAD THIS SAFETY ISSUE. THE DEALER KNEW I OWNED THIS CAR THAT WAS HAVING THIS ISSUE AND NEVER MENTIONED IT. WHO IS GOING TO REPAIR THIS RECALLED PROBLEM? THANKS.
Engine and engine cooling, Jan 29, 2019
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE THE VEHICLE WAS BEING INSPECTED AT AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE MUFFLER WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS LATER TAKEN TO JACK TAYLOR'S ALEXANDRIA TOYOTA (3750 RICHMOND HWY, ALEXANDRIA, VA 22305), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE CONTACT WAS REFERRED TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.
Engine, Jan 25, 2019
I NOTICED THAT I WAS LOSING OIL BETWEEN OIL CHANGES. THE DEALER THAT HAS ALWAYS CHANGED MY OIL FOUND NO LEAKS. THEY TOLD ME THAT MY ENGINE HAD A RECALL COVERING LOSS OF OIL BUT THAT THE WARRANTY HAD EXPIRED SIX WEEKS PRIOR. I WAS NEVER NOTIFIED ABOUT THIS WARRANTY. IF TOYOTA MANUFACTURED A DEFECTIVE ENGINE, WHY IS THE RECALL TIME SENSITIVE? THE DEALER NEVER NOTIFIED ME THAT MY YEAR MODEL VEHICLE HAD THIS ISSUE. *JS
Engine, Jan 14, 2019
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE OIL LEVEL WAS LOW RIGHT AFTER AN OIL CHANGE WAS PERFORMED. THE VEHICLE WAS TAKEN TO C.F. SCHWARTZ TOYOTA (1536 N DUPONT HWY, DOVER, DE 19901, (302) 734-5748) AND THE OIL WAS CHANGED. THE DEALER INFORMED THE CONTACT TO WATCH AND CHECK THE OIL LEVEL AFTER FUEL WAS ADDED TO THE VEHICLE. ONE MONTH LATER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE CONTACT WAS INFORMED OF A WARRANTY ENHANCEMENT PROGRAM THAT REQUIRED AN ENGINE REPLACEMENT AT THE COST OF $4,000. THE WARRANTY HAD SPECIAL QUALIFICATIONS, BUT THE EXPIRATION DATE HAD PASSED; THEREFORE, THE DEALER WOULD NOT COVER THE REPAIRS. THE MANUFACTURER STATED THAT THEY COULD NOT HONOR THE WARRANTY AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 114,000.
Engine, Dec 22, 2018
AN EXCESSIVE OIL CONSUMPTION, 1 QUART EVERY 1500 MILES. NO OIL LEAKS IDENTIFIED. IT'S A KNOWN ISSUE RELATED TO 2AZ-FE ENGINES DUE TO DESIGN ISSUES RELATED TO PISTONS AND RINGS. IT'S A SAFETY ISSUE WHICH CAN CAUSE A STALL OF ENGINE DUE TO LOW AMOUNT OF OIL. TOYOTA DEALER REFUSED TO REPAIR THE ENGINE DUE TO JUST EXPIRED WARRANTY (10 YEARS/150K MILES).
Engine, Nov 28, 2018
STARTED TO USE A QUART OF OIL EVERY FEW HUNDRED MILES. TOOK IT TO MY LOCAL TOYOTA DEALER AND THEY CONFIRMED THAT IT NEEDS THE NEW PISTONS AND RINGS. UNFORTUNATELY, THEY WILL NOT DO IT UNDER WARRANTY BECAUSE MY VEHICLE IS 4 MONTHS PAST THE WARRANTY EXTENSION TOYOTA ISSUED. THAT POLICY WAS FOR 10YRS OR 150,000 MILES, MY VEHICLE ONLY HAS 123,000 MILES ON IT BUT AS MENTIONED BEFORE IT IS 10 YEARS AND 4 MONTHS OLD.
Engine, Fuel/propulsion system, Nov 5, 2018
VEHICLE SPONTANEOUSLY DUMPED ALL OF OIL IN DRIVEWAY DUE TO DEFECTIVE AD RECALLED VALVE OIL HOSE. I IMMEDIATELY DROVE VEHICLE TO NEARBY MECHANIC. I HAD VEHICLE TOWED TO KINGS TOYOTA, CINCINNATI OHIO. HOWEVER, RECALLED OIL HOSE DAMAGED THE INTAKE CAM GEARS. KINGS TOYOTA STATED THEY WILL COVER THE RECALLED PART BUT REFUSE TO COVER THE DAMAGED ENGINE REPAIR. COST OF REPAIR IS $3340.78 + TAX. KINGS TOYOTA ALSO REFUSES TO REIMBURSE FOR TOWING FEE AND RENTAL CAR. I SHOULD NOT HAVE TO PAY FOR DAMAGE TO THE ENGINE DUE TO A DEFECTIVE, RECALLED PART. THE RECALL IS CALLED THE EXTENSION OF LSK 090K CAMPAIGN TO DECEMBER 31, 2021.
