2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
575 reports, newest first.
Engine, Sep 9, 2014
THE 2008 RAV4'S SEEM TO HAVE A SERIOUS DEFECT WITH THE ENGINES BURNING A LOT OF OIL DUE TO BAD PISTON RINGS. THIS DEFECT IS COSTING RAV4 OWNERS QUITE A BIT OF MONEY AND TOYOTA ISN'T RECALLING THE ENGINES FOR REPAIR. TOYOTA SHOULD BE HELD REASONABLE FOR THE DESIGN FLAWS AND GET THESE CARS FIXED RIGHT AWAY BEFORE SOMETHING HAPPENS TO SOMEONE. *TR
Steering, Sep 9, 2014
I WENT TO THE DEALER BECAUSE I HEARD A CLUNKING NOISE WHEN TURNING THE STEERING WHEEL. THEY DID NOT HEAR ANYTHING AND I COULD NOT DO ANYTHING BECAUSE THE VEHICLE WAS UNDER WARRANTY. A YEAR LATER, AT A ROUTINE CHECKUP, THEY SAID THEY HEARD THE SOUND AND IT WAS A DAMAGE STEERING SHAFT AND RACK & PINION. A YEAR LATER THE SAME SOUND, BUT ONLY THE STEERING SHAFT WAS REPLACED. THE YEAR AFTER THAT, THE NOISE AGAIN AND THEY HAD TO REPLACE THE STEERING SHAFT AND RACK AND PINION. TODAY I WAS TOLD THAT I HAVE TO CHANGE THE RACK AND PINION. I READ ON INTERNET THAT THIS IS A COMMON PROBLEM THROUGHOUT RAV4 2008, BUT THIS IS RIDICULOUS. *TR
Suspension, Sep 5, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THERE WAS A LOUD ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 12V373000 (SUSPENSION) AND NHTSA CAMPAIGN ID NUMBER: 13V383000 (SUSPENSION). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE WHEEL BEARING/HUB ASSEMBLY WAS REPLACED AND WHILE SERVICING THE VEHICLE, THE MECHANIC NOTICED THAT THE NUT THAT GOES ONTO THE AXLE, WHICH HOLDS THE WHEEL BEARING IN PLACE ON THE RIGHT FRONT WHEEL BEARING, WAS CROOKED. THE MECHANIC STATED THAT THE RECALL REPAIRS WERE NOT COMPLETED PROPERLY. THE CONTACT FELT THAT THE RECALL REMEDY INSTRUCTION FAILED TO REMEDY THE VEHICLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. THE VIN WAS NOT AVAILABLE.
Engine, Sep 2, 2014
EXCESSIVE OIL CONSUMPTION I WENT FOR AN OIL CHANGE AS I DO EVERY 3000 MILES AND WAS TOLD THERE WAS LITTLE OIL. THEY LOOKED FOR LEAKS ETC. NONE FOUND. THOUGHT IT WAS A FLUKE. ABOUT 1500 MILES IN MY ENGINE LIGHT COMES ON MY BROTHER IN LAW WHO IS A CERTIFIED MECHANIC FOR 30 YEARS AND TAKES CARE OF MY CAR TELLS ME MY CAR IS CONSUMING OIL AND YOUR TALKING A BIG JOB ADVISED ME TO TAKE IT TO THE DEALER TO RUN A CONSUMPTION TEST WHICH I DID AND YES THAT IS WHAT I AM TOLD. THERE IS NOTHING I CAN DO UNLESS I PAY TO HAVE IT FIXES WHICH IS VERY COSTLY I WAS ADVISED TO CHECK OIL EVERY 1000 MILES AND FILL. UPON RESEARCH THIS HAS BEEN REPORTED BY NUMEROUS TOYOTA OWNERS NOT ONLY ON RAVA4'S BUT OTHER MODELS AS WELL AROUND THE 2006/2008 TIME FRAME. TOYOTA ADMITS TO PROBLEM AND FIXES IN LATER MODELS BUT DOES NOT DO ANYTHING TO FIX A KNOWN DEFECT!!!! I HAVE JOINED EVERY LAW SUIT, COMPLAINT BOARD, ETC. AND FOR THIS REASON WILL NEVER BUY ANOTHER TOYOTA. *TR
