2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
575 reports, newest first.
Visibility/wiper, Sep 14, 2015
THE DRIVER'S SIDE SUN VISOR WILL NOT STAY UP, SO IT NORMALLY STAYS IN A VIEW-OBSTRUCTED POSITION WHEN DRIVING. THIS IS A SERIOUS SAFETY ISSUE AND TOYOTA REFUSES TO BUDGE IN TERMS OF RECALLING THIS ITEM. I BROUGHT THIS TO THE ATTENTION OF TOYOTA A YEAR OR SO AGO AND THEY ASKED ME FOR A QUOTE TO FIX - I SENT THEM A COPY OF THE DEALER PRICE QUOTE (AROUND $150) AND TOYOTA REFUSED TO PAY FOR IT AS A SAFETY ISSUE AND BASICALLY TOLD ME TO GO AWAY. I WOULDN'T NORMALLY COMPLAIN ABOUT SOMETHING LIKE THIS BUT I'VE NOTICED MULTIPLE COMPLAINTS ABOUT THIS SAME ISSUE ON THE INTERNET....AND EVEN FROM THOSE WHO HAD THE VISOR REPLACED UNDER WARRANTY AND IT HAPPENED AGAIN. PLEASE FEEL FREE TO CALL ME AT [XXX] IF YOU'D LIKE ANY ADDITIONAL INFORMATION. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC
Vehicle speed control, Jul 30, 2015
THE RAV4 HAS EXHIBITED SUDDEN UNINTENDED ACCELERATION THREE TIMES: LATEST OCCURRED ON 7/17/2015 AT 7:30 PM WHILE STOPPED AT AN INTERSECTION; THE 2ND ON 7/06/15 WHILE IN PARK IN MY DRIVEWAY JUST AFTER STATING THE CAR; THE 1ST ON ABOUT 6/30/15 AROUND NOON WHILE STOPPED AT A TRAFFIC LIGHT. FORTUNATELY, I HAD MY FOOT ON THE BREAK OR WAS IN PARK SO THAT THE CAR DID NOT MOVE. AFTER TURNING THE CAR OFF AND RESTARTING THE PROBLEM WENT AWAY. THE VEHICLE WAS TESTED AT LOCAL DEALER ON 7/20 WITH DIAGNOSTIC DATA SENT TO TOYOTA CENTRAL, BUT THEY COULD FIND NO PROBLEM IN THE DATA - NO ERROR CODES. THE TECHNICAL CASE NUMBER IS [XXX]. AFTER CONTACTING TOYOTA CUSTOMER SERVICE (CASE # [XXX]) I WAS TOLD THEY COULD DO NOTHING FURTHER THAT THE CAR "PERFORMED AS DESIGNED" PER SABINA CHARFAUROS, CASE MANAGER, 188-331-4331 EXT. 73846 UPDATED 9/28/15 *LN UPDATED 3/23/2016*JS
Engine, Jul 26, 2015
I'VE HAD MY 08 TOYOTA RAV4 FOR OVER 4 YEARS NOW. I GET THE OIL CHANGED ON IT EVERY 5,000 MILES REGULARLY. I GOT IT WITH ABOUT 25,000 MILES ON IT AND RIGHT AROUND 70,000 MILES I NOTICED THAT THE OIL LIGHT WOULD COME ON BEFORE I REACHED MY NEXT OIL CHANGE. IT HOLDS ABOUT 5 QUARTS AND WITH BEING CHANGED EVERY 5,000 MILES THAT MEANS IT IS BURNING MORE THEN 1 QUART EVERY 1,000 MILES! MY BROTHER-IN-LAW DID SOME RESEARCH AND FOUND OUT THAT THIS IS BECOMING A PROBLEM WITH MANY RAV4'S WITH THE PISTONS IN THE 2AZ FE MOTOR. I LOVE THIS CAR SO MUCH AND IT BREAKS MY HEART TO KNOW THAT THERE IS SOMETHING WRONG THAT I CAN'T FIX. I DON'T WANT TO GET A DIFFERENT CAR BUT NOW I HAVE TO!
