2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: steering
73 reports, newest first. Show all
Steering, Feb 1, 2016
I HEAR A " THUD NOISE " WHENEVER I TURN THE STEERING WHEEL LEFT OR RIGHT, ESPECIALLY WHEN GETTING IN AND OUT OF A PARKING SPACE.
Steering, Jan 7, 2016
VEHICLE DEVELOPED A CLUNK NOISE THAT COULD BE HEARD AND FELT THROUGHOUT THE VEHICLE, ESPECIALLY IN THE STEERING SYSTEM AND ESPECIALLY DURING SLOW SPEED OPERATION. THE PROBLEM BEGAN IN 8/2015 AT ~45,000 MILES. VEHICLE ALSO DEVELOPED A LOOSE FEEL IN THE STEERING AND WOULD PULL TO THE RIGHT UNDER HARD ACCELERATION. BY 1/2016, THE PROBLEM GOT NOTICEABLY WORSE. I THEN TOOK THE VEHICLE TO A LOCAL AUTO REPAIR SHOP FOR DIAGNOSIS/REPAIR. AFTER AN HOUR OR SO OF CHECKING THE ENTIRE SUSPENSION AND STEERING SYSTEM, THE PROBLEM WAS DIAGNOSED AS A BAD "STEERING INTERMEDIATE SHAFT". THE LOCAL SHOP OWNER STATED HE HAD REPLACED SEVERAL OF THESE SAME STEERING SHAFTS ON OTHER RAV4S AROUND THE SAME VINTAGE (2006-2010). I CONTACTED MY LOCAL TOYOTA DEALERSHIP AND THE SERVICE AGENT ALSO STATED THEY HAD "SEVERAL" INCIDENTS WITH THIS VINTAGE OF RAV4S AND STEERING SHAFT PROBLEMS BUT THERE WAS NO RECALL AND SINCE THE VEHICLE WAS OUT OF THE WARRANTY PERIOD, TOYOTA WOULD NOT COVER THE REPAIRS. I THEN LOOKED ONLINE TO SEE IF ANY OTHER OWNERS HAD THE SAME PROBLEM AND WAS SHOCKED TO SEE HOW MANY OTHERS HAVE HAD THE SAME ISSUE WITH RAV4S OF THE SAME VINTAGE AND HAD SIMILAR RESULTS WITH LOCAL TOYOTA DEALERS. I BELIEVE THIS IS A SERIOUS SAFETY CONCERN AS EVENTUALLY THE STEERING SHAFT AND/OR SHAFT U-JOINT KNUCKLES COULD FAIL DUE TO THIS POOR DESIGN AND CAUSE LOSS OF CONTROL (STEERING) OF THE VEHICLE. TOYOTA DOES NOT SEEM TO BE TAKING THIS SERIOUSLY, HOPEFULLY THE NHTSA WILL.
Steering, Jan 6, 2016
2008 RAV 4 HAS LESS THAN 60K MILES. WAS EXPERIENCING A CLUNKING NOISE WHEN TURNING LEFT OR RIGHT AT LOW SPEEDS. TOOK MY VEHICLE INTO THE DEALERSHIP AND WAS TOLD IT NEEDS A NEW STEERING SHAFT AT A COST TO ME OF $688. UPON RESEARCHING THIS ISSUE I HAVE DISCOVERED THAT IT HAS BEEN AN ISSUE WITH THIS MAKE, YEAR AND MODEL FOR A LONG TIME. WOULD LIKE TO SEE A RECALL GENERATED FOR THIS AS TOYOTA OWNERS SHOULD NOT HAVE TO BEAR THE COST OF FAULTY MANUFACTURING.