Engine and engine cooling, Sep 2, 2014
IN MARCH 2014 AFTER DRIVING MY 2008 TOYOTA RAV 4 APPROXIMATELY 3000 MILES AFTER AN OIL CHANGE I CHECKED MY OIL AND WAS DOWN ABOUT 1 1/2 QUARTS. THE OIL AND FILTER WERE THEN CHANGED. IN SEPTEMBER 2014 AFTER DRIVING 3000 MILES THE OIL LEVEL FELL 2 QUARTS SHORT. *TR
Air bags, Sep 2, 2014
I WAS DRIVING ON THE WEST VIRGINIA TURNPIKE WHEN THE AIRBAG LIGHT CAME ON. THE BAG DIDN'T OPEN, BUT IT SCARED ME. THERE IS NO SHOULDER ON THE TURNPIKE TO GET OVER AND THERE IS LOTS OF TRUCKERS. THE AIRBAG LIGHT STAYED ON UNTIL I GOT OFF THE TURNPIKE AND PULLED OVER TO A REST STOP. I TURNED OFF THE CAR AND MY SON AND I RESTED FOR ABOUT 30 MINUTES BEFORE STARTING THE CAR AGAIN TO DRIVE HOME. WHEN I TURNED ON THE CAR THE LIGHT WAS OFF. IT COMES ON EVERY ONCE IN A WHILE. NOT SURE WHY AND NOT SURE WHAT IS CAUSING IT TO COME ON? *TR
Visibility, Aug 26, 2014
DRIVER'S VISOR IS LOOSE. IT WON'T FOLD UP. PLEASE KINDLY HAVE A RECALL ON THIS. THANKS! *TR
Suspension, Aug 15, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR OF THE VEHICLE WOULD BECOME UNCONTROLLABLE AND THE STEERING WHEEL WOULD BECOME UNSTABLE. THE CONTACT STATED THAT THE VEHICLE WAS RECENTLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V37000 (SUSPENSION) HOWEVER, THE RECALL REPAIRS FAILED TO REMEDY THE FAILURE. THE DEALER WAS NOT ABLE TO DETERMINE HOW TO REMEDY THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
Engine and engine cooling, Vehicle speed control, Aug 12, 2014
CHECK ENGINE LIGHT, VSC LIGHT, AND 4WD LIGHTS STAYED ON AFTER WE PURCHASED VEHICLE. WE WERE ADVISED TO DISCONNECT BATTERY TO RESET, IT WORKED UNTIL CAR WAS SHUT OFF. THEN THE LIGHTS CARE ON AGAIN, AND 4WD WOULD NOT WORK. OUR DRIVEWAY REQUIRES 4WD! TOOK IT TO TOYOTA SERVICE NEAR OUR HOME, HE CALLED WARRANTY COMPANY, THEY WOULD NOT PAY BECAUSE EVAP CANNISTER AND HOSES HAD PREVIOUS WATER DAMAGE, AND WERE RUSTED. MANLY HONDA IN SANTA ROSA HAS PUT US OFF FOR TWO AND A HALF WEEKS. THIS IS WHERE WE PURCHASED THE CAR FOR OUR DAUGHTER. THEY WILL NOT RETURN CALLS. WE WERE INFORMED TOYOTA ONLY COVERED THIS PROBLEM UP TO 70,000 MILES. TO TAKE IT TO DEALER!! THEY WILL NO LONGER RESPOND. *TR
Engine and engine cooling, Aug 6, 2014