Steering, Jul 24, 2015
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE THE VEHICLE WAS BEING SERVICED, IT WAS DISCOVERED THAT THE VEHICLE HAD A FRACTURED STEERING ROD. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,901.
Structure, Jul 23, 2015
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE SOFTWARE WAS UPDATED IN THE VEHICLE DUE TO A MANUFACTURER'S RECALL. WHILE TRAVELING AT ANY RATE OF SPEED, THE CONTACT'S ANKLE WAS IMPACTED BY THE ACCELERATOR PEDAL AND THE BRAKE PEDAL, WHICH GENERATED AN UNSAFE CONDITION AND A SUDDEN LOSS OF POWER. THE CONTACT EXPERIENCED THE FAILURE MORE THAN ONCE AND HAD TO MOVE OVER TO THE RIGHT LANE TO GET THE VEHICLE TO PICK UP SPEED EACH TIME THE FAILURE RECURRED WHILE IN DRIVE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V113000 (VEHICLE SPEED CONTROL). THE DEALER'S TECHNICIAN CAME TO THE CONTACT'S RESIDENCE FOR A TEST DRIVE AND THE TECHNICIAN INDICATED THAT THE POWER LOSS WAS DUE TO THE PLACEMENT OF THE CONTACT'S FOOT ASSOCIATED WITH THE SPACING NEAR THE ANKLE BY THE BRAKE PEDAL AND THE ACCELERATOR PEDAL. THE VEHICLE WAS NOT REPAIRED FROM THE RECALL REMEDY OF THE SOFTWARE UPDATE AND THE CONTACT INDICATED THAT THE FAILURE MAY RECUR WITHOUT WARNING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 57,315. UPDATED 09/10/15*LJ UPDATED 12/06/2017*CN
Other or unspecified, Engine, Fuel/propulsion system, Jul 8, 2015
THE HOSE CONNECTING THE CANISTER FILTER TO THE CANISTER BROKE OFF DRIVING IN THE RAIN AND I DIDN'T SEE UNTIL NEXT DAY WHILE 8 HRS AWAY FROM HOME. CALLED THE LOCAL DEALER THEY DIDN'T HAVE THE PART. NO CHECK ENGINE LIGHT SHOWN.I GOT HOME AND HAVE THE CANISTER FILTER REPLACED WITH THE DEALER AND NEXT DAY CHECK ENGINE, VSC AND 4WD LIGHT CAME ON, DEALER SAYS IT COST $1800 TO FIX IT. I RESEARCHED ONLINE AND LOT OF 2006 AND UP RAV 4 OWNER HAVE SAME ISSUE. CANNISTER HOSE BROKEN OR FILTER DROPPED AND WATER GETTING INTO THE SYSTEM. I GOT TOYOTA SERVICE BULLETIN T-SB-0098-09 WHICH WAS UPDATED TO T-SB0161-11 ON OCTOBER 20,2011 FOR THIS ISSUE. TOYOTA HAD COVERED WARRANTY FOR 2GR-FE ENGINE FROM 2006-2011 SOLD ON CA, CT, ME, MD, MA, NJ, NM,VT,WA, RI UNDER CALIFORNIA LONG TERM EMISSION WARRANTY OF 64 MONTHS OR 70,000 MILES WHICH EVER OCCURS FIRST. TOYOTA KNEW THE ISSUE AND EVEN ADDED A NEW COVER (PART NO 77641-0R020) THE PROTECT THE CANISTER FILTER AND THE HOSES BUT THEY DIDN'T ISSUE THE RECALL. A LOT OF PEOPLE HAVE SAME ISSUE. THE FILTER AND HOSE ARE UNPROTECTED UNDERNEATH THE CHASSIS AND IT CAN BREAK OR FALL DRIVING UNDER NORMAL DRIVING IN A RAIN OR SNOW. I CALLED TOYOTA AND THEY REVIEW MY CASE AND GAVE ME