Steering, Dec 1, 2015
HAVING JUST EXITED I-95, I WAS TURNING THE STEERING WHEEL TO THE RIGHT TO PULL UP TO THE CURB AT THE PHILADELPHIA AIRPORT TO PICK UP A PASSENGER. UPON DOING SO, THE STEERING COLUMN MADE A LOUD POP OR CLUNK SOUND, AND THE STEERING WHEEL IMMEDIATELY LURCHED APPROXIMATELY 6-8" TO THE LEFT - AND NEARLY OUT OF MY HANDS - ALMOST CAUSING ME TO CRASH INTO THE CROWD AT THE CURB. AFTER THIS SOUND OCCURRED, THE STEERING WHEEL (AS IN A PREVIOUS COMPLAINT IN 2013) WAS STILL OPERATIONAL, HOWEVER WAS ABLE TO MOVE APPROXIMATELY 6 - 9" UP, DOWN, RIGHT, OR LEFT WHILE STILL REMAINING OPERABLE. UPON TAKING THE VEHICLE TO THE TOYOTA DEALERSHIP, I WAS ASKED IF I HAD BEEN IN A FRONT-END COLLISION (ANSWER, "NEVER"), AS A FACTORY WELD HAD FAILED THAT KEEPS THE STEERING COLUMN ATTACHED TO A SAFETY ROD IN THE DASH. REPAIRS ARE EXPECTED TO RUN APPROXIMATELY $3,700. MATTER HAS BEEN SENT TO TOYOTA CORPORATE, HOWEVER NO WORD HAS COME BACK. IT APPEARS AS IF I WILL BE RESPONSIBLE FOR THE FULL REPAIR COST, DESPITE FAILURE IN FACTORY WELD. APPARENTLY NO FAIL-SAFES ARE IN PLACE SHOULD THIS WELD FAIL, SUCH THAT A VERY DANGEROUS SITUATION ARISES, ESPECIALLY IF THIS HAD HAPPENED THREE MINUTES EARLIER WHEN I WAS IN VERY HEAVY INTERSTATE TRAFFIC, INSTEAD OF JUST HAVING EXITED, AND MOVING AT 10 MPH OR LESS.
Steering, Wheels, Service brakes, Oct 20, 2015
ON OCTOBER 5 AND 6, 2015 MY 2008 TOYOTA RAV4 WAS IN FOR SERVICE AT PIERCEY TOYOTA IN MILPITAS TO REPLACE ALL FOUR TIRES, FRONT/BACK BRAKES AND FRONT SHOCK ABSORBERS, A TOTAL OF $2,000. ON OCTOBER 8, 2015, WHILE I WAS DRIVING MY CAR BACK FROM STANFORD LUCILE PACKARD OVER DUMBARTON BRIDGE, I HAVE NOTICED THAT MY BRAKES WOULD NOT ENGAGE AND I COULD NOT SLOW DOWN MY CAR. JUST BEFORE THIS EVENT, THE ABS, VSC, AND SLIP WARNING LIGHTS ALL CAME ON. THE BRAKE PEDAL FELT VERY STIFF AND I WAS NOT ABLE TO DO ANY REPETITIVE PUMPING OF THE BRAKE. I CALLED 911 AND REQUESTED ASSISTANCE. WHEN THE FRONT TRAFFIC CAME TO A HOLD I HAD TO USE MY EMERGENCY BRAKE AND MY ENTIRE CAR SLIPPED TO THE LEFT. WE ALMOST GOT HIT BY THE BUS BEHIND US. SOME GOOD SAMARITANS SAW WHAT HAPPENED AND HELPED ME TO GET MY CAR OFF THE ROAD. THAT DAY, MY 9 YRS. OLD SON AND I COULD HAVE BEEN KILLED. I REQUEST THAT TOYOTA INVESTIGATES/RECALLS THE BRAKE LIGHT SWITCH CIRCUIT THAT HAS MALFUNCTIONED. PIERCEY TOYOTA IN MILPITAS INVESTIGATED THE INCIDENT ON 10/09/15. THEY FOUND C1249 OPEN STOP LIGHT SWITCH CIRCUIT, C1223 ABS SYSTEM MALFUNCTION, MY VEHICLE HAD INTERMITTENT BRAKE LIGHT SWITCH CIRCUIT MALFUNCTION. PIERCEY TOYOTA REPLACED BRAKE LIGHT SWITCH ASSEMBLY.
Steering, Oct 8, 2015
I HAVE A 2008 RAV4. IN 2010, I EXPERIENCED A "CLUNKING" OR "THUNKING" SENSATION IN THE STEERING COLUMN ON LOW SPEED TURNS. THE DEALER DETERMINED THAT A FAULTY INTERMEDIATE STEERING SHAFT WAS THE CAUSE AND REPLACED IT. THE SAME PROBLEM OCCURRED AGAIN IN 2012 AND THE DEALER REPLACED THE INTERMEDIATE STEERING SHAFT AGAIN. IN 2015, I HAD STEERING PROBLEMS WHICH HAD A SIMILAR FEEL (A "THUNK" OR "CLUNK" FEELING WHEN TURNING). THIS TIME THE DEALER DETERMINED THAT THE STEERING RACK AND RELATED PARTS NEEDED TO BE REPLACED AND CHARGED ME $2,400 FOR THE REPAIR.