MY CAR WOULD NOT START, AND THE CHECK ENGINE LIGHT AND OIL LIGHT REMAINED ON EVEN WHILE KEY WAS NOT IN IGNITION. ALSO, THERE WAS A HUMMING AND SLIGHT TICKING NOISE COMING FROM THE ENGINE WHILE THE CAR WAS TURNED OFF. IT SEEMED LIKE SOMETHING HAD SHORTED OUT AND SOMETHING ELECTRICAL WAS CAUSING SOMETHING TO STAY ON CONSTANTLY AND IT WAS DRAINING THE BATTERY. AFTER RESEARCHING ON THE INTERNET SOMEONE ELSE HAD THIS SAME PROBLEM, AND THEY FOUND THAT THERE WAS A LEAK COMING FROM THE WINDSHIELD ON THE PASSENGER SIDE OF THE VEHICLE. SO I PULLED UP MY CARPET AND SURE ENOUGH THE ENTIRE FLOOR BOARD WAS COVERED WITH WATER AND THE PAD WAS COMPLETELY SOAKING WET. IT APPEARS THAT WATER HAS DAMAGED SOMETHING IN THE ELECTRICAL SYSTEM. I AM NOT THE ONLY ONE WITH THIS PROBLEM, AND I DO NOT FEEL THAT I SHOULD HAVE TO REPAIR THIS MYSELF. THE VEHICLE SHOULD BE VOID OF LEAKS AND ABLE TO FUNCTION IN RAIN AND SNOW CONDITIONS. TOYOTA REALLY NEEDS TO ADDRESS THIS ISSUE AND TAKE RESPONSIBILITY FOR THIS DEFECT. ANY ASSISTANCE IN THIS MATTER WOULD BE GREATLY APPRECIATED. THIS IS THE LINK TO THE OTHER TOYOTA OWNERS EXPERIENCE: HTTP://WWW.RAV4WORLD.COM/FORUMS/96-4-3-GENERAL/93222-RANDOM-DASH-LIGHTS-GAUGES-EVEN-KEY-REMOVED-2.HTML. *TR
Suspension, Jul 17, 2014
ABOUT 2 MONTHS AGO I RECEIVED A SECOND URGENT RECALL LETTER FROM TOYOTA REGARDING THE REAR LOWER SUSPENSION ARM, MEANING THEY DIDN'T FIX IT THE FIRST TIME ABOUT A YEAR AGO. HAVE BEEN TRYING TO FIX THE PROBLEM BUT LOCAL DEALERS AND TOYOTA USA SAY THEY DON'T HAVE THE PARTS AND DON'T KNOW WHEN THE PARTS WILL BE AVAILABLE. *TR
Engine and engine cooling, Fuel/propulsion system, Jul 9, 2014
EVAPORATIVE CONTROL (EVAP) SYSTEM DESIGN FLAW. THIS DESIGN FLAW ALLOWS WATER/DEBRIS/ETC TO ENTER THE EVAP SYSTEM, RESULTING IN THE NEED TO REPLACE PIECES OF THE EVAP SYSTEM SUCH AS FILTER EMISSION HOSES, CHARCOAL CANISTER, CANISTER VENT VALVE, OR ACCORDING TO MY LAST TOYOTA DEALERSHIP VISIT THE WHOLE EVAP SYSTEM! NEWER RAV4 MODELS HAVE BEEN UPDATED TO INCLUDE A COVERING UNDER THE CAR AS TO BE ABLE TO DRIVE IN NORMAL DRIVING CONDITIONS SUCH AS RAIN WITHOUT RISKING AN EMISSION HOSE OR CHARCOAL CANISTER GETTING DEBRIS IN IT OR GETTING CAUGHT ON SOMETHING. *TR
Suspension, Jul 1, 2014
I RECEIVED AN "URGENT SAFETY RECALL" FROM TOYOTA SOMETIME JAN - APRIL 2014, REGARDING "REAR LOWER SUSPENSION ARMS (NO 1), ONE OF SEVERAL RECALL NOTICES I'VE RECEIVED SINCE OWNING THIS VEHICLE. HOWEVER, THIS IS THE FIRST TIME WHERE I CANNOT GET THIS PROBLEM FIXED AT THE LOCAL DEALERSHIP, BECAUSE THE AFFECTED PARTS ARE NOT AVAILABLE WHEN I CALLED IN LATE MAY AND AGAIN TODAY. AND THE DEALERSHIP CANNOT TELL ME WHEN THEY WILL GET THE PART AND ADVISED TO CALL BACK AT END OF THE SUMMER. WHAT IS THE POINT OF SENDING OUT THESE URGENT SAFETY RECALL NOTICES IF THE DEALERSHIPS DO NOT HAVE THE PARTS TO FIX THEM FOR SUCH A LONG TIME? IT SHOULDN'T BE TITLED "URGENT" IF NO REMEDY CAN BE DONE TO FIX THE CAR. IF IT IS TRULY AN URGENT SAFETY ISSUE, TOYOTA SHOULD BE WORKING HARDER TO HAVE THE PARTS READY. *TR