CASE # BUT THEY WON'T FIX IT BECAUSE MY VEHICLE WAS NOT DRIVEN AND SOLD ON THE AFOREMENTIONED STATES. TOYOTA HAS COVERED THE WARRANTY ON THE STATES WITH HEAVY SNOW AND RAIN ONLY. BUT THESE THINGS ARE TRUE FOR THE STATE I AM IN TOO. REMAINING STATE STANDARD 36 MONTHS 36,000 WARRANTY. BUT THIS THING CAN HAPPEN TO ANYONE AT ANY MILEAGE. TOYOTA KNEW IT AND HAD A FIX BY PUTTING THE NEW COVER BUT DIDN'T ISSUE A RECALL . THE SERVICE BULLETIN EVEN STATES THE VEHICLES MANUFACTURED BEFORE CERTAIN VIN NUMBER AND MINE DOES FALL UNDER IT. I PAID $220 TO REPLACE FILTER AND $62.5 TO DIAGNOSE. NOW THEY WANT ANOTHER $1800 TO FIX IT. I WISH I COULD ATTACHED THE SERVICE BULLETIN. UPDATED 09/15/15*LJ UPDATED 11/08/2017*CN
Air bags, Seat belts, Jun 24, 2015, crash
TL* THE CONTACT OWNED A 2008 TOYOTA RAV4. WHILE DRIVING AT APPROXIMATELY 45 MPH, THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF A TRUCK. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT DID NOT RESTRAIN THE DRIVER. THE VEHICLE WAS DESTROYED AND TOWED TO AN IMPOUND LOT. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE FAILURE MILEAGE WAS UNKNOWN. ...UPDATED 08/20/15 *BF
Air bags, Jun 11, 2015
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V168000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, May 30, 2015
CLUNKING NOISE WHEN TURNING THE STEERING WHEEL.
Suspension, May 23, 2015
MY 2008 TOYOTA RAV 4 HAD A RECALL FOR THE REAR LOWER CONTROL ARMS, THE FIRST RECALL WAS AROUND JAN. 12, 2013. (64,306) MILES. AT THIS TIME TOYOTA TIGHTENED THE CONTROL ARMS TO THE CORRECT TORQUE AND I BELIEVE COMPLETED ALIGNMENT. ABOUT 1 YR LATER, ON JAN.17, 2014 (78,847) MILES, THE LOWER CONTROL ARMS WHERE REPLACED, ALIGNMENT WAS DONE, AND EPOXY WAS APPLIED TO THE BOLTS FOR A PERMANENT FIX APPROVED BY TOYOTA. WHEN HAVING MY BRAKES REPLACED AT TOYOTA DEALER ON MAY 17, 2015 (101,475) MILES, THEY INFORMED ME MY REAR ALIGNMENT WAS OUT SLIGHTLY. I WAS TOLD THE ONLY WAY TO FIX THIS IS TO HAVE THE SAME JOB DONE, AS WAS DONE IN JANUARY 2014, AT A COST OF APPROX. $900.00. I WAS TOLD I MUST HAVE HIT A POT HOLE?? THIS WAS A TOYOTA RECALL FOR A DEFECT ON THEIR PART WITH THEIR PARTS. OBVIOUSLY, THE PERMANENT FIX DIDN'T WORK. I GUESS THEY WOULD EXPECT ME TO PAY EVERY TIME MY VEHICLES REAR COMES OUT OF ALIGNMENT TO PAY $900.00. MY TOYOTA RAV 4 HAS ALWAYS BEEN SERVICED AT THE SAME TOYOTA DEALERSHIP IN VINELAND, NEW JERSEY, WHICH IS WHERE I PURCHASED IT NEW. I CONTACTED TOYOTA CORP, AND THEY WHERE NO HELP. ALSO, HAVING A PROBLEM WITH EXCESSIVE OIL CONSUMPTION, LIKE MANY OTHERS. WHAT HAS HAPPENED TO TOYOTA AND THEIR REPUTATION!