Steering, Oct 3, 2015
UPON STARTING THE VEHICLE AND ATTEMPTING TO GO IN REVERSE, THE POWER STEERING BECAME DIFFICULT TO TURN. HAD IT TOWED TO MY MECHANIC AND WAS TOLD THE ELECTRIC STEERING CONTROL MODULE AND STEERING COLUMN MOTOR ASSEMBLY HAD TO BE REPLACED. TOTAL COST WAS $3,300. THIS IS BECOMING A COMMON COMPLAINT AND, CONSIDERING THE COST INVOLVED, SHOULD BE THOROUGHLY REVIEWED BY THE NHTSA.
Steering, Jul 24, 2015
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE THE VEHICLE WAS BEING SERVICED, IT WAS DISCOVERED THAT THE VEHICLE HAD A FRACTURED STEERING ROD. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,901.
Steering, May 30, 2015
CLUNKING NOISE WHEN TURNING THE STEERING WHEEL.
Steering, May 16, 2015, crash, fire
WE RECENTLY TOOK OUR RAV4 IN FOR RECALL WORK. THE SERVICE DEPARTMENT DECIDED TO DO A COMPLIMENTARY INSPECTION ON MY RAV4. WE WERE TOLD THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. IT HAD NEVER BEEN A PROBLEM BEFORE. NOW, THE POWER STEERING PUMP IS SQUEALING ON TIGHTER THAN REGULAR CORNER TURNING. I RESEARCHED THIS ISSUE ON THE INTERNET. THE DISTURBING, MORE CONSTANT COMPLIANT IS THAT THE POWER STEERING ON MY YEAR, MAKE AND MODEL WILL FAIL INTERMITTENTLY AND THEN SUDDENLY FAIL. THIS IS A VERY SERIOUS ISSUE SINCE MOST OF THE DRIVERS ON THE ROAD ARE USED TO POWER STEERING AND MAY NOT KNOW WHAT TO DO IF THE POWER STEERING SHOULD SUDDENLY FAIL WHILE DRIVING. I WANT TO MAKE IT CLEAR THAT I AM NOT BLAMING THE DEALERSHIP OR THE SERVICE DEPARTMENT. THEY GAVE US A HEADS-UP ON WHAT WE HAD NO IDEA WAS ABOUT TO BECOME A PROBLEM. THE POWER STEERING PUMP PROBLEM IS A SERIOUS ISSUE, THE RAV4 IS A FAMILY CAR FOR THE MOST PART.
Steering, Mar 20, 2015
MAKES A CLUNKING SOUND WHEN I TURN AND I FEEL A "BUMP" IN THE STEERING WHEEL. I WAS CHARGED $594.45 AT THE DEALERSHIP FOR THE REPAIR REPLACE THE INTERMEDIATE STEERING SHAFT. AFTER SEARCHING ONLINE, I FOUND THAT THERE ARE MANY COMPLAINTS ABOUT THIS PROBLEM. PLEASE ENFORCE A VEHICLE RECALL FOR THIS PROBLEM. *TR
Steering, Feb 15, 2015
POWER STEERING BECAME DIFFICULT,DEALER REPLACED STEERING COLUMN. PROBLEM WITH SENSOR LOCATED AT COLUMN. COST TO ME $1260.00. *TR
Steering, Dec 22, 2014
CLUNKING NOISE FROM STEERING SHAFT THAT IS BOTH AUDIBLE AND FELT THROUGH STEERING WHEEL. OCCURS TURNING BOTH LEFT AND RIGHT, GOING FORWARD OR REVERSE, BUT NOT WHEN DRIVING STRAIGHT. *TR
Steering, Nov 11, 2014
REQUESTED STEERING SHAFT REPLACEMENT DURING INSPECTION (NEED ATTENTION SOON). THOUGHT THAT WAS ODD. WENT ONLINE AND APPEARS TO BE A PROBLEM WITH TOYOTA VEHICLES. CALLED TOYOTA 800 331-4331, THEY DIDN'T CARE. THOUGHT I FILE A COMPLAINT TO GET IT RECALLED. *TR
Steering, Oct 1, 2014
AFTER BEING TOLD I NEEDED A STEERING INTERMEDIATE SHAFT, I STARTED INVESTIGATING ON THE INTERNET AND COME TO REALIZE THERE ARE HUNDREDS OF COMPLAINTS ON THIS ISSUE DATING BACK TO 2007. WHEN STEERING I HEAR A CRACKING SOUND AND FEEL THAT IT IS A DEFECT. ALL OF THE RAV 4'S ARE HAVING THE SAME PROBLEM, AND THIS CAN REALLY CAUSE INJURY. *TR