Power train, Engine, Jun 24, 2014
WATER PUMP STARTING MAKING INCREDIBLE DIESEL / MECHANICAL GRINDING SOUNDS. COOLANT LEAKING FROM WATER PUMP. WATER PUMP BEARING OVERHEATING - ODOR CLEARLY DISCERNIBLE FROM INSIDE VEHICLE. CHECKED INTERNET - THIS IS A VERY COMMON COMPLAINT AMONG RAV4 V6 OWNERS - MANY OWNERS HAVING REPLACED WATER PUMP ON THIS YEAR VEHICLE AT 25,000K MILES! DEALERS CHARGING ANYWHERE FROM US $325.00 - $900.00. *TR
Visibility, Jun 23, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE REAR WINDOW EXPLODED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 8/27/14*CN THE VEHICLE HAS UNDERGONE 8 RECALLS. UPDATED 09/11/2014 *JS
Suspension, Jun 20, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV-4. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER 13V383000 (SUSPENSION); HOWEVER, THE PART WAS NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE PARTS DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Engine, Jun 18, 2014
THE CAR IS BURNING OIL. I WAS TOLD THAT IT WAS BURNING 1/2 QUART EVERY 1200 MILES & TO KEEP ADDING OIL. THAT THIS USAGE WAS WNL. AFTER AN ONLINE SEARCH I FIND THIS IS A COMMON PROBLEM THAT TOYOTA HAS NOT BEEN DEALING WITH. I HAVE AN EXTENDED WARRANTY THAT WILL BE RUNNING OUT SOON. I FEEL THE CAR SHOULD BE RECALLED AND THEY SHOULD DO THE RIGHT THING. I HAVE FILLED A COMPLAINT WITH THE USA COOPERATE OFFICE. *TR
Fuel system, Gasoline, Jun 17, 2014
VAPOR CANISTER FOR CAPTURE OF FUEL VAPOR FROM FUEL TANK BECOMES DETACHED FROM THE VEHICLE WHEN VEHICLES GO THROUGH SNOW OR WATER. CANISTER, WHICH IS CONNECTED TO SEVERAL HOSES EITHER DANGLES UNDER VEHICLE OR PULLS LOOSE. THE LOSS OF THE CANISTER CAUSES ENGINE LIGHT TO INDICATE MALFUNCTION OF EMISSIONS SYSTEM. TOYOTA HAS REDESIGNED MOUNTING SYSTEM ON NEWER MODELS WHICH INCLUDES A SHIELD UNDER THE CANISTER AND MORE CONNECTION POINTS, BUT HAS NOT MADE AVAILABLE A CORRECTION FOR OLDER MODELS. CANISTER HAS COME LOOSE OR OFF TWICE; ONCE DRIVING ON SNOWY ROADS AND THE SECOND TIME WHEN VEHICLE WENT THROUGH A PUDDLE OF WATER ON HIGHWAY AFTER HEAVY RAIN. WITH CANISTER DISCONNECTED IT DISABLES 4 WHEEL DRIVE AND ALSO WILL NOT PASS EMISSIONS TESTS. *TR
Suspension, Jun 16, 2014