Engine, May 17, 2015
MY ENGINE SEIZED ON A MOVING HIGHWAY. I HAD TO HAVE IT TOWED TO THE NEAREST MECHANIC WHO IDENTIFIED THE VEHICLE HAD VERY LITTLE OIL IN IT DESPITE JUST HAVING HAD AN OIL CHANGE 3 WEEKS PRIOR. HE CHECKED THAT THERE WAS NO OIL LEAL AND ADVISED TO ME TAKE IT TO THE DEALERSHIP BECAUSE HE FELT MY VEHICLE HAD A FAULTY ENGINE. MY CAR WAS TOWED TO THE NEAREST TOYOTA DEALERSHIP WHO LIED FIRST ABOUT MY VEHICLE HAVING A FAULTY ENGINE AND THEN WHEN I PRESENTED TO THEM THE EXISTING LITERATURE ON THE ENGINE OIL CONSUMPTION PROBLEM, ONLY THEN DID THEY CONFIRM MY VEHICLE AS HAVING A FAULTY ENGINE. BASED ON MY VIN, I HAVE THE 2AZ-FE ENGINE WHICH POSES A SAFETY RISK TO CONSUMERS IN THAT IT CAUSES ENGINE PROBLEMS INCLUDING FAILURE. TOYOTA KNEW OF THIS DEFECT WHEN I PURCHASED MY VEHICLE AND DID NOT DISCLOSE THIS TO ME. THEY ALSO ISSUED A SAFETY BULLETIN IN 2011 BUT ONLY TO DEALERSHIPS AND NOT TO CONSUMERS. TOYOTA HAS NOT DISCLOSED OF THIS PROBLEM TO ITS CONSUMERS AND CONTINUES TO REGARD THEIR VEHICLES AS SAFE. MY SAFETY WAS COMPROMISED BECAUSE OF TOYOTA'S DISHONESTY AND DECEIT.
Steering, May 16, 2015, crash, fire
WE RECENTLY TOOK OUR RAV4 IN FOR RECALL WORK. THE SERVICE DEPARTMENT DECIDED TO DO A COMPLIMENTARY INSPECTION ON MY RAV4. WE WERE TOLD THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. IT HAD NEVER BEEN A PROBLEM BEFORE. NOW, THE POWER STEERING PUMP IS SQUEALING ON TIGHTER THAN REGULAR CORNER TURNING. I RESEARCHED THIS ISSUE ON THE INTERNET. THE DISTURBING, MORE CONSTANT COMPLIANT IS THAT THE POWER STEERING ON MY YEAR, MAKE AND MODEL WILL FAIL INTERMITTENTLY AND THEN SUDDENLY FAIL. THIS IS A VERY SERIOUS ISSUE SINCE MOST OF THE DRIVERS ON THE ROAD ARE USED TO POWER STEERING AND MAY NOT KNOW WHAT TO DO IF THE POWER STEERING SHOULD SUDDENLY FAIL WHILE DRIVING. I WANT TO MAKE IT CLEAR THAT I AM NOT BLAMING THE DEALERSHIP OR THE SERVICE DEPARTMENT. THEY GAVE US A HEADS-UP ON WHAT WE HAD NO IDEA WAS ABOUT TO BECOME A PROBLEM. THE POWER STEERING PUMP PROBLEM IS A SERIOUS ISSUE, THE RAV4 IS A FAMILY CAR FOR THE MOST PART.