Steering, Sep 9, 2014
I WENT TO THE DEALER BECAUSE I HEARD A CLUNKING NOISE WHEN TURNING THE STEERING WHEEL. THEY DID NOT HEAR ANYTHING AND I COULD NOT DO ANYTHING BECAUSE THE VEHICLE WAS UNDER WARRANTY. A YEAR LATER, AT A ROUTINE CHECKUP, THEY SAID THEY HEARD THE SOUND AND IT WAS A DAMAGE STEERING SHAFT AND RACK & PINION. A YEAR LATER THE SAME SOUND, BUT ONLY THE STEERING SHAFT WAS REPLACED. THE YEAR AFTER THAT, THE NOISE AGAIN AND THEY HAD TO REPLACE THE STEERING SHAFT AND RACK AND PINION. TODAY I WAS TOLD THAT I HAVE TO CHANGE THE RACK AND PINION. I READ ON INTERNET THAT THIS IS A COMMON PROBLEM THROUGHOUT RAV4 2008, BUT THIS IS RIDICULOUS. *TR
Steering, Jun 9, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHEN THE CONTACT STARTED THE VEHICLE, THE POWER STEERING MALFUNCTIONED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE DEALER STATED THAT THE POWER STEERING CONTROL UNIT NEEDED TO BE REPLACED. THE REPAIR WAS MADE AND THE STEERING OPERATED NORMALLY. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 65,262. UPDATED 9/8/14*CN
Steering, May 27, 2014
VEHICLE MAKES NOISE WHEN THE STEERING WHEEL IS TURN. DIAGNOSED WITH RACK & PINION PROBLEMS BY THE TOYOTA DEALER AT 20, 070 MILES. *TR
Steering, Nov 22, 2013
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT SHE HEARD A KNOCKING NOISE WHILE TURNING AT VARIOUS SPEEDS AND STEERING THE VEHICLE BECAME DIFFICULT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 23,000.
Steering, Engine, Aug 6, 2013
MY ALTERNATOR WENT IN MY VEHICLE BUT WAS DISCOVERED WAS DISTURBING. I HAD JUST HAD MY OIL CHANGED 4 WEEKS PRIOR AND THE VEHICLE WAS ALMOST EMPTY OF OIL. IF THE ALTERNATOR HAD NOT FAILED MY ENGINE WOULD HAVE BLOWN DUE TO THE LACK OF OIL. THE LACK OF OIL IS DUE TO THE PISTON ASSEMBLY IN MY 2008 TOYOTA RAV4. THIS IS A KNOWN PROBLEM WITH TOYOTA SINCE THEY ISSUED A TECHNICAL SERVICE BULLETIN ON AUG. 11 KNOWN AS SB002411 AND SB009411. TOYOTA SAID THE PROBLEM WAS TRACED TO THE PISTON ASSEMBLY, YET I HAVE NOT RECEIVED ANY NOTIFICATION FROM TOYOTA REGARDING THIS ISSUE. THERE ISN'T ANY RECALL. THIS REPAIR IS ONLY COVERED FOR 60 MONTHS OR 60,000 MILES, WHICHEVER OCCURS FIRST. IN MY SITUATION, THE FINANCIAL BURDEN OF THIS REPAIR IS ON MYSELF ($4-$5K). THIS IS THE SECOND ISSUE WITH TOYOTA RAV 4 WHERE IT SHOULD BE A RECALL. MY PRIOR ISSUE WAS THE STEERING INTERMEDIATE SHAFT WHICH WAS MAKING A CLUCKING SOUND AND IF NOT ADDRESSED THE I COULD LOSE CONTROL OF THE VEHICLE, THAT FINANCIAL BURDEN WAS $800. BOTH SHOULD BE A RECALL BY TOYOTA. *TR
Steering, Power train, Jul 19, 2013