REGARDING NHTSA CAMPAIGN NUMBER: 13V383000 TOYOTA NOTIFIED ME OF THIS RECALL IN APRIL, 2014, AS I WAS IN THE LAST GROUP NOTIFIED. SINCE THEN, REPEATED CONTACTS TO MY DEALER RESULTED IN BEING TOLD THE PARTS WERE NOT AVAILABLE. TODAY, JUNE 16, THEY STATED THEY COULD INSPECT THE CAR LATER THIS MONTH, AND IF PARTS ARE NEEDED [PARTS HAVE BEEN NEEDED IN NEARLY ALL CASES], I WOULD THEN BE PLACED ON A WAITING LIST, AND IT COULD BE MANY MONTHS, IF EVER, THE PARTS WOULD ACTUALLY ARRIVE. TODAY, CUSTOMER SERVICE AT TOYOTA HQ TOLD ME THAT PARTS CAN ONLY BE ORDERED AT THE RATE OF 1 PER WEEK. A CHECK OF YOUR RECORDS INDICATES THAT LESS THAN 10% OF THE AFFECTED VEHICLES HAD BEEN REPAIRED IN THE FIRST 6 MONTHS OF THE RECALL. IS THIS GOOD PERFORMANCE, OR JUST A DODGE BY THE MANUFACTURER TO LIMIT THE COST OF ACTUALLY PERFORMING THE RECALL, BY MOVING SO SLOWLY THAT FEW VEHICLES ARE IN FACT REPAIRED? IS THERE ANYTHING I CAN DO, SHORT OF GARAGING THE CAR FOR THE NEXT YEAR; OR DRIVING A POSSIBLY UNSAFE VEHICLE? *TR
Steering, Jun 9, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHEN THE CONTACT STARTED THE VEHICLE, THE POWER STEERING MALFUNCTIONED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE DEALER STATED THAT THE POWER STEERING CONTROL UNIT NEEDED TO BE REPLACED. THE REPAIR WAS MADE AND THE STEERING OPERATED NORMALLY. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 65,262. UPDATED 9/8/14*CN
Power train, Jun 2, 2014
TL* THE CONTACT OWNS A 2008 RAV4 TOYOTA. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE WAS MAKING A HUMMING NOISE AS UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR DIFFERENTIAL COUPLING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE 114,000 AND THE CURRENT MILEAGE WAS 116,000.
Engine and engine cooling, May 31, 2014
THE MUFFLER HAS ALREADY SHOWN CORROSION TO THE POINT IT IS LOUD AND NOW MAY CAUSE HEAT ISSUES AND VAPOR ISSUES INTO THE CAR. *TR
Steering, May 27, 2014
VEHICLE MAKES NOISE WHEN THE STEERING WHEEL IS TURN. DIAGNOSED WITH RACK & PINION PROBLEMS BY THE TOYOTA DEALER AT 20, 070 MILES. *TR
Suspension, May 22, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 13V383000(SUSPENSION). THE CONTACT STATED THAT THE REPAIR HAD EXCEEDED A REASONABLE AMOUNT OF TIME. THE DEALER INDICATED THAT PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. DR
Structure, Vehicle speed control, May 22, 2014, crash
I WAS PULLING INTO MY GARAGE. I TOOK MY FOOT OFF THE ACCELERATOR AND WENT FOR THE BRAKE AND THE CAR SUDDENLY LURCHED FORWARD AND STRUCK A FOLDED DECK CHAIR WHICH WAS PUSHED THROUGH THE GARAGE WALL. *TR