Engine, May 5, 2015
LOW ENGINE OIL LIGHT CAME ON AT 4200 MILES OF SCHEDULED 5000 MILE OIL CHANGE. DIPSTICK CHECKED AND NO OIL WAS IN ENGINE. TWO QUARTS ADDED AND BROUGHT TO DEALERSHIP FOR OIL CONSUMPTION TEST. CAR FILLED WITH OIL DRIVEN 1200 MILES AND BROUGHT BACK. DEALER STATES APPROXIMATELY 1 QUART OF OIL CONSUMED AND IT DOES NOT QUALIFY FOR EXCESSIVE OIL CONSUMPTION CORRECTION. *TR
Engine, May 1, 2015
4 CYLINDER ENGINE EXCESSIVE OIL CONSUMPTION - BETWEEN 5000 MILE OIL CHANGES WE ARE PUTTING IN 4 - 5 QUARTS OF OIL. THERE IS A WELL-KNOWN PISTON DESIGN FAULT ON THIS ENGINE WHICH REQUIRES THE FITTING OF NEW PISTONS AND THIS SHOULD BECOME A RECALL ISSUE NOT AN DISCRETIONARY MATTER DECIDED ARBITRARILY BY TOYOTA AND ITS DEALERS. WE RAISED THIS ISSUE WITH A DEALER ABOUT 3 YEARS AGO AND WAS FOBBED OFF WITH THE USUAL RESPONSE LIKE '' IT'S NOTHING TO WORRY ABOUT'' WE INTEND GETTING THE OIL CONSUMPTION CHECKED AGAIN BY TOYOTA BUT IN THE MEANTIME PLEASE PUT PRESSURE ON TOYOTA TO DEAL WITH THIS MATTER IN A RESPONSIBLE WAY. SUCH A SERIOUS ENGINE DESIGN FAULT SHOULD NOT RESULT IN CONSUMERS LOSING OUT WITH A COLLAPSE IN CAR VALUE AND FURTHER PROBLEMS WITH OIL CONTAMINATION OF THE CATALYTIC CONVERTER DUE TO BURNING LARGE QUANTITIES OF OIL. *TR
Suspension, Apr 18, 2015
THE REAR SUSPENSION WHEEL NUTS GAVE UP, WHICH CAUSED THE ENTIRE CAR GO TO THE DITCH. MY WIFE AND MY TWO KIDS WAS ON THE CAR, AND LUCKILY THEY GET OUT AND SAFELY STOPPED THE CAR. TOYOTA INFORMED ME THAT THEY REPAIRED THESE REAR BOLTS LAST YEAR BECAUSE IT HAD RECALL BEFORE, BUT STILL THE ISSUE IS HAPPENING EVEN IF THEY PERFORM REPAIR. LITERALLY THIS CAN CAUSE A LOT OF BAD ACCIDENTS AND LOST IF TOYOTA EVEN DON'T REPAIR CORRECTLY ON THE REAR SUSPENSIONS OF RAV4. *TR
Engine, Fuel/propulsion system, Apr 13, 2015
VEHICLE STARTED PINGING WHEN GOING UP HILLS. CHECKED OIL AND IT DIDN'T EVEN REGISTER! HAD JUST HAD OIL CHANGED 2 WEEKS BEFORE. SINCE THIS TIME, I HAVE HAD TO ADD ABOUT 5 QUARTS OF OIL. NOW I'M TOLD TOYOTA CONSIDERS USING 1 QUART PER 1,000 DRIVING MILES IS "NORMAL". THE ENGINE COULD BURN UP BASED ON THIS EXCESSIVE OIL CONSUMPTION LEAVING THE OCCUPANTS STRANDED. *TR
Power train, Apr 13, 2015
WATER PUMP HAS FAILED, DESPITE TIMELY AND COMPLETE MAINTENANCE AND NORMAL OPERATING CONDITIONS. A GOOGLE SEARCH REVEALS WIDESPREAD, PREMATURE WATER PUMP FAILURE ON 2008 V6 RAV4 VEHICLES AT EVEN EARLIER MILEAGES. *TR