Other or unspecified, Engine, Oct 22, 2018
2008 TOYOTA RAV4 - EXCESSIVE OIL CONSUMPTION ON 2AZ-FE ENGINE LSC ZE7 MY DAUGHTERS TOYOTA RAV4 WAS CONSUMING AN UNUSUAL AMOUNT OF OIL. WE ORIGINALLY THOUGHT THE CAR WAS BURNING OIL. AFTER DOING MORE RESEARCH, WE DISCOVERED IT WAS A KNOWN ISSUE. TOYOTA HAS AN EXTENDED WARRANTY FOR 10 YEARS AND/OR 150,000 MILES FOR AN OIL CONSUMPTION ISSUE (ZE7). THE CAR WAS PURCHASED AUGUST 2008. WE PURCHASED THE CAR IN 2017 FROM A FAMILY MEMBER. THE PREVIOUS OWNER HAD NO IDEA THAT THIS WAS A KNOWN ISSUE. THEY THOUGHT THAT THE CAR JUST BURNED A LOT OF OIL. WE TOOK THE CAR INTO THE TOYOTA DEALERSHIP SEPTEMBER 2018, ONE MONTH BEFORE THE WARRANTY EXPIRED. TOYOTA AGREED TO START THE OIL CONSUMPTION TEST WHICH REQUIRED THEM TO CEIL THE ENGINE AND OIL STICK. WE WERE TOLD TO DRIVE THE CAR FOR 1100 TO 1300 MILES. THE CAR HAD THE BE TOWED BACK TO TOYOTA AT 1600 MILES DUE TO THE OIL LIGHT FLASHING ON AND OFF. THEY ACKNOWLEDGE THE CAR MOST LIKELY HAS THE OIL CONSUMPTION ISSUE, BUT SINCE THE CAR WAS DRIVEN APPROXIMATELY 318 MILES OVER THE LIMIT, TOYOTA CLAIMS THAT THEY MUST RESTART THE TEST AND REFUSE TO HONOR THE WARRANTY. A TUNE UP WAS DONE BY TOYOTA A FEW MONTHS PRIOR. WHEN WE DISCOVERED THAT THE OIL LEAK WAS POTENTIALLY RELATED TO A KNOWN OIL CONSUMPTION ISSUE, WE TOOK THE CAR IN TO START THE PHASE 1 TEST. THE SERVICE DEPARTMENT MARKED THE OIL AS SEVERELY LOW. UNDER NO CIRCUMSTANCES SHOULD THE CAR RUN LOW ON OIL, WHEN THE OIL WAS FILLED BY TOYOTA AND WAS DRIVEN ONLY 1600 MILES. SINCERELY, [XXX] MORE COMPLAINTS: HTTPS://WWW.TOYOHEADQUARTERS.COM/THREADS/EXCESSIVE-OIL-CONSUMPTION-ON-2AZ-FE-ENGINE-LSC-ZE7.362/PAGE-2 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine, Oct 1, 2018
MY RAV4 IS NOW BURNING OIL. I AM PUTTING OIL INTO IT BEFORE I GET TO THE DATE OF MY NEXT SERVICE. I'VE HEARD ABOUT AN ENHANCED WARRANTY THAT WENT OUT TO DEALERS THAT TOLD ABOUT THIS BEING A PROBLEM WITH PISTONS AND RINGS BUT THE DEALERS CHOSE NOT TO TELL CUSTOMERS ABOUT IT. HOW DO WE FIX THE PROBLEM NOW?
Engine, Sep 20, 2018
HAVE EXCESSIVE OIL CONSUMPTION. ENGINE LIGHT KEPT GOING ON. TOOK IT TO THE TOYOTA DEALER THAT I BOUGHT THE CAR AND SERVICED AT. THEY RECOMMENDED AN OIL CONSUMPTION TEST. PERFORMED THE TEST AND IT FAILED. DEALER AND TOYOTA CORPORATE SAID THERE IS NOTHING THEY WOULD DO. CLAIMED THEY SENT A RECALL LETTER THAT I NEVER RECEIVED. I DON'T BELIEVE THERE WAS A RECALL JUST A MAJOR DEFECT IN THEIR POWERTRAIN. THE VEHICLE IS NOW IN MY DAUGHTERS PROCESSION AND HAVE GRAVE CONCERNS THE ENGINE COULD SEAZE OR CATCH FIRE LEADING TO A CRASH. IN RESEARCHING I FOUND THAT THIS IS A COMMON DEFECT AMONGST VARIOUS TOYOTA MODALS AND MODAL YEARS. IF THERE WAS A RECALL THEM I BELIEVE THE TOYOTA DEALER SERVICING THE VEHICLE WAS NEGLIGENT TO FOR PRESCRIBING AN OIL CONSUMPTION TEST AND NOT TELLING ME OF ALL RECALLS FOR MY VEHICLE. IF THERE WAS NO RECALL THEN TOYOTA IS NEGLIGENT FOR KNOWINGLY AVOIDING A DEFECT AND NOT STANDING BY THEIR PRODUCT. I WOULD LIKE THEM TO REPLACE THE DEFECTIVE ENGINE OR REPAIR IT SO THE EXCESSIVE OIL CONSUMPTION IS ELIMINATE. ANY ASSISTANCE YOU CAN PROVIDE WOULD BE GREATLY APPRECIATED
Engine, Jul 29, 2018
ENGINE IS USING EXCESSIVE OIL AT THE RATE OF .9 QUARTS PER 1200 MILES. DEALER SAID THIS IS NORMAL AND TOYOTA WILL NOT COVER ANY WORK UNDER WARRANTY.