I TOOK MY 2008 TOYOTA RAV4 TO THE DEALERSHIP FOR ITS SCHEDULE APPOINTMENT, AND I WAS TOLD THAT THE RACK AND PINION AND SHAFT NEEDED REPLACEMENT. RESEARCHING ABOUT THIS PROBLEM ONLINE, IT WAS EVIDENT THAT MANY RAV4 OWNERS WERE EXPERIENCING THE SAME SITUATION. THIS A COMMON PROBLEM WITH MANY RAV4S. A SO CALLED DEPENDABLE CAR SHOULD NOT HAVE THIS PROBLEM BEFORE REACHING 100,000 MILES. CERTAINLY, TOYOTA MUST CLEARLY KNOW THAT THIS IS A COMMON PROBLEM AND SHOULD ADDRESS IT AS SOON AS POSSIBLE BECAUSE THIS PROBLEM COULD POTENTIALLY LEAD TO AN ACCIDENT WHICH CAN DISRUPT THE SAFETY OF OUR COMMUNITIES. *TR
Steering, Jul 1, 2013
WHILE DRIVING THE STEERING BECOMES TIGHT DOES NOT SMOOTHLY GO INTO A CURVE AS IF THE STEERING NEEDS TO BE LUBRICATED THROWS OFF THE VEHICLE BECAUSE I HAVE TO JERK THE WHEEL.I AM AFRAID I'M GOING TO HAVE A CRASH DUE TO THIS. *TR
Steering, Suspension, Jul 1, 2013
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, SHE NOTICED THAT THE REAR PASSENGER'S SIDE TIRE HAD BUCKLED INWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN STATED THAT ONE OF THE TIE ROD BOLTS WAS MISSING AND HAD CAUSED THE TIE ROD TO BECOME BENT. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V373000 (SUSPENSION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. *TR
Steering, Jun 10, 2013
I HAD JUST DROPPED OFF MY FIANCE AT WORK AND WAS ATTEMPTING TO TURN AROUND IN THE PARKING LOT WHEN MY STEERING WHEEL DROPPED ROUGHLY 8 INCHES HITTING MY LEG. THE STEERING WHEEL CAN BE MOVED 8 TO 12 INCHES UP AND DOWN WITH LITTLE RESISTANCE. IT CAN ALSO MOVE BE MOVED 6 TO 8 INCHES LEFT TO RIGHT WITH NO RESISTANCE. IT'S NOT GUIDED IN ANY WAY, YOU CAN MOVE IT AROUND IN A LARGE CIRCULAR MOTION. THE CAR AMAZINGLY ENOUGH STILL STEERS. THE STEERING ASSEMBLY IS STILL ATTACHED TO THE STEERING INTERMEDIATE SHAFT AS WELL AS THE RACK AND PINION. THOUGH WHEN YOU DO ATTEMPT TO STEER, IT MAKES A HORRIBLE POPPING SOUND, WHICH MAKES SENSE BECAUSE THE SHAFT IS NO LONGER IN A FIXED POSITION. UPON INVESTIGATION IT LOOKS LIKE A FACTORY WELD HAS FAILED. FOR A 2008 RAV4, THE STEERING COLUMN ASSEMBLY IS MOUNTED TO THE INSTRUMENT PANEL REINFORCEMENT BAR. THIS IS A LARGE BAR THAT RUNS THE LENGTH OF YOUR DASHBOARD. THIS BAR HAS A FEW WELDED MOUNTS ON IT THAT ALLOW YOU TO BOLT ON THE STEERING COLUMN ASSEMBLY, WHICH HOLDS THE STEERING WHEEL IN PLACE, IT IS THESE WELDS WHICH HAVE FAILED. THIS IS A MAJOR SAFETY ISSUE, IF THE STEERING WHEEL HAD DROPPED 5 MINUTES EARLIER WHEN I WAS TRAVELING AT HIGHWAY SPEEDS I COULD HAVE EASILY LOST CONTROL OF THE VEHICLE. THE CAR HAD 65,000 MILES ON IT AT THE TIME OF INCIDENT. *TR
Steering, Jan 9, 2013
RESISTANCE IS FELT AT INTERVALS WHEN TURNING THE STEERING WHEEL. STEERING FEELS LOOSE, UNRESPONSIVE AND DANGEROUS. DEALER RECOMMENDED REPLACING INTERMEDIATE STEERING SHAFT. ONLINE RESEARCH SHOWED THIS IS A COMMON PROBLEM AND AN UPGRADED PART EXISTS TO REMEDY THE PROBLEM. CONTACTED TOYOTA CUSTOMER SERVICE. HAD COMPLAINT ESCALATED TO TOYOTA CORPORATE REGIONAL MANAGER. WAS ONLY OFFERED 15% OFF REPAIR AT DEALER. I BELIEVE THIS IS A SAFETY ISSUE CREATED BY A DEFECTIVE PART. THANK YOU. *TR