Vehicle speed control, Apr 12, 2015
WHILE STOPPED AT A LIGHT WAITING TO TURN LEFT THE RAV4 ENGINE BEGAN TO REV AND LURCHED FORWARD WITH DRIVER'S FOOT STILL ON THE BRAKE. DRIVER PUT CAR INTO NEUTRAL WHILE HOLDING DOWN THE BRAKE PEDAL TO PREVENT THE CAR HURTLING INTO THE INTERSECTION. DRIVER THEN TURNED OFF THE CAR AND PUT GEAR SHIFT TO PARK. AFTER 30 SECONDS RESTARTED THE CAR WITH FOOT ON BRAKE AND THE ENGINE BEGAN TO REV AGAIN WITH CAR IN PARK. THE ENGINE NOISE WAS VERY LOUD. CAR WAS AGAIN TURNED OFF. CAR WAS RESTARTED AFTER ABOUT 2-3 MINUTES AND ENGINE BEHAVED NORMALLY. OWNERS TOOK CAR TO TOYOTA DEALER WITHIN AN HOUR OF THE INCIDENT. TOYOTA DEALERSHIP RAN DIAGNOSTIC AND MANAGER SAID DRIVER HAD FOOT ON THE ACCELERATOR WHEN IT HAPPENED WHICH IS CERTAINLY NOT TRUE. DEALER WOULD NOT RELEASE A COPY OF THE DIAGNOSTIC REPORT. OWNERS HAVE HAD ALL RECALL WORK DONE ON THE VEHICLE AND HAVE DONE REGULAR MAINTENANCE AS REQUIRED IN THE OWNER MANUAL. *TR
Engine, Apr 8, 2015
I WENT TO THE DEALERSHIP FOR MY NORMAL OIL CHANGE IN SEPT 2013 AND WAS TOLD THERE WAS NO OIL ON THE DIPSTICK, RAV HAD 85,000 MILES AT THE TIME. NO LIGHTS HAD COME ON THAT ALERTED ME TO AN ISSUE. THEY NOTED IT ON THE RECORDS AND SAID THEY WOULD KEEP AN EYE ON IT. I WENT FOR MY NEXT OIL CHANGE NOV 2013 AND SAME ISSUE OF NO OIL ON DIPSTICK AND AGAIN NO WARNING LIGHTS. THEY NOTED IT AGAIN ON PAPERWORK AND SAID WE MIGHT NEED TO LOOK INTO WHY IT IS USING OIL. WE MADE A PHONE CALL TO A FRIEND WHO IS A TOYOTA MECHANIC AND WAS TOLD THERE WAS A SERVICE BULLETIN ISSUED TO THE DEALERSHIPS ABOUT OIL CONSUMPTION ISSUES. DEALERSHIP DID NOT SAY ANYTHING ABOUT THIS TO ME EITHER TIME. WE HAVE WATCHED THE OIL EVER SINCE AND HAVE TO ADD OIL BETWEEN CHANGES. IN JANUARY 2015 WE RECEIVED WARRANTY ENHANCEMENT NOTIFICATION ABOUT OIL CONSUMPTION ISSUE. IN FEBRUARY WE HAD OIL CONSUMPTION TEST PERFORMED AND WAS TOLD THE RAV WAS WITHIN NORMAL LIMITS OF OIL USAGE. I CALLED TOYOTA CUSTOMER SERVICE AND LOGGED A CASE. THEY TOLD ME TO GO BACK TO DEALERSHIP BETWEEN 1100-1300 MILES AND HAVE OIL LEVEL CHECKED AGAIN. IT WAS 1500 MILES LATER BEFORE I COULD GET BACK IN TO DEALERSHIP. THEY NOTED THE RAV HAD USED 1 QUART OF OIL IN 1500 MILES. I AM BEING TOLD THAT IS NORMAL USAGE AND AT THIS TIME MY VEHICLE WILL NOT BE INCLUDED IN THE "FIX". THE RAV ONLY HAS 120,000 MILES ON IT. *TR