Engine, Jul 15, 2018
BURNING MOTOR OIL
Engine, Jun 21, 2018
IT WAS RECOMMENDED BY MY TECHNICIAN THAT I HAVE AN OIL CONSUMPTION TEST BECAUSE I GO THROUGH A LOT OF OIL. I TOOK IT TO NALLEY TOYOTA OF ROSWELL GA ON 11/7/17 AND MY CAR "PASSED" THE TEST, HOWEVER MY CAR STILL CONSUMES OIL AT RATES NOT HEALTHY FOR THE CAR. I WENT TO ANOTHER DEALER; MARIETTA TOYOTA IN GEORGIA ON 6/21/18. THEY TESTED THE CAR, ADDED 2 QUARTS OF OIL AND SAID THAT I HAVE AN ISSUE, HOWEVER 10 YEARS HAS PASSED SINCE 6/6/06, THE FIRST USE OF THE CAR. I DO NOT BELIEVE THE OIL CONSUMPTION ISSUE MANIFESTED ITSELF IN THAT AMOUNT OF TIME BETWEEN DEALER VISITS. I BELIEVE THAT I WAS IMPROPERLY DIAGNOSED BY THE FIRST DEALER BECAUSE THEY DID NOT WANT TO HAVE TO RECTIFY THE PROBLEM.
Engine, Apr 11, 2018
EXCESSIVE OIL CONSUMPTION
Engine, Mar 5, 2018
2008 TOYOTA RAV4 EXCESSIVE OIL CONSUMPTION. AFTER REACHING 100,000 MILE ON MY VEHICLE, IT BEGAN TO USE 1 QUART OF OIL EVERY 1,200-1,500 MILES. TOYOTA KNEW OF THIS PROBLEM (TSB TO DEALERS) BUT REFUSE TO OFFER ANY RESTITUTION TO CUSTOMERS IF THE VEHICLE HAS PASSED THE 60,000 MILE POWER TRAIN WARRANTY. THIS IS A MANUFACTURE PROBLEM AND TOYOTA SHOULD HAVE TO MAKE THESE REPAIRS FREE OF ANY CHARGE TO THE CUSTOMER.
Engine, Feb 18, 2018
IT HAS EXCESSIVE OIL CONSUMPTION AND HAS FOR AT LEAST A YEAR THAT I HAVE BEEN AWARE OF. I HAVE TO ADD AT LEAST A QUART OF OIL EVERY 1000 MILES OR LESS. I FEEL I HAVE TO CARRY OIL EVERYWHERE AND THAT I NEED TO CHECK THE DIP STICK FREQUENTLY. THE DEALER HAS CHARGED A FAIR AMOUNT OF MONEY FOR THINGS THAT HAVE NOT FIXED IT YET AND NOW IS QUOTING ME $3800.00 FOR ENGINE DIAGNOSTIC/REPAIR. THEY NEVER ONCE MENTIONED TO ME THAT THERE IS A KNOWN CONSUMPTION PROBLEM WITH THIS ENGINE TYPE ON ANY OF MY OTHER EXPENSIVE VISITS TO THEM BACK WHEN MY MILEAGE WAS UNER 150,000 MILES. IT'S KNOW OVER 167,000 MILES AND SO IS NOT COVERED BY THEIR SO CALLED WARRANTY ENHANCEMENT PROGRAM.
Engine, Feb 1, 2018
ECSESSIVE OIL CONSUMPTION OVER LAST YEAR INCREASING OVER TIME NOW USING 5-6 QUARTS BETWEEN OIL CHANGE... TOYOTA ACKNOWLEDGES OIL CONSUMPTION PROBLEM BUT WILL NOT REPAIR'
Electrical system, Engine, Jan 8, 2018
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT COULD NOT PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, AND IT RETURNED TO NORMAL. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR, BATTERY, AND IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED SEVERAL OTHER TIMES AFTER THE REPAIR. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-331-4331 AND ASKED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 213,000. THE VIN WAS NOT AVAILABLE.
Engine, Dec 8, 2017
I HAVE A TOYOTA RAV 4 (2008), WHICH I LOVE. IT HAS BEEN A WONDERFUL CAR. NO REAL PROBLEMS TO SPEAK OF. BUT AT AROUND 146,000 MILES I WAS SURPRISED TO SEE MY OIL LIGHT COME ON 1/4 OF THE WAY THROUGH MY REGULAR MAINTENANCE SCHEDULE. I ADDED OIL AND MADE A MENTAL NOTE TO BRING IT UP TO MY MECHANIC. ANOTHER 1/4 OF THE WAY THE OIL LIGHT COMES BACK ON. I HAD TO ADD MORE OIL. MY CAR HAS 149,000 MILES ON IT NOW. I HAVE HAD MY CAR IN FOR MAINTENANCE EVERY 5,000 MILES SINCE I BOUGHT IT NEW. IT IS NOW BURNING ABOUT 1 QUART EVERY 1200 MILES. THIS JUST HAPPENS TO BE THE AMOUNT THAT TOYOTA CALLS A PROBLEM AND EXCESSIVE, BUT MY CAR IS OUT OF WARRANTY. I WAS HOPING TO KEEP MY CAR FOR SEVERAL MORE YEARS. THIS IS VERY DISAPPOINTING, ESPECIALLY SINCE PEOPLE HAVE ALWAYS SAID 'GET A TOYOTA, THEY LAST FOREVER'.
Engine, Nov 11, 2017
MY CAR HAS BEEN NEEDING OIL CHANGES MORE FREQUENTLY. I AM IN GETTING OIL CHANGE TODAY AND MY CAR WASN'T DUE FOR 1000 MORE MILE AND 1/18 (WHICHEVER CAME FIRST). I HAVE NO LEAKS,HAVEN'T DAMAGED A ANYTHING AND ITS ALWAYS DONE PROFESSIONALLY.. ITS BEEN CHANGED AT TOYOTA,GOOD YEAR,OIL CHANGE SHOPS.NO SMOKE OR BURNING OD OIL. CAR GETS REGULAR MAINTENANCE.
Power train, Other or unspecified, Engine, Sep 18, 2017
1. EXCESSIVE OIL CONSUMPTION UP TO 1QT EVERY 1200 MILES, UNDER NORMAL DRIVING CONDITIONS NOTICED DECEMBER OF 2013. 2. ECM FAILS TO HOLD REVERSE GEAR. GEAR FREQUENTLY SLIPS IN REVERSE WHEN GAS PEDAL IS PRESSED, WON'T BACK UP HILLS. NOTICED DECEMBER OF 2013, NO POWER WHEN FIRST STARTING UP FOR FIRST 10 TO 15 MINUTES OF DRIVE. OCTOBER OF 2013 IMMEDIATELY AFTER PURCHASING 3. HEAD GASKET FAIL BETWEEN NUMBER 2 AND 3 CYLINDERS DUE TO FAULTY HEAD GASKET. REPLACED HEAD GASKET JUNE 2016 4. VERY LOW FUEL ECONOMY DECEMBER 2013. 5. NO OIL PRESSURE VERY RUFF IDLE OIL PRESSURE LIGHT ON, WITH OIL LEVEL READING FULL. SEPTEMBER 2017
Engine, Sep 4, 2017
MY 2008 TOYOTA RAV4 GOES THROUGH EXCESSIVE AMOUNTS OF OIL. I HAVE TO ADD UPWARDS OF A QUART A WEEK, AFTER 300-600 MILES IN THAT PERIOD. IT'S BEEN AN ONGOING PROBLEM, BUT I STARTED NOTICING SOMETHING WAS OFF IN THE LAST SIX MONTHS, AND TRACKING IT RELIGIOUSLY IN THE LAST TWO MONTHS OR SO.
Engine, Aug 27, 2017
I HAVE CHANGED MY OIL 3 TIMES AND EACH TIME IT CONSUMES OIL MORE QUICKLY THIS LAST TIME I CHANGED THE OIL RIGHT BEFORE A1000 MILE TRIP..WHEN I GOT BACK HOME (2000 MILES LATER) I HAD LESS THAN A QUART IN THERE. NO LEAKS..NO BLACK CLOUDS OF SMOKE. THIS WAS IN LESS THAN 7 DAYS. VERY CONCERNED! I HAVE OWNED THIS CAR ABOUT 6 MONTHS NOW.
Engine, Aug 24, 2017
EXCESSIVE OIL CONSUMPTION. ENGINE DOWN 2 QUARTS OF OIL AFTER 2000 MILES OF DRIVING AFTER OIL CHANGE.