Service brakes, Apr 6, 2015
I PURCHASED MY RAV4 NEW IN 2008. OVER THE YEARS OCCASIONALLY WHEN BRAKING THE VEHICLE WOULD NOT SLOW DOWN LIKE IT SHOULD AND A REALIZED THAT MY FOOT WAS DEPRESSING BOTH THE BRAKE PEDAL AND THE ACCELERATOR PEDAL AT THE SAME TIME. I DIDN'T LIKE IT VERY MUCH THAT THIS COULD OCCUR BUT NEVER DID ANYTHING ABOUT IT. RECENTLY WHEN BRAKING AT A 4-WAY STOP SIGN IT HAPPENED AGAIN BUT THIS TIME IT CAUGHT ME OFF-GUARD AND I NEARLY BROADSIDED A VEHICLE THAT HAD JUST PULLED OUT FROM THE OTHER DIRECTION. FORTUNATELY I REALIZED WHAT HAD HAPPENED AND WAS ABLE TO MOVE MY FOOT FROM THE ACCELERATOR IN TIME TO STOP. THIS TIME IT SCARED ME SINCE I WAS SO CLOSE TO HITTING THE OTHER VEHICLE. THIS TIME I WENT TO MY DEALERSHIP AND TOLD THEM ABOUT THE ISSUE BUT WAS TOLD I HAD TO CONTACT TOYOTA ABOUT THE ISSUE. I DID THIS AND WAS TOLD TO HAVE THE VEHICLES COMPUTER UPDATED TO CORRECT THE PROBLEM. I HAD THIS DONE BUT IT DOES NOT CORRECT THE ISSUE. THE DEALERSHIP INFORMED ME THAT THE UPDATE IS DESIGNED TO NOT ALLOW THE ENGINE TO OVERPOWER THE BRAKES BUT IT WILL STILL ALLOW THE ENGINE TO PUT POWER TO THE WHEELS WHEN BRAKING. I CONTACTED TOYOTA ABOUT THIS ISSUE AGAIN BUT WASN'T GIVEN ANY SATISFACTION AS TO HOW THIS ISSUE COULD BE CORRECTED. I SPOKE WITH MY BROTHER WHO HAS A 2009 RAV4 AND SAYS HE HAS THE SAME PROBLEM WITH HIS VEHICLE. THIS IS A SAFETY ISSUE AND IF THERE ARE 2 PEOPLE IN OUR FAMILY WITH THIS ISSUE, I'M SURE THERE ARE A LOT MORE PEOPLE OUT THERE WHO ALSO EXPERIENCE THE PROBLEM. ISN'T THERE SOMETHING THAT CAN BE DONE ABOUT THIS PROBLEM??
Engine, Apr 3, 2015
WHEN STARTING MY CAR MY 4 WHEEL DRIVE LIGHT, ENGINE LIGHT, VSC LIGHT WOULDN'T GO OUT. WHEN TAKEN THIS TO MY MECHANIC I WAS TOLD THAT THE VACUUM SYSTEM. AFTER CHECKING EVERYTHING , THINGS SEEMED TO BE OK. WHEN IT HAPPENED AGAIN I WAS TOLD THAT THE GAS CAP WAS PUT ON TO TIGHT. THE LIGHTS WHERE RESET. IN JANUARY IT BEGAN TO HAPPEN AGAIN. TOOK IT TO A NEW MECHANIC, I WAS TO TOLD THAT THE CHARCOAL FILTER NEEDED TO BE REPLACED, WHICH I NEEDED TO WAIT ABOUT 10 DAYS FOR IT TO COME IN. REPLACED THE ABOUT 25 MILES LATER LIGHTS CAME BACK ON. NEW CLAMPS WHERE PUT ON ALL HOSES. 50 MILES LATER LIGHTS BACK ON , NOW CODE IS SAYING THE CHARCOAL CANISTER FAULTY. NOW THAT NEEDS TO BE REPLACED. MY MECHANIC DID RESEARCH, FOUND OUT THAT THEIR HAS BEEN MANY COMPLAINTS ABOUT THIS PROBLEM. THIS PART COST OVER 800$ I MYSELF HAVE READ OTHER RAV4 OWNERS THAT THIS ISN'T A NEW PROBLEM. HOW LONG OR HOW MANY COMPLAINTS DOES IT TAKE FOR SOMEONE TO DO SOMETHING ABOUT THIS. THEIR HAVE BEEN TIMES WHEN THIS HAS HAPPENS THE CAR SPUTTERS AND REALLY DOESN'T GO ANYWHERE. DOES MY LIFE HAVE END WHEN MY VEHICLE DOES THIS AND I GET HIT FROM BEHIND. OH DON'T EVEN GET ME STARTED ON THE AMOUNT OF OIL THIS CAR USES. MAYBE MY ENGINE NEEDS TO BLOW UP FIRST. PLEASE FINALLY DO SOMETHING BEFORE SOMEONE GETS HURT. OR IS THIS WHAT NEEDS TO HAPPEN. *TR
Engine, Apr 2, 2015
TOYOTA OIL CONSUMPTION TEST CONDUCTED. USAGE OF ~3/4 QT PER 1,200 MILES. FIRST NOTED EXCESSIVE USAGE AT ~ 95,000 MI. TESTED AT 138,739 MI. 2.4L 4-CYL DOHC ENGINE. *TR
Power train, Engine, Mar 22, 2015
WHILE STOPPED AT A LIGHT WAITING TO TURN LEFT THE RAV4 ENGINE BEGAN TO REV AND LURCHED FORWARD WITH DRIVER'S FOOT STILL ON THE BRAKE. DRIVER PUT CAR INTO NEUTRAL WHILE HOLDING DOWN THE BRAKE PEDAL TO PREVENT THE CAR HURTLING INTO THE INTERSECTION. DRIVER THEN TURNED OFF THE CAR AND PUT GEAR SHIFT TO PARK. AFTER 30 SECONDS RESTARTED THE CAR WITH FOOT ON BRAKE AND THE ENGINE BEGAN TO REV AGAIN WITH CAR IN PARK. THE ENGINE NOISE WAS VERY LOUD. CAR WAS AGAIN TURNED OFF. CAR WAS RESTARTED AFTER ABOUT 2-3 MINUTES AND ENGINE BEHAVED NORMALLY. OWNERS TOOK CAR TO TOYOTA DEALER WITHIN AN HOUR OF THE INCIDENT. TOYOTA DEALERSHIP RAN DIAGNOSTIC AND MANAGER SAID DRIVER HAD FOOT ON THE ACCELERATOR WHEN IT HAPPENED WHICH IS CERTAINLY NOT TRUE. DEALER WOULD NOT RELEASE A COPY OF THE DIAGNOSTIC REPORT. OWNERS HAVE HAD ALL RECALL WORK DONE ON THE VEHICLE AND HAVE DONE REGULAR MAINTENANCE AS REQUIRED IN THE OWNER MANUAL. *TR
Electrical system, Mar 20, 2015, fire
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. SHORTLY AFTER PARKING, THE VEHICLE CAUGHT FIRE. A POLICE AND A FIRE REPORT WERE FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE INSPECTED BY THE INSURANCE COMPANY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 69,000. UPDATED 5/5/15*CN UPDATED 9/16/2015 *JS
Steering, Mar 20, 2015
MAKES A CLUNKING SOUND WHEN I TURN AND I FEEL A "BUMP" IN THE STEERING WHEEL. I WAS CHARGED $594.45 AT THE DEALERSHIP FOR THE REPAIR REPLACE THE INTERMEDIATE STEERING SHAFT. AFTER SEARCHING ONLINE, I FOUND THAT THERE ARE MANY COMPLAINTS ABOUT THIS PROBLEM. PLEASE ENFORCE A VEHICLE RECALL FOR THIS PROBLEM